Drawing and storing blood using a 3D printed bottle cap and a disinfected 500 mL drinking bottle: A proof-of-concept study.

BACKGROUND: Today, with wars raging in Ukraine and the Middle East, the demand for blood is high. Despite this, few companies produce the necessary equipment to draw, store, and transfuse whole blood. This study evaluated the safety and performance of a 3D printed bottle cap in conjunction with a water bottle and some available consumables to draw and store fresh whole blood. STUDY DESIGN AND METHODS: Bags of saline, and freshly donated whole blood, was transferred to the water bottle through a 3D printed bottle cap and stored for 72 h. An identical setup, transferring saline to a Terumo blood collection bag was used as control. Performance and safety were evaluated by calculating infusion rate and observing for backflow, respectively. The blood was also tested for hemolysis and bacterial growth at four sampling points. RESULTS: The cap-and-bottle setup was faster than control in terms of flow rate when transferring saline (1.53 vs. 1.81 mL/s, p < .001), and non-inferior to saline control when transfusing blood (1.53 vs. 1.49 mL/s, p = .641). We did not observe any risks of causing the donor iatrogenic harm, and there was no evidence of increased hemolysis. However, there were traces of bacterial contamination in three of six bottles. CONCLUSION: This study indicates that drawing blood is both feasible and safe, utilizing a 3D printed cap and bottle setup. Flow rate was faster than control, and mechanical properties of the blood were not affected. We were unable to determine the source of bacterial contamination in the blood.

The effectiveness of the manual pressure points technique for hemorrhage control-The 2022 THOR pre-conference meeting experience.

INTRODUCTION: Limb and junctional hemorrhage are leading causes of potentially preventable death among trauma casualties. Hemorrhage control for these regions could be achieved by direct or indirect pressure. The manual pressure points (MPP) involves applying manual pressure on the arterial supply to occlude distal blood flow without the need for specialized equipment. STUDY DESIGN AND METHODS: Prospective, non-randomized, human volunteer, controlled environment study involving 38 healthy military caregivers, with 26 participants attending a short instructional session. During a medical exercise, participants were requested to apply pressure on the supraclavicular and femoral points aiming to stop regional blood flow, measured by distal pulse palpation. The measures recorded included achievement of distal pulse cessation, success in achieving cessation for a full minute, and subjects' pain scores reported after each attempt. RESULTS: All participants succeeded in achieving distal pulse cessation for both the supraclavicular and femoral points for a full minute. The median time to initial success was 3.0 (interquartile range 2.0-5.0) seconds in the supraclavicular point and 4.5 (interquartile range 3.0-6.0) seconds in the femoral point. Pain scores ranging between 0 and 3 were reported by most subjects during supraclavicular (68.4%) and femoral occlusion (84.2%). CONCLUSION: The MPP technique was highly effective in occluding distal palpable pulses in healthy volunteers when applied to the supraclavicular and femoral arteries. Brief instruction on the technique can potentially improve the chances of achieving hemorrhage control within 5 s. Further research is required to determine efficacy among different populations and providers with varying experience levels.

Risk of Harm Associated With Using Rapid Sequence Induction Intubation and Positive Pressure Ventilation in Patients With Hemorrhagic Shock.

Based on limited published evidence, physiological principles, clinical experience, and expertise, the author group has developed a consensus statement on the potential for iatrogenic harm with rapid sequence induction (RSI) intubation and positive-pressure ventilation (PPV) on patients in hemorrhagic shock. "In hemorrhagic shock, or any low flow (central hypovolemic) state, it should be noted that RSI and PPV are likely to cause iatrogenic harm by decreasing cardiac output." The use of RSI and PPV leads to an increased burden of shock due to a decreased cardiac output (CO)2 which is one of the primary determinants of oxygen delivery (DO2). The diminishing DO2 creates a state of systemic hypoxia, the severity of which will determine the magnitude of the shock (shock dose) and a growing deficit of oxygen, referred to as oxygen debt. Rapid accumulation of critical levels of oxygen debt results in coagulopathy and organ dysfunction and failure. Spontaneous respiration induced negative intrathoracic pressure (ITP) provides the pressure differential driving venous return. PPV subsequently increases ITP and thus right atrial pressure. The loss in pressure differential directly decreases CO and DO2 with a resultant increase in systemic hypoxia. If RSI and PPV are deemed necessary, prior or parallel resuscitation with blood products is required to mitigate post intervention reduction of DO2 and the potential for inducing cardiac arrest in the critically shocked patient.

