Higienização de ambiente em agroindústria familiar de embutidos cárneos / Environmental hygienization in family meat product

A higienização é um procedimento importante na indústria de alimentos e sua realização deve ocorrer rotineiramente para evitar que os alimentos sejam contaminados. Além disso, todos os manipuladores de alimentos devem receber treinamentos de modo a entender como ocorrem as contaminações e como evitá-las, para que não ocorra deterioração antecipada dos alimentos e para que não exponham os consumidores ao risco de doenças transmitidas por alimentos em caso de contaminação. Esta pesquisa avaliou o processo de higienização e sua eficiência em superfícies presentes em uma agroindústria da agricultura familiar produtora de embutidos cárneos. Apesar de ter instalações adequadas a agroindústria apresentava inadequações quanto aos produtos utilizados e a frequência inadequada para uma higienização eficiente. Foi realizada análise microbiológica das superfícies dos equipamentos para contagem de aeróbios mesófilos e notou-se uma elevada carga microbiana que indicou uma baixa eficiência no processo de higienização. Sugeriu-se melhorias na higiene ambiental associado à instrução dos colaboradores, para contribuir na promoção da qualidade dos produtos, aumento dos lucros e salvaguardando a saúde do consumidor.

Hygiene is an important procedure in the food industry, and its performance must occur routinely to prevent food from being contaminated. In addition, all food handlers must receive training in order to understand how contamination occurs and how to avoid it, so that there is no anticipated deterioration of food and that consumers are not exposed to the risk of foodborne diseases. in case of contamination by pathogenic microorganisms. Thus, this research evaluated the cleaning process and its efficiency on surfaces present in a family farming agroindustry that produces meat products, which despite having adequate facilities, had some difficulties such as product use and inadequate frequency for eficiente cleaning. After performing a microbiological analysis to count surface mesophilic aerobes, a high level of contamination was noted, relating to low efficiency in the cleaning process. Improvements in environmental hygiene are suggested, associated with the instruction of employees for the implementation of the Standard Operating Hygiene Procedure, promoting improvements in product quality, increasing profits and safeguarding consumer health.

Effect of dietary fat on proximal composition, sensorial analysis and shelf life of a traditional Spanish cooked pork product "Lomo de Sajonia" from Iberian pork.

This study aims to evaluate the effect of different dietary fat sources on the quality of a Spanish-cooked meat product Lomo de Sajonia (LSA) and its shelf-life. Forty loins were selected from Iberian pigs fed four dietary treatments containing pork fat (G-1), Greedy-Grass Olive® (GGO) (enriched oleic-acid oil) (G-2), G-2 and high oleic sunflower (G-3), and G-3 plus a mixture of commercial organic acids (Bioll®) (G-4). Loins were manufactured to obtain LSA, and the quality and sensorial attributes were assessed. The shelf life was established according to microbial count and sensorial analysis, which was packed in a modified atmosphere and stored under retail conditions. All meat quality parameters of LSA remained stable in all groups, except fat content and overall liking, which showed the highest values for G-2 LSA. Regarding the shelf life, sensorial attributes remained acceptable in all groups during storage time, while a delay in microbial growth was recorded for the LSA of G-3. According to the results, including GGO in Iberian pig diets could enhance LSA traits, possibly linked to increased assimilation compared with conventional fat sources. However, adding organic acids to the diet did not have the expected effect on improving the shelf life of the LSA.

Emerging challenges and efficacy of polyphenols-proteins interaction in maintaining the meat safety during thermal processing.

Polyphenols are well documented against the inhibition of foodborne toxicants in meat, such as heterocyclic amines, Maillard's reaction products, and protein oxidation, by means of their radical scavenging ability, metal chelation, antioxidant properties, and ability to form protein-polyphenol complexes (PPCs). However, their thermal stability, low polarity, degree of dispersion and polymerization, reactivity, solubility, gel forming properties, low bioaccessibility index during digestion, and negative impact on sensory properties are all questionable at oil-in-water interface. This paper aims to review the possibility and efficacy of polyphenols against the inhibition of mutagenic and carcinogenic oxidative products in thermally processed meat. The major findings revealed that structure of polyphenols, for example, molecular size, no of substituted carbons, hydroxyl groups and their position, sufficient size to occupy reacting sites, and ability to form quinones, are the main technical points that affect their reactivity in order to form PPCs. Following a discussion of the future of polyphenols in meat-based products, this paper offers intervention strategies, such as the combined use of food additives and hydrocolloids, processing techniques, precursors, and structure-binding relationships, which can react synergistically with polyphenols to improve their effectiveness during intensive thermal processing. This comprehensive review serves as a valuable source for food scientists, providing insights and recommendations for the appropriate use of polyphenols in meat-based products.

