Production performance and nitrogen metabolism in dairy cows fed supplemental blends of rumen undegradable protein and rumen-protected amino acids in low- compared with high-protein diets containing corn distillers grains.

Feeding corn dried distillers grains with solubles (DDGS) in low crude protein (CP) diets could limit N waste in lactating cows. However, it also could possibly reduce metabolizable AA supply, especially Lys, and compromise milk production. Therefore, the objective of this study was to evaluate the effects of feeding supplemental blends of rumen undegradable protein (RUP) and rumen-protected (RP) AA in a low compared with high CP diet containing corn DDGS on milk production and selected measures of N utilization. Six multiparous Holstein cows (619.3 ± 49.8 kg of body weight; 26.8 ± 6.2 d in milk) were subjected to a split-plot, 3 × 3 Latin square design (21-d periods) with dietary CP content [low (14.6%; LP) or high (16.6%; HP)] as the whole-plot factor, and blend of RUP and RP-AA [control (CON), no supplement; blend A (0.11 kg/cow per d); or blend B (0.45 kg/cow per d)] as the sub-plot factor. All diets contained 10% corn DDGS; blends of RUP and RP-AA were top-dressed during morning feeding. There was no dietary CP content × supplemental blend interaction for all measured variables. Nutrient (dry matter, organic matter, neutral detergent fiber, acid detergent fiber, and CP), milk and milk component yields, and feed and apparent N efficiency did not differ for cows fed the low- compared with the high-protein diet. However, apparent total-tract CP digestibility, blood and milk urea-N concentrations, and urinary excretion (g/d) of N and urea-N were lower for cows fed the low-protein compared with the high-protein diet. There was no supplemental blend effect on nutrient intake and apparent total-tract digestibility, and milk and milk component yields. Except for a tendency for total urinary purine derivative excretion and microbial N flow to be lower for cows fed blend B compared with CON but not blend A, there was no supplemental blend effect on measures of N utilization. Both dietary CP content and supplemental blend of RUP and RP-AA had a marginal effect on the plasma free AA profile. In summary, reducing dietary CP content in diets containing corn DDGS had no effect on lactation performance, possibly accounting for the lack of a positive response following the provision of supplemental blends of RUP and RP-AA. However, reducing dietary CP content resulted in a decrease in blood and milk urea-N concentrations, and urinary excretion of N and urea-N, suggestive of an improvement in the efficiency of N use.

Impacts of dietary fat level and saturation when feeding distillers grains to high producing dairy cows.

This experiment was conducted to determine whether increasing the net energy (NEL ) of a total mixed ration (TMR) with mainly unsaturated fat from corn distillers dried grains with solubles (DDGS) vs. rumen inert (RI)-saturated fat has similar impacts on animal performance. The experiment was an incomplete Youden square with three treatments and four 28-days periods, completed on a large commercial dairy using three early lactation pens each with approximately 380 multiparity cows. The TMR for all treatments was the same, except for 150 g/kg dry matter (DM) of each TMR which contained 90 g/kg high-protein DDGS (HPDDGS) and 60 g/kg beet pulp (i.e. low-fat control diet; LFC); 150 g/kg DDGS (i.e. high-fat diet with unsaturated fat; HFU); or 111 g/kg HPDDGS, 20 g/kg beet pulp and 19 g/kg RI fat (i.e. high-fat diet with saturated fat; HFS). The DM intake was highest (p < 0.05) for HFU-fed cows. Milk, fat and true protein yields, as well as milk energy output, were higher (p < 0.01) when cows were fed HFS vs. HFU and LFC diets. Milk true protein concentration was lowest (p < 0.01) for HFS-fed cows, but milk fat % was lowest (p < 0.01) for HFU and highest (p < 0.01) for HFS-fed cows. There were numerous differences (p < 0.01) in milk fatty acid levels amongst diets. The increase in body condition score was lowest (p < 0.01) for LFC. Whole tract digestibility of acid detergent fibre was lower (p < 0.01) for LFC vs. HFS cows, and fat digestion was lowest (p < 0.01) for LFC-fed cows. This DDGS, high in unsaturated fatty acids, was fed at high levels (i.e. 152 g/kg DM) with little impact on animal performance vs. a lower fat control diet, although addition of an RI-saturated fat to create a diet with a similarly higher fat level resulted in higher animal productivity.

Ration formulations containing reduced-fat dried distillers grains with solubles and their effect on lactation performance, rumen fermentation, and intestinal flow of microbial nitrogen in Holstein cows.

