RESUMEN
The effect of Silybum marianum seed extract (SMSE), added freely or in co-encapsulated with L. plantarum (MT, ZH593), on cell survivability, physicochemical and textural parameters in synbiotic cheeses for 60 days at 4 °C were studied. Incorporated cheeses with free, single encapsulated, and co-encapsulated probiotic + SMSE experimented a reduction of 3.19, 1.23, and 0.76 log CFU/mL for the cell survivability and their antioxidant activity reached 15.19, 16.26, and 31.73%, respectively, at the end of the storage. Decrease in hardness, cohesiveness, and springiness of the cheese containing free probiotic + SMSE upon compression during storage revealed proteolysis pattern and pH development being the most effective agents while whey percentage and moisture loss were the most effective agents in the rest of the cheeses. Overall, microcapsules containing L. plantarum and SMSE propose an easy and efficient delivery vehicle for the transition of bio-compounds into cheese as a novel synbiotic food.
RESUMEN
Over the past few decades, the demand for high-quality food has increased steadily. Therefore, it is essential to develop innovative technologies that effectively reduce microbial load while minimizing any negative effect on the quality of spices. The objective of this study was to determine the efficacy of a self-designed non-contact induction heating system using contaminated cumin seeds. The non-contact induction heating decontamination process was performed at different temperatures of 115, 135 and 155°C and durations (45, 60 and 75 s) through continuous process (screw conveyor) in Pyrex cylinder chamber. Various parameters including microbial load, color characteristics, essential oil content, surface morphology, sample temperature, and energy consumption were analyzed as dependent variables in the study. The results showed that the treatment combination (155°C - 60 s) reduced the aerobic plate count from 6.21 to 2.97 CFU/g. Mold, yeast and coliforms in the treatment combination (155°C-45 s) were also reduced by 3.26 and 3.6 CFU/g, respectively. The total color difference of the samples increased due to the degradation and alteration of pigments at high temperatures. However, no statistically significant disparity in essential oil content was observed between the treatment groups and the control group. The quantities of essential oil components in the cumin seeds were determined to align with the ISO standard, with the primary constituents identified as follows: Terpinen-7-al γ (38.98%), Cumin aldehyde (20.75%), γ-Terpinene (18.81%), ß-Pinene (13.66%), and p-Cymene (6.2%). In summary, non-contact induction heating system shows promise as an effective technology for surface decontamination of spices. The acquired findings contribute to a deeper understanding of the impact of the induction heating process on both the microbial contamination levels and the quality attributes of cumin seeds. This scientific knowledge serves as a foundational framework for the prospective adoption and integration of this technology on a larger industrial scale.
RESUMEN
Arachidonic acid (ARA) is an omega-6 fatty acid that plays a major role in human health. The present study optimizes the production of ARA by the soil fungus Mortierella alpina CBS 754.68 on oil cakes. In the first step, the best substrate was chosen from four oil cakes, namely soybean, sunflower, olive, and colza oil cakes, of which sunflower oil cake showed the highest yield. In the next step, screening tests were performed using the Plackett-Burman design. Seven variables (substrate particle size, moisture content, time, temperature, yeast extract, glucose, and glutamate) were investigated (each taking values of +1 and -1). Among these variables, time, temperature, and substrate particle size significantly affected ARA production (p < .05), so they were further investigated in the optimization step. The optimal fermentation time, temperature, and substrate particle size calculated by response surface methodology were 8.75 days, 18.5°C, and 1.3 mm-1.7 mm, respectively. Under these conditions, M. alpina was predicted to produce 4.19 mg of ARA/g dry weight of substrate (DWS). The actual yield, determined in evaluation tests, was 4.48 ± 0.16 mg ARA/g DWS, which shows the accuracy of the model. In the final step, the effect of the aeration rate on producing ARA was investigated in a packed-bed solid-state fermenter under the determined optimal conditions. In this stage, the highest ARA yield was 10.13 ± 0.26 mg/g DWS, approximately double that of the optimization step, and this confirms that aeration increases ARA production by M. alpina.
RESUMEN
Date palm (phonix dactylifera L.) is an important tropical fruit growing in central and southern regions of Iran. Date seed is composed of cellulose, hemicellulose, and lignin, that make it an excellent candidate for xylooligosaccharide (XOS) production. In this study, two different protocols are used for the extraction of hemicellulose from date seeds. In the first protocol, hemicellulose (xylan1) was extracted by 2.25 M alkaline solution at room temperature for 24 hr. In the second protocol, date seed was treated with LCHTA (low concentration, 0.1 M, high temperature, 80°C, alkaline solution) for 3 hr, and thereafter, hemicellulose (xylan2) was extracted by 2.25 M alkaline solution at room temperature for 24 hr. The carbohydrate units of xylan1 and xylan2 were qualified and quantified by HPAEC- PAD. Side groups of xylan1 and xylan2 were detected by FTIR. In the next step, xylan1 and xylan2 were exposed to two commercial endoxylanases namely veron 191 and pentopan mono BG. Temperature, pH, time, and enzyme dosage of hydrolyzation were optimized to maximize XOS and minimize xylose. The results showed that the enzymes successfully hydrolyzed xylan2 and produced XOS, but cannot hydrolyze xylan1. Pentopan mono BG and veron 191 produced the highest amount of XOS after 4 (1.17 mmol/g) and 6 hr (1.13 mmol/g) of incubation, respectively. Conversion factors of xylan2 to XOS for pentopan mono BG and veron were 0.41 and 0.36, respectively. This study presence the possible prebiotic properties of date seed XOS and its application in functional foods.