Evaluation of the antimicrobial activity of Eucalyptus radiata essential oil against Escherichia coli strains isolated from meat products.

The present study sought to evaluate the antimicrobial and anti-adherent potential of Eucalyptus radiata essential oil against food-borne strains of Escherichia coli. The study was performed using the Minimum Inhibitory Concentration (MIC) and Minimum Bactericidal Concentration (MBC). In addition, the disk diffusion technique was used to evaluate the association of Eucalyptus radiata essential oil with synthetic antimicrobials. The Minimum Inhibitory Adherence Concentration (MIC) was also performed. The results revealed that E. radiata showed antimicrobial activity against the E. coli strains tested, with MIC values ranging from 500 µg/mL to 1000 µg/mL and MBC values ranging from 500 µg/mL to 1,024 µg/mL. As for the associations, it was observed that E. radiata oil exhibited a synergistic effect for some antibiotics, especially Ceftriaxone, with greater interference from the essential oil. Furthermore, it was effective in inhibiting the adherence of bacterial strains of E. coli, showing a more significant antibiofilm effect than the antibacterial agent 0.12% chlorhexidine digluconate. In summary, the essential oil of E. radiata showed antimicrobial potential against strains of E. coli of food origin, and can therefore, through in-depth studies, be used alone or in association with synthetic antimicrobials to combat infections caused by this pathogen.

Evaluation of the Nutritional Quality of Chinese Processed Meat Products: Comparison of Two Nutrient Profile Models.

Processed meat products are one of the most consumed pre-packaged foods in China. They are also group-1 carcinogens, whose consumption has proved to be positively associated with the risk of noncommunicable diseases (NCDs). The purpose of this study is to analyze the nutrient content on the food label of processed meat products based on the China Standardized Database for the Composition of Pre-packaged Food and the National Open Database of the UK and France. The Chilean front-of-pack warning label (FOPWL) and the Chinese Healthier Choice Logo were used to compare the nutrient content of processed meat products from the three countries. It was found that cured meat products have the highest median energy (483 kcal/100 g), total fat content (38.7 g/100 g), and sodium content (2076 mg/100 g) and dried meat products have the highest median protein content (30.2 g/100 g) and carbohydrate content (38.2 g/100 g). In addition, there were significant differences in energy content and contents of total fat, protein, and carbohydrate across different products of the three countries (p < 0.001). A large number of processed meat products currently collected did not meet the criteria of the Chilean FOPWL and the Chinese Healthier Choice Logo. This study provided information on the healthiness of Chinese processed meat products and provided data for improving food formulations for different categories of processed meat products.

Effect of novel and conventional food processing technologies on Bacillus cereus spores.

This chapter provides a summary of the effect of thermal and non-thermal processing technologies on Bacillus cereus spores, a well-known pathogenic bacterium associated with foodborne illnesses. B. cereus has been frequently detected in rice, milk products, infant food, liquid eggs products and meat products all over the world. This Gram positive, rod-shaped, facultative anaerobe can produce endospores that can withstand pasteurization, UV radiation, and chemical reagents commonly used for sanitization. B. cereus spores can germinate into vegetative cells that can produce toxins. The conventional regime for eliminating spores from food is retorting which uses the application of high temperature (121 °C). However, at this temperature, there could be a significant amount of loss in the organoleptic and functional qualities of the food components, especially proteins. This leads to the research on the preventive measures against germination and if possible, to reduce the resistance before using a non-thermal technology (temperatures less than retorting-121 °C) for inactivation. This chapter reviews the development and success of several food processing technologies in their ability to inactivate B. cereus spores in food.

