Shelf-life of minimally processed lettuce and cabbage treated with gaseous chlorine dioxide and cysteine.

Gaseous ClO2 was evaluated for effectiveness in prolonging the shelf-life of minimally processed (MP) lettuce and MP cabbage, previously immersed in a cysteine solution in order to inhibit browning occurring during ClO2 treatment. Each vegetable was shredded, washed, and separated in two portions, one to be treated with ClO2 gas and the other to remain untreated as reference sample. The batch to be treated with ClO2 gas was immersed for 1 min in a 0.5% solution of HCl.L-cysteine monohydrate. Then both batches were spun dried. MP vegetables were decontaminated in a cabinet at 90-91% relative humidity and 22-25 degrees C up to 10 min, including 30 s of ClO2 injection into the cabinet. The ClO2 concentration rose to 1.74 mg/L (MP lettuce) and 1.29 mg/L (MP cabbage). Then samples were stored under modified atmosphere at 7 degrees C for shelf-life studies. Changes in O2 and CO2 headspace concentrations, microbiological quality (aerobic plate count (APC), psychrotrophs, lactic acid bacteria, and yeasts), sensory quality, and pH were followed during storage. The respiration rate of the minimally processed vegetables was significantly increased by the ClO2 gas treatment only in the case of MP cabbage (P<0.05). The gas treatment reduced initially APC and psychrotroph count of MP lettuce and APC, psychrotroph counts, yeast counts and pH of MP cabbage (P<0.05). ClO2 treatment did not cause initially any significant (P<0.05) sensorial alteration, except for a weak off-odour in MP lettuce. Interestingly, no browning was observed after treating, which can be accounted to the use of L-cysteine. Although an initial microbiological reduction was observed due to ClO2 gas treatment, APC and psychrotroph counts reached in the samples treated with ClO2 higher levels than in those non-treated with ClO2 before the third day of the shelf-life study. Untreated and treated samples of MP lettuce were sensorial unacceptable due to bad overall visual quality after 4 days, while treated and untreated MP cabbage remained sensorial acceptable during the 9 days of the study. L-cysteine reduced (P<0.05) the decontamination efficacy of ClO2 when applied to MP cabbage but not in the case of MP lettuce. Gaseous ClO2 failed to prolong the shelf-life of MP lettuce and MP cabbage, the reason for the enhanced growth of microorganisms in decontaminated samples should be investigated. Nonetheless, our results prove that it is possible to inhibit browning caused by ClO2.

Electrical conductivity of nutrient solution influenced photosynthesis, quality, and antioxidant enzyme activity of pakchoi (Brassica campestris L. ssp. Chinensis) in a hydroponic system.

To find an electrical conductivity (EC) in the nutrient solution used for pakchoi (Brassica campestris L. ssp. Chinensis) cultivation that optimizes the plant's physiology, growth, and quality, we conducted an experiment with eight EC treatments (from EC0 to EC9.6) in a hydroponic production system (i.e. soilless culture) under greenhouse condition in Shanghai, China. Plants biomass production, leaf photosynthesis, vegetable quality variables, tissue nitrate and nitrite contents, and antioxidant enzyme activities were measured. The results showed that very high (EC9.6) or low EC (EC0-0.6) treatments clearly decreased plants fresh weight (FW) and dry weight (DW), leaf size, leaf water content, leaf net photosynthetic rate (Pn), stomatal conductance (Gs), transpiration rate (Tr), and taste score. Nitrite content, and antioxidant enzyme activities were low in medium EC treatments (EC1.8 and EC2.4), but high in very high or low EC treatments. Leaf relative chlorophyll, ascorbic acid, and nitrate contents increased gradually from low EC to high EC treatments, while crude fiber and soluble sugar contents decreased. Based on growth and quality criteria, the optimal EC treatment would be EC1.8 or EC2.4 for pakchoi in the hydroponic production system. Too high or too low EC would induce nutrient stress, enhance plant antioxidant enzyme activities, and suppress pakchoi growth and quality.

Shelf life extension of minimally processed cabbage and cucumber through gamma irradiation.