Sixteen multiparous lactating Holstein cows were used in 2 experiments to evaluate the effects of reduced-fat dried distillers grains with solubles (RFDG) on milk production, rumen fermentation, intestinal microbial N flow, and total-tract nutrient digestibility. In experiment 1, RFDG was fed at 0, 10, 20, or 30% of diet dry matter (DM) to 12 noncannulated Holstein cows (mean ± standard deviation: 89 ± 11 d in milk and 674 ± 68.2 kg of body weight) to determine effects on milk production. In experiment 2, the same diets were fed to 4 ruminally and duodenally cannulated Holstein cows (mean ± standard deviation: 112 ± 41 d in milk; 590 ± 61.14 kg of body weight) to evaluate the effects on rumen fermentation, intestinal flow of microbial N, and total-tract nutrient digestibility. In both experiments, cows were randomly assigned to 4 × 4 Latin squares over 21-d periods. Treatments (DM basis) were (1) control (0% RFDG), (2) 10% RFDG, (3) 20% RFDG, and (4) 30% RFDG. Feed intake and milk yield were recorded daily. In both experiments, milk samples were collected on d 19 to 21 of each period for analysis of milk components. In experiment 2, ruminal pH was measured; samples of rumen fluid, duodenal digesta, and feces were collected on d 18 to 21. Microbial N was estimated by using purines and DNA as microbial markers. Milk yield was not affected by treatment and averaged 34.0 ± 1.29 kg/d and 31.4 ± 2.81 kg/d in experiments 1 and 2, respectively. Percentage of milk protein tended to increase in experiment 1; estimates were 3.08, 3.18, 3.15, and 3.19 ± 0.06% when RFDG increased from 0 to 30% in the diets. However, milk protein concentration was not affected in experiment 2 and averaged 3.02 ± 0.07%. Percentage of milk fat was not affected and averaged 3.66 ± 0.05% and 3.25 ± 0.14% in experiments 1 and 2, respectively. Total ruminal volatile fatty acids and ammonia concentrations were not affected by treatment and averaged 135.18 ± 6.45 mM and 18.66 ± 2.32 mg/dL, respectively. Intestinal microbial N flow was not affected by treatment; however, purines yielded higher estimates of flow compared with DNA markers. When averaged across treatments, intestinal flow of microbial N was 303 and 218 ± 18 g of N/d, using purines and DNA as the markers. Dry matter, organic matter, neutral detergent fiber, and nonfiber carbohydrate digestibility tended to increase with increasing inclusion of RFDG. Results from these experiments indicate that dairy rations can be formulated to include up to 30% RFDG while maintaining lactation performance, volatile fatty acids concentration, and intestinal supply of microbial N.

Live production and carcass characteristics of broilers fed a blend of poultry fat and corn oil derived from distillers dried grains with solubles.

Corn distillers dried grains with solubles (DDGS) are now being further processed to remove corn oil, which may be used as a dietary energy source for poultry. The objectives of this study were to compare the effects of a poultry fat (PF) and a new DDGS-derived corn oil blend (CO) on live performance and carcass characteristics of 49-d-old broilers. Four corn-soybean meal based diets were formulated with differing blends of PF and CO. All diets contained the same percentage of total fat, but differed in the fat source. One diet had the sole source of fat as PF (100:0% PF:CO) and was then replaced with 25% CO, 75% CO, and a 100% replacement of CO. Each of the diets was fed in a 3-phase feeding program to 6 replicate pens. At day of hatch, Ross × Ross 708 broilers were randomly allocated to 24 pens composed of 42 birds of equal sex. On d 49, 10 birds from each pen were processed, and carcass, abdominal fat pad, and breast muscle components were determined. There were no significant differences in live performance for the starter phase (0-18 d). For the grower phase (19-35 d), birds fed 75:25% PF:CO significantly (P ≤ 0.05) increased BW, BW gain, and decreased feed conversion compared with the control (100:0% PF:CO). Birds fed 0:100% PF:CO also observed similar improvements in BW, BW gain, and feed conversion during the grower phase. There were no significant differences for the finisher phase (36-48 d). On d 49, live weights for birds fed the 0:100% PF:CO diets were significantly lower compared with other treatments. A trend for lower carcass and breast weights and increased abdominal fat was also observed for birds fed the 0:100% PF:CO. The addition of CO led to significant improvements in pellet durability for grower and finisher pellets. The results of this study indicate that DDGS-derived CO can be used to partially replace PF in broiler diets without any detrimental effects.

Evaluation of in vitro gas production and rumen bacterial populations fermenting corn milling (co)products.

The objective of this study was to evaluate the fermentation dynamics of 2 commonly fed corn (co)products in their intact and defatted forms, using the in vitro gas production (IVGP) technique, and to investigate the shifts of the predominant rumen bacterial populations using the 16S rDNA bacterial tag-encoded FLX amplicon pyrosequencing (bTEFAP) technique. The bTEFAP technique was used to determine the bacterial profile of each fermentation time at 24 and 48 h. Bacterial populations were identified at the species level. Species were grouped by substrate affinities (guilds) for cellulose, hemicellulose, pectin, starch, sugars, protein, lipids, and lactate. The 2 (co)products were a dried distillers grain (DDG) plus solubles produced from a low-heat drying process (BPX) and a high-protein DDG without solubles (HP). Chemical analysis revealed that BPX contained about 11.4% ether extract, whereas HP contained only 3.88%. Previous studies have indicated that processing methods, as well as fat content, of corn (co)products directly affect fermentation rate and substrate availability, but little information is available regarding changes in rumen bacterial populations. Fermentation profiles of intact and defatted BPX and HP were compared with alfalfa hay as a standard profile. Defatting before incubation had no effect on total gas production in BPX or HP, but reduced lag time and the fractional rate of fermentation of BPX by at least half, whereas there was no effect for HP. The HP feed supported a greater percentage of fibrolytic and proteolytic bacteria than did BPX. Defatting both DDG increased the fibrolytic (26.8 to 38.7%) and proteolytic (26.1 to 37.2%) bacterial guild populations and decreased the lactate-utilizing bacterial guild (3.06 to 1.44%). Information regarding the fermentation kinetics and bacterial population shifts when feeding corn (co)products may lead to more innovative processing methods that improve feed quality (e.g., deoiling) and consequently allow greater inclusion rates in dairy cow rations.

Evaluation of protein fractionation and ruminal and intestinal digestibility of corn milling co-products.

