RESUMEN
ß-Caryophyllene is a plant-derived bicyclic sesquiterpene with multiple biological functions. ß-Caryophyllene production by engineered Saccharomyces cerevisiae represents a promising technological route. However, the low catalytic activity of ß-caryophyllene synthase (CPS) is one of the main restrictive factors for ß-caryophyllene production. Here, directed evolution of the Artemisia annua CPS was performed, and variants of CPS enhancing the ß-caryophyllene biosynthesis in S. cerevisiae were obtained, in which an E353D mutant enzyme presented large improvements in Vmax and Kcat. The Kcat/Km of the E353D mutant was 35.5% higher than that of wild-type CPS. Moreover, the E353D variant exhibited higher catalytic activity in much wider pH and temperature ranges. Thus, both the higher catalytic activity and the robustness of the E353D variant contribute to the 73.3% increase in ß-caryophyllene production. Furthermore, the S. cerevisiae chassis was engineered by overexpressing genes related to ß-alanine metabolism and MVA pathway to enhance the synthesis of the precursor, and ATP-binding cassette transporter gene variant STE6T1025N to improve the transmembrane transport of ß-caryophyllene. The combined engineering of CPS and chassis resulted in 70.45 mg/L of ß-caryophyllene after 48 h of cultivation in a test tube, which was 2.93-fold of that of the original strain. Finally, a ß-caryophyllene yield of 594.05 mg/L was obtained by fed-batch fermentation, indicating the potential of ß-caryophyllene production by yeast.
Asunto(s)
Artemisia annua , Sesquiterpenos , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , Sesquiterpenos Policíclicos/metabolismo , Sesquiterpenos/metabolismo , Artemisia annua/genética , Óxido Nítrico Sintasa/metabolismo , Ingeniería Metabólica/métodosRESUMEN
Cat8 is an important transcription factor regulating the utilization of non-fermentative carbon sources in Saccharomyces cerevisiae. However, our previous studies found that Cat8 may play a critical role in nitrogen metabolism, but the regulatory mechanism has not been elucidated. In this study, the nuclear localization and analysis of regulatory activity showed that the Cat8 function relies on Snf1 kinase. In the fermentation with glucose or glycerol as carbon sources under phenylalanine (Phe) induction, by comparing the changes of cellular gene expression and Cat8 target gene binding profiles after Cat8 overexpression, enhanced transcription was shown among key genes involved in the Ehrlich pathway (e.g., ARO9, ARO10, and ADH2) and its upstream and downstream related factors (e.g., GAP1, AGP1, GAT1, PDR12, and ESPB6), indicating that Cat8 participated in the regulation of nitrogen metabolism. Moreover, highly active Cat8 interacts with transcriptional activator Aro80 and GATA activator Gat1 coordinately to regulate the transcription of ARO10. Altogether, our results showed that Cat8 may act as a global transcription factor in response to nutritional changes, regulating both carbon and nitrogen utilization. This provides a new insight for us to explore the regulation of cell nutrient metabolism networks in yeast.
RESUMEN
Copper is an essential micronutrient for life, whose homeostasis is rigorously regulated to meet the demands of normal biological processes and to minimize the potential toxicity. Copper enriched by yeast is regarded as a safe and bioavailable form of copper supplements. Here, a Saccharomyces cerevisiae mutant strain H247 with expanded storage capability of copper was obtained through atmospheric and room-temperature plasma treatment. Transcriptomic analyses found that transcriptional upregulation of DGA1 might be the major contributor to the enhancement of intracellular copper accumulation in strain H247. The positive correlation between biogenesis of lipid droplets and intracellular accumulation of copper was confirmed by overexpression of the diacylglycerol acyltransferase encoding genes DGA1 and LRO1 or knockout of DGA1. Lipid droplets are not only the storage pool of copper but might prompt the copper trafficking to mitochondria, vacuoles, and Golgi apparatus. These results provide new insights into the sophisticated copper homeostatic mechanisms and the biological functions of lipid droplets.