Validation of a point-of-care capillary lactate measuring device (Lactate Pro 2).

BACKGROUND: The measurement of lactate in emergency medical services has the potential for earlier detection of shock and can be performed with a point-of-care handheld device. Validation of a point-of-care handheld device is required for prehospital implementation. AIM: The primary aim was to validate the accuracy of Lactate Pro 2 in healthy volunteers and in haemodynamically compromised intensive care patients. The secondary aim was to evaluate which sample site, fingertip or earlobe, is most accurate compared to arterial lactate. METHODS: Arterial, venous and capillary blood samples from fingertips and earlobes were collected from intensive care patients and healthy volunteers. Arterial and venous blood lactate samples were analysed on a stationary hospital blood gas analyser (ABL800 Flex) as the reference device and compared to the Lactate Pro 2. We used the Bland-Altman method to calculate the limits of agreement and used mixed effect models to compare instruments and sample sites. A total of 49 intensive care patients with elevated lactate and 11 healthy volunteers with elevated lactate were included. RESULTS: There was no significant difference in measured lactate between Lactate Pro 2 and the reference method using arterial blood in either the healthy volunteers or the intensive care patients. Capillary lactate measurement in the fingertip and earlobe of intensive care patients was 47% (95% CI (29 to 68%), p < 0.001) and 27% (95% CI (11 to 45%), p < 0.001) higher, respectively, than the corresponding arterial blood lactate. In the healthy volunteers, we found that capillary blood lactate in the fingertip was 14% higher than arterial blood lactate (95% CI (4 to 24%), p = 0.003) and no significant difference between capillary blood lactate in the earlobe and arterial blood lactate. CONCLUSION: Our results showed that the handheld Lactate Pro 2 had good agreement with the reference method using arterial blood in both intensive care patients and healthy volunteers. However, we found that the agreement was poorer using venous blood in both groups. Furthermore, the earlobe may be a better sample site than the fingertip in intensive care patients.

Cognitive and physical performance are well preserved following standard blood donation: A noninferiority, randomized clinical trial.

BACKGROUND: A walking blood bank (WBB) refers to the use of fellow combatants for battlefield blood donation. This requires pretesting combatants for infectious diseases and blood type. A fundamental prerequisite for this technique is that the donating soldier will suffer minimal physiological and mental impact. The purpose of the current study is to assess the effect of blood shedding on battlefield performance. METHODS: This is a double-blind randomized control trial. Forty Israel Defense Forces combatants volunteered for the study. Participants underwent baseline evaluation, including repeated measurement of vital signs, cognitive evaluation, physical evaluation, and a strenuous shooting test. Three weeks after the baseline evaluation, subjects were randomized to either blood donation or the control group. For blinding purposes, all subjects underwent venous catheterization for the duration of a blood donation. Repeated vital signs and function evaluation were then performed. RESULTS: Thirty-six patients were available for randomization. Baseline measurements were similar for both groups. Mean strenuous shooting score was 80.5 ± 9.5 for the control group and 82 ± 6.6 for the test group (p = 0.58). No clinically or statistically significant differences were found in tests designed to evaluate cognitive performance or physical functions. Vital signs taken multiple times were also similar between the test and control groups. CONCLUSIONS: Executive, cognitive, and physical functions were well preserved after blood donation. This study supports the hypothesis that a WBB does not decrease donor combat performance. The categorical prohibition of physical exercise following blood donation might need to be reconsidered in both military and civilian populations.