The Nutri-Score Scale-A Tool for Assessing the Nutritional Quality of Processed Meat Products Available on the Polish Market.

Although meat and meat products are important sources of protein in the human diet, consumption appears to be a predisposing factor in the onset of several civilisation diseases, particularly red meat and its products. One way to reduce diet-related diseases is to guide consumers towards consciously purchasing healthier foods by including a nutrition declaration on product labels, such as by using a "front-of-pack" (FOP) labelling system. This study aimed to determine the Nutri-Score classes for processed meat products, distinguish products that are potentially better for consumers, and determine whether the refined algorithm significantly contributed to a change in product classification. An analysis of the labels of 1700 products available on the Polish market indicated that most processed meat products qualified as class D and E. Comparing the refined Nutri-Score calculation algorithm with the original algorithm resulted in a slight change in product allocation. Poultry products were ranked more favourably than red meat products. The most significant change in product allocation (by 35.2%) was achieved by reducing salt content by 30% and fat content by 10%. Among the processed meat products, some are more highly ranked and are hence considered better from a nutritional perspective than others in that group.

Effects of pre-formulation and post-cooking method on the rheological and gelation properties of 3D printed chicken products.

This study investigated the influence of oil type (olive, soybean, and peanut oil) and post-cooking methods (oven bake and microwave) on the quality of 3D printed chicken meat products. The Ostwald-de-Waele model was used to describe the flow behavior of chicken meat paste (R2 > 0.995). Oil-fortified groups present significantly lower consistency index (K) and flow behavior index (n), indicating better fluidity. A modified Cox-Merz rule was applied by multiplying angular frequency with shift factors (αSF). Surprisingly, the values of αSF are well-correlated with accuracy parameters of 3D printed cubes (|r| >0.8). For post-heating methods, baking results in higher fluid loss but contributes to a smoother surface. The microwaved gels showed better fluid retention ability and higher accuracy but lost the detail shape of the 3D printing model. Overall, the PO (peanut oil) meat emulsion group presented better textural properties and flat surfaces than other oil-added counterparts.

Detection of Toxoplasma gondii in artisanal salted meat products sold in street markets of the Ilhéus-Itabuna microregion.

This study aimed to detect Toxoplasma gondii in artisanal salted meat products sold in street markets in the Ilhéus-Itabuna microregion and to assess the salt concentration used in their preparation and its influence on the parasite's viability. A total of 125 samples of various artisanal meat products sold in street markets located in the Ilhéus-Itabuna microregion were collected during 2021. Serological analysis using indirect hemagglutination (HAI) and molecular analysis (PCR) were performed on these samples to detect the presence of the parasite. Möhr's method was utilized to determine the sodium chloride concentration in the samples. Of all samples, 21 were subjected to a bioassay in albino mice to verify the viability of possible tissue cysts. Among the 125 meat products, 10 (8%) tested positive in the serological analysis including four cured pork sausages, five beef sun-dried meats, and one mixed fresh sausage (pork and chicken). None of 125 samples tested positive in the molecular analysis. On bioassay, all mice tested negative for the presence of the parasite. The NaCl concentration in the positive samples ranged from 2.9% to 8%. The results demonstrated that the salt concentration in the collected samples was sufficient to inactivate the parasite T. gondii.

Assessment of functional efficacy of sheep plasma protein hydrolysates and their utilization in mutton sausage.

The present study examines the bioactive potential of sheep plasma protein hydrolysates (SPPH) produced by in-vitro gastrointestinal digestion as antioxidants, antimicrobials, anti-obesity agents, and inhibitors of lipid oxidation in sausage to address the oxidative stability and shelf-life issues of mutton. The antioxidant and antimicrobial activities, indicate a positive relationship between the degree of hydrolysis and digestion duration. The study finds that SPPH has a potent inhibitory effect on pancreatic lipase and cholesterol esterase. It has higher oil holding capacity than sheep plasma protein, observed at one hour of hydrolysis time. SPPH exhibit an improved behavior in foaming properties along alkaline pH and digestion time while display lower emulsifying activity and stability with hydrolysis advancement. The SPPH act as a natural preservative in developing functional mutton sausage by inhibiting lipid-oxidation. This study showed that the recovery of SPPH can be a cost-effective and sustainable strategy for generating available ingredients for enhanced shelf-life of meat products.

