SavorPhos as an all-natural phosphate replacer in water- and oil-based marinades for rotisserie birds and boneless-skinless breast.

As consumer demand for all-natural marinades increases, the need to replace phosphate with a natural product that can produce equivalent or improved yield in products such as but not limited to rotisserie chickens (whole birds without giblets) and boneless/skinless breast (BSB) is a challenge for processors. The objective of this study was to determine if using an all-natural nonphosphate blend (SavorPhos-200, SP) in water-based (WB) and oil-based (OB) marinades would perform better than a commercial phosphate blend (PB). The treatments included WB+PB (water, 0.4% phosphate, 0.7% salt), WB+SP (water, 0.5% SavorPhos-200, 0.7% salt), OB+PB (water, 3% oil, 0.4% phosphate, 0.7% salt), and OB+SP (water, 3% oil, 0.5% SavorPhos-200, 0.7% salt). The rotisserie chickens and BSB were injected with a multineedle injector to 20% (wt/wt) pickup at a constant pressure (103-138 kPa). The parameters measured were marinade pickup %, 20-min and 24-h marinade retention %, and cook loss %. Color, tenderness, total moisture, and sensory test were conducted on BSB. Data were analyzed within marinade type (WB and OB). Rotisserie birds picked up and retained the same yield in WB marinades. In OB marinades, SP had higher yields postinjection and lower cook loss % than the PB, while retaining the same yield over 24 h. For BSB, the cook loss was lower in SP than the PB in WB marinades. Higher yields postinjection were achieved with OB, but had the same retention 20 min and 24 h postinjection and cook loss % as the PB. No differences were observed for total moisture or L* (lightness) within marinade type and treatment. Texture was lower, indicating increased tenderness (P < 0.05) on SP samples in both marinades. However, consumers were not able to distinguish between treatments in sensory analyses. Therefore, SavorPhos-200 can be used as a natural nonphosphate blend in WB marinades with no detriment to yield. In addition, SavorPhos-200 can be used as a natural nonphosphate blend in OB marinades with yield improvements.

Marination and packaging impact on textural properties of home-frozen broiler breast fillets.

Different packaging is available to consumers, and marination is widely applied. However, their effects on the quality of broiler breast fillets during home freezing are not well known to consumers. Therefore, the objective of this study was to evaluate the effect of packaging materials on the quality of chicken breast fillets after 1, 3, and 6 wk storage at -18°C. A total of 256 fillet were randomly placed in tray packs, freezer bags, butcher paper, and nonpackaged controls. Samples were analyzed for raw pH, color, percent moisture content, and TBA reactive substances (TBARS) at d 0 (only nonpackaged controls), wk 1, 3, and 6, and cooked texture and sensory attributes at wk 1 and 6. There were differences (P < 0.05) in pH, color, percent moisture content, and texture among the treatments by wk 6, but no differences (P < 0.05) in TBARS values and the sensory evaluation (tenderness, juiciness, and overall flavor) were seen. Consumers were not able to detect quality differences (P < 0.05) among treatments despite analytical differences. Experiment 2 was conducted to evaluate the effects of marination on the quality of chicken breast fillets after 2 wk of storage in a home freezer (-18°C). A total of 240 fillets were used in the treatments: nonmarinated fresh nonfrozen, nonmarinated frozen, marinated fresh nonfrozen, and marinated frozen. Fillets were vacuum-tumbled in a 10% solution yielding a final concentration of 0.45% sodium tripolyphosphate and 0.65% salt in the meat. Raw samples were evaluated for color, TBARS, and thaw loss. Cooked samples after 2 wk of storage were analyzed for cook loss, texture, moisture, and sensory evaluation (color, juiciness, tenderness, overall flavor, and preference). Both marinated samples showed better (P < 0.05) quality in terms of L* value, TBARS, cook loss, texture, moisture content, and better sensory attributes (except color) than nonmarinated samples. Quality of marinated samples was not negatively affected by home freezing after 2 wk.

Quality and safety of broiler meat in various chilling systems.