Novel corn milling co-products developed from technological advancements in ethanol production vary widely in chemical composition and nutrient availability. The objectives of this study were to characterize feed protein fractions and evaluate differences in rumen-undegradable protein (RUP) and its digestible fraction (dRUP), amino acid concentration, and in vitro gas production of 7 corn milling co-products. The crude protein (CP; % of dry matter) of co-products was 12.7 for germ, 26.9 for dried distillers grains plus solubles that had no heat exposure before fermentation (DDGS1), 45.4 for high-protein dried distillers grains (HPDDG), 12.7 for bran, 30.2 for wet distillers grains plus solubles (WDGS), 23.1 for wet corn gluten feed (WCGF), and 26.0 for dried distillers grains plus solubles that had heat exposure before fermentation (DDGS2). Two ruminally and duodenally fistulated Holstein steers weighing 663+/-24 kg were used to determine RUP and dRUP with the in situ and mobile bag techniques. Samples of each feed were ruminally incubated for 16 h, and mobile bags were exposed to simulated abomasal digestion before insertion into the duodenum and subsequent collection in the feces. Protein fractions A, B(1), B(2), B(3), and C were characterized as follows (% CP): germ=30.0, 15.0, 38.1, 13.5, 3.4; DDGS1=17.0, 7.0, 67.0, 4.8, 4.2; HPDDG=7.4, 0.6, 82.4, 8.8, 0.8; bran=33.5, 4.0, 54.3, 6.0, 2.2; WDGS=18.6, 2.4, 53.1, 11.0, 14.9; WCGF=36.6, 15.9, 33.2, 10.1, 4.1; and DDGS2=17.9, 2.1, 41.1, 11.1, 27.9. The proportions of RUP and dRUP were different and are reported as follows (% CP): DDGS2=56.3, 91.9; HPDDG=55.2, 97.7; WDGS=44.7, 93.1; DDGS1=33.2, 92.1; bran=20.7, 65.8; germ=16.5, 66.8; and WCGF=11.5, 51.1. The concentrations of Lys and Met in the RUP were different and are listed as follows (% CP): germ=2.9, 2.0; DDGS1=1.9, 2.0; HPDDG=2.0, 3.2; bran=3.2, 1.5; WDGS=1.9, 2.3; WCGF=3.5, 1.6; and DDGS2=1.9, 2.4. In vitro gas production (mL/48h) was highest for germ (52.1) followed by bran (50.1), WDGS (40.7), DDGS2 (40.1), WCGF (39.0), DDGS1 (38.6), and HPDDG (37.5). Comparison of co-products defined differences in chemical composition, protein fractionation, ruminal availability, and microbial fermentation.

Response of lactating dairy cows to high protein distillers grains or 3 other protein supplements.

This study compared high protein dried distillers grains (HPDDG) with soybean meal (SBM), canola meal (CM), and dried distillers grains with solubles (DDGS) as protein supplements in dairy diets. A lactation trial used 12 multiparous cows averaging 78 d in milk at the start of the experiment in a 4 x 4 Latin square design with 28-d periods. Weeks 1 and 2 of each period were used for adjustment and wk 3 and 4 for data collection. Each treatment diet consisted of 55% forage and one of the 4 protein supplements in a concentrate mix. Total mixed diets averaged 15.3% crude protein, with 38% of the protein from one of the 4 protein supplements. Dry matter intake (24.4 kg/d) and crude protein intake (3.57 kg/d) were similar for all 4 diets. Milk production (31.8 kg/d), protein yield (1.05 kg/d), fat yield (1.29 kg/d), and protein percentage (3.31) were similar for all 4 treatment diets. Milk fat percentage was lower when fed DDGS (3.78) than when fed SBM or HPDDG (4.21), but similar with CM (4.07). Feed efficiency (1.44kg of energy-corrected milk/kg of dry matter intake) and nitrogen efficiency (0.29) were not affected by diet. Total milk nitrogen and true milk protein were highest when fed the HPDDG diet. Molar proportions of acetate, propionate, and the acetate to propionate ratio in ruminal contents and ruminal ammonia concentrations were similar for all diets. Arterial and venous concentrations of total essential AA tended to be lower when fed CM, reflecting lower concentrations of His, Ile, Leu, and Val when fed the CM diet. Extraction efficiency of AA from blood by the mammary gland indicated that Met was the first limiting AA when fed the SBM diet, whereas Lys was first limiting for the other diets. Phenylalanine was third limiting with all diets. Feeding HPDDG was equally as effective as feeding SBM, CM, and regular distillers grains as a protein supplement for lactating cows.

Effects of chemical composition variation on the dynamics of ruminal fermentation and biological value of corn milling (co)products.

