Characterization of tableting using the OSDRC system.

PURPOSE: We compared the compression properties and characteristics of tablets obtained using the OSDRC system (method (OSDRC)) and conventional compression methods including multi-layer compression with a pharmaceutical powder. MATERIALS AND METHODS: We prepared tablets using four methods of compression. The force profiles, ejection force, stress relaxation, pressure transmission ratio, and internal intensity of the tablets were measured as compression properties. RESULTS: Method (OSDRC) gave the highest value for the crushing strength of the tablets. Although the compression properties were similar regardless of the method of compression, the internal intensity of tablets compressed by method (OSDRC) was significantly larger than that of the tablets produced by the other methods. CONCLUSIONS: In terms of crushing strength, the tablets compressed by method (OSDRC) were superior of those obtained by the conventional compression method. Therefore, it is possible to increase the crushing strength of tablets without changing the pharmaceutical formulation.

Development and evaluation of a novel dry-coated tablet technology for pellets as a substitute for the conventional encapsulation technology.

Pellet formulations as represented by multiparticulate systems are often contained in hard capsules. We examined the use of a different approach to the making of compressed tablets containing pellets, OSDRC-technology. OSDRC-technology employs a double-structure punch (center punch and outer punch) allowing for dry-coated tablets to be assembled in a single run. We examined the effects of the thickness of the outer punch, formability of pellets, and diameter of tablets on pellet filling. The results revealed that thinner outer punches are not always better for filling small tablets with large amounts of pellets. We considered that this was because the core pellets spread in a cone shape within the formulating tablets at filling, requiring a thickness of the outer punch and a particle density of the diluents at which pellets would not exude from the formulating tablets. It was suggested that the formability of core pellets affects the maximum number of layers of pellets, and higher formability would yield better results. However, we found that pellets with poor formability (tensile strength of < or =2 kPa) could be used in tablets. For the tablets, the larger the diameter, the greater the maximum number of layers. We considered this to be due to the friction between the pellets and punch wall. We concluded that OSDRC-technology could be applied to capsule-like forms containing pellets > or =50 wt% through an unconventional approach.

Evaluation of a novel sugar coating method for moisture protective tablets.

A novel method of manufacturing one-step dry-coated (OSDRC) tablets, which we recently invented, was used to produce sugar-coated tablets protected from moisture without the need for a conventional complicated sugar coating process. Amorphous sucrose was selected for the outer layer of the OSDRC tablets as sugar-coated layer. The isothermal crystallization behavior and characteristics such as water vapor permeability, tensile strength, and disintegration time of compressed amorphous sucrose were investigated. Water vapor adsorption measurements showed the crystallization behavior of amorphous tablets to be similar to that of amorphous powder, although it was affected by compression pressure. We found that the crystallized amorphous sucrose after compression at 200 MPa was moisture protective, and the water vapor permeability coefficient was decreased to 1/2000 or less compared with a tablet prepared with a lactose-microcrystalline cellulose (MCC) mixture, hydroxypropylmethylcellulose (HPMC), and sucrose crystal. The water vapor permeability and physicochemical characteristics were influenced by the amorphous content or additive content. It was confirmed that a new sugar-coated tablet using amorphous sucrose and OSDRC technology was moisture protective, therefore, it was concluded that the novel sugar coating method was very useful to obtain a moisture protective tablet.

Neurotrophin-3-induced production of nerve growth factor is suppressed in Schwann cells exposed to high glucose: involvement of the polyol pathway.