Chilling is a critical step in poultry processing to attain high-quality meat and to meet the USDA-Food Safety and Inspection Service temperature standards. This study was conducted to determine the effects of commercially available chilling systems on quality and safety of broiler meat. A total of 300 carcasses in 2 replications were randomly selected from a commercial processor and subjected to 3 systems: immersion chill (IC), air chill (AC), and combi in-line air chill (CIAC). Incidence of Salmonella and Campylobacter were determined on pre- and postchilled carcasses. Quality of the meat was evaluated by carcass yield, drip loss, cook loss, texture, moisture content, sensory qualities, and color (L*, a*, and b*) of boneless skinless breast fillets and skin-on drums. Shelf life of whole carcasses, breast fillets, and drums was also determined. The IC resulted in the most reduction of Salmonella (39.7%) and Campylobacter (43%) incidence due to the washing effect and presence of chlorine in the chilled water. There was no significant difference in shelf-life when comparing the chilling methods. The IC had the highest (P < 0.05) carcass yield (6.5%), followed by CIAC (+1.98.0%) and then AC (-1.10%). Drip loss, cook loss, and moisture content of breast fillets were not significantly different for all the chilling systems, but higher L* value was observed for breast fillets at 24 h postmortem treated with IC and CIAC. However, IC exhibited the lightest color and AC was darkest in the drum samples. Shear force of breast meat was significantly more tender for AC and CIAC. There were no differences in the sensory qualities of breast fillets and drums among the 3 chilling systems.

Attachment of Salmonella serovars and Listeria monocytogenes to stainless steel and plastic conveyor belts.

In poultry industry, cross-contamination due to processing equipment and contact surfaces is very common. This study examined the extent of bacterial attachment to 6 different types and design of conveyor belts: stainless steel-single loop, stainless steel-balance weave, polyurethane with mono-polyester fabric, acetal, polypropylene mesh top, and polypropylene. Clean conveyor belts were immersed separately in either a cocktail of Salmonella serovars (Salmonella Typhimurium and Salmonella Enteritidis) or Listeria monocytogenes strains (Scott A, Brie 1, ATCC 6744) for 1 h at room temperature. Soiled conveyor chips were dipped in poultry rinses contaminated with Salmonella or Listeria cocktail and incubated at 10°C for 48 h. The polyurethane with mono-polyester fabric conveyor belt and chip exhibited a higher (P<0.05) mean number of attached Salmonella serovars (clean: 1.6 to 3.6 cfu/cm2; soiled: 0.8 to 2.4 cfu/cm2) and L. monocytogenes (clean: 4.0 to 4.3 cfu/cm2; soiled: 0.3 to 2.1 cfu/cm2) in both clean and soiled conditions. The stainless steel conveyor belt attached a lower (P<0.05) number of Salmonella serovars (clean: 0 to 2.6 cfu/cm2; soiled: 0.4 to 1.3 cfu/cm2) and L. monocytogenes (clean: 0.4 to 2.9 cfu/cm2; soiled: 0 to 0.7 cfu/cm2) than the polymeric materials, indicating weaker adhesion properties. Plastic conveyor belts exhibited stronger bacterial adhesion compared with stainless steel. The result suggests the importance of selecting the design and finishes of conveyor belt materials that are most resistant to bacterial attachment.

Postrigor tumble marination strategies for improving color and water-holding capacity in normal and pale broiler breast fillets.

Pale or pale, soft, and exudative-like meat can be caused by a decline in pH early postmortem while carcass temperatures are still high. This decrease in pH leads to protein denaturation, attributing to the pale color and poor water-holding capacity that is characteristic of this lesser quality meat. Marination with NaCl and phosphates has been shown to improve protein functionality, thereby reducing lost meat yield and improving meat quality. However, there are few studies relating marination with phosphates to improvements in pale meat. Therefore, the purpose of this experiment was to determine if meat quality improvements could be obtained in pale meat via marination with various phosphate and NaCl treatments without altering the quality and stability of normal or pale meat. The treatments used in this study were 1) sodium tripolyphosphate, an industry control; 2) a high pH phosphate (11.9); 3) a sodium tripolyphosphate and high pH mixture; 4) an agglomerated phosphate; and 5) a nonagglomerated phosphate. The marinades used in this study increased the pH, decreased the L* values of the pale fillets, and improved water-holding capacity. There were no significant differences in overall flavor preference for any of the 5 phosphate treatments. There was also no difference in oxidation or shelf-life trends in either the pale or normal fillets marinated with each of the 5 treatments. The results of this study were that marination with phosphates can be used to marinate pale meat without altering flavor, increasing the development of oxidation, or reducing shelf life.

Validation of a lactic acid- and citric acid-based antimicrobial product for the reduction of Escherichia coli O157: H7 and Salmonella on beef tips and whole chicken carcasses.

