MWCNT-7 administered to the lung by intratracheal instillation induces development of pleural mesothelioma in F344 rats.

Multi-walled carbon nanotube-7 (MWCNT-7) fibers are biopersistent and have a structure similar to asbestos. MWCNT-7 has been shown to induce malignant mesothelioma when administered by intrascrotal or intraperitoneal injection in rats and mice, and an inhalation study demonstrated that rats exposed to respirable MWCNT-7 developed lung tumors. MWCNT-N, which is similar to MWCNT-7, was shown to induce both lung tumors and malignant mesothelioma in rats when administered by trans-tracheal intrapulmonary spraying (TIPS). The present study was performed to investigate the carcinogenicity of MWCNT-7 when administered by the TIPS method. Ten-week-old male F344/Crj rats were divided into 3 groups and administered 0.5 mL vehicle, 0.250 µg/mL MWCNT-7 or 0.250 µg/mL crocidolite once a week for 12 weeks (total doses of 1.5 mg/rat) and then observed for up to 104 weeks. Rats in the MWCNT-7 group began to die from pathologies associated with the development of malignant mesothelioma 35 weeks after the final TIPS administration. Overall, the incidence of malignant mesothelioma in the MWCNT-7 group was significantly higher than in the vehicle or crocidolite groups.

Carcinogenic effect of potassium octatitanate (POT) fibers in the lung and pleura of male Fischer 344 rats after intrapulmonary administration.

BACKGROUND: Potassium octatitanate fibers (K2O•8TiO2, POT fibers) are used as an asbestos substitute. Their physical characteristics suggest that respirable POT fibers are likely to be carcinogenic in the lung and pleura. However, previous 2-year inhalation studies reported that respired POT fibers had little or no carcinogenic potential. In the present study ten-week old male F344 rats were left untreated or were administered vehicle, 0.25 or 0.5 mg rutile-type nano TiO2 (r-nTiO2), 0.25 or 0.5 mg POT fibers, or 0.5 mg MWCNT-7 by intra-tracheal intra-pulmonary spraying (TIPS), and then observed for 2 years. RESULTS: There were no differences between the r-nTiO2 and control groups. The incidence of bronchiolo-alveolar cell hyperplasia was significantly increased in the groups treated with 0.50 mg POT and 0.50 mg MWCNT-7. The overall incidence of lung tumors, however, was not increased in either the POT or MWCNT-7 treated groups. Notably, the carcinomas that developed in the POT and MWCNT-7 treated rats were accompanied by proliferative fibrous connective tissue while the carcinomas that developed in the untreated rats and the r-nTiO2 treated rats were not (carcinomas did not develop in the vehicle control rats). In addition, the carcinoma that developed in the rat treated with 0.25 mg POT was a squamous cell carcinoma, a tumor that develops spontaneously in about 1 per 1700 rats. The incidence of mesothelial cell hyperplasia was 4/17, 7/16, and 10/14 and the incidence of malignant mesothelioma was 3/17, 1/16, and 2/14 in the 0.25 mg POT, 0.5 mg POT, and MWCNT-7 treated groups, respectively. Neither mesothelial cell hyperplasia nor mesothelioma developed in control rats or the rats treated with r-nTiO2. Since the incidence of spontaneously occurring malignant mesothelioma in rats is extremely low, approximately 1 per 1000 animals (Japan Bioassay Research Center [JBRC] historical control data), the development of multiple malignant mesotheliomas in the POT and MWCNT-7 treated groups was biologically significant. CONCLUSION: The incidence of pleural mesotheliomas in male F344 rats administered POT fibers and MWCNT-7 was significantly higher than the JBRC historical control data, indicating that the incidence of pleural mesothelioma in the groups administered POT fibers and MWCNT-7 fibers via the airway using TIPS was biologically significant. The incidence of type II epithelial cell hyperplasia and the histology of the carcinomas that developed in the POT treated rats also indicates that respirable POT fibers are highly likely to be carcinogenic in the lungs of male F344 rats.

Pulmonary and pleural toxicity of potassium octatitanate fibers, rutile titanium dioxide nanoparticles, and MWCNT-7 in male Fischer 344 rats.