Development of hypesthesia, a loss of sensitivity to stimulation, is associated with impaired regeneration of peripheral sensory fibers, in which Schwann cells play a key role by secreting nerve growth factor (NGF). Recent clinical trials indicated that an inhibitor of aldose reductase (AR), the rate-limiting enzyme in the polyol pathway, significantly improved hypesthesia in diabetic patients. The fact that AR is localized in Schwann cells led us to investigate the role of the polyol pathway in NGF production of isolated Schwann cells. Among various endogenous factors examined, increased production of NGF was demonstrated in the cells treated with neurotrophin-3 (NT-3) for 24 h. NT-3-induced NGF production was significantly suppressed when cells were cultured in the medium containing high glucose. In these cells, the levels of glutathione (GSH) and cAMP-response element binding protein (CREB) were reduced, whereas the level of activated nuclear factor-kappaB (NF-kappaB) was elevated. These changes were abolished when an AR inhibitor fidarestat was included in the medium. NT-3-induced NGF production was further attenuated in the cells treated with an inhibitor of GSH synthesis. Together, the enhanced polyol pathway activity under high-glucose conditions seems to elicit reduced NT-3-induced NGF production in Schwann cells. Enhanced oxidative stress linked to the polyol pathway activity may mediate this process.

Functional characterization of single nucleotide polymorphisms with amino acid substitution in CYP1A2, CYP2A6, and CYP2B6 found in the Japanese population.

As a part of the studies conducted by the Pharma SNPs Consortium (PSC), the enzyme activities of CYP1A2, CYP2A6 and CYP2B6 variants with altered amino acids as a result of single nucleotide polymorphisms (SNPs) found among the Japanese population were analyzed under a unified protocol using the same lots of reagents by the laboratories participating in the PSC. Mutations in CYP1A2, CYP2A6 and CYP2B6 were introduced by site-directed mutagenesis and the wild type and mutated CYP molecules were expressed in Escherichia coli. The expressed cytochrome P450s were purified and the enzyme activities were measured in reconstitution systems. CYP1A2 and CYP1A2Gln478His did not show any differences in 7-ethoxyresorufin O-deethylase activity. CYP2A6 and CYP2A6Glu419Asp metabolized coumarin to form 7-hydroxycoumarin in a similar manner, whereas CYP2A6Ile471Thr showed low activity compared to the wild-type CYP2A6. CYP2B6, CYP2B6Pro167Ala and CYP2B6Arg487Cys showed the same activity for 7-ethoxy-4-triflouromethyl-coumarin O-deethylation. However, CYP2B6Gln172His was roughly twice as active as CYP2B6 and the other CYP2B6 variants for 7-ethoxy-4-triflouromethylcoumarin O-deethylation activity. Although higher inter- and intra-laboratory variations were observed for the calculated Km and V(max) values because the studies were conducted in several different laboratories, the degree of variations was reduced by the increased number of analyses and the adoption of a simple analysis system.

Long-term treatment with fidarestat suppresses the development of diabetic retinopathy in STZ-induced diabetic rats.

It is important to suppress retinal vascular changes for prevention of the onset and progression of diabetic retinopathy. In the present study, we investigated the dose-response effect of an aldose reductase (AR) inhibitor, fidarestat, on retinal vascular changes in the retinas of streptozotocin (STZ)-induced diabetic rats. Fidarestat (0.5, 1, and 2 mg/kg) was administered once a day, from 4 days after STZ injection, for 15 months. Microaneurysms and thickness of the basement membrane were frequently observed in the untreated diabetic group as compared to the nondiabetic control group. In addition, the number of pericytes decreased in the untreated diabetic group. Fidarestat diminished the prevalence rate of microaneurysms, basement membrane thickness and decrease in the number of pericytes, and complete suppression was observed at a dose of 2 mg/kg. Fidarestat also dose-dependently inhibited sorbitol accumulation in the retina. Furthermore, a close correlation was observed between the prevalence rate of microaneurysms and the decrease in the number of pericytes, which indicated that damage to pericytes triggers retinal vascular changes. These results suggest that fidarestat, by virtue of its long-term correction of the accelerated polyol pathway, has a potential role in preventing the progression of diabetic retinopathy.

Pharmacokinetic and pharmacodynamic studies of SK-896, a new human motilin analogue, in healthy male volunteers.