Asunto(s)
Proteínas de Saccharomyces cerevisiae , Saccharomyces cerevisiae , Cobre/farmacología , Gotas Lipídicas/metabolismo , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismo , TranscriptomaRESUMEN
Mevalonate (MVA) pathway is the core for terpene and sterol biosynthesis, whose metabolic flux influences the synthesis efficiency of such compounds. Saccharomyces cerevisiae is an attractive chassis for the native active MVA pathway. Here, the truncated form of Enterococcus faecalis MvaE with only 3-Hydroxy-3-methylglutaryl coenzyme A reductase (HMGR) activity was found to be the most effective enzyme for MVA pathway flux using squalene as the metabolic marker, resulting in 431-fold and 9-fold increases of squalene content in haploid and industrial yeast strains respectively. Furthermore, a positive correlation between MVA metabolic flux and ß-alanine metabolic activity was found based on a metabolomic analysis. An industrial strain SQ3-4 with high MVA metabolic flux was constructed by combined engineering HMGR activity, NADPH regeneration, cytosolic acetyl-CoA supply and ß-alanine metabolism. The strain was further evaluated as the chassis for terpenoids production. Strain SQ3-4-CPS generated from expressing ß-caryophyllene synthase in SQ3-4 produced 11.86 ± 0.09 mg l-1 ß-caryophyllene, while strain SQ3-5 resulted from down-regulation of ERG1 in SQ3-4 produced 408.88 ± 0.09 mg l-1 squalene in shake flask cultivations. Strain SQ3-5 produced 4.94 g l-1 squalene in fed-batch fermentation in cane molasses medium, indicating the promising potential for cost-effective production of squalene.
Asunto(s)
Hidroximetilglutaril-CoA Reductasas , Ácido Mevalónico , Saccharomyces cerevisiae , beta-Alanina , Hidroximetilglutaril-CoA Reductasas/metabolismo , Ingeniería Metabólica , Ácido Mevalónico/metabolismo , Ingeniería de Proteínas , Saccharomyces cerevisiae/enzimología , Saccharomyces cerevisiae/genética , Escualeno/metabolismo , Terpenos/metabolismo , beta-Alanina/metabolismoRESUMEN
Carotenoids are unsaturated compounds with terpene groups. Among them, astaxanthin has strong antioxidant properties. It is widely used in aquaculture, food, medicine, and cosmetics with a broad market prospect. Phaffia rhodozyma is an important microorganism that synthesizes astaxanthin, but its wild strains have low pigment content, long growth cycle, and low fermentation temperature. Therefore, it is important to research the genetic improvement of the physiological and biochemical properties of P. rhodozyma. In this study, the atmospheric and room temperature plasma mutagenesis technology was adopted, through the functional evolution of the carotenoid production performance; then, through the comparative analysis of the genomics and transcriptomics of the wild strain and evolved strain, the key factor GST1 gene that affects carotenoid synthesis was discovered.
RESUMEN
Copper is an essential trace element for living organisms. Copper enriched by yeast of Saccharomyces cerevisiae is regarded as the biologically available organic copper supplement with great potentiality for application. However, the lower uptake ratio of copper ions makes the production of copper enriched by yeast uneconomically and environmentally unfriendly. In this study, S. cerevisiae Cu-5 with higher copper tolerance and intracellular copper accumulation was obtained by screening of our yeast strains collection. To increase the uptake ratio of copper ions, the medium composition and cultivation conditions for strain Cu-5 were optimized systematically. A medium comprised of glucose, yeast extract, (NH4)2SO4, and inorganic salts was determined, then a novel cultivation strategy including pH control at 5.5 and increasing amounts of yeast extract for a higher concentration of copper ion in the medium was developed. The uptake ratios of copper ions were more than 90% after combining 50 to 100 mg/L copper ions with 3.5 to 5.0 g/L yeast extract, which is the highest until now and is conducive to the cost-effective and environmentally friendly production of bioactive copper in yeast-enriched form.