The influence of irradiation of minimally processed cabbage and cucumber on microbial safety, texture, and sensory quality was investigated. Minimally processed, polyethylene-packed, and irradiated cabbage and cucumber were stored at refrigeration temperature (5 degrees C) for 2 weeks. The firmness values ranged from 3.23 kg (control) to 2.82 kg (3.0-kGy irradiated samples) for cucumbers, with a gradual decrease in firmness with increasing radiation dose (0 to 3 kGy). Cucumbers softened just after irradiation with a dose of 3.0 kGy and after 14 days storage, whereas the texture remained within acceptable limits up to a radiation dose of 2.5 kGy. The radiation treatment had no effect on the appearance scores of cabbage; however, scores decreased from 7.0 to 6.7 during storage. The appearance and flavor scores of cucumbers decreased with increasing radiation dose, and overall acceptability was better after radiation doses of 2.5 and 3.0 kGy. The aerobic plate counts per gram for cabbage increased from 3 to 5 log CFU (control), from 1.85 to 2.93 log CFU (2.5 kGy), and from a few colonies to 2.6 log CFU (3.0 kGy) after 14 days of storage at 5 degrees C. A similar trend was noted for cucumber samples. No coliform bacteria were detected at radiation doses greater than 2.0 kGy in either cabbage or cucumber samples. Total fungal counts per gram of sample were within acceptable limits for cucumbers irradiated at 3.0 kGy, and for cabbage no fungi were detected after 2.0-kGy irradiation. The D-values for Escherichia coli in cucumber and cabbage were 0.19 and 0.17 kGy, and those for Salmonella Paratyphi A were 0.25 and 0.29 kGy for cucumber and cabbage, respectively.

Prewashing with acidified sodium chlorite reduces pathogenic bacteria in lightly fermented Chinese cabbage.

Efficacy of prewashing with acidified sodium chlorite (ASC) for the sanitation of lightly fermented Chinese cabbage was evaluated. The population of the natural microflora on the cabbage leaves was reduced about 2.0 log CFU/g just after washing with ASC, a significant reduction compared with the control distilled water wash (P < or = 0.05). In the control experiment, viable aerobic bacteria increased gradually when incubated at 10 degrees C; however, ASC-washed cabbage maintained a lower microbial concentration. The treatment of Chinese cabbage with ASC reduced the population of artificially inoculated Escherichia coli O157:H7, Salmonella Enteritidis, Staphylococcus aureus, and Listeria monocytogenes by 2.4 log CFU/g. The sanitation efficacy of ASC was 1.6 log CFU/g higher than that of distilled water washing. The viable cell counts of all pathogenic bacteria tested remained constant during 8 days of storage at 10 degrees C for both washing treatments, with the exception of L. monocytogenes, whose viable cell counts increased gradually with time for both treatments. No significant differences in color, odor, taste, and texture in raw leaves were observed after the ASC wash compared with after the distilled water wash. These results indicate that prewashing with ASC could control bacterial growth in lightly fermented Chinese cabbage without changing the product quality.

Efficacy of acidified sodium chlorite treatments in reducing Escherichia coli O157:H7 on Chinese cabbage.

Efficacy of acidified sodium chlorite for reducing the population of Escherichia coli O157:H7 pathogens on Chinese cabbage leaves was evaluated. Washing leaves with distilled water could reduce the population of E. coli O157:H7 by approximately 1.0 log CFU/g, whereas treating with acidified chlorite solution could reduce the population by 3.0 log CFU/g without changing the leaf color. A similar level of reduction was achieved by washing with sodium chlorite solution containing various organic acids. However, acidified sodium chlorite in combination with a mild heat treatment reduced the population by approximately 4.0 log CFU/g without affecting the color, but it softened the leaves. Moreover, the efficacy of the washing treatment was similar at low (4 degrees C) and room (25 degrees C) temperatures, indicating that acidified sodium chloride solution could be useful as a sanitizer for surface washing of fresh produce.

Effect of gamma irradiation on the microbiological quality of minimally processed vegetables.

The initial microflora of minimally processed celery and cabbage packaged under a modified atmosphere was determined. The samples came from the same producer and were sold in a supermarket chain of Santiago, Chile. Although neither E. coli nor Salmonella spp. were detected, initial total plate and Enterobacteriaceae counts were high (= 10(5) cfu/g), not meeting in most cases the specifications of the Chilean legislation. The D10 value for two strains of E. coli (ATCC 8739 and a wild type) inoculated as indicator microorganisms was determined. After irradiating with 5 D10 doses (1kGy), the variation of the microbial population and sensory quality during a 7 days storage period at 5 degrees C was studied. In irradiated celery, a reduction of 4.7 and 3.8 logs for total plate and Enterobacteriaceae counts respectively was observed. There was a decrease of 3.8 and 3.6 logs in cabbage for total plate and Enterobacteriaceae counts respectively. In both irradiated and non-irradiated vegetables, neither E. coli nor Salmonella spp. were detected. An increase of 1.6 - 1.7 logs in both microbiological parameters in non-irradiated samples was observed during storage. In irradiated products, only celery showed an increase of 1.2 log in total plate count. Both Enterobacteriaceae count in the two vegetables and Total plate count in cabbage presented essentially no variation in time. No significant differences (p = 0.05) were detected in sensory total quality between the control and the irradiated vegetable and between days of storage.