OBJECTIVE: To investigate the pharmacokinetics and pharmacodynamics of SK-896 ([Leu(13)]motilin-Hse) after intravenous administration to healthy male volunteers. DESIGN AND SETTING: This was a non-blinded phase I study. PARTICIPANTS: Thirty male Japanese volunteers (mean age 30.6 years) participated in this study. The volunteers were divided into five groups receiving different doses of SK-896. METHODS: The pharmacokinetics and pharmacodynamics of SK-896 were evaluated after single intravenous infusions of doses of 10, 20, 40 and 80 micro g over 20 minutes to fasting volunteers, or after multiple intravenous infusions (twice a day for 3 days) of doses of 40 micro g over 20 minutes to volunteers in the morning (fasting) and afternoon (non-fasting). Plasma concentrations of immunoreactive SK-896 were determined by radioimmunoassay, and borborygmus was measured as an indicator of drug effect (acceleration of gastrointestinal motility) with an improved Holter electrocardiograph attached to the abdomen. RESULTS: When SK-896 was given by single intravenous infusion at each dose, the plasma concentration of immunoreactive SK-896 rapidly increased to a maximum at the end of the infusion. After the infusion was completed, plasma concentrations declined monoexponentially with an elimination half-time of 4.57-5.64 minutes. The area under the concentration-time curve and the maximum concentration (1.04-9.08 microg-equiv./L) increased in proportion to the dose, and there were no dose-related changes in plasma clearance (7.59-9.34 mL/min/kg), mean residence time (7.83-9.51 minutes) or steady-state volume of distribution (62.9-73.9 mL/kg), indicating that SK-896 plasma concentrations can be described by a linear pharmacokinetic model within the dose range of the present study. After beginning administration, an increase in borborygmus was observed. At doses of 40 and 80 micro g, the borborygmus did not continue even when the plasma concentration was maintained, suggesting that tachyphylaxis occurs at a higher dose. When SK-896 was given as multiple intravenous infusions, the pharmacokinetics did not change with repeated administration. The intensity of borborygmus was low with afternoon administration, reaching only one-third to one-half that with morning administration, suggesting that, like native motilin, SK-896 does not stimulate gastrointestinal motility in the non-fasting state. CONCLUSIONS: The appropriate dose and administration period (fasting or non-fasting) are important factors in stimulating and maintaining gastrointestinal motility when treating gastroparalysis with SK-896.

Effects of SK-896, a new human motilin analogue ([Leu13]motilin-Hse), on postoperative ileus in dogs after laparotomy.

The effects of SK-896, a new human motilin analogue ([Leu13]motilin-Hse), on digestive tract motility in postoperative ileus were evaluated in a dog model of ileus after laparotomy. SK-896 was intravenously administered at 0.17, 0.33 and 0.67 microg/kg starting soon after operation and then at 6-h intervals, for a total of 9 times. SK-896 progressively, dose-dependently and significantly increased the duodenal motility from 1 h after operation. The recovery time of the gastrointestinal-interdigestive migrating complex (GI-IMC) activity, which is an indicator of normal gastrointestinal tract activity after laparotomy, was 56.5 +/- 5.0 h in the control group. SK-896 significantly shortened this recovery time. On the other hand, the plasma SK-896 concentrations declined diexponentially after administration, and can be described by a linear pharmacokinetic model within the dose range used. In addition, the pharmacokinetics of SK-896 did not change significantly at any postoperative time. There was no correlation between the plasma SK-896 concentrations and the intensity of duodenal motility, because the activity in the duodenum decreased transiently 13 h after laparotomy and increased with time thereafter. The changes in the activity are considered to reflect the progressive changes in the state of ileus. In conclusion, SK-896 increased the duodenal motility significantly, shortening the recovery time of GI-IMC-like activity in dogs with post-laparotomy ileus. Therefore, it is expected from these results that SK-896 would be useful and effective for the treatment of gastroparalysis after abdominal surgery.