Asunto(s)
Cobre , Saccharomyces cerevisiae , Transporte Biológico , Medios de Cultivo , IonesRESUMEN
Transcriptional downregulation is widely used for metabolic flux control. Here, marO, a cis-element of Escherichia coli mar operator, was explored to engineer promoters of Saccharomyces cerevisiae for downregulation. First, the ADH1 promoter (PADH1) and its enhanced variant PUADH1 were engineered by insertion of marO into different sites, which resulted in decrease in both gfp5 transcription and GFP fluorescence intensity to various degrees. Then, marO was applied to engineer the native ERG1 and ERG11 promoters due to their importance for accumulation of value-added intermediates squalene and lanosterol. Elevated squalene content (4.9-fold) or lanosterol content (4.8-fold) and 91 or 28% decrease in ergosterol content resulted from the marO-engineered promoter PERG1(M5) or PERG11(M3), respectively, indicating the validity of the marO-engineered promoters in metabolic flux control. Furthermore, squalene production of 3.53 g/L from cane molasses, a cheap and bulk substrate, suggested the cost-effective and promising potential for squalene production.
Asunto(s)
Proteínas de Saccharomyces cerevisiae , Saccharomyces cerevisiae , Regulación hacia Abajo , Ergosterol , Ingeniería Metabólica , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismo , EscualenoRESUMEN
BACKGROUND: Saccharomyces cerevisiae is well-known as an ideal model system for basic research and important industrial microorganism for biotechnological applications. Acetic acid is an important growth inhibitor that has deleterious effects on both the growth and fermentation performance of yeast cells. Comprehensive understanding of the mechanisms underlying S. cerevisiae adaptive response to acetic acid is always a focus and indispensable for development of robust industrial strains. eIF5A is a specific translation factor that is especially required for the formation of peptide bond between certain residues including proline regarded as poor substrates for slow peptide bond formation. Decrease of eIF5A activity resulted in temperature-sensitive phenotype of yeast, while up-regulation of eIF5A protected transgenic Arabidopsis against high temperature, oxidative or osmotic stress. However, the exact roles and functional mechanisms of eIF5A in stress response are as yet largely unknown. RESULTS: In this research, we compared cell growth between the eIF5A overexpressing and the control S. cerevisiae strains under various stressed conditions. Improvement of acetic acid tolerance by enhanced eIF5A activity was observed all in spot assay, growth profiles and survival assay. eIF5A prompts the synthesis of Ume6p, a pleiotropic transcriptional factor containing polyproline motifs, mainly in a translational related way. As a consequence, BEM4, BUD21 and IME4, the direct targets of Ume6p, were up-regulated in eIF5A overexpressing strain, especially under acetic acid stress. Overexpression of UME6 results in similar profiles of cell growth and target genes transcription to eIF5A overexpression, confirming the role of Ume6p and its association between eIF5A and acetic acid tolerance. CONCLUSION: Translation factor eIF5A protects yeast cells against acetic acid challenge by the eIF5A-Ume6p-Bud21p/Ime4p/Bem4p axles, which provides new insights into the molecular mechanisms underlying the adaptive response and tolerance to acetic acid in S. cerevisiae and novel targets for construction of robust industrial strains.
RESUMEN
BACKGROUND: 2-phenylethanol (2-PE) is an important aromatic compound with a lovely rose-like scent. Saccharomyces cerevisiae is a desirable microbe for 2-PE production but its natural yield is not high, and one or two crucial genes' over-expression in S. cerevisiae did not improve 2-PE greatly. RESULTS: A new metabolic module was established here, in which, permease Gap1p for L-phenylalanine transportation, catalytic enzymes Aro8p, Aro10p and Adh2p in Ehrlich pathway respectively responsible for transamination, decarboxylation and reduction were assembled, besides, glutamate dehydrogenase Gdh2p was harbored for re-supplying another substrate 2-oxoglutarate, relieving product glutamate repression and regenerating cofactor NADH. Due to different promoter strengths, GAP1, ARO8, ARO9, ARO10, ADH2 and GDH2 in the new modularized YS58(G1-A8-A10-A2)-GDH strain enhanced 11.6-, 15.4-, 3.6-, 17.7-, 12.4- and 7.5-folds respectively, and crucial enzyme activities of aromatic aminotransferases and phenylpyruvate decarboxylase were 4.8- and 7-folds respectively higher than that of the control. CONCLUSIONS: Under the optimum medium and cell density, YS58(G1-A8-A10-A2)-GDH presented efficient 2-PE synthesis ability with ~ 6.3 g L-1 of 2-PE titer in 5-L fermenter reaching 95% of conversation ratio. Under fed-batch fermentation, 2-PE productivity at 24 h increased 29% than that of single-batch fermentation. Metabolic modularization with promoter strategy provides a new prospective for efficient 2-PE production.
