Influence of the growth phase and culture medium on the survival of Mannheimia haemolytica during storage at different temperatures.

AIMS: To quantify the influence of the growth phase, storage temperature and nutritional quality of the plate count medium on the apparent viability of Mannheimia haemolytica during storage at different temperatures. METHODS AND RESULTS: Mannheimia haemolytica was grown in shake flasks and in aerobic continuous culture to investigate factors affecting cell viability during storage, which was determined using plate counts on different media and epifluorescence microscopy. The high specific death rates of cells harvested after cessation of exponential growth and stored at 22, 4, -18 and -75 degrees C could be related to the rapid onset of exponential death in batch cultures. Yeast extract supplementation of the culture medium increased the viability of cells at most of the above-mentioned storage temperatures. Of the total cell count in continuous culture, only 48% could be recovered on brain-heart infusion agar, whereas supplementation of the agar medium with foetal calf serum increased the plate count to 71% of the total count. CONCLUSIONS: Mannheimia haemolytica cells harvested from the exponential growth phase had the highest survival rate during storage at low temperatures. Plate count values also depended on the nutritional quality of the agar medium. SIGNIFICANCE AND IMPACT OF THE STUDY: Results presented here impact on the procedures for culture preservation and plate count enumeration of this fastidious animal pathogen.

Conservation and release of osmolytes by yeasts during hypo-osmotic stress.

In response to fluctuations in environmental osmolarity, yeast cells adjust their intracellular solute concentrations in order to maintain a constant turgor pressure and ensure continuation of cellular activity. In this study, the effect of hypo-osmotic stress on osmolyte content of osmotolerant yeasts Zygosaccharomyces rouxii and Pichia sorbitophila and the less tolerant Saccharomyes cerevisiae was investigated. All these yeasts released glycerol upon hypo-osmotic shock. However, Z. rouxii also released arabitol, whereas P. sorbitophila released erythritol in addition to arabitol and glycerol. Osmolyte release was very rapid and specific and was neither affected by reduced temperatures nor inhibited by the channel blocker gadolinium or the protonophore carbonyl cyanide m-chlorophenyl hydrazone. Extracellular osmolyte levels increased drastically suggesting that osmolytes were not metabolised but mainly released upon exposure to hypotonic conditions. The export process is well controlled, and the amount of osmolyte released was proportional to the shock intensity. Osmolyte release occurred with little cell lysis and thus the survival as well as the subsequent growth of yeast cells was largely unaffected after hypo-osmotic shock. The kinetics and patterns of osmolyte export suggest the involvement of channel proteins, but the molecular nature of this export pathway in yeasts, with exception of S. cerevisiae, remains to be established.

Implications of FPS1 deletion and membrane ergosterol content for glycerol efflux from Saccharomyces cerevisiae.

The deletion of the gene encoding the glycerol facilitator Fps1p was associated with an altered plasma membrane lipid composition in Saccharomyces cerevisiae. The S. cerevisiae fps1delta strain respectively contained 18 and 26% less ergosterol than the wild-type strain, at the whole-cell level and at the plasma membrane level. Other mutants with deficiencies in glycerol metabolism were studied to investigate any possible link between membrane ergosterol content and intracellular glycerol accumulation. In these mutants a modification in intracellular glycerol concentration, or in intra- to extracellular glycerol ratio was accompanied by a reduction in plasma membrane ergosterol content. However, there was no direct correlation between ergosterol content and intracellular glycerol concentration. Lipid composition influences the membrane permeability for solutes during adaptation of yeast cells to osmotic stress. In this study, ergosterol supplementation was shown to partially suppress the hypo-osmotic sensitivity phenotype of the fps1delta strain, leading to more efficient glycerol efflux, and improved survival. The erg-1 disruption mutant, which is unable to synthesise ergosterol, survived and recovered from the hypo-osmotic shock more successfully when the concentration of exogenously supplied ergosterol was increased. The results obtained suggest that a higher ergosterol content facilitates the flux of glycerol across the plasma membrane of S. cerevisiae cells.

Transcriptional repression of ADH2-regulated beta-xylanase production by ethanol in recombinant strains of Saccharomyces cerevisiae.

The regulation of endo-beta-(1,4)-xylanase production by two different strains of Saccharomyces cerevisiae, each transformed with the XYN2 gene from Trichoderma reesei under control of the promoter of the alcohol dehydrogenase II (ADH2) gene of S. cerevisiae, was investigated. In batch culture, the rate of xylanase production was severely reduced by the pulse addition of 390 mmol ethanol l(-1). Pulses of 190-630 mmol ethanol l(-1) into aerobic glucose-limited steady-state continuous cultures reduced the xylanase activity about five-fold and showed that ethanol repressed the ADH2 promoter, as was evident from Northern blot analyses. Derepression of the ADH2-regulated xylanase gene occurred at ethanol concentrations below approximately 50 mmol l(-1).