Aptamer-Based Sensor for Rapid and Sensitive Detection of Ofloxacin in Meat Products.

Ofloxacin (OFL) is widely used in animal husbandry and aquaculture due to its low price and broad spectrum of bacterial inhibition, etc. However, it is difficult to degrade and is retained in animal-derived food products, which are hazardous to human health. In this study, a simple and efficient method was developed for the detection of OFL residues in meat products. OFL coupled with amino magnetic beads by an amination reaction was used as a stationary phase. Aptamer AWO-06, which showed high affinity and specificity for OFL, was screened using the exponential enrichment (SELEX) technique. A fluorescent biosensor was developed by using AWO-06 as a probe and graphene oxide (GO) as a quencher. The OFL detection results could be obtained within 6 min. The linear range was observed in the range of 10-300 nM of the OFL concentration, and the limit of the detection of the sensor was 0.61 nM. Furthermore, the biosensor was stored at room temperature for more than 2 months, and its performance did not change. The developed biosensor in this study is easy to operate and rapid in response, and it is suitable for on-site detection. This study provided a novel method for the detection of OFL residues in meat products.

Phosphoproteomics analysis reveals the anti-bacterial and anti-virulence mechanism of eugenol against Staphylococcus aureus and its application in meat products.

The increasing risk of food poisoning caused by Staphylococcus aureus (S. aureus) contamination has aroused great concern about food safety. Eugenol is highly favored due to its broad-spectrum antibacterial activity and non-drug resistance property. The study aimed to reveal the anti-bacterial and anti-virulence mechanisms of eugenol against S. aureus using phosphoproteomics. The results indicated that eugenol could inhibit the phosphorylation levels of enzyme I in the bacterial phosphotransferase system (PTS). Meanwhile, it could also inhibit the phosphorylation levels of key enzymes in bacterial carbon metabolism (such as glucose-6-phosphate isomerase of glycolysis and succinyl-CoA synthetase of tricarboxylic acid cycle), thereby decreasing the content of ATP and accelerating bacterial death. In addition, eugenol could inhibit the phosphorylation of AgrA in the quorum sensing system, thereby inhibiting the expression of agr operons (agrA and agrC) and downstream virulence genes (RNAIII, hla and seb). Finally, the application on beef indicated that eugenol could effectively decrease the content of enterotoxins and improve its storage quality. These findings provide a new way for eugenol to prevent S. aureus contamination and food poisoning in meat products.

Schiff base linkage of citral to zinc-casein hydrolysate chelates for preparing starch-based active films against L. monocytogenes on ready-to-eat foods.

Listeria monocytogenes (L. monocytogenes) is a foodborne pathogen often found in ready-to-eat (RTE) foods, posing significant threats to human health. In this study, an active film based on cross-linking via Schiff base and electrostatic interaction to inactivate L. monocytogenes on RTE foods was constructed. Zinc-casein hydrolysate chelates (Zn-HCas) was prepared and blended with cationic starch (CSt) to form the substrates of the film. Then, Citral (CI) with excellent antibacterial properties was added to enhance the biological and packaging properties of the film through covalent cross-linking (Schiff base). Based on the zinc ion-activated metalloproteinases produced by L. monocytogenes, the cross-linked film could be disrupted and the release of CI was accelerated. The variation in color, FTIR, and amino group content proved that Schiff base reaction had taken place. Enhanced mechanical properties, barrier properties, thermal stability and antimicrobial activity against L. monocytogenes (exceed 99.99 %) were obtained from the CI/Zn-HCas/CSt film. The application on RTE cheese results demonstrated that the cross-linked film could be employed in active packaging field with the ability in maintaining the original chroma and texture properties of RTE cheese. In summary, the prepared cross-linked film could be used as an active packaging against L. monocytogenes contamination with great potential.

Recent advancements in the utilization of ultrasonic technology for the curing of processed meat products: A comprehensive review.