Asunto(s)
Fermentación , Ingeniería Metabólica/métodos , Alcohol Feniletílico/metabolismo , Regiones Promotoras Genéticas , Saccharomyces cerevisiae/metabolismo , Reactores Biológicos , Carboxiliasas/genética , Carboxiliasas/metabolismo , Microbiología Industrial , Ácidos Cetoglutáricos/farmacología , Proteínas de Transporte de Membrana/genética , Proteínas de Transporte de Membrana/metabolismo , Redes y Vías Metabólicas , Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismo , Transaminasas/genética , Transaminasas/metabolismoRESUMEN
2-Phenylethanol (2-PE) is widely used in food, perfume and pharmaceutical industry, but lower production in microbes and less known regulatory mechanisms of 2-PE make further study necessary. In this study, crucial genes like ARO8 and ARO10 of Ehrlich pathway for 2-PE synthesis and key transcription factor ARO80 in Saccharomyces cerevisiae were re-regulated using constitutive promoter; in the meantime, the effect of nitrogen source in synthetic complete (SC) medium with L-phenylalanine (L-Phe) on Aro8/Aro9 and Aro10 was investigated. The results showed that aromatic aminotransferase activities of ARO8 over-expressing strains were seriously inhibited by ammonia sulfate in SC + Phe medium. Flask fermentation test demonstrated that over-expressing ARO8 or ARO10 led to about 42 % increase in 2-PE production when compared with the control strain. Furthermore, influence of transcription factors Cat8 and Mig1 on 2-PE biosynthesis was explored. CAT8 over-expression or MIG1 deletion increased in the transcription of ARO9 and ARO10. 2-PE production of CAT8 over-expressing strain was 62 % higher than that of control strain. Deletion of MIG1 also led to 2-PE biosynthesis enhancement. The strain of CAT8 over-expression and MIG1 deletion was most effective in regulating expression of ARO9 and ARO10. Analysis of mRNA levels and enzyme activities indicates that transaminase in Ehrlich pathway is the crucial target of Nitrogen Catabolize Repression (NCR). Among the engineering strains, the higher 3.73 g/L 2-PE production in CAT8 over-expressing strain without in situ product recovery suggests that the robust strain has potentiality for commercial exploitation.
Asunto(s)
Alcohol Feniletílico/metabolismo , Proteínas de Saccharomyces cerevisiae/metabolismo , Saccharomyces cerevisiae/metabolismo , Factores de Transcripción/metabolismo , Carboxiliasas/metabolismo , Fermentación , Metabolismo , Fenilalanina/metabolismo , Ingeniería de Proteínas/métodos , ARN Mensajero/metabolismo , Transaminasas/metabolismoRESUMEN
In Saccharomyces cerevisiae, when l-phenylalanine (l-Phe) is used as the sole nitrogen source, 2-phenylethanol (PE) is mainly synthesized via the Ehrlich pathway. General amino acid permease Gap1p is response of aromatic amino acids transportation, and GATA transcription factors Gln3p and Gat1p regulate the transcription of permease gene and catabolic enzyme genes for nitrogen sources and aromatic amino acids utilization. In this study, it was demonstrated that over-expressing GLN3 gene from industrial yeast strain MT2 or S. cerevisiae haploid strain YS58, 2-PE synthesis levels of recombinant strains increased 54% or 40% than that of the control strain, which suggested that higher Gln3p activity in yeast has positive regulation effect on 2-PE biosynthesis via Ehrlich pathway. The recombinant strains with over-expression of GAT1 gene from MT2 or YS58 also up-regulated Ehrlich pathway for 2-PE biosynthesis and increased 2-PE production. Similarly, when GAP1 gene respectively from MT2 or YS58 was over-expressed, 2-PE yield was improved obviously, suggesting that GAP1 over-expressing in yeast also promoted Ehrlich pathway to produce 2-PE. The synergistic regulation of GLN3/GAT1 or GLN3/GAP1 over-expression was similar to that of single factor over-expression. Among these regulatory factors, Gln3p of industrial yeast strain MT2 caused stronger regulation on target genes than that of haploid strain YS58, which might be due to the differences in translational efficiency or nuclear localization of each Gln3p, or due to their different spatial structures and binding domains. Further results showed that efficient Gln3p expression in MT2 brought about higher 2-PE, 3.59gL-1, which was of potential significant for commercial exploitation.