Trauma Hemostasis and Oxygenation Research Network position paper on the role of hypotensive resuscitation as part of remote damage control resuscitation.

The Trauma Hemostasis and Oxygenation Research (THOR) Network has developed a consensus statement on the role of permissive hypotension in remote damage control resuscitation (RDCR). A summary of the evidence on permissive hypotension follows the THOR Network position on the topic. In RDCR, the burden of time in the care of the patients suffering from noncompressible hemorrhage affects outcomes. Despite the lack of published evidence, and based on clinical experience and expertise, it is the THOR Network's opinion that the increase in prehospital time leads to an increased burden of shock, which poses a greater risk to the patient than the risk of rebleeding due to slightly increased blood pressure, especially when blood products are available as part of prehospital resuscitation.The THOR Network's consensus statement is, "In a casualty with life-threatening hemorrhage, shock should be reversed as soon as possible using a blood-based HR fluid. Whole blood is preferred to blood components. As a part of this HR, the initial systolic blood pressure target should be 100 mm Hg. In RDCR, it is vital for higher echelon care providers to receive a casualty with sufficient physiologic reserve to survive definitive surgical hemostasis and aggressive resuscitation. The combined use of blood-based resuscitation and limiting systolic blood pressure is believed to be effective in promoting hemostasis and reversing shock".

Immediate effects of blood donation on physical and cognitive performance-A randomized controlled double-blinded trial.

BACKGROUND: The success of implementing damage control resuscitation principles pre-hospital has been at the expense of several logistic burdens including the requirements for resupply, and the question of donor safety during the development of whole blood programs. Previous studies have reported effects on physical performance after blood donation; however, none have investigated the effects of blood donation on cognitive performance. METHOD: We describe a prospective double-blinded, randomized, controlled study comprised of a battery of tests: three cognitive tests, and VO2max testing on a cycle ergometer. Testing was performed 7 days before blinded donation (baseline day), immediately after donation (Day 0), and 7 days (Day 7) after donation. The inclusion criteria included being active blood donors at the Haukeland University Hospital blood bank, where eligibility requirements were met on the testing days, and providing informed consent. Participants were randomized to either the experimental (n = 26) or control group (n = 31). Control group participants underwent a 'mock donation" in which a phlebotomy needle was placed but blood was not withdrawn. RESULTS: In the experimental group, mean ± SEM VO2max declined 6% from 41.35 ± 1.7 mLO2/(min·kg) at baseline to 39.0 ± 1.6 mLO2/(min·kg) on Day 0 and increased to 40.51 ± 1.5 mLO2/(min·kg) on Day 7. Comparable values in the control group were 42.1 ± 1.8 mLO2/(min·kg) at baseline, 41.6 ± 1.8 mLO2/(min·kg)) on Day 1 (1% decline from baseline), and 41.8 ± 1.8 mLO2/(min·kg) on Day 7.Comparing scores of all three cognitive tests on Day 0 and Day 7 showed no significant differences (p > 0.05). CONCLUSION: Our main findings are that executive cognitive and physical performances were well maintained after whole blood donation in healthy blood donors. The findings inform postdonation guidance on when donors may be required to return to duty. LEVEL OF EVIDENCE: Randomized, controlled, double-blinded prospective trial study, level 1.

Emergency sternal intraosseous access for warm fresh whole blood transfusion in damage control resuscitation.