The objectives of this study were to determine the effects of a lactic acid- and citric acid-based antimicrobial product on the reduction of Salmonella on whole broiler carcasses during processing and the reduction of Salmonella and Escherichia coli O157:H7 on beef trim. Freshly harvested broiler carcasses were inoculated with an inoculum of Salmonella strains to yield a 10(5) CFU/ml pathogen load on the surface of the carcass. The beef tips were inoculated as well with an inoculum of either E. coli O157:H7 or Salmonella to yield 10(4) CFU/100 cm(2). After 30 min for attachment, the broiler carcasses were treated with Chicxide applied for 5 s via a spray or immersed in Chicxide for 5, 10, or 20 s. Broiler carcasses were rinsed in poultry rinse bags with 400 ml of Butterfield's phosphate buffer in which Salmonella was enumerated from the diluents and Butterfield's phosphate. Chicxide significantly reduced Salmonella by 1.3 log CFU/ml with spray treatment and 2.3 log CFU/ml for all dip treatments. Following 30 min of attachment, the beef tips were placed into a spray cabinet with either Beefxide or sterilized water (control) and sprayed at 1 ft/2.5 s chain speed at 40 lb/in(2). The external surface of each beef tip was swabbed (100 cm(2)) to determine pathogen loads. Beefxide significantly reduced E. coli O157:H7 by 1.4 log CFU/100 cm(2) and Salmonella by 1.1 log CFU/100 cm(2) (P < 0.05) compared with the control samples.

Research developments in pale, soft, and exudative turkey meat in North America.

Pale, soft, and exudative (PSE) refers to meat that is pale in color, forms soft gels, and has poor water-holding ability. Most frequently used in reference to pork, this defective meat is being seen with increasing frequency in turkey and broiler processing plants. It has been estimated that this PSE-type meat represents 5 to 40% of meat that is produced in the poultry industry. With the increased production of further-processed products, this PSE problem has become more apparent in the turkey industry. It has been estimated that due to the high incidence, a single turkey processing plant could be losing $2 to 4 million per year, resulting in a loss in excess of $200 million dollars by the turkey industry alone.

Control of Listeria monocytogenes in turkey deli loaves using organic acids as formulation ingredients.

The growth of Listeria monocytogenes in further-processed meat products has become a major concern and an important food safety issue. The meat and poultry industries have incorporated interventions such as organic acids in marinades to inhibit the growth of L. monocytogenes. In this study, organic acids were utilized in the raw product and as a postcook dip to determine their inhibitory effect on the growth of L. monocytogenes in turkey deli loaves. The turkey deli loaves were processed, cooked, cooled, inoculated with streptomycin-resistant L. monocytogenes, and then dipped. Treatments were potassium lactate (PL) in the raw product with sodium lactate (SL), sodium diacetate (SD) dip, PL with SL/PL/SD dip, SL with SL/SD dip, and SL with SL/PL/SD dip. There was also a positive (inoculated) and negative (noninoculated) control, which was dipped in distilled water. Days 0, 7, 14, 21, 28, 42, and 56 were sampled for L. monocytogenes. There were no differences (P>0.05) among the organic acid treatments in the turkey deli loaves at any time points; therefore, all of the treatments increased the lag phase of L. monocytogenes, extending the shelf-life of the product. However, there was a difference between the treatments and the positive control at d 7, 14, 21, 28, 42, and 56. The growth of L. monocytogenes increased immediately in the positive control, whereas the negative control appeared to have no growth. These organic acids can provide meat processors with a useful method for extending the lag phase of L. monocytogenes in ready-to-eat meat and poultry products.

Comparison of quality attributes of shell eggs subjected to directional microwave technology.

Microwaves have been shown to cause thermal as well as nonthermal destruction of pathogens such as Salmonella, which can be found in shell eggs. The objective of this study was to determine if using microwave technology would cause detrimental quality effects in shell eggs. Treatments included control (no treatment) and microwave-treated (20 s) shell eggs. There were no differences in mineral content, fatty acid profile, Haugh units, broken-out score, yolk index, emulsion stability, pH of whole egg, and foaming capacity between 2 treatments (P >or= 0.05). At 0 and 30 d, there were no noticeable differences in H(2)O activity between 2 treatments. The foaming stability and albumen thermocoagulation of microwave-treated eggs were significantly higher than control eggs (P or= 0.05). Therefore, microwave technology can be applied to shell eggs without causing detrimental effects to quality.