Asunto(s)
Sistemas de Transporte de Aminoácidos/metabolismo , Factores de Transcripción GATA/metabolismo , Alcohol Feniletílico/metabolismo , Proteínas de Saccharomyces cerevisiae/metabolismo , Factores de Transcripción/metabolismo , Sistemas de Transporte de Aminoácidos/genética , Carboxiliasas/metabolismo , Diploidia , Activación Enzimática , Escherichia coli/genética , Factores de Transcripción GATA/genética , Genes Fúngicos , Haploidia , Redes y Vías Metabólicas , Nitrógeno/metabolismo , Fenilalanina/metabolismo , Plásmidos , Saccharomyces cerevisiae/enzimología , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/crecimiento & desarrollo , Saccharomyces cerevisiae/metabolismo , Proteínas de Saccharomyces cerevisiae/genética , Factores de Transcripción/genética , Activación Transcripcional , Regulación hacia ArribaRESUMEN
Yeast cells are challenged by various environmental stresses in the process of industrial fermentation. As the currently main organism for bio-ethanol production, Saccharomyces cerevisiae suffers from ethanol stress. Some amino acids have been reported to be related to yeast tolerance to stresses. Here the relationship between arginine and yeast response to ethanol stress was investigated. Marked inhibitions of ethanol on cell growth, expression of genes involved in arginine biosynthesis and intracellular accumulation of arginine were observed. Furthermore, extracellular addition of arginine can abate the ethanol damage largely. To further confirm the protective effects of arginine on yeast cells, yeast strains with different levels of arginine content were constructed by overexpression of ARG4 involved in arginine biosynthesis or CAR1 encoding arginase. Intracellular arginine was increased by 18.9% or 13.1% respectively by overexpression of ARG4 or disruption of CAR1, which enhanced yeast tolerance to ethanol stress. Moreover, a 41.1% decrease of intracellular arginine was observed in CAR1 overexpressing strain, which made yeast cells keenly sensitive to ethanol. Further investigations indicated that arginine protected yeast cells from ethanol damage by maintaining the integrity of cell wall and cytoplasma membrane, stabilizing the morphology and function of organellae due to low ROS generation.
Asunto(s)
Arginasa/genética , Arginina/biosíntesis , Etanol/efectos adversos , Proteínas de Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/crecimiento & desarrollo , Arginasa/metabolismo , Vías Biosintéticas/efectos de los fármacos , Regulación Fúngica de la Expresión Génica/efectos de los fármacos , Ingeniería Genética , Especies Reactivas de Oxígeno , Saccharomyces cerevisiae/efectos de los fármacos , Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismo , Estrés FisiológicoRESUMEN
With increasing application of Hansenula polymorpha in fundamental research and biotechnology, many more genetic manipulations are required. However, these have been restricted for the finiteness of selectable markers. Here, MazF, a toxin protein from Escherichia coli, was investigated as a counter-selectable marker in H. polymorpha. The lethal effect of MazF on yeast cells suggested that it is a candidate for counter-selection in H. polymorpha. Markerless or scarless gene deletion in H. polymorpha was conducted based on selectable markers cassette mazF-zeoR, in which the zeocin resistance cassette and mazF expression cassette were used as positive and counter-selectable markers, respectively. For markerless deletion, the target region can be replaced by CYC1TT via two-step homologous recombination. For scarless deletion, the innate upstream region (5'UP) of target genes rather than CYC1TT mediates homologous recombination to excise both selectable markers and 5' sequence of target genes. Moreover, scarless deletion can be accomplished by using short homologous arms for the effectiveness of mazF as a counter-selectable marker. The applicability of the strategies in markerless or scarless deletion of PEP4, LEU2, and TRP1 indicates that this study provides easy, time-efficient, and host-independent protocols for single or multiple genetic manipulations in H. polymorpha.