The objectives of this study were to evaluate the dynamics of gas production of several corn (co)products, to develop equations to predict the rate of ruminal fiber digestion, to estimate total digestible nutrients (TDN) and net energy for lactation (NE(L)), and to assess the stochasticity of chemical composition and nutritive value variability. Four corn milling (co)products were evaluated in this study: high protein dried distillers grains (HP-DDG), corn bran (BRAN) and dehydrated germ (GERM), and a dried distillers grains plus soluble produced with a low-heat drying process (BPX). Alfalfa hay was used as an internal standard feed in the in vitro fermentation dynamics analysis. Standard chemical analyses, in vitro digestibility, and in vitro gas production techniques were used to obtain the necessary physicochemical characterization of feeds. The in vitro dry matter digestibility at 24 and 48 h of incubation decreased exponentially as acid detergent insoluble nitrogen increased. However, the degree of in vitro dry matter digestibility reduction was more accentuated at 24 than at 48 h of incubation. The difference among these feeds regarding the dynamics of the anaerobic fermentation within different substrates (intact feed, and fiber and defatted residues) was evaluated. Results suggested that the proportion of fiber digested in the rumen was affected by the degree of sample processing and fat removal. Fractional fermentation rate (kf) of neutral detergent residue (without sodium sulfite) and defatted fiber residue for BRAN, GERM, HP-DDG, and BPX was estimated to be 0.0635 and 0.0852 h(-1), 0.0803 and 0.0914 h(-1), 0.118 and 0.117 h(-1), and 0.0695 and 0.0844 h(-1), respectively. The most influential variables affecting kf(NDR) of HP-DDG and BPX also affected the predicted TDN, suggesting that fiber quality is essential to ensure higher TDN values for these feeds. Our study indicated that it is possible to routinely quantify the rate of fiber digestion and this approach may be based on common analytical procedures namely estimates of neutral detergent fiber, acid detergent fiber, acid detergent insoluble nitrogen, ether extract, and acid detergent lignin. Our simulations of TDN values demonstrated that differences in fermentability and chemical composition of these corn (co)products might considerably affect the supply of energy to lactating dairy cow. The analytical methods developed in this study may serve as a valuable tool to assess nutrient quality and uniformity when samples differ in chemical composition.

Effects of feeding three types of corn-milling coproducts on milk production and ruminal fermentation of lactating Holstein cattle.

Two experiments were conducted to determine the effects of feeding 3 corn-milling coproducts on intake, milk production, ruminal fermentation, and digestibility of lactating Holstein cows. In experiment 1, three corn-milling coproducts were fed at 15% of the diet dry matter (DM) to 28 Holstein cows averaging (+/-SD) 625 +/- 81 kg of body weight and 116 +/- 33 d in milk to determine effects on DM intake and milk production. In experiment 2, the same rations were fed to 4 ruminally fistulated, multiparous Holstein cows averaging 677 +/- 41 kg of body weight and 144 +/- 5 d in milk to determine the effects on ruminal fermentation and digestibility. In both experiments, cows and treatments were assigned randomly in 4 x 4 Latin squares over four 21-d periods. Treatments were formulated by replacing portions of forage and concentrate feeds with 15% coproduct and included 1) 0% coproduct (control), 2) dried distillers grains plus solubles (DDGS), 3) dehydrated corn germ meal (germ), and 4) high-protein dried distillers grains (HPDDG). Feed intake was recorded daily, and milk samples were collected on d 19 to 21 of each period for analysis of major components. Rumen fluid was collected at 10 time points over 24 h post feeding on d 21 of experiment 2. In experiment 1, DM intake was greater for the germ (24.3 kg/d) and DDGS treatments (23.8 kg/d), but DDGS was not different from the control (22.9 kg/d) and HPDDG treatments (22.4 kg/d). Milk production paralleled DM intake and tended to be greater for the germ (32.1 kg/d) and DDGS treatments (30.9 kg/d), but the DDGS treatment was not different from the control (30.6 kg/d) and HPDDG treatments (30.3 kg/d). However, yields of milk fat, milk protein, and 3.5% FCM were similar and averaged (+/-SEM) 1.1 +/- 0.1, 0.9 +/- 0.03, and 31.7 +/- 1.3 kg/d. Milk urea nitrogen was greater for the HPDDG (15.9 mg/dL) and germ treatments (15.5 mg/dL) than for the control (15.0 mg/dL) and DDGS treatments (14.9 mg/dL). In experiment 2, DM intake and milk production were not different across treatments and averaged 26.1 +/- 2.3 and 28.3 +/- 3.9 kg/d. Ruminal pH (6.26 +/- 0.08) and total concentration of volatile fatty acids (125.3 +/- 4.2 mM) were similar. Acetate concentration was higher for the control treatment than the DDGS, germ, and HPDDG treatments (81.7 vs. 75.8, 75.0, and 78.4 mM). Concentrations of propionate and butyrate were not different and averaged 27.8 +/- 1.2 and 14.3 +/- 0.9 mM across treatments. The acetate:propionate ratios for the control, germ, and HPDDG treatments were greater than for the DDGS treatment (3.02, 2.88, and 2.91 vs. 2.62). Dry matter, organic matter, and neutral detergent fiber digestibilities were similar across treatments and averaged 63.5 +/- 2.7, 67.3 +/- 2.2, and 43.5 +/- 4.2%. Milk production followed DM intake in experiment 1, and yield of major milk components was not affected. Results of these experiments indicate that dairy rations can be successfully formulated to include 15% of diet DM as corn-milling coproducts while maintaining or increasing DM intakes and yields of milk and milk components.

Short communication: The effect of feeding high protein distillers dried grains on milk production of Holstein cows.