Irradiation D-values for Escherichia coli O157:H7 and Salmonella sp. on inoculated broccoli seeds and effects of irradiation on broccoli sprout keeping quality and seed viability.

Like alfalfa sprouts, broccoli sprouts can be a vehicle for bacterial pathogens, which can cause illness when they are consumed. The gamma irradiation process was used to reduce numbers of bacterial pathogens on broccoli sprouts and seeds, and the effect of this process on the seeds was studied. The irradiation destruct values for Salmonella sp. and for strains of Escherichia coli O157:H7 inoculated on broccoli seeds were determined. Results obtained in this study indicate that a dose of 2 kGy reduced total background counts for broccoli sprouts from 10(6) to 10(7) CFU/g to 10(4) to 10(5) CFU/g and increased the shelf life of the sprouts by 10 days. Yield ratio (wt/wt), germination percentage, sprout length, and thickness were measured to determine the effects of various irradiation doses on the broccoli seeds. Results show a decreased germination percentage at a dose level of 4 kGy, whereas the yield ratio (wt/wt), sprout length, and thickness decreased at the 2-kGy dose level. The radiation doses required to inactivate Salmonella sp. and strains of E. coli O157:H7 were higher than previously reported values. D-values, dose required for a 1-log reduction, for the nonvegetable and vegetable Salmonella sp. isolates were 0.74 and 1.10 kGy, respectively. The values for the nonvegetable and vegetable isolated strains of Escherichia coli O157:H7 were 1.43 and 1.11 kGy, respectively. With the irradiation process, a dose of up to 2 kGy can extend the shelf life of broccoli sprouts. A dose of > 2 kGy would have an adverse effect on the broccoli seed and decrease the yield of broccoli sprouts.

Chemopreventive effects of cabbage on 7,12-dimethylbenz(a)-anthracene-induced hepatocarcinogenesis in toads (Bufo viridis).

Hepatocellular carcinoma was induced in the toad, Bufo viridis, in 29 out of 100 cases by the administration of 0.5 mg of 7,12-dimethylbenz(a)anthracene (DMBA)/toad, 3 times/week for 12 weeks. In contrast, toads treated with DMBA and cabbage diet 1 or 2 ml (3 h prior to the carcinogen)/toad, every day for 12 weeks showed a lower incidence of liver tumors: 15 and 12 cases out of 100. However, cabbage diet (2 ml/toad, every day for 12 weeks) was ineffective when administered 3 h after the carcinogen (DMBA) in 27 out of 100 cases. Neither tumor growth nor neoplastic changes were observed in toads treated with olive oil alone or with cabbage diet. It is concluded that a cabbage diet during initiation has an inhibitory effect on hepatocarcinogenesis in toads.

Nutritional evaluation of low glucosinolate mustard meals (Brassica juncea) in broiler diets.

Experiments were conducted to evaluate the nutritional value of meal derived from low glucosinolate cultivars of mustard (Brassica juncea) in comparison to samples of canola meal (Brassica napus, Brassica rapa). Samples of Brassica seed (four B. juncea, one B. napus, and one B. rapa) were processed using laboratory procedures to produce oil-extracted meals, which were examined for composition (DM basis), and nutritional value for broiler chickens as judged by nutrient retention (AMEn, ileal protein digestibility) and performance. Meals derived from B. juncea contained more CP and less total dietary fiber (TDF) on a dry basis than either B. napus or B. rapa, 45.9 vs 44.6 and 43.1% CP and 27.22 vs 29.47 and 29.67% TDF, respectively. Acid detergent fiber (ADF) and neutral detergent fiber (NDF) levels for B. juncea and B. rapa meals were similar to each other, but lower than those of B. napus, 12.79 and 13.20 vs 20.6% ADF, and 21.15 and 19.58 vs 29.47% NDF, respectively. Brassica juncea meals contained more glucosinolates than B. napus and B. rapa, 34.3 vs 21.8 and 25.5 mumol/g total glucosinolates, respectively. Brassica juncea meals were equal or superior to B. napus and B. rapa meals for AMEn and apparent ileal protein digestibility. Similarly, broilers fed B. juncea meals grew as quickly and converted feed to BW gain as efficiently to 21 d of age as those birds fed B. napus and B. rapa meals. Feeding meal from B. rapa reduced growth rate and gain to feed ratio. In conclusion, the nutritional value of meal from low glucosinolate mustard was equal or superior to that of canola meal samples derived from B. napus and B. rapa cultivars.