BACKGROUND: Intraosseous (IO) vascular access is increasingly used as an emergency tool for achieving access to the systemic circulation in critically ill patients. The role of IO transfusion of blood in damage control resuscitation is however questionable due to possible inadequate flow rate and hemolysis. Some experts claim that IO transfusion is contraindicated. In this study, we have challenged this statement by looking at flow rates of autologous fresh whole blood reinfusion and hemolysis using two of the commonly used Food and Drug Administration-approved and Conformité Européenne (CE)-marked sternal needles. Additionally, the success rate of sternal access between the two devices is evaluated. METHODS: Volunteer professional military personnel, were enrolled prospectively in a nonrandomized observational study design. We collected 450 mL of autologous whole blood from each participant. Participants were divided into the following three groups of 10: Tactically Advanced Lifesaving IO Needle (T.A.L.O.N.) IO, FAST1 IO, and intravenous group. The reinfusion was done by gravity only. Blood sampling was performed before blood collection and 30 minutes after reinfusion. Investigation of hemolysis was performed by measurements of haptoglobin and lactate dehydrogenase. Success rate was evaluated by correct aspiration of bone marrow. RESULTS: Median reinfusion rate was 46.2 mL/min in the FAST1 group, 32.4 mL/min in the T.A.L.O.N. group, and 74.1 mL/min in the intravenous group. Blood samples from all participants were within normal ranges. There was no statistically significant difference in haptoglobin and lactate dehydrogenase between the groups. In the FAST1 group, 1 (9%) of 11 procedures failed. In the T.A.L.O.N. group, 4 (29%) of 14 procedures failed. CONCLUSION: Although preferable, achieving peripheral venous access in the bleeding patient is a major problem. Our findings suggest that fresh whole-blood transfusion through the IO route is safe, reliable, and provide sufficient flow for resuscitation. LEVEL OF EVIDENCE: Therapeutic/Care management study, level III.

Staff officers as blood suppliers: Effects of repeated donations and autologous reinfusions of untransfused units.

BACKGROUND: Limited blood inventory and resupply chains in combat settings can result in preventable deaths from traumatic hemorrhage. One way of mitigating this could be to establish donor pools where blood is collected in advance of high-risk missions and then reinfused back to the donor if not needed to treat casualties. METHODS: Four hundred fifty milliliters plus 56 mL of blood was collected, rested for 2 hours in room temperature, and stored at 4°C. The blood was reinfused 22 to 24 hours after donation and the donor observed for adverse reactions. Samples were collected before and 20 minutes after each donation for hematology, immunoglobulin G, ferritin, C-reactive protein, total protein, lactate dehydrogenase, bilirubin, haptoglobin, and activated partial thromboplastin time. RESULTS: Nine participants went through a total of 36 donation and reinfusion procedures. Four donors participated in five rounds, two in four rounds, two in three rounds, and one in two rounds. A significant drop was seen in hemoglobin (14.6 ± 0.9 to 13.9 ± 0.9) and ferritin (179 ± 70 to 149 ± 78) from before the first donation to after the last reinfusion (p < 0.05). Other parameters were unaffected. CONCLUSION: This small pilot study suggests that repeated donations and reinfusions may be both feasible and safe. Blood collected in this way should be labeled with the donor's full name and social security number (or similar) and the identity visually verified by the donor immediately before both donation and reinfusion. To further reduce risk, this form of donation should be restricted to scenarios where there is no other option for making blood available. LEVEL OF EVIDENCE: Therapeutic/Care management study, level V.

A proposed field emergency donor panel questionnaire and triage tool.

BACKGROUND: The provision of transfusion support to isolated military or civilian projects may require the use of an emergency donor panel (EDP) for immediate warm fresh whole blood (WFWB). The aim of this short discussion article is to raise and resolve some of the practical aspects for the nonspecialist faced with the emergency collection of WFWB whole blood in the austere medical environment (AME). METHODS AND RESULTS: A proposed field EDP questionnaire and triage tool (QTT) is presented. It is designed for the hostile, remote, or austere environment that falls outside normal regulated supply of cold-stored blood products or removed from trained blood collection personnel, where collection may fall to an isolated medical provider. The tool has been drafted based on review of existing guidelines and consultation with practitioners. It serves as a point of reference for local guidelines and has yet to be validated. CONCLUSIONS: The use of the EDP is associated with risk; however, it remains the simplest method of providing rapid transfusion support. The best way to manage the risk is to brief and prescreen blood donors before deployment. An abbreviated donor QTT can be an aide to decision making at the time of donation. The tool should be tailored to requirements and underpinned by policy and training.