The relationship between transport kinetics and glucose uptake by Saccharomyces cerevisiae in aerobic chemostat cultures.

The steady-state residual glucose concentrations in aerobic chemostat cultures of Saccharomyces cerevisiae ATCC 4126, grown in a complex medium, increased sharply in the respiro-fermentative region, suggesting a large increase in the apparent kS value. By contrast, strain CBS 8066 exhibited much lower steady-state residual glucose concentrations in this region. Glucose transport assays were conducted with these strains to determine the relationship between transport kinetics and sugar assimilation. With strain CBS 8066, a high-affinity glucose uptake system was evident up to a dilution rate of 0.41 h(-1), with a low-affinity uptake system and high residual glucose levels only evident at the higher dilution rates. With strain ATCC 4126, the high-affinity uptake system was present up to a dilution rate of about 0.38 h(-1), but a low-affinity uptake system was discerned already from a dilution rate of 0.27 h(-1), which coincided with the sharp increase in the residual glucose concentration. Neither of the above yeast strains had an absolute vitamin requirement for aerobic growth. Nevertheless, in the same medium supplemented with vitamins, no low-affinity uptake system was evident in cells of strain ATCC 4126 even at high dilution rates and the steady-state residual glucose concentration was much lower. The shift in the relative proportions of the high and low-affinity uptake systems of strain ATCC 4126, which might have been mediated by an inositol deficiency through its effect on the cell membrane, may offer an explanation for the unusually high steady-state residual glucose concentrations observed at dilution rates above 52% of the wash-out dilution rate.

The effect of vitamins and amino acids on glucose uptake in aerobic chemostat cultures of three Saccharomyces cerevisiae strains.

In the respiro-fermentative region of aerobic chemostat cultures at steady state, Saccharomyces cerevisiae CBS 8066 produced high concentrations of ethanol with concomitant low levels of residual glucose which followed Monod kinetics. By contrast, very high residual glucose concentrations were observed in cultures of S. cerevisiae strains ATCC 4126 and NRRL Y132 at dilution rates above 60% of the washout dilution rate, resulting in much lower ethanol concentrations, even though clearly glucose-limited at lower dilution rates in the respiratory region. The addition of a vitamin mixture resulted in decreased residual glucose concentrations in respiro-fermentative cultures of all three strains, but the effect was much more pronounced with strains ATCC 4126 and NRRL Y132. Meso-inositol was mainly responsible for this effect, although with strain ATCC 4126 other vitamins as well as an amino acid mixture were also required to minimise the steady-state residual glucose levels. The residual glucose concentration in continuous culture was, therefore, greatly dependent on the growth factor requirements of the particular yeast strain, which apparently increased on increasing the dilution rate into the respiro-fermentative region. The strain differences with respect to growth factor requirements at high dilution rates, which were not evident at low dilution rates, had a profound effect on the kinetics of glucose assimilation in aerobic chemostat culture.

Fps1p controls the accumulation and release of the compatible solute glycerol in yeast osmoregulation.

The accumulation of compatible solutes, such as glycerol, in the yeast Saccharomyces cerevisiae, is a ubiquitous mechanism in cellular osmoregulation. Here, we demonstrate that yeast cells control glycerol accumulation in part via a regulated, Fps1p-mediated export of glycerol. Fps1p is a member of the MIP family of channel proteins most closely related to the bacterial glycerol facilitators. The protein is localized in the plasma membrane. The physiological role of Fps1p appears to be glycerol export rather than uptake. Fps1 delta mutants are sensitive to hypo-osmotic shock, demonstrating that osmolyte export is required for recovery from a sudden drop in external osmolarity. In wild-type cells, the glycerol transport rate is decreased by hyperosmotic shock and increased by hypo-osmotic shock on a subminute time scale. This regulation seems to be independent of the known yeast osmosensing HOG and PKC signalling pathways. Mutants lacking the unique hydrophilic N-terminal domain of Fps1p, or certain parts thereof, fail to reduce the glycerol transport rate after a hyperosmotic shock. Yeast cells carrying these constructs constitutively release glycerol and show a dominant hyperosmosensitivity, but compensate for glycerol loss after prolonged incubation by glycerol overproduction. Fps1p may be an example of a more widespread class of regulators of osmoadaptation, which control the cellular content and release of compatible solutes.

Characteristics of Fps1-dependent and -independent glycerol transport in Saccharomyces cerevisiae.