The objectives of this study were to evaluate the effects of feeding high-protein distillers dried grains (HPDDG) on rumen degradability, dry matter intake, milk production, and milk composition. Sixteen lactating Holstein cows (12 multiparous and 4 primiparous) averaging 80 +/- 14 d in milk were randomly assigned to 1 of 2 dietary treatments in a 2 x 2 crossover design. A portion of forage and all soy-based protein in the control diet were replaced by HPDDG (20% dry matter). Milk production and dry matter intake were recorded daily and averaged for d 19 to 21 of each 21-d period. Milk samples were collected on d 20 to 21 of each period. Milk yield increased with the inclusion of HPDDG (33.4 vs. 31.6 +/- 2.13 kg/d), and 3.5% FCM was higher for the ration containing HPDDG (36.3 vs. 33.1 +/- 2.24 kg/d). Percentage protein was not affected by treatment (average 3.04 +/- 0.08%), but protein yield increased with inclusion of HPDDG (0.95 to 1.00 +/- 0.05 kg/d). Milk fat concentration was not different between treatments (average 3.95 +/- 0.20%), but fat yield increased for the ration containing HPDDG (1.35 vs. 1.21 +/- 0.09 kg/d). Dry matter intake was not affected and averaged 21.9 +/- 0.80 kg across treatments. Because of greater milk production, feed conversion was improved by the inclusion of HPDDG (1.47 to 1.73 +/- 0.09). Milk urea N was greater for the HPDDG ration than the control (14.5 vs. 12.8 +/- 0.67 mg/dL). This research suggests that HPDDG may effectively replace soy-based protein in lactating dairy cow diets.

Evaluation of corn germ from ethanol production as an alternative fat source in dairy cow diets.

Sixteen multiparous cows (12 Holstein and 4 Brown Swiss, 132 +/- 20 d in milk) were used in a replicated 4 x 4 Latin square design with 4-wk periods to determine the effects of feeding corn germ on dairy cow performance. Diets were formulated with increasing concentrations of corn germ (Dakota Germ, Poet Nutrition, Sioux Falls, SD) at 0, 7, 14, and 21% of the diet dry matter (DM). All diets had a 55:45 forage to concentrate ratio, where forage was 55% corn silage and 45% alfalfa hay. Dietary fat increased from 4.8% in the control diet to 8.2% at the greatest inclusion level of corn germ. The addition of corn germ resulted in a quadratic response in DM intake with numerically greater intake at 14% of diet DM. Feeding corn germ at 7 and 14% of diet DM increased milk yield and energy-corrected milk as well as fat percentage and yield. Milk protein yield tended to decrease as the concentration of corn germ increased in the diet. Dietary treatments had no effect on feed efficiency, which averaged 1.40 kg of energy-corrected milk/kg of DMI. Increasing the dietary concentration of corn germ resulted in a linear increase in milk fat concentrations of monounsaturated and polyunsaturated fatty acids at the expense of saturated fatty acids. Milk fat concentration and yield of cis-9, trans-11 and trans-10, cis-12 conjugated linoleic acid were increased with increased dietary concentrations of corn germ. Although milk fat concentrations of both total trans-18:1 and cis-18:1 fatty acids increased linearly, a marked numeric increase in the concentration of trans-10 C18:1 was observed in milk from cows fed the 21% corn germ diet. A similar response was observed in plasma concentration of trans-10 C18:1. Feeding increasing concentrations of corn germ had no effect on plasma concentrations of glucose, triglyceride, or beta-hydroxybutyrate; however, the concentration of nonesterified fatty acids increased linearly, with plasma cholesterol concentration demonstrating a similar trend. Germ removed from corn grain before ethanol production provides an alternative source of fat for energy in lactating dairy cows when fed at 7 and 14% of diet DM. Our results suggest that fat from corn germ may be relatively protected with no adverse effect on DM intake, milk production, and milk composition when fed up to 14% of diet DM.

Conjugated linoleic acid increases in milk from cows fed condensed corn distillers solubles and fish oil.

Twelve lactating Holstein cows were randomly assigned to 1 of 4 experimental diets in a replicated 4 x 4 Latin square design with 4-wk periods to ascertain the lactational response to feeding fish oil (FO), condensed corn distillers solubles (CDS) as a source of extra linoleic acid, or both. Diets contained either no FO or 0.5% FO and either no CDS or 10% CDS in a 2 x 2 factorial arrangement of treatments. Diets were fed as total mixed rations for ad libitum consumption. The forage to concentrate ratio was 55:45 on a dry matter basis for all diets and the diets contained 16.2% crude protein. The ether extract concentrations were 2.86, 3.22, 4.77, and 5.02% for control, FO, CDS, and FOCDS diets, respectively. Inclusion of FO or CDS or both had no effect on dry matter intake, feed efficiency, body weight, and body condition scores compared with diets without FO and CDS, respectively. Yields of milk (33.3 kg/d), energy-corrected milk, protein, lactose, and milk urea N were similar for all diets. Feeding FO and CDS decreased milk fat percentages (3.85, 3.39, 3.33, and 3.12%) and yields compared with diets without FO and CDS. Proportions of trans-11 C18:1 (vaccenic acid), cis-9 trans-11 conjugated linoleic acid (CLA; 0.52, 0.90, 1.11, and 1.52 g/100 g of fatty acids), and trans-10 cis-12 CLA (0.07, 0.14, 0.13, and 0.16 g/100 g of fatty acids) in milk fat were increased by FO and CDS. No interactions were observed between FO and CDS on cis-9 trans-11 CLA although vaccenic acid tended to be higher with the interaction. The addition of CDS to diets increased trans-10 C18:1. Greater ratios of vaccenic acid to cis-9 trans-11 CLA in plasma than in milk fat indicate tissue synthesis of cis-9 trans-11 CLA in the mammary gland from vaccenic acid in cows fed FO or CDS. Feeding fish oil at 0.5% of diet dry matter with a C18:2 n-6 rich source such as CDS increased the milk CLA content but decreased milk fat percentages.

The feeding value of corn distillers solubles for lactating dairy cows.