Curation meat products involves multiple stages, including pre-curing processing (thawing, cleaning, and cutting), curing itself, and post-curing processing (freezing, and packaging). Ultrasound are nonthermal processing technology widely used in food industry. This technology is preferred because it reduces the damages caused by traditional processing techniques on food, while simultaneously improving the nutritional properties and processing characteristics of food. The utilization of ultrasonic-assisted curing technology has attracted significant attention within the realm of meat product curing, encouraging extensive research efforts. In terms of curing meat products, ultrasonic-assisted curing technology has been widely studied due to its advantages of accelerating the curing speed, reducing nutrient loss, and improving the tenderness of cured meats. Therefore, this article aims to comprehensively review the application and mechanism of ultrasound technology in various stages of meat product curing. Furthermore, it also elaborates the effects of ultrasonic-assisted curing on the tenderness, water retention, and flavor substances of the meat products during the curing process. Besides, the implication of the ultrasound in the processing of meat curation plays a potent role together with other technologies or methods. The use of ultrasound technology in the process of meat curation was analyzed, which might be a theoretical insight for the industrialization prospects of the meat product.

Consumer preferences and willingness to pay for safe pork products in rural Kenya.

Designing interventions to support the safe development of rapidly growing livestock value chains in sub-Saharan Africa requires a clear understanding of consumer demands. This study aimed to determine purchase patterns, consumers' preferences, and willingness to pay for safe pork attributes; specifically, the presence of a veterinary inspection stamp and the cleanliness of the butchery. A discrete choice experiment-based survey was used to investigate the purchasing behavior of 401 pork consumers: 253 buying raw pork for household consumption, and 148 buying cooked pork for out-of-home consumption. The study findings indicate that the average quantity of pork purchased by consumers was approximately 0.4 Kg per transaction, with the majority of consumers making several purchases per week. The average price per Kg of pork was KES 310 (Approx. 2.60 USD) at the time of the study. Data from the choice experiment showed that consumers were willing to pay a price premium of KES 245 (Approx. 2.1 USD) and KES 164 (Approx. 1.4 USD) per Kg for evidence of better veterinary meat inspection and higher butchery hygiene respectively; further, these were the two most important attributes they considered while making a pork purchase decision. These findings highlight the potential to leverage consumers' willingness to pay to improve the food safety within pork value chains in this context. Investing to increase consumer awareness on food safety issues should be considered to generate an effective market demand, especially in rural areas with relatively lower literacy levels.

The utilisation of agricultural by-products in processed meat products: Effects on physicochemical, nutritional and sensory quality - Invited Review.

Several plant-based materials are discarded by the food industry due to oversupply, lack of transport, and inappropriate storage. These materials contain valuable essential micronutrients such as minerals, vitamins and bioactive components (e.g., polyphenol, tocopherols, ascorbic acid, carotenoids) with antioxidant, antimicrobial, and anti-inflammatory effects, among others. In the context of making our agriculture-food based economy more circular and sustainable, and to develop foods with clean labels and less E-numbers, fruits, vegetables, yams, cereal distillers, oilseeds and other plant by-products could be utilised and upcycled back into new food formulations. Meat products are a particularly suitable matrix for this purpose, due to their susceptibility to lipid and protein oxidation and microbial spoilage (which shorten their shelf life). This review brings together the latest (2020-23) reformulation efforts, preservative methods and other innovative pathways, including studies on by-products as plant-based additives and bio-actives. It will cover the use of plant-based by-products as natural additives into production of processed meat products such as burgers, fermented meats and sausages, produced from ruminant and monogastric animals (except poultry). The extraction methods, inclusion levels, processing methods used and the quality of the resulting meat products will be reported, including preservative effects (microbial growth, oxidative stability and shelf life) and effects on instrumental, nutritional and sensory quality. Furthermore, it will also critically discuss the gaps identified, recommendation of the most promising ingredients for quality enhancement, and provide directions for future research.

Maillard reaction products and metabolite profile of plant-based meat burgers compared with traditional meat burgers and cooking-induced alterations.