Making whole blood available in austere medical environments: donor performance and safety.

BACKGROUND: To provide whole blood on the battlefield can be a challenge, but a buddy system protocol is both an elegant and the only currently available means to supply blood to a Special Forces team in far-forward locations. Our aim was to investigate donor-safety associated with such a protocol. METHODS: This study was a randomized, double-blinded, controlled trial that aimed to evaluate the immediate effects of a 450 cc blood donation on physical performance in fatigued and dehydrated Special Forces soldiers. The primary outcome variables were absolute and relative maximal oxygen uptake (VO2max ), exercise tolerance time (ETT) and heart rate (HR). RESULTS: Relative VO2max decreased by 7.1% in the donation group between pre and posttest, compared to no change in the control group. Absolute VO2max decreased by 11.2 and 3.6% between pre and posttest in the donation and control groups, respectively. Mean ETT in the donation group was on average 92 seconds shorter compared to baseline, which represents a decrease of 9.5%. CONCLUSION: Donating blood after a week of strenuous physical activity is feasible for Special Forces personnel. While the donation results in some diminishment of VO2max , a 3.6%-11.2% decrease in relative VO2max , and in elevation of submaximal HR levels highly trained personnel continue to perform well both at both sub-maximal and maximal effort levels.

"Blood failure" time to view blood as an organ: how oxygen debt contributes to blood failure and its implications for remote damage control resuscitation.

Hemorrhagic shock is both a local and systemic disorder. In the context of systemic effects, blood loss may lead to levels of reduced oxygen delivery (DO2 ) sufficient to cause tissue ischemia. Similar to other physiologic debts such as sleep, it is not possible to incur a significant oxygen debt and suffer no consequences for lack of timely repayment. While the linkage between oxygen debt and traditional organ failure (renal, hepatic, lung, and circulation) has been long recognized, we should consider failure in two additional linked and very dynamic organ systems, the endothelium and blood. These systems are very sensitive to oxygen debt and at risk for failing, having further implications on all other organ systems. The degree of damage to the endothelium is largely modulated by the degree of oxygen debt. Thus hypoperfusion is believed to begin a cascade of events leading to acute traumatic coagulopathy (ATC). This combination of oxygen debt driven endothelial damage and ATC might be considered collectively as "blood failure" due to the highly connected networks between these drivers. This article presents the implications of oxygen debt for remote damage control resuscitation strategies, such as permissive hypotension and hemostatic resuscitation. We review the impact of whole blood resuscitation and red blood cell efficacy in mitigation of oxygen debt. At last, this article recognizes the need for simple and durable, lightweight equipment that can detect the adequacy of tissue DO2 and thus patient needs for resuscitative care. Point-of-care lactate measuring may be a predictive tool for identifying high-risk trauma patients and occult shock because it provides information beyond that of vital signs and mechanism of injury as it may help predict the level of oxygen debt accumulation and need for resuscitation. Serial measurements may also be valuable as a tool in guiding resuscitative efforts.

Blood far forward: Time to get moving!

In planning for future contingencies, current problems often crowd out historical perspective and planners often turn to technological solutions to bridge gaps between desired outcomes and the reality of recent experience. The US Military, North Atlantic Treaty Organization, and other allies are collectively taking stock of 10-plus years of medical discovery and rediscovery of combat casualty care after the wars in Iraq and Afghanistan. There has been undeniable progress in the treatment of combat wounded during the course of the conflicts in Southwest Asia, but continued efforts are required to improve hemorrhage control and provide effective prehospital resuscitation that treats both coagulopathy and shock. This article presents an appraisal of the recent evolution in medical practice in historical context and suggests how further gains in far forward resuscitation might be achieved using existing technology and methods based on whole-blood transfusion while research on new approaches continues.