[Histamine and tyramine levels in selected food products]. / Poziom histaminy i tyraminy w wybranych srodkach spozywczych.

Histamine and tyramine contents were determined in parallel in fish and fish products ripening and processed cheese, yeast, wine, cabbage and sauerkraut, and tomato paste. Histamine was assayed by the colorimetric method of Hardy and Smith, and by TLC. Tyramine was determined by TLC. Levels of histamine and tyramine were found to be low in all products tested. For histamine and tyramine, respectively, they amounted: in raw fish to 0.0-8.0 and 0.0-2.6 mg/100 g, in fish products to 0.0-16.0 and 0.0-10.0 mg/100 g, and in cheeses to 0.0-0.8 and 1.3-20.0 mg/100 g. In the remaining food products (tomato paste, yeast, wine, cabbage and sauerkraut), histamine content was between 0.0-16.6 mg/100 g (highest in tomato paste), and tyramine content fluctuated between 0.0-8.0 mg/100 g (highest in sauerkraut).

Quality changes of fresh-cut kohlrabi sticks under modified atmosphere packaging.

The aim of this study was to determine the effect of different gas compositions on quality attributes and shelf life of kohlrabi sticks stored in modified atmosphere up to 14 d at 0 degrees C. Two commercial films were tested: oriented polypropylene (OPP) and amide-polyethylene (amide-PE). As a control, a microperforated OPP film was used. In order to study the changes in metabolic activity by minimal processing, the respiration rate and ethylene production at 0 degrees C were monitored for both intact stems and sticks. Changes in color, chemical parameters, sugars and organic acid contents, and sensorial quality of kohlrabi sticks were evaluated. An initial ethylene production of sticks was 13-fold higher than that of intact stems; meanwhile CO(2) production was 2-fold higher. However after 4 d of storage, a similar respiration rate for stems and sticks was found. Also the ethylene production of sticks and stems was steady around 15 to 20 nL/kg(/)h after 10 d. Kohlrabi sticks showed a little change in chemical parameters and very low weight losses during cold storage. Sticks under an equilibrium atmosphere of 7 kPa O(2) and 9 kPa CO(2) at 0 degrees C reached by amide-PE kept an acceptable sensorial quality for 14 d.

Effects of Leuconostoc mesenteroides starter culture on fermentation of cabbage with reduced salt concentrations.

Sauerkraut fermentations rely upon selection of naturally occurring lactic acid bacteria by addition of 2.0% to 2.25% granulated sodium chloride (NaCl) to shredded cabbage. Excess brine generated is a waste product with high levels of organic material (BOD) and nonbiodegradable NaCl. The objective was to determine whether addition of Leuconostoc mesenteroides starter culture to reduced-salt cabbage fermentations would yield sauerkraut with reproducible and acceptable chemical composition and sensory qualities. Shredded cabbage was salted with 0.5%, 1.0%, or 2.0% NaCl (wt/wt) at 2 starter culture levels, none or L. mesenteroides strain LA 81, ATCC 8293 (10(6) CFU/g). Fermentation products were quantified by high-performance liquid chromatography, and pH was measured during the initial stages of fermentation and after 10 mo storage at 18 degrees C. A trained descriptive sensory panel used category scales to rate the flavor and texture of selected sauerkrauts. A modified Kramer shear test was used to measure firmness. Cabbage fermented with L. mesenteroides consistently resulted in sauerkraut with firm texture and reduced off-flavors across all salt levels (P < 0.05). Conversely, sauerkraut quality was highly variable, with softening and off-flavors occurring as salt concentrations were decreased in natural fermentations (P < 0.05). Fermentations were rapid, with a more uniform decline in pH when starter culture was added. L. mesenteroides addition to cabbage fermentations ensured that texture and flavor quality were retained, while allowing 50% NaCl reduction. Application of this technology to commercial sauerkraut production could improve the uniformity of fermentations and substantially reduce generation of nonbiodegradable chloride waste.