Fifteen Holstein cows (10 multiparous and 5 primiparous) in early to mid lactation (79.3 +/- 9.2 d in milk) were used in a multiple 5 x 5 Latin square design with 4-wk periods to evaluate and compare the use of condensed corn distillers solubles (CCDS) and dried distillers grains with solubles (DDGS) in the total mixed ration. The forage portion of the diets was kept constant at 27.5% corn silage and 27.5% alfalfa hay (dry matter basis). Diets were 1) 0% distillers grains products (control); 2) 18.5% DDGS; 3) 10% CCDS; 4) 20% CCDS; and 5) a combination diet of 18.5% DDGS with 10% CCDS. Diets 2 and 3 contained 2% fat from DDGS or CCDS, whereas diet 4 contained 4% fat from CCDS and diet 5 contained 4% fat from the blend of DDGS and CCDS. The diets were balanced to provide 17% crude protein with variation in acid detergent fiber, neutral detergent fiber, and fat concentration. Dry matter intake (21.5 kg/d) was similar for all diets. Milk yield (33.8, 36.2, 35.5, 36.0, and 36.0 kg/d) tended to be greater for diets 2 to 5 than for diet 1, whereas yields of fat (1.04 kg/d), protein (1.02 kg/d), fat percentage (2.94), and protein percentage (2.98) were similar for all diets. Energy-corrected milk (32.2 kg/d) and feed efficiency (1.58 kg of energy-corrected milk/kg of dry matter intake) were similar for all diets. Milk urea nitrogen (15.0, 10.9, 11.1, 11.0, and 11.4 mg/dL) as well as blood urea nitrogen (15.6, 12.5, 14.6, 13.8, and 14.2 mg/dL) were decreased in diets 2 to 5 compared with diet 1. Milk concentrations of long-chain fatty acids as well as polyunsaturated fatty acids were greater and medium-chain fatty acid concentrations were lower for diets 2 to 5 compared with diet 1. Concentrations of cis-9, trans-11 conjugated linoleic acid (CLA; 0.33, 0.68, 0.51, 0.85, and 1.07 g/100 g of fatty acids) as well as trans-10, cis-12 CLA (<0.01, 0.01, <0.01, 0.02, and 0.02 g/100 g of fatty acids) were greater for diets 2 to 5 compared with diet 1. Molar proportions of ruminal acetate decreased and propionate increased for diets 2 to 5 compared with diet 1. The results showed that CCDS is as effective as DDGS in replacing soybean meal and corn grain in the total mixed ration.

Short communication: Effect of increasing levels of corn bran on milk yield and composition.

Thirty-nine lactating Holstein cows (23 multiparous and 16 primiparous) were randomly assigned to 1 of 3 dietary treatments in a crossover design. Dietary treatments differed by the proportion of corn bran [10, 17.5, and 25% dry matter (DM); designated as low, medium, and high] replacing corn silage and alfalfa. The corn bran coproduct contained 8.2% moisture and 12.9% crude protein, 30.4% neutral detergent fiber (NDF), and 45.0% nonfiber carbohydrate, 9.9% ether extract, and 0.70% P (DM basis). The low treatment consisted of 15.8% NDF from forage (fNDF) and 33.1% total NDF; the medium treatment consisted of 12.9% fNDF and 32.5% total NDF; and the high diet contained 9.9% fNDF and 31.8% total NDF. Dry matter intake was not affected by treatment. The percent milk fat decreased by 0.26% with the inclusion of corn bran from 10 to 25% of the diet DM, but total milk fat yield was not affected. In comparison, corn bran increased yield of milk protein 0.12 kg/d when bran increased from 10 to 25% of the diet DM. Total milk yield tended to increase when bran increased from 10 to 25% of the diet DM, but no differences were observed on 3.5% fat-corrected milk. Lastly, feed conversion significantly improved with increasing inclusion: 1.39, 1.39, and 1.55 +/- 0.05 kg of milk/kg of DMI for low, medium, and high, respectively. Observed effects were likely due to the increase in energy intake associated with increasing levels of corn bran.

Effects of ruminally degradable and escape protein supplements on steers grazing summer native range.

One experiment was conducted during 1989 to determine whether a deficiency exists for either ruminally degradable or escape protein in steers grazing summer native range. Increasing levels of ruminally degradable (.15, .27, and .37 kg/d) and escape protein (.07, .14, and .21 kg/d) replaced a cornstarch and molasses (energy control) supplement. Supplements were isoenergetic and fed individually to steers (.88 kg/d). No response to the degradable protein supplement (P = .15) was observed; however, a linear gain response (P less than .01) was observed in steers fed escape protein in addition to ruminally degradable protein. An in vitro study indicated that more (P less than .01) microbial protein was synthesized from the energy supplement than from the degradable protein; this finding presumably relates to the numerical decrease in weight gains observed for steers fed degradable protein supplements. Analyses of esophageal extrusa samples indicated that CP was relatively constant for the 1989 growing season compared with the 1988 growing season (P less than .05). Escape protein values differed (P less than .01) between years and among months within year. Forages that were apparently grazed in 1989 were never deficient in degradable protein. Additional gain observed from feeding escape protein would indicate that microbial protein synthesis may be insufficient to satisfy the metabolizable protein requirement, which probably limited gains by steers grazing summer native range.

Effects of supplemental vitamin D3 on feed intake, carcass characteristics, tenderness, and muscle properties of beef steers.