Eadie-Hofstee plots of glycerol uptake in wild-type Saccharomyces cerevisiae W303-1A grown on glucose showed the presence of both saturable transport and simple diffusion, whereas an fps1delta mutant displayed only simple diffusion. Transformation of the fps1delta mutant with the glpF gene, which encodes glycerol transport in Escherichia coli, restored biphasic transport kinetics. Yeast extract-peptone-dextrose-grown wild-type cells had a higher passive diffusion constant than the fps1delta mutant, and ethanol enhanced the rate of proton diffusion to a greater extent in the wild type than in the fps1delta mutant. In addition, the lipid fraction of the fps1delta mutant contained a lower percentage of phospholipids and a higher percentage of glycolipids than that of the wild type. Fps1p, therefore, may be involved in the regulation of lipid metabolism in S. cerevisiae, affecting membrane permeability in addition to fulfilling its specific role in glycerol transport. Simultaneous uptake of glycerol and protons occurred in both glycerol- and ethanol-grown wild-type and fps1delta cells and resulted in the accumulation of glycerol at an inside-to-outside ratio of 12:1 to 15:1. Carbonyl cyanide m-chlorophenylhydrazone prevented glycerol accumulation in both strains and abolished transport in the fps1delta mutant grown on ethanol. Likewise, 2,4-dinitrophenol inhibited transport in glycerol-grown wild-type cells. These results indicate the presence of an Fps1p-dependent facilitated diffusion system in glucose-grown cells and an Fps1p-independent proton symport system in derepressed cells.

The utilization of short-chain monocarboxylic acids as carbon sources for the production of gamma-linolenic acid by Mucor strains in fed-batch culture.

The Fischer-Tropsch reaction water, which contains C2 to C5 monocarboxylic acids, generated as a co-product of the Sasol industrial oil-from-coal process, constitutes a potential cheap carbon substrate for the production of gamma-linolenic acid (GLA) by selced Mucor species. Three strains of Mucor were each grown in an air-lift reactor operated in a fed-batch, pH-stat mode under N-limitation with a mixture of C2 to C5 monocarboxylic acids as both pH titrant and carbon source. The production of GLA from this substrate was evaluated. Growth typically resulted in the rapid assimilation of acetic, n-butyric and n-valeric acids. Although propionic, iso-butyric and iso-valeric acids were assimilated to varying degrees, these acids accumulated in the culture. Mucor circinelloides CBS 203.28 gave the best results in that it assimilated 36% to 100% of each acid, had a biomass yield coefficient of 0.3 (calculated on acids utilized), and contained 28% crude oil, 84% of which comprised neutral lipids with a GLA content of 14.4%, giving 33 mg GLA/g biomass. GLA accumulation coincided with a decrease in the stearic-acid content of the neutral-lipid fraction. The results were comparable with previous results obtained with acetic acid and glucose as sole carbon sources, demonstrating the feasibility of producing GLA from the above mixture of organic acids.

Factors affecting gibberellic acid production by Fusarium moniliforme in solid-state cultivation on starch.

The production of gibberellic acid (GA3) by Fusarium moniliforme M-7121 in solid-state culture was evaluated in flask cultures as well as in 3-I horizontal rotary reactors. The highest production rate of GA3 was with 80% (w/v) maize flour mixed with wheat bran. The optimum initial moisture content was inversely dependent on the ambient relative humidity. The initial water activity range for optimal growth and GA3 accumulation was about 0.98 to 0.99, which is unusually high for a filamentous fungus. A low O2 concentration resulted in a much decreased GA3 yield and the appearance of a yellow to reddish pigmentation in the mycelium. The lag phase was short and rapid growth continued for up to 2 days in the rotary reactor, with a maximum specific growth rate of 0.12 h(-1). The maximum rate of GA3 production occurred during the subsequent 3 to 10 days of incubation and the final GA3 concentration reached was 18.7 mg to 19.3 mg/g dry culture. The point of maximum GA3 accumulation after 10 to 12 days of incubation was usually marked by a sharp increase in pH.

Growth characteristics of Geotrichum ingens on propionic acid and acetic acid in batch and continuous culture.

Growth of Geotrichum ingens in batch cultures was completely inhibited by 47 g acetic acid/l or 33 g propionic acid/I. With mixtures of acetic and propionic acids, however, growth only ceased at 55 g/l. Acetic acid inhibited growth linearly, whereas propionic acid inhibited growth non-linearly. In continuous culture, two steady states at each dilution rate were observed at high dilution rates for acetic acid and propionic acid. The highest yield coefficient (0.69 g cells/g substrate) was achieved with propionic acid as substrate. On both substrates and their mixtures, the protein content of the biomass increased when the dilution rate was increased.