Asunto(s)
Genes Fúngicos , Pichia/genética , Toxinas Bacterianas/genética , Biotecnología , Proteínas de Unión al ADN/genética , Endorribonucleasas/genética , Proteínas de Escherichia coli/genética , Eliminación de Gen , Marcación de Gen/métodos , Genes Bacterianos , Genes Letales , Marcadores Genéticos , Modelos Genéticos , Pichia/crecimiento & desarrollo , Pichia/metabolismoRESUMEN
High-performance liquid chromatography was used to separate Cr(III) and Cr(VI) in samples with detection by inductively coupled plasma mass spectrometry(ICP-MS). The separation was achieved on a weak anion exchange column. The mobile phase was pH 7.0 ammonium nitrate solution. The redox reaction between Cr(III) and Cr(VI) was avoided during separation and determination. This separation method could be used to separate the samples with large concentration differences between Cr(III) and Cr(VI). The alkaline digestion was used to extract chromium in solid sample, which had no effect on the retention time and the peak area of the Cr(VI). However, the conversion of Cr(VI) from Cr(III) was observed during alkaline digestion, which displayed positive relation with the ratio of Cr(III) and Cr(VI) in samples. Both Cr(III) and Cr(VI) contents of chromium yeasts cultured in media with different chromium additions were determined. The spike recoveries of Cr(VI) for chromium yeasts were in the range of 95-108 %.
Asunto(s)
Cromo/análisis , Iones/análisis , Saccharomyces cerevisiae/química , Medios de Cultivo/química , Espectrometría de Masas , Saccharomyces cerevisiae/crecimiento & desarrolloRESUMEN
Yeast flocculation is described as a reversible, asexual and calcium dependent process, in which cells adhere to form flocs by interaction of specific cell surface proteins named flocculins on yeast cells with mannose residues present on the cell wall of adjacent yeast cells. Yeast flocculation provides a very economical and convenient pathway for separation of yeast cells from the fermentation broth or removal of heavy metal ions from effluent. A large number of tandem repeats have been found in genes encoding flocculins, which not only have great regulatory effect on the structure and function of flocculins, generating the diversity of flocculation characteristics, but lead to genetic instability in flocculation as well for driving slippage and recombination reactions within and between FLO genes. Here, the research progress in effect of variation of tandem repeats in FLO genes on flocculation characteristics and genetic stability were reviewed to direct and promote the controllable application of flocculation in industrial fermentation process and environmental remediation.
Asunto(s)
Floculación , Proteínas de la Membrana/genética , Proteínas de Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/genética , Secuencias Repetidas en Tándem , Fermentación , Manosa , Saccharomyces cerevisiae/crecimiento & desarrolloRESUMEN
Flocculation is an attractive property for Saccaromyces cerevisiae, which plays important roles in fermentation industry and environmental remediation. The process of flocculation is mediated by a family of cell surface flocculins. As one member of flocculins, Flo1 is characterized by four families of repeats (designated as repeat units A, B, C and D) in the central domain. It is generally accepted that variation of repeat unit A in length in Flo1 influences the degree of flocculation or specificity for sugar recognization. However, no reports were observed for other repeat units. Here, we compared the flocculation ability and its sensitivity to environmental factors between yeast strain YSF1 carrying the intact FLO1 gene and yeast strains carrying the derived forms of FLO1 with partial or complete deletion of repeats in unit C. No obvious differences in flocculation ability and specificity of carbohydrate recognition were observed among these yeast strains, which indicates the truncated flocculins can stride across the cell wall and cluster the N-terminal domain on the surface of yeast cells as the intact Flo1 thereby improving intercellular binding. However, yeast strains with the truncated flocculins required more mannose to inhibit completely the flocculation, displayed broad tolerance of flocculation to pH fluctuation, and the fewer the repeats in unit C, the stronger adaptability of flocculation to pH change, which was not relevant to the position of deletion. This suggests that more stable active conformation is obtained for flocculin by deletion the repeat unit C in the central domain of Flo1, which was validated further by the higher hydrophobicity on the surface of cells of YSF1c with complete deletion of unit C under neutral and alkaline conditions and the stabilization of GFP conformation by fusion with flocculin with complete deletion of unit C in the central domain.