We are undergoing a food transformation with the introduction of plant-based meat analogues, but little is known about their chemical characteristics. This study aimed to elucidate the Maillard reactions in plant-based meat burger alternatives (PBMBA). For this purpose, NMR-based metabolomics and targeted MS analysis of Maillard and dehydroalanine pathway markers were conducted on six PBMBA prototypes with different proportions of high-moisture protein extrudates, low-moisture extrudates and pea protein on a commercial PBMBA and on a meat burger before and after cooking. Results revealed that higher levels of Maillard reaction markers were present in PBMBAs in the uncooked state, with lower levels formed during cooking compared with conventional meat. The metabolite profile disclosed that the distinct pattern of the Maillard reaction could be attributed to different substrate availability, but data also revealed that pre-processing of the plant protein affects the presence of Maillard reaction products in PBMBAs.

A review of hazards in meat products: Multiple pathways, hazards and mitigation of polycyclic aromatic hydrocarbons.

Polycyclic aromatic hydrocarbons (PAHs) are stable carcinogens that are widely distributed in the environment and food, and humans are exposed to PAHs primarily through the respiratory tracts, dermal contact, and dietary intake. Meat products are an essential part of the human diet, and the formation of PAHs during meat processing is unavoidable. Therefore, a comprehensive understanding of PAHs in meat products can be a contribution to the minimization of human exposure dose. The aim of this review is to provide a comprehensive description of the toxicological analysis of PAHs intake and the various production pathways. The distribution of different PAHs in various meat products, including poultry and aquatic products, is analyzed. The discussion focuses on controlling PAHs through the use of endogenous marinades and antioxidants as well as reducing exogenous particulate matter-PAHs attachment. In addition, potential strategies for PAHs reduction and possible directions for future research are proposed.

Comparison of competitive and sandwich immunochromatographic analysis in the authentication of chicken in meat products.

Cheap chicken meat is often used as an undeclared substitute in meat products. In this study, two formats of the immunochromatographic assay (ICA) of immunoglobulins of class Y (IgY) as a biomarker for chicken authentication were developed. In both competitive ICA (cICA) and sandwich ICA (sICA), gold nanoparticles (GNP) were conjugated with anti-species antibodies. A simple procedure of sample preparation, which took only 30 min, was proposed. Test systems demonstrated high sensitivity and rapidity: visual limits of detection of IgY and assay durations were 12/14 ng/mL and 10/15 min for cICA and sICA, respectively. The absence of cross-reactivity with the mammalian species confirmed the high specificity of the test systems. Good applicability of the assays was confirmed for the detection of chicken in raw meat mixtures: as low as 3% and 0.2% (w/w) of chicken could be revealed in beef and pork by cICA and sICA, respectively. The influence of heat processing of meat-based products on immune recognition and, consequently, the analytical performance of the test systems was revealed. It was shown that sICA is preferable for the detection of IgY even in thermally processed meat. The proposed ICAs can be recommended for rapid on-site control of meat products' composition.

Effect of magnetic field mediated CaCl2 on the edible quality of low-sodium minced pork gels.

Magnetic field combined with calcium chloride (CaCl2,) treatment is a highly promising technique for reducing sodium chloride (NaCl) in meat. Therefore, this paper investigated the effect of reducing NaCl addition (0-10%) by CaCl2 in combination with a magnetic field (3.8 mT) on the edible quality of low-salt pork mince. It is desired to drive the application of magnetic field and CaCl2 in low-sodium meat processing in this way. Results showed that the cooking yield, color, hardness, elasticity, mouthfeel, apparent texture, and orderliness of protein conformation of all minced pork were improved as compared to the control group, while the electron nose response values of their volatile sulfides and nitrogen oxides were decreased. In particular, the best edible quality and perceived salty intensity of minced pork gel was obtained by using CaCl2 in place of 5% NaCl under magnetic field mediation. In addition, energy dispersive X-ray spectroscopy scans showed that the reduced NaCl treatment by magnetic field combined with CaCl2 could increase the signal intensity of sodium in minced pork matrices to some extent. Magnetic field-mediated substitution of NaCl for CaCl2 treatment was also found to be favorable for inducing the transition of the protein secondary structure from an irregularly coiled to a ß-folded structure (demonstrated by infrared spectroscopy). In short, magnetic fields combined with CaCl2 instead of NaCl was a highly promising method of producing low-NaCl meats.