Role of D-ribose as a cometabolite in D-xylose metabolism by Saccharomyces cerevisiae.

The influence of D-ribose as a cosubstrate on the uptake and metabolism of the non-growth substrate D-xylose by Saccharomyces cerevisiae ATCC 26602 was investigated. Xylose was taken up by means of low- and high-affinity glucose transport systems. In cells exposed for 2 days to a mixture of xylose and ribose, only the high-affinity system could be detected. Glucose strongly inhibited the transport of xylose by both systems. Starvation or exposure to either xylose or ribose resulted in inactivation of xylose transport, which did not occur in the presence of a mixture of ribose and xylose. A constitutive non-glucose-repressible NADPH2-dependent xylose reductase with a specific activity of ca. 5 mU/mg of protein that converted xylose to xylitol was present in a glucose-grown culture. No activity converting xylitol to xylulose or vice versa was found in crude extracts. Both xylose and ribose were converted to their corresponding polyols, xylitol and ribitol, as indicated by 13C nuclear magnetic resonance spectroscopy. Furthermore, ethanol was detected, and this implied that pathways for the complete catabolism of xylose and ribose exist. However, the NADPH2 required for the conversion of xylose to xylitol is apparently not supplied by the pentose phosphate pathway since the ethanol produced from D-[1-13C]xylose was labelled only in the C-2 position. Acetic acid was produced from ribose and may assist in the conversion of xylose to xylitol by cycling NADPH2.

The kinetics and regulation of M-xylose transport in Candida utilis.

Low-affinity (K m=67.6±3.2 mM) and high-affinity (K m=1.9±1.2 mM) D-xylose transport occur in Candida utilis grown, respectively, on D-glucose or D-xylose. Starvation of glucose-grown cells decreases the K m value (10.5±2.6 mm). The high-affinity system appearing during starvation required protein synthesis and it was inactivated when cells were exposed to glucose, by a process independent of protein synthesis. High-affinity transport was accompanied by transient alkalinization of yeast suspensions, indicating that it is a proton symport, whereas low-affinity transport was not. Both systems, however, were inhibited by metabolic inhibitors and by replacing H2O in the transport assay with D2O, indicating that both may be proton symports. Glucose and acetic acid also inhibited both high-and low-affinity xylose transport.

Selection and evaluation of astaxanthin-overproducing mutants of Phaffia rhodozyma.

Mutagenesis of Phaffia rhodozyma with NTG yielded a mutant with an astaxanthin content of 1688 µg (g dry biomass)(-1), a cell yield coefficient of 0.47 on glucose and a maximum specific growth rate of 0.12 h(-1). Re-mutation of the mutant decreased the cell yield and maximum specific growth rate but increased the astaxanthin content. The use of mannitol or succinate as carbon sources enhanced pigmentation, yielding astaxanthin contents of 1973 µg g(-1) and 1926 µg g(-1), respectively. The use of valine as sole nitrogen source also increased astaxanthin production, but severely decreased the maximum specific growth rate and cell yield coefficient. The optimum pH for growth of P. rhodozyma was between pH 4.5 and 5.5, whereas the astaxanthin content remained constant above pH 3.

Chemostat cultivation of Candida blankii on sugar cane bagasse hemicellulose hydrolysate.

A Candida blankii yeast isolate was grown in sugar cane bagasse hemicellulose hydrolysate at 38 degrees C in carbon-limited chemostat culture. The pretreatment of the acid hydrolysate prior to microbial cultivation consisted of partial neutralization with ammonia and sodium hydroxide, plus the addition of phosphorus, which was the only other growth-limiting nutrient apart from nitrogen. The cell yield coefficient on nitrogen was 16.78. The critical dilution rate was higher (0.35 h(-1)) in diluted hydrolysate than in undiluted hydrolysate (0.21 h(-1)). In undiluted hydrolysate at a dilution rate of 0.1 h(-1) and pH 4, where aseptic procedures proved unnecessary, the cell and protein yield coefficients were 0.53 and 0.26, respectively, and no residual carbon substrates (D-xylose, L-arabinose, D-glucose, and acetic acid) were detected. The cell yield on oxygen increased linearly as a function of dilution rate. The cellular content of protein, carbohydrate, and RNA also increased with an increase in dilution rate, whereas the DNA content decreased slightly. C. blankii has considerable potential for the production of single cell protein from hemicellulose hydrolysate, because of its ability to utilize all of the major carbon substrates in the hydrolysate at a low pH and at a relatively high temperature with a high protein yield.