Asunto(s)
Secuencia de Bases , Lectinas de Unión a Manosa/química , Manosa/metabolismo , Proteínas de Saccharomyces cerevisiae/química , Saccharomyces cerevisiae/genética , Eliminación de Secuencia , Secuencias Repetidas en Tándem , Floculación/efectos de los fármacos , Genes Reporteros , Proteínas Fluorescentes Verdes , Concentración de Iones de Hidrógeno , Interacciones Hidrofóbicas e Hidrofílicas , Manosa/farmacología , Lectinas de Unión a Manosa/genética , Lectinas de Unión a Manosa/metabolismo , Datos de Secuencia Molecular , Estabilidad Proteica , Estructura Terciaria de Proteína , Proteínas Recombinantes de Fusión/química , Proteínas Recombinantes de Fusión/genética , Proteínas Recombinantes de Fusión/metabolismo , Saccharomyces cerevisiae/efectos de los fármacos , Saccharomyces cerevisiae/metabolismo , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismoRESUMEN
Ergosterol is an economically important metabolite produced by yeast. To improve the production of ergosterol by Saccharomyces cerevisiae YEH56 (pHXA42) from molasses, a cheap and regenerative material, different strategies were applied. First, Plackett-Burman design and central composite design were applied to screen the significant factors in fermentation medium using ergosterol yield (g/L) as the response value. Ergosterol yield reached 371.56 mg/L by using the optimal fermentation medium in shake-flask culture (total sugar in molasses 40 g/L, KH2PO4 1 g/L, K2HPO4 1.86 g/L, CuSO4 x 5H2O 17.5 mg/L, FeSO4 x 7H2O 13.9 mg/L, MgSO4 x 5H2O 12.3 mg/L, corn steep liquor 10 mL/L), which was increased by 29.5% compared with the initial culture. Second, ergosterol yield was increased by 62.1% using a pH-control strategy in a 5-L bioreactor. Third, ergosterol production was improved further by using molasses feeding strategy. After 38 h fermentation, ergosterol yield reached 1 953.85 mg/L, which was 3.2 times of that in batch fermentation. Meanwhile, ergosterol production rate was increased by 42.7% compared with that in the batch culture.
Asunto(s)
Ergosterol/biosíntesis , Fermentación , Melaza , Saccharomyces cerevisiae/metabolismo , Medios de Cultivo , Microbiología Industrial , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/crecimiento & desarrolloRESUMEN
OBJECTIVE: Many tandem repeats exist in FLO1 gene of Saccharomyces cerevisiae, which might have great regulatory effect on the conformation and function of flocculation protein (flocculin). In this study, we analyzed the effect of 3'-terminal tandem repeats B, C and D complete deletion on the function of flocculin. METHODS: We constructed the derived gene FLO1 bcd with complete deletion of tandem repeats B, C and D of FLO1 by fusion PCR. We then constructed plasmid pYCF1 bcd by insertion of FLO1 bcd into YCp50, and transformed such plasmid, pYCF1 and YCp50 into S. cerevisiae YS58 separately to generate recombinant strains YSF1 bcd, YSF1 and YSP50. We compared the flocculation ability and characteristics of these strains. RESULT: Compared to YSF1, YSF1 bcd displayed only a slight reduction (4%) in flocculation ability in optimal flocculation buffer (50 mmol/L NaAC, pH 4.5). Moreover, the dependence of flocculation on Ca2+, sensitivity to metal ions and ethanol, and the specificity to different sugars showed no obvious difference between strains YSF1 and YSF1 bcd. However, strain YSF1 bcd displayed much higher flocculation levels than strain YSF1 under conditions with extreme pH, high temperature, or high concentration of mannose. CONCLUSION: Combined deletion of tandem repeats B, C and D adjacent to the 3'-terminal of FLO1 increases the conformation stability of flocculin in response to changes of pH, temperature or concentration of mannose in environment, but does not influence the other characteristics of flocculation.