RESUMEN
Wholemeal bread is strongly recommended due to its nutritional value. However, whole-grain foods contain a high level of phytic acid, an antinutritional factor that decreases the mineral bioavailability. The objective of this study was isolation and identification of lactic acid bacteria with phytase activity to find a suitable starter for bread-making. Wheat-legume sourdoughs were prepared by the back-slopping procedure. Lactic acid bacteria were isolated from the sourdough of wheat flour-mung bean, and their phytase activity was tested in the solid and liquid media. Out of the nine phytase-active isolates in the solid medium, only three isolates produced extracellular phytase in the liquid medium with activity ranging from 16.3 to 53.2 (U/ml). These isolates belonged to species Weissella confusa mk.zh95 and Pediococcus pentosaceus. The highest phytase activity was found for Weissella confusa mk.zh95. Weissella confusa mk.zh95 is considered an interesting source of phytase during cereals and legumes fermentation which improves the bioavailability of minerals.
RESUMEN
Nowadays, the use of agricultural by-products, as the cheap substrate for the production of value-added products, is of high interest for the researchers and practitioners. Cellulase is a relatively expensive and a very important industrial enzyme where in this study was produced form rice by-products under solid-state fermentation. A new mutant of Trichoderma reesei was used for cellulase production. The effective variables were initially screened by "Plackett and Burman design." Afterward, the main variables including moisture content, P source, incubation temperature, and incubation time were optimized by "one factor at a time design." Finally, the resulting variables including 74% for moisture content, 2 g/L for K2 HPO 4, 30°C of incubation temperature, and 4 days of incubation time were reported as the ultimate optimal condition for cellulase production.
RESUMEN
Jujube extract was concentrated by various heating methods including vacuum, microwave and conventional heating. The effect of concentration methods and storage time (for 90 days at 4 °C) on total phenolic and total monomeric anthocyanin contents, individual anthocyanins, individual organic acids, and color values of jujube concentrate was investigated separately. The desired level of concentration (65.0 °Brix) was achieved in 45, 96 and 117 min by the microwave, vacuum and conventional heating methods, respectively. The concentrate obtained with microwave method had the highest total phenolic content (159.32 mg GAE/g DW) and total monomeric anthocyanin content (48.84 mg cyn-3-glu/100 g DW) in comparison to the other methods at the beginning of storage. Hunter color parameters (L*, a* and b*) decreased significantly with increasing the time of storage in all cases; however, this effect was more obvious in the vacuum heating. Cyanidin-3,5-diglucoside was determined as the major anthocyanin in all concentrates, while its degradation was more pronounced in the conventional heating (25.59%) comparing to the microwave (11.14%) and vacuum methods (17.59%) during the 90-day storage. The jujube concentrate prepared with the microwave method had the highest organic acid contents (e.g. malic, citric, succinic and ascorbic acids) as compared to the other methods. Thus, according to the results, the heating method and storage time had significant effects on the bioactive compounds and color values of jujube concentrate. In general, microwave energy could be successfully used in production of jujube concentrate followed by 90-day storage.
RESUMEN
Pistachio (Pistacia vera) is an important nut for its economic, nutritional and health aspects but it can be contaminated by aflatoxigenic fungi in the field and during storage. Biological control could be considered as an alternative to chemical treatment. In this study, we evaluated the antifungal and anti-mycotoxigenic capability of two Bacillus spp. both in vitro and on pistachio kernels. In in vitro conditions, both strains were able to reduce the mycelial growth and they were able to degrade the four aflatoxins during the first three days after inoculation. AFG1 and AFG2 were rapidly degraded within two days of incubation with the bacterial strains. No aflatoxin was found in the bacterial cell walls, permitting exclusion of mycotoxin adsorption and hypothesis of an in vitro biodegradation as a mode of action. The cultivar of pistachio most susceptible to fungal colonization was 'Ahmad-Aghaei', selected among four main Iranian cultivars. A. parasiticus was able to grow and produce aflatoxins on pistachios, but at longer inoculation periods, a natural decrease of aflatoxins was registered. Both strains were able to reduce the fungal incidence and number of spores on pistachio with a stronger effect during the first 5dpi. The effect on aflatoxin content in vivo was less pronounced than in vitro, with a maximum effect at 8dpi. At longer times, there was a contrasting effect due to the lower activity of Bacillus spp. in stationary phase and higher growth of Aspergillus species. This consideration could explain the lack of aflatoxin reduction at 12dpi. Both bacterial strains showed good antifungal activity and aflatoxin reduction in in vitro conditions and on pistachio kernels. Altogether, these results indicate that Bacillus species could be considered as potential biocontrol agents to combat toxigenic fungal growth and subsequent aflatoxin contamination of nuts and agricultural crops in practice.