Research was conducted to determine the effects of supplemental dietary vitamin D3 on DMI, carcass traits, Warner Bratzler shear (WBS) force, calpastatin activity, plasma minerals, pH (0, 3, 12, and 24 h after slaughter), water-holding capacity (WHC), and sensory characteristics of three muscles. Pre-slaughter vitamin D3 treatments included no supplemental vitamin D3, 6 x 106 IU (MIU) of vitamin D3 for 4 d, or 6 MIU of vitamin D3 for 6 d. Cattle were slaughtered and carcasses were chilled for 48 h before removal of steaks from the longissimus, gluteus medius, and biceps femoris muscles. Steaks were aged at 2 degrees C for 7, 14, or 21 d before cooking to a final internal temperature of 70 degrees C for WBS and sensory panel analysis. Dry matter intake was lower for steers supplemented with vitamin D3 for 4 or 6 d. Live and carcass weights were lower (P < 0.05) in steers supplemented with vitamin D3. Supplementing 6 MIU/6 d of vitamin D3 decreased (P < 0.05) WBS values of gluteus steaks (pooled over aging times). Longissimus steaks from steers supplemented with vitamin D3 for 6 d had lower (P < 0.05) WBS force values than these steaks from control steers or steers fed vitamin D3 for 4 d at 7 d postmortem. Biceps femoris steaks from steers receiving vitamin D3 for 4 d had higher WBS values than steaks from control steers at 14 and 21 d postmortem. Feeding vitamin D3 at 6 MIU for 6 d decreased (P < 0.05) the percentage of steaks that had WBS values > or = 3.86 kg for all steaks. Feeding vitamin D3 had no effect on palatability traits evaluated by trained panelists. Blood Ca concentrations were greater (P < 0.05) when vitamin D3 was fed and with increased vitamin D3 feeding time. Feeding vitamin D3 for 6 d (vs 4 d) delayed pH decline for all muscle types after 0, 3, and 12 h postmortem. Water-holding capacity was increased (P > 0.02) after 0 h, 24 h, and 21 d postmortem when vitamin D3 was fed and was greater at 0 and 24 h if vitamin D3 was fed for 6 d rather than 4 d. These data suggest that supplementing 6 MIU of vitamin D3 will decrease DMI and improve beef tenderness through increased blood plasma Ca concentrations and WHC.

Interaction of corn processing and distillers dried grains with solubles on health and performance of steers.

Feeding increased concentrations of distillers dried grains with solubles (DDGS) to ruminants has been avoided due to risks of S toxicity and concerns about animal performance. The objective of this study was to evaluate the influence of feeding an increasing concentration of DDGS and corn processing method on animal performance, incidence of polioencephalomalacia (PEM), and concentration of H(2)S gas in feedlot steers. Sixty steer calves (336 ± 13.2 kg) were individually fed for an average of 136 d in a completely random design with a 3 × 2 factorial arrangement of treatments. Main effects included concentration of DDGS (20, 40, or 60% DM basis) and corn processing method [high-moisture (HMC; 71.7% DM) vs. dry-rolled corn (DRC; 86.2% DM)] resulting in treatments of 1) 20% DDGS with DRC, 2) 40% DDGS with DRC, 3) 60% DDGS with DRC, 4) 20% DDGS with HMC, 5) 40% DDGS with HMC, and 6) 60% DDGS with HMC. Ruminal H(2)S gas concentrations were measured on d 0, 7, 14, 21, 28, 35, 49, 63, and 91 via rumen puncture. Animal performance and carcass characteristic data were collected. The day × corn processing × DDGS interaction for H(2)S gas concentrations was not significant (P = 0.91). Ruminal H(2)S concentration increased with increasing DDGS concentration (P < 0.001) and day (P < 0.001), but was not influenced by corn processing method (P = 0.94). Carcass-adjusted final BW decreased linearly (P = 0.009), whereas carcass-adjusted ADG decreased quadratically (P = 0.05) with increasing concentration of DDGS in the diet. Carcass-adjusted G:F was not affected (P ≥ 0.28) by increasing concentration of DDGS in the diet. Carcass characteristics reflected the decrease in final BW with decreased HCW (P = 0.009), as well as decreased fat depth (P = 0.005) with increasing concentrations of DDGS. The combination of decreased HCW and backfat thickness resulted in decreased (P = 0.02) yield grade with increasing DDGS inclusion. There were no confirmed cases of PEM. In conclusion, corn processing did not influence animal performance, incidence of PEM, or H(2)S concentrations under the conditions of this study. Feeding 60% DDGS in beef cattle finishing diets is not recommended due to poor animal performance.

Effects of distillers grains with high sulfur concentration on ruminal fermentation and digestibility of finishing diets.