Sanitization of Chicken Frames by a Combination of Hydrogen Peroxide and UV Light To Reduce Contamination of Derived Edible Products.

Chicken carcass frames are used to obtain mechanically separated chicken (MSC) for use in other further processed food products. Previous foodborne disease outbreaks involving Salmonella-contaminated MSC have demonstrated the potential for the human pathogen to be transmitted to consumers via MSC. The current study evaluated the efficacy of multiple treatments applied to the surfaces of chicken carcass frames to reduce microbial loads on noninoculated frames and frames inoculated with a cocktail of Salmonella enterica serovar Enteritidis and Salmonella enterica serovar Typhimurium. Inoculated or noninoculated frames were left untreated (control) or were subjected to treatment using a prototype sanitization apparatus. Treatments consisted of (i) a sterile water rinse, (ii) a water rinse followed by 5 s of UV-C light application, or (iii) an advanced oxidation process (AOP) combining 5 or 7% (v/v) hydrogen peroxide (H2O2) with UV-C light. Treatment with 7% H2O2 and UV-C light reduced numbers of aerobic bacteria by up to 1.5 log CFU per frame (P < 0.05); reductions in aerobic bacteria subjected to other treatments did not statistically differ from one another (initial mean load on nontreated frames: 3.6 ± 0.1 log CFU per frame). Salmonella numbers (mean load on inoculated, nontreated control was 5.6 ± 0.2 log CFU per frame) were maximally reduced by AOP application in comparison with other treatments. No difference in Salmonella reductions obtained by 5% H2O2 (1.1 log CFU per frame) was detected compared with that obtained following 7% H2O2 use (1.0 log CFU per frame). The AOP treatment for sanitization of chicken carcass frames reduces microbial contamination on chicken carcass frames that are subsequently used for manufacture of MSC.

Use of UV light for the inactivation of Listeria monocytogenes and lactic acid bacteria species in recirculated chill brines.

Ready-to-eat meat products have been implicated in several foodborne listeriosis outbreaks. Microbial contamination of these products can occur after thermal processing when products are chilled in salt brines. The objective of this study was to evaluate UV radiation on the inactivation of Listeria monocytogenes and lactic acid bacteria in a model brine chiller system. Two concentrations of brine (7.9% [wt/wt] or 13.2% [wt/wt]) were inoculated with a approximately 6.0 log CFU/ml cocktail of L. monocytogenes or lactic acid bacteria and passed through a UV treatment system for 60 min. Three replications of each bacteria-and-brine combination were performed and resulted in at least a 4.5-log reduction in microbial numbers in all treated brines after exposure to UV light. Bacterial populations were significantly reduced after 5 min of exposure to UV light in the model brine chiller compared with the control, which received no UV light exposure (P < 0.05). The maximum rate of inactivation for both microorganisms in treated brines occurred between minutes 1 and 15 of UV exposure. Results indicate that in-line treatment of chill brines with UV light reduces the number of L. monocytogenes and lactic acid bacteria.

Comparison of air and immersion chilling on meat quality and shelf life of marinated broiler breast fillets.

Marinated broiler breast fillets were evaluated using both air- and immersion-chilling treatments. Ninety fillets from air-chilled broiler carcasses and 90 fillets from immersion-chilled broiler carcasses were obtained from a processor to determine differences in meat quality, sensory, and shelf life. At 24 h postmortem, the fillets were vacuum-tumbled (25 in Hg, 30 min, 14 rpm, 4 degrees C) in 2 replications per treatment with a 20% solution (wt/wt) yielding 0.70% NaCl and 0.45% sodium tripolyphosphate in the final product. One-third of the fillets in each replication were packaged in a tray covered with plastic wrap and stored in retail cases to simulate retail shelf-life conditions. The remaining fillets were stored at 4 degrees C for 24 h until analysis for marinade retention, cook loss, consumer evaluation, and objective tenderness. The immersion-chilled fillets had a significantly lower pH (5.56) and were lighter (L* 54.73) when compared with the air-chilled fillets (5.64, L* 50.13, respectively). The air-chilled fillets had a significantly higher marinade pickup (15.51%) than the immersion-chilled (14.07%) fillets. However, there were no significant differences in cook loss percentage in either treatment (approximately 20.03). Shear value was significantly higher in the immersion-chilled fillets (4.14 N), indicating less tender meat than the air-chilled fillets (3.62 N). In the consumer analyses, the air-chilled fillets were significantly different. Of the respondents that noted differences, 19% indicated differences in texture, and 9.67% indicated taste differences. The air-chilled treatment had significantly lower aerobic plate count in postpackaging d 0, 3, and 9. Also, coliforms were significantly lower in the air-chilled treatment through d 6. Therefore, air chilling carcasses may improve color, marination yield, tenderness, and increase the shelf life of retail-packaged broiler breast fillets.