Protein enrichment of grain sorghum by submerged culture of the amylolytic yeastsSchwanniomyces occidentalis andLipomyces kononenkoae.

Cultivation of aSchwanniomyces occidentalis derepressed mutant in a 10% (w/v) gelatinized grain sorghum slurry increased the crude protein content of the biomass from an initial value of 12% to 41% (dry) within 20 h, with no detectable residual starch. Co-cultivation ofCandida utilis with theS. occidentalis mutant improved the final crude protein content to 47% within 18 h, whereas a co-culture ofC. utilis with aLipomyces kononenkoae mutant resulted in a cultivation time of 50 h with a significantly lower protein content and a low final α-amylase activity. In a 15% (w/v) grain sorghum slurry aC. utilis/S. occidentalis co-culture increased the protein content to about 44% within 30 h. Yeast cultivation increased the lysine and threonine content of the final biomass considerably.

Effect of temperature and pH onCandida blankii in chemostat culture.

The growth characteristics ofCandida blankii as a function of temperature and pH in a simulated bagasse hemicellulose hydrolysate were determined in chemostat culture. The highest maximum specific growth rate of 0.44h(-1) was reached at 38°C and at pH 5.5, with a sharp decrease in growth rate on either side of this temperature. Growth occurred at 46°C but not at 48°C. The protein and cell yields varied little below 40°C and the respective values were 0.22 and 0.5 g/g at 38°C. At the lower pH values, a severe linear decrease in cell and protein yields occurred, whereas a small increase in these yields at decreasing pH values was found when acetic acid was omitted from the medium. In the presence of acetic acid, a very sharp decrease in the growth rate at pH values below pH 4.5 was noted, despite the very low residual acetic acid concentrations, of less than 50 mg/l, in the culture.

Occurrence and taxonomic aspects of proton movements coupled to sugar transport in the yeast genus Kluyveromyces.

The occurrence of proton symport mechanisms for the transport of glucose, galactose, fructose, raffinose and sucrose in 21 yeast strains representing the species of the genus Kluyveromyces was surveyed. Proton symport of one or more sugars occurred in 57% of the strains. Similarly, all the sugars investigated were transported by symports by several strains. Symport systems for non-utilisable sugars were rare. Starvation of cells frequently resulted in the appearance of a symport absent in non-starved glucose-grown cells, indicating that repression of proton symports by glucose and subsequent derepression by starvation is a general phenomenon in members of Kluyveromyces. The addition of a sugar to cell suspensions resulted in acidification in 80% of cases, indicating the activity of a membrane-bound ATPase. Acidification was also observed with a number of sugars that cannot be utilised by the particular species. Interesting correlations between the number of proton symports and the abundance of other phenotypic characteristics in members of the genus emerged. Most members of the infertile group of species showing an increase in the number of small chromosomes, inability to produce well-developed pseudomycelium, linoleic and linolenic acid, a decrease in the number of carbon compounds utilised and inability to utilise ethylamine also had no proton symports, whereas most members of the interfertile species produced one or more proton symports. It was concluded that the distribution of the number of proton symports amongst Kluyveromyces species coincided with that of other positive characteristics and may therefore be of taxonomic value.

D-xylose utilization by Saccharomyces cerevisiae.

Although it is generally accepted that Saccharomyces cerevisiae is unable to assimilate D-xylose, four strains were found to utilize xylose aerobically at different efficiencies in the presence of a mixture of substrates. The degree of D-xylose utilization by S. cerevisiae ATCC 26602 depended upon the presence of other substrates or yeast extract. The greatest amount of xylose (up to 69% over 7 d) was utilized when sugar substrates such as D-ribose were co-metabolized. Much lower degrees of utilization occurred with co-metabolism of organic acids, polyols or ethanol. A mixture of D-glucose, D-ribose, D-raffinose, glycerol and D-xylose resulted in greater xylose utilization than the presence of a single substrate and xylose. The absence of growth on a co-substrate alone did not prevent the utilization of xylose in its presence. Xylose was co-metabolized with ribose under anaerobic conditions but at a much slower rate than under aerobic conditions. When [14C]xylose was utilized in the presence of ribose under anaerobic conditions, the radioactive label was detected mainly in xylitol and not in the small amounts of ethanol produced. Under aerobic conditions the radioactive label was distributed between xylitol (91.3 +/- 0.8%), CO2 (2.6 +/- 2.3%) and biomass (1.7 +/- 0.6%). No other metabolic products were detected. Whereas most xylose was dissimilated rather than assimilated by S. cerevisiae, the organism apparently possesses a pathway which completely oxidizes xylose in the presence of another substrate.