Twelve ruminally cannulated crossbred Angus steers were used to evaluate ruminal fermentation characteristics and diet digestibility when 30% (DM) corn dried distillers grains with solubles (DDGS) containing 0.42 or 0.65% (DM) of dietary S was incorporated into finishing diets based on steam-flaked corn (SFC) or dry-rolled corn (DRC). The study was a replicated, balanced randomized incomplete block design with a 2 × 2 factorial arrangement of treatments. Factors consisted of dietary S concentration (0.42 and 0.65% of DM; 0.42S and 0.65S, respectively) and grain processing method (SFC or DRC). The 0.65S concentration was achieved by adding H(2)SO(4) to DDGS before mixing rations. Steers were assigned randomly to diets and individual, slatted-floor pens, and fed once daily for ad libitum intake. Two 15-d experimental periods were used, each consisting of a 12-d diet adaptation phase and a 3-d sample collection phase. Samples were collected at 2-h intervals postfeeding during the collection phase. Ruminal pH was measured immediately after sampling, and concentrations of ruminal ammonia and VFA were determined. Fecal samples were composited by steer within period and used to determine apparent total tract digestibilities of DM, OM, NDF, CP, starch, and ether extract. Feeding 0.65S tended (P = 0.08) to decrease DMI but resulted in greater apparent total tract digestibilities of DM (P = 0.04) and ether extract (P = 0.03). Ruminal pH increased (P < 0.05) in steers fed 0.65S diets, which may be attributable, in part, to decreased (P = 0.05) VFA concentrations and greater (P < 0.01) ruminal ammonia concentrations when 0.65S was fed, compared with feeding 0.42S. These effects were more exaggerated in steers fed DRC (interaction, P < 0.01), compared with steers fed SFC. Steers fed DRC-0.65S had greater (P < 0.01) acetate concentration than steers fed DRC-0.42S, but acetate concentration was not affected by S concentration when SFC was fed. Propionate concentration was decreased (P < 0.01) in steers fed SFC-0.65S compared with steers fed SFC-0.42S, but dietary S concentration had no effect on propionate concentration when DRC was fed. Butyrate concentration was less (P < 0.01) in steers fed 0.65S diets than in steers fed 0.42S. Lactate concentrations tended (P = 0.06) to decrease in steers fed 0.65S diets. Feeding DDGS with increased S concentration may decrease feed intake and ruminal VFA concentration but increase ruminal ammonia concentration.

Evaluation of sulfur content of dried distillers grains with solubles in finishing diets based on steam-flaked corn or dry-rolled corn.

Crossbred yearling steers (n=80; 406 ± 2.7 kg of BW) were used to evaluate the effects of S concentration in dried distillers grains with solubles (DDGS) on growth performance, carcass characteristics, and ruminal concentrations of CH(4) and H(2)S in finishing steers fed diets based on steam-flaked corn (SFC) or dry-rolled corn (DRC) and containing 30% DDGS (DM basis) with moderate S (0.42% S, MS) or high S (0.65% S, HS). Treatments consisted of SFC diets containing MS (SFC-MS), SFC diets containing HS (SFC-HS), DRC diets containing MS (DRC-MS), or DRC diets containing HS (DRC-HS). High S was achieved by adding H(2)SO(4) to DDGS. Ruminal gas samples were analyzed for concentrations of H(2)S and CH(4). Steers were fed once daily in quantities that resulted in traces of residual feed in the bunk the following day for 140 d. No interactions (P ≥ 0.15) between dietary S concentration and grain processing were observed with respect to growth performance or carcass characteristics. Steers fed HS diets had 8.9% less DMI (P < 0.001) and 12.9% less ADG (P=0.006) than steers fed diets with MS, but S concentration had no effect on G:F (P=0.25). Cattle fed HS yielded 4.3% lighter HCW (P = 0.006) and had 16.2% less KPH (P=0.009) than steers fed MS. Steers fed HS had decreased (P=0.04) yield grades compared with steers fed MS. No differences were observed among treatments with respect to dressing percentage, liver abscesses, 12th-rib fat thickness, LM area, or USDA quality grades (P ≥ 0.18). Steers fed SFC had less DMI (P < 0.001) than steers fed DRC. Grain processing had no effect (P > 0.05) on G:F or carcass characteristics. Cattle fed HS had greater (P < 0.001) ruminal concentrations of H(2)S than cattle fed MS. Hydrogen sulfide concentration was inversely related (P ≤ 0.01) to ADG (r=-0.58) and DMI (r=-0.67) in cattle fed SFC, and to DMI (r=-0.40) in cattle fed DRC. Feeding DDGS that are high in dietary S may decrease the DMI of beef steers and compromise the growth performance and carcass characteristics of feedlot cattle.

Dried distillers grains with solubles with reduced corn silage levels in beef finishing diets.

Two finishing experiments were conducted to evaluate the use of 25% dried corn distillers grains with solubles (DDG) in beef cattle finishing diets by partially replacing a portion of the grain and soybean meal in the control diets. In Exp.1, crossbred heifers (n = 377; BW 378 +/- 4.1 kg) were fed diets consisting of steam-flaked corn (SFC) with a control diet containing 0% DDG and 15% corn silage (CS), 25% DDG and 15% CS, or 25% DDG and 5% CS. Compared with the control treatment, heifers fed DDG and 15% CS had a greater proportion of USDA yield grade 4 and 5 carcasses (P = 0.04; 5.68 vs. 14.12), and smaller LM area (P = 0.04; 86.09 vs. 82.48 cm(2)). In Exp. 2, crossbred heifers (n = 582; BW = 377 +/- 27.09 kg) were fed diets similar to Exp. 1 except dry-rolled corn (DRC) and SFC were compared as the basal grain sources. Treatments included DRC or SFC: with control diets containing 0% DDG and 15% CS, 25% DDG and 15% CS, or 25% DDG and 5% CS. Feeding SFC decreased DMI (P < 0.01), improved G:F (P < 0.01) and final shrunk BW (P = 0.05) compared with DRC. Average USDA yield grade was greater for cattle fed DRC than for those fed SFC (P = 0.02), but calculated yield grade was not different among treatments (P = 0.71). Feeding DDG and 5% CS, regardless of grain source, led to decreased DMI and greater G:F than feeding DDG and 15% CS (P = 0.02). When comparing the control treatments with the diets containing 25% DDG and 15% CS shrunk final BW, ADG, and G:F were decreased (P < or = 0.05); however, carcass-adjusted measurements were not different (P > 0.52). Results indicate that roughage levels can be reduced in feedlot diets containing 25% DDG with no adverse effects on BW gain, feed efficiency, or carcass quality.