Development of a surface tension