Reduction of Salmonella Enteritidis in shell eggs using directional microwave technology.

Microwaves have been shown to cause thermal as well as nonthermal destruction of pathogens such as Salmonella Enteritidis, which is commonly found in shell eggs. The objective of this study was to examine the use of new directional microwave technology to reduce Salmonella Enteritidis without causing any detrimental effects on quality in white and brown eggs. Treatments were control and microwaved white and brown eggs. Applying directional microwave technology resulted in a 2-log reduction of Salmonella Enteritidis in both the high (10(5) cfu/g) and low (10(2) cfu/g) inoculum. At d 0, there were no differences in water activities, albumen pH, and combined pH between treatments; however, there were significant changes in yolk pH. Collectively, these results indicate that applying directional microwave technology can reduce Salmonella Enteritidis in shell eggs without causing any detrimental effects to quality.

Descriptive sensory and instrumental texture profile analysis of woody breast in marinated chicken.

The broiler industry is currently experiencing a muscle anomaly referred to as "woody breast," and the effect of different cooking methods on the marination properties of severe woody breast (SWB) has not yet been reported. This study compared the texture attributes of marinated (injected) normal (NOR) and SWB using a convection oven and a flat-top grill. The objectives were 1) to develop and validate a descriptive texture attribute panel with 6 trained panelists using a 16-point scale and 2) to evaluate the instrumental texture profile analysis (TPA) using a texture analyzer. Sixty-four NOR and SWB were obtained from a commercial facility. Fillet color (L*, a*, b*) and pH were measured before marination. In each of 2 trials, the breast muscles were injected in bulk with 15% brine (0.48 STPP, 0.55% NaCl, final concentration), and marinade retention was determined after 20 minutes. The meat was vacuum packaged, stored at -20°C (7 d sensory; 29 d TPA) and then thawed (4°C, 24 h). Fillets were cooked to 73°C on a flat-top grill (176°C) or in an oven (176°C), and cook loss % was determined. Panelist samples (2 × 2 cm) and TPA samples (4 × 2 cm) were cut into 3 pieces. Color and pH were higher for SWB than NOR fillets (P < 0.05). Marinade retention was 83.21% for NOR meat and 59.23% for SWB meat. The flat-top grill method resulted in higher cook loss than oven (P < 0.05). SWB had higher cook loss when compared to NOR (P < 0.05). Sensory texture descriptors springiness, hardness, denseness, cohesiveness, fracturability, fibrousness, crunchiness, and chewiness were higher for SWB than NOR fillets (P < 0.05). TPA attributes also showed higher values for SWB compared to NOR (P < 0.05). No differences in texture were found between the grill and oven for sensory and TPA attributes. In summary, marinated SWB has significant texture differences when compared to NOR, regardless of cooking method.

Utilizing original XPC™ in feed to reduce stress susceptibility of broilers.

Reduction of stress is an important factor in improving poultry welfare, especially during periods of heat stress. A study was conducted to evaluate the effects of feeding the functional metabolites of Diamond V Original XPCTM to broilers reared under ambient or heat stress temperatures. Dietary treatments included: control feed (CON) and Original XPC fed continuously at 1.25 kg/MT (XPC). Half the birds in each dietary treatment were subjected to either no heat stress (24°C constant) or heat stress (35°C:24°C for 18:6 h daily) from 28 to 42 d. At the end of the heat stress period, blood was collected from 40 birds/treatment. Blood was analyzed for plasma corticosterone (CORT), plasma HSP70 (HSP70), and heterophil/lymphocyte ratios (H/L). At 42 d, bilateral metatarsal traits were also measured in 40 birds/treatment to assess physical asymmetry. Birds fed XPC had significantly lower CORT levels than CON (P < 0.001; 5,129 ± 617 vs. 8,433 ± 730, respectively). Physical asymmetry scores were also significantly higher in CON compared to XPC fed broilers (P < 0.001; 1.50 ± 0.13 vs. 0.54 ± 0.05, respectively). H/L ratios were significantly greater in CON than for XPC birds (P = 0.01; 0.81 ± 0.05 mm vs. 0.62 ± 0.05 mm, respectively). No differences were observed between CON and XPC fed broilers in HSP70. However, heat stress did increase (P < 0.0001) HSP70 compared to no heat stress birds (5.65 ± 0.12 vs. 4.78 ± 0.11 pg/mL, for heat stress and no heat stress, respectively). Feeding XPC to broiler chickens improved animal welfare via reduced stress indicators while under heat stress or no heat stress conditions. These results indicate that feeding XPC may improve poultry welfare by reducing heat stress susceptibility.