Extending the shelf life of kohlrabi stems by modified atmosphere packaging.

Kohlrabi stems (without leaves) were stored under modified atmosphere packaging (MAP) for 60 d at 0 degrees C. An additional retail sale period of 3 d at 12 degrees C after each cold storage evaluation (30 and 60 d) was applied. Under high relative humidity (RH) and 0 degrees C, the stems showed low metabolic activity, as no changes in sugars and organic acids were found. From day 21 at 0 degrees C, air-stored stems showed a yellowing of stalks and later they fell down. This disorder severely affected the appearance of stems. A gas composition of 4.5 to 5.5 kPa O(2) plus 11 to 12 kPa CO(2) was reached using antimist oriented polypropylene plastic bags of 20-mum thicknesses. The stems in MAP conditions kept a high sensorial quality. It was enough for commercial purpose of 2 mo. The storage of kohlrabi stems in plastic bags, either MA or in perforated (control) packages, provided an additional protection reducing physical damage. The MAP conditions delayed the weight loss and development of bacterial soft and black rot, extending the shelf life of kohlrabi stems to 60 d at 0 degrees C plus 3 d at 12 degrees C. Stems are not chilling injury sensitive.

The influence of processing and preservation on the retention of health-promoting compounds in broccoli.

In this work the effects of common household practices such as chilling, freezing, and cooking on vitamin C retention in broccoli (Marathon cv.), as well as their influence on the release of sulforaphane upon enzymatic hydrolysis of glucoraphanin by the endogenous enzyme myrosinase, were investigated. When chilled at 6 degrees C and 95% R.H. for 35 d, broccoli showed a vitamin C and sulforaphane loss of about 39% and 29%, respectively, while storage at -18 degrees C for 60 d resulted in similar losses, but mainly due to the blanching step. Boiling, steaming, microwaving, pressure-cooking, and the combined use of pressure and microwaves were the cooking methods investigated. Boiling and steaming caused significant vitamin C losses, 34% and 22%, respectively, while with the other treatments more than 90% retention was observed. Sulforaphane was no more detectable after boiling or steaming, while pressure/microwave cooking did not cause any significant loss. The quantitative distribution of these moieties in the florets and stems of fresh and chilled broccoli was also investigated.

[Fattening and slaughter values of pigs in relation to their genotype and to the protein source in their feed rations]. / Mast-und Schlachtleistung von Schweinen in Abhängigkeit vom Genotyp und von der Proteinquelle in Futterrationen.

The studies were carried out on F1 progeny of multiparous Polish Large White sows and boars of Belgian Landrace, Hampshire x Pietrain hybrid, and Pietrain breed. The control group consisted of purebred Polish Large White pigs. The experimental part of the studies was performed on 120 fatteners divided up to 4 race groups, with 30 heads in each (namely 15 barrows and 15 gilts). Moreover, each group was divided into two following subgroups: the SoS one, which was given feed mixture with extracted soybean meal and the RpS one, which was given feed mixture with extracted rapeseed meal. The fattening started with 23 kg of body weight and was realized up to 100 kg. Twenty fatteners from each group (including 5 barrows and 5 gilts from a subgroup) were subjected to the control slaughter. The fatteners average daily body weight gains, and energy and digestible crude protein conversion per 1 kg of gain were as follows: after Belgain Landrace boars 788 g, 32.3 MJ and 358 g; after Hampshire x Pietrain boars 766 g, 33.6 MJ and 373 g; after Pietrain boars 720 g, 34.4 MJ and 382 g; after control group boars 705 g, 36.3 MJ and 403 g, respectively. It was found that hybrids after boars of evaluated breeds have positively (P < or = 0,01) better carcass meatness, and in a better way use digestible protein and metabolizable energy for production of 1 kg of meat. On that reason the best are hybrids after Belgian Landrace boars, carcasses of which yielded 52.4% of meat and converted 27% less of digestible crude protein and metabolizable energy for 1 kg meat production, than the White Large Polish fatteners. For no examined feature interaction between genotype and protein source in feeding diet was found. The growth rate and utilization of fodder were better for pigs fed on mixture with extracted soybean meal than for the ones fed on mixture with extracted rapeseed meal (P < or = 0.05). The fodders with high protein content did not differentiate meatness traits, whereas digestible crude protein and metabolizable energy conversion for 1 kg meat production in pigs, being given extracted soybean meal in diet, was lower (P < or = 0.05) than in pigs given extracted rapeseed meal.