The lost art of whole blood transfusion in austere environments.

The optimal resuscitation fluid for uncontrolled bleeding and hemorrhagic shock in both pre- and in-hospital settings has been an ongoing controversy for decades. Hemorrhage continues to be a major cause of death in both the civilian and military trauma population, and survival depends on adequacy of hemorrhage control and resuscitation between onset of bleeding and arrival at a medical treatment facility. The terms far-forward and austere are defined, respectively, as the environment where professional health care providers normally do not operate and a setting in which basic equipment and capabilities necessary for resuscitation are often not available. The relative austerity of a treatment setting may be a function of timing rather than just location, as life-saving interventions must be performed quickly before hemorrhagic shock becomes irreversible. Fresh whole blood transfusions in the field may be a feasible life-saving procedure when facing significant hemorrhage.

Emergency whole-blood use in the field: a simplified protocol for collection and transfusion.

Military experience and recent in vitro laboratory data provide a biological rationale for whole-blood use in the treatment of exsanguinating hemorrhage and have renewed interest in the reintroduction of fresh whole blood and cold-stored whole blood to patient care in austere environments. There is scant evidence to support, in a field environment, that a whole blood-based resuscitation strategy is superior to a crystalloid/colloid approach even when augmented by a limited number of red blood cell (RBC) and plasma units. Recent retrospective evidence suggests that, in this setting, resuscitation with a full compliment of RBCs, plasma, and platelets may offer an advantage, especially under conditions where evacuation is delayed. No current evacuation system, military or civilian, is capable of providing RBC, plasma, and platelet units in a prehospital environment, especially in austere settings. As a result, for the vast minority of casualties, in austere settings, with life-threatening hemorrhage, it is appropriate to consider a whole blood-based resuscitation approach to provide a balanced response to altered hemostasis and oxygen debt, with the goal of reducing the risk of death from hemorrhagic shock. To optimize the successful use of fresh whole blood/cold-stored whole blood in combat field environments, proper planning and frequent training to maximize efficiency and safety will be required. Combat medics will need proper protocol-based guidance and education if whole-blood collection and transfusion are to be successfully and safely performed in austere environments. In this article, we present the Norwegian Naval Special Operation Commando unit-specific remote damage control resuscitation protocol, which includes field collection and transfusion of whole blood. This protocol can serve as a template for others to use and adjust for their own military or civilian unit-specific needs and capabilities for care in austere environments.

Blood Far Forward--a whole blood research and training program for austere environments.

The Blood Far Forward (BFF) research program was established to conduct blood product efficacy and safety studies, donor performance studies, and research on optimal training methods to improve the safety of blood collection and transfusion performed by Norwegian Naval Special Operation Commando soldiers. The use of intravenous fluids for volume replacement during hemorrhagic shock is controversial, but it is currently the standard of care. In the far-forward environment, large volume resuscitation for massive bleeding is a great challenge. Crystalloid and colloid solutions add weight and bulk to the medic's kit, require temperature sensitive storage, and should be warmed before infusion to prevent hypothermia. Excessive use of these solutions causes a dilutional coagulopathy, acidosis, and potentially increased inflammatory injury compared with blood products. Type-specific whole blood from an uninjured combat companion on the other hand is almost always available. It is warm, replaces intravascular volume, and provides oxygen delivery and hemostatic capacity to prevent or treat shock and coagulopathy. Whole blood may be ideal for the resuscitation of combat casualties with hemorrhagic shock. BFF program pilot studies on use of platelet-sparing leukoreduction filters, whole blood transport tolerance, donor performance, and autologous reinfusion of 24-hour ambient temperature stored whole blood have been performed and suggest the feasibility of expanding whole blood use in resuscitation. If successful, the BFF program will change tactics, techniques, and procedures with a new lifesaving capability.