The effect of blood removal on oxidation and shelf life of broiler breast meat.

Blood components, especially hemoglobin, are powerful promoters of lipid oxidation and may decrease the shelf life of meat products. Therefore, this study examined different slaughter techniques to determine their effects on pH (24 h), color (L*a*b* values at 24 h), lipid oxidation, residual hemoglobin concentration (24 h), and sensory evaluation (d 1 and 4 postmortem; PM) in broiler breast fillets. The treatments included 1) CO(2) slaughter and not bled, 2) no stunning and bled, 3) electrical stunning (ES) and bled, 4) CO(2) stunning and bled, and 5) ES and decapitation. The birds were conventionally processed, and analyses were performed at 24 h PM except residual hemoglobin for which the samples were frozen (-80 degrees C) until analyses ( < 2 mo). There were no significant differences in pH or b* values at 24 h PM among any of the treatments. L* values were significantly higher, indicating lighter fillets in the ES and decapitated birds compared with the darker fillets from the CO(2) stunned and bled birds. The CO(2) slaughter and not bled birds had significantly higher a* values, indicating more red color, when compared with the ES and bled and decapitated birds. There were no significant differences in the residual hemoglobin contents in the broiler breast muscle when comparing all of the treatments except CO(2) slaughter and not bled, which was significantly (around 15%) greater. Overall TBA-reactive substances (TBARS; raw, cooked at 24 h, and cooked at 72 h PM) indicated that ES and bled birds had the lowest TBARS when compared with the remaining treatments. Consumer panels detected increased aroma (chicken meaty and warmed-over aromas) and flavor (chicken meaty and warmed-over flavors) in not bled samples at 24 h PM. By 72 h PM, however, there were no significant differences in aroma or flavor. Therefore, different slaughter and bleeding method may affect color and sensory properties of the broiler breast fillets, and the ES and decapitation method had the most favorable results for sensory quality.

Marination of turkey breast fillets to control the growth of Listeria monocytogenes and improve meat quality in deli loaves.

Turkey deli loaves were evaluated using organic marinades in the raw product to control the growth of Listeria monocytogenes (LM) and improve meat quality in the cooked product. Treatments included sodium tripolyphosphate (STP; 0.45%, control), sodium lactate (3%), sodium diacetate (0.25%), sodium citrate (0.75%), and sodium lactate (3%)/sodium diacetate (0.25%) combination, all containing 1.5% salt. Data collected in the 2 trials included pH; lightness, redness, and yellowness; bind ability; cooked meat moisture; oxidation (thiobarbituric acid reactive substances); aerobic plate count (d 0 to 80); and sensory evaluation. Also, thirty-two slices from each loaf were inoculated with a 10(3) cfu/ mL surface inoculum streptomycin-resistant LM cocktail and analyzed for LM levels (d 0 to 77). The sodium lactate treatment was lower in pH (5.84) postmarination. Lactate, citrate, and the combination treatments had significantly lower lightness values; lactate, diacetate, and citrate had higher redness values; and lactate had lower yellowness values postmarination compared with premarination. Cook loss, moisture, and bind ability were higher in the STP treatment. Citrate and the combination treatments had lower thiobarbituric acid reactive substances on d 3, but there were no differences by d 15. Cohesiveness was significantly higher in the STP, lactate, and diacetate treatments, and turkey flavor was more intense in the combination treatment. The STP loaves had >10(6) cfu/cm(2) aerobic plate count by 14 d, lactate by 20 d, citrate by 40 d, diacetate by 70 d, and lactate/diacetate by 74 d. Sodium diacetate, citrate, and lactate/diacetate all extended the lag phase of LM. Therefore, acidic marinades applied in the raw product do have a negative effect on some cooked product quality attributes but do improve shelf life and decrease LM growth by extending the lag phase through 21 d postmortem.