Asunto(s)
Lectinas de Unión a Manosa/genética , Lectinas de Unión a Manosa/metabolismo , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismo , Saccharomyces cerevisiae/química , Saccharomyces cerevisiae/metabolismo , Secuencias Repetidas en Tándem , Secuencias de Aminoácidos , Animales , Floculación , Concentración de Iones de Hidrógeno , Manosa/metabolismo , Lectinas de Unión a Manosa/química , Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/química , TemperaturaRESUMEN
OBJECTIVE: There are a large numbers of tandem repeats in FLO1, which are highly dynamic components in genome leading to the unstable flocculation profiles in Saccharomyces cerevisiae. The effects of repeated unite B or D deletion on the function of flocculation protein was studied to provide theory basis for constructing genetically stable flocculation gene with minimal size. METHODS: We cloned the intact flocculation gene FLO1 from S. cerevisiae YS59 by PCR, and constructed the derived genes FLO1b and FLO1d with repeated unite B or D deletion respectively by fusion PCR. We analyzed the physiological characteristics of flocculation in yeast strains YSF1, YSF1b and YSF1d containing FLO1, FLO1b and FLO1d respectively. RESULTS: YSF1b and YSF1d displayed almost the same level of Flo1-type flocculation as YSF1. However, flocculation of YSF1b and YSF1d, especially YSF1d was more tolerant to pH change and mannose concentration than strain YSF1. CONCLUSION: Tandem repeats regulate the function of flocculation protein. Deletion of repeated unite B or D, especially D increases the stability of flocculation protein.
Asunto(s)
Lectinas de Unión a Manosa/fisiología , Proteínas de Saccharomyces cerevisiae/fisiología , Saccharomyces cerevisiae/genética , Secuencias Repetidas en Tándem , Secuencia de Bases , Floculación , Concentración de Iones de Hidrógeno , Lectinas de Unión a Manosa/genética , Datos de Secuencia Molecular , Proteínas de Saccharomyces cerevisiae/genéticaRESUMEN
OBJECTIVE: There are a large number of tandem repeats in FLO1, which are highly dynamic components in genome leading to the unstable flocculation profiles in Saccharomyces cerevisiae. The effects of complete or partial deletion of repeated DNA sequence A in FLO1 on the flocculation characteristics and genetic stability in yeast were studied to provide theoretical guide for construction genetically stable flocculation gene with minimal size. METHODS: We constructed the derived gene FLO1a with complete deletion of repeated DNA sequence A in the central domain by fusion PCR, and isolated the derived genes FLO1a1 - FLO1a5 with partial deletion of repeated DNA sequence A at different sites using E. coli DH5alpha carrying the FLO1 gene as selective model. We analyzed the physiological characteristics and genetic stability of flocculation in yeast strains YSF1, YSF1a, and YSF1a1 - YSF1a5 containing FLO1, FLO1a and FLO1a1 - FLO1a5 respectively. RESULTS: No obvious flocculation was observed for yeast strain YSF1a, but various levels of flocculation were observed for strains YSF1a1 - YSF1a5. Flocculation of YSF1a3, YSF1a4 and YSF1a5 were more tolerant to environmental changes than that of strain YSF1, and displayed more genetic stability. CONCLUSION: Repeated DNA sequence A is important for the function of flocculation protein.