Potassium octatitanate (K2O·8TiO2, POT) fibers are used as an alternative to asbestos. Their shape and biopersistence suggest that they are possibly carcinogenic. However, inhalation studies have shown that respired POT fibers have little carcinogenic potential. We conducted a short-term study in which we administered POT fibers, and anatase and rutile titanium dioxide nanoparticles (a-nTiO2, r-nTiO2) to rats using intra-tracheal intra-pulmonary spraying (TIPS). We found that similarly to other materials, POT fibers were more toxic than non-fibrous nanoparticles of the same chemical composition, indicating that the titanium dioxide composition of POT fibers does not appear to account for their lack of carcinogenicity. The present report describes the results of the 3-week and 52-week interim killing of our current 2-year study of POT fibers, with MWCNT-7 as a positive control and r-nTiO2 as a non-fibrous titanium dioxide control. Male F344 rats were administered 0.5 ml vehicle, 62.5 µg/ml and 125 µg/ml r-nTiO2 and POT fibers, and 125 µg/ml MWCNT-7 by TIPS every other day for 2 weeks (eight doses: total doses of 0.25 and 0.50 mg/rat). At 1 year, POT and MWCNT-7 fibers induced significant increases in alveolar macrophage number, granulation tissue in the lung, bronchiolo-alveolar cell hyperplasia and thickening of the alveolar wall, and pulmonary 8-OHdG levels. The 0.5 mg POT- and the MWCNT-7-treated groups also had increased visceral and parietal pleura thickness, increased mesothelial cell PCNA labeling indices, and a few areas of visceral mesothelial cell hyperplasia. In contrast, in the r-nTiO2-treated groups, none of the measured parameters were different from the controls.

Identification of Gene Transcription Start Sites and Enhancers Responding to Pulmonary Carbon Nanotube Exposure in Vivo.

Increased use of nanomaterials in industry, medicine, and consumer products has raised concerns over their toxicity. To ensure safe use of nanomaterials, understanding their biological effects at the molecular level is crucial. In particular, the regulatory mechanisms responsible for the cascade of genes activated by nanomaterial exposure are not well-characterized. To this end, we profiled the genome-wide usage of gene transcription start sites and linked active enhancer regions in lungs of C57BL/6 mice 24 h after intratracheal instillation of a single dose of the multiwalled carbon nanotube (MWCNT) Mitsui-7. Our results revealed a massive gene regulatory response, where expression of key inflammatory genes (e.g., Csf3, Il24, and Fgf23) was increased >100-fold 24 h after Mitsui-7 exposure. Many of the Mitsui-7-responsive transcription start sites were alternative transcription start sites for known genes, and the number of alternative transcription start sites used in a given gene was correlated with overall Mitsui-7 response. Strikingly, genes that were up-regulated after Mitsui-7 exposure only through their main annotated transcription start site were linked to inflammatory and defense responses, while genes up-regulated only through alternative transcription start sites were functionally heterogeneous and not inflammation-associated. Furthermore, we identified almost 12 000 active enhancers, many of which were Mitsui-7-responsive, and we identified similarly responding putative target genes. Overall, our study provides the location and activity of Mitsui-7-induced enhancers and transcription start sites, providing a useful resource for targeted experiments elucidating the biological effects of nanomaterials and the identification of biomarkers for early detection of MWCNT-induced inflammation.

Acute in vitro and in vivo toxicity of a commercial grade boron nitride nanotube mixture.

Boron nitride nanotubes (BNNTs) are an emerging engineered nanomaterial attracting significant attention due to superior electrical, chemical and thermal properties. Currently, the toxicity profile of this material is largely unknown. Commercial grade BNNTs are composed of a mixture (BNNT-M) of ∼50-60% BNNTs, and ∼40-50% impurities of boron and hexagonal boron nitride. We performed acute in vitro and in vivo studies with commercial grade BNNT-M, dispersed by sonication in vehicle, in comparison to the extensively studied multiwalled carbon nanotube-7 (MWCNT-7). THP-1 wild-type and NLRP3-deficient human monocytic cells were exposed to 0-100 µg/ml and C57BL/6 J male mice were treated with 40 µg of BNNT-M for in vitro and in vivo studies, respectively. In vitro, BNNT-M induced a dose-dependent increase in cytotoxicity and oxidative stress. This was confirmed in vivo following acute exposure increase in bronchoalveolar lavage levels of lactate dehydrogenase, pulmonary polymorphonuclear cell influx, loss in mitochondrial membrane potential and augmented levels of 4-hydroxynonenal. Uptake of this material caused lysosomal destabilization, pyroptosis and inflammasome activation, corroborated by an increase in cathepsin B, caspase 1, increased protein levels of IL-1ß and IL-18 both in vitro and in vivo. Attenuation of these effects in NLRP3-deficient THP-1 cells confirmed NLRP3-dependent inflammasome activation by BNNT-M. BNNT-M induced a similar profile of inflammatory pulmonary protein production when compared to MWCNT-7. Functionally, pretreatment with BNNT-M caused suppression in bacterial uptake by THP-1 cells, an effect that was mirrored in challenged alveolar macrophages collected from exposed mice and attenuated with NLRP3 deficiency. Analysis of cytokines secreted by LPS-challenged alveolar macrophages collected after in vivo exposure to dispersions of BNNT-M showed a differential macrophage response. The observed results demonstrated acute inflammation and toxicity in vitro and in vivo following exposure to sonicated BNNT-M was in part due to NLRP3 inflammasome activation.