Comparative evaluation of texture wheat ingredients and soy proteins in the quality and acceptability of emulsified chicken nuggets.

Chicken nuggets are commonly made with varying levels of textured vegetable proteins, such as soy and wheat, for their ability to bind water and their meat like conformation. This project compared textured wheat proteins and soy proteins at 10%, 20%, 30%, and 40% in emulsified chicken nuggets. A total of 3,024 chicken nuggets were evaluated in replications for batter breader pickup (%), par fry yield (%), cook loss (%), L*, a*, b* color value, texture profile analysis, and sensory analysis. The analysis was conducted for all 4 concentrations of wheat and soy treatments then compared to each other and an all white meat chicken nugget control. All data were analyzed with an α < 0.05 using SAS with PROC GLM and Duncan's MRT, except for sensory data, which were analyzed as a complete randomized block design using analysis of variance with a α < 0.05 and was analyzed using SAS with PROC GLM. Chicken nuggets prepared with increasing levels of textured soy and wheat proteins exhibited generally similar properties in terms of yields, color, and objective texture. Trained panel sensory analysis indicated an increased detection of soy flavors over wheat flavors at higher inclusion percentages (30% and 40%); however, these results do not have any implication of consumer acceptance.

Meat quality of broiler breast fillets with white striping and woody breast muscle myopathies.

The global poultry industry has been faced with emerging broiler breast meat quality issues including conditions known as white striping (WS, white striations parallel to muscle fibers) and woody breast (WB, hardness of raw fillet). Experiments were conducted to evaluate effects of WS and WB hardness on meat quality traits in broiler breast fillets. In Exp. 1, birds were processed at approximately 9 wk of age and deboned at 4 h postmortem (PM); in Exp. 2, birds were processed at approximately 6 and 9 wk of age and deboned at 2 h PM. Fillets were categorized as: normal for both white striping and woody breast (NORM); moderate for white striping and mild for woody breast (MILD); severe for white striping and mild for woody breast (WS); severe for woody breast and moderate for white striping (WB); or severe for both white striping and woody breast (BOTH). Sarcomere length, gravimetric fragmentation index, marination uptake, cook loss, and Meullenet-Owens razor shear energy (MORSE) values on non-marinated and marinated fillets were assessed. Sarcomeres tended to be longer (P = 0.07) with increasing severity of WS and WB in both experiments and gravimetric fragmentation index did not differ (P > 0.05) among categories. Marinade uptake decreased (P < 0.05) with increasing severity of WS and WB. Cook losses of non-marinated and marinated fillets were greatest (P < 0.05) in the BOTH category. Even though MORSE values did not differ (P > 0.05) in non-marinated fillets, the marinated BOTH fillets had greater MORSE values (P < 0.05) than other categories of fillets in Exp. 1. Non-marinated NORM fillets had greater (P < 0.05) MORSE values than the other categories at 6 wk age; however, MORSE values did not differ (P > 0.05) among categories of marinated breasts. At 9 wk, WS and BOTH were higher (P < 0.05) in MORSE compared to NORM for non-marinated fillets, but similar to NORM marinated fillets. Results suggest that severe degrees of white striping and woody breast, individually or in combination, negatively impact meat quality, especially water holding capacity attributes such as marinade uptake and cook loss.

Utilization of pork collagen for functionality improvement of boneless cured ham manufactured from pale, soft, and exudative pork.

This study was designed to determine the effect of raw material and the inclusion of pork collagen on the protein functionality of boneless cured pork manufactured from 100% pale, soft, and exudative (PSE), 50% PSE, and 0% PSE with either 3 or 0% collagen. A Randomized Complete Block Design with six replications was utilized as the experimental design. Inclusion of collagen decreased (P<0.05) expressible moisture and increased (P<0.05) CIE b* value. Differences (P<0.05) revealed that collagen inclusion caused the 0% PSE treatments to have a lower cooking loss for 100% PSE treatments with and without collagen and a higher protein-protein bind value for 100% PSE treatments without collagen. Utilization of pork collagen in boneless cured pork that incorporates PSE meat increases water holding capacity and has the potential to improve protein functionality characteristics of the product.