Asunto(s)
Aflatoxinas/análisis , Aspergillus/crecimiento & desarrollo , Bacillus amyloliquefaciens/metabolismo , Bacillus subtilis/metabolismo , Agentes de Control Biológico/metabolismo , Micotoxinas/análisis , Nueces/microbiología , Pistacia/microbiología , Antifúngicos/metabolismo , Aspergillus/metabolismo , Irán , Micelio/crecimiento & desarrolloRESUMEN
The time courses for production of fungal biomass, lipid, phenolic and arachidonic acid (ARA) as well as expression of the genes involved in biosynthesis of ARA and lipid were examined in Mortierella alpina CBS 754.68. A significant increase in the arachidonic acid content in lipids that coincided with reduced levels of lipid was obtained. Reduced gene expression occurred presumably due to the steady reduction of carbon and nitrogen resources. However, these energy resources were inefficiently compensated by the breakdown of the accumulated lipids that in turn, induced up-regulated expression of the candidate genes. The results further indicated that the expression of the GLELO encoding gene is a rate-limiting step in the biosynthesis of ARA in the early growth phase.
Asunto(s)
Ácido Araquidónico/biosíntesis , Vías Biosintéticas/genética , Perfilación de la Expresión Génica , Mortierella/genética , Mortierella/metabolismo , Carbono/metabolismo , Genes Fúngicos , Nitrógeno/metabolismo , Reacción en Cadena en Tiempo Real de la PolimerasaRESUMEN
Using fresh foods which undergo the least processing operations developed widely in recent years. Active packaging is a novel method for preserving these products. Active starch-clay nanocomposite films which contained potassium sorbate (PS) at a level of 0, 5, 7.5 and 10 g PS/100 g starch were produced and their physical, mechanical and antimicrobial properties were evaluated. In order to evaluate antimicrobial properties of films Aspergillus niger was used. The results showed that 5% of the PS did not produce antimicrobial property in the film, but by increasing the content of the additive in film formulation, antimicrobial effect increased. PS increased water permeability and elongation at break of the films, but decreased tensile strength. The rate of PS migration into the semi-solid medium in starch-nanocomposites was lower than starch films. This shows that nanocomposite films could retain their antimicrobial property for longer time.
Asunto(s)
Silicatos de Aluminio/química , Antiinfecciosos/química , Embalaje de Alimentos , Nanocompuestos/química , Ácido Sórbico/química , Almidón/química , Silicatos de Aluminio/farmacología , Antiinfecciosos/farmacología , Aspergillus niger/efectos de los fármacos , Aspergillus niger/fisiología , Arcilla , Embalaje de Alimentos/métodos , Fenómenos Físicos , Ácido Sórbico/farmacología , Almidón/farmacología , Resultado del TratamientoRESUMEN
The time courses for production of fungal biomass, lipid, phenolic and arachidonic acid (ARA) as well as expression of the genes involved in biosynthesis of ARA and lipid were examined in Mortierella alpina CBS 754.68. A significant increase in the arachidonic acid content in lipids that coincided with reduced levels of lipid was obtained. Reduced gene expression occurred presumably due to the steady reduction of carbon and nitrogen resources. However, these energy resources were inefficiently compensated by the breakdown of the accumulated lipids that in turn, induced up-regulated expression of the candidate genes. The results further indicated that the expression of the GLELO encoding gene is a rate-limiting step in the biosynthesis of ARA in the early growth phase.
Asunto(s)
Ácido Araquidónico/biosíntesis , Vías Biosintéticas/genética , Perfilación de la Expresión Génica , Mortierella/genética , Mortierella/metabolismo , Carbono/metabolismo , Genes Fúngicos , Nitrógeno/metabolismo , Reacción en Cadena en Tiempo Real de la PolimerasaRESUMEN
Response surface methodology (RSM) was used to evaluate the effects of fermentation parameters for cellulase production by Trichoderma reesei QM9414 and T. reesei MCG77 in solid-state fermentation using rice bran as substrate. Initial pH, moisture content and temperature were optimized using filter paper activity (FPA) as response. Statistical analysis of the results for T. reesei QM9414 showed that only moisture content had significant effect on cellulase activity and had a linear effect on enzyme activity (maximum enzyme activities were obtained at 70% moisture content). The results for T. reesei MCG77 showed that temperature and moisture content were the most significant parameters for cellulase activity. The optimum cellulase production was in the temperature range of 25-30 degrees C and moisture content between 55% and 70%. After the optimization, the FPA in T. reesei MCG77 was increased by 2.5 folds compared to that of T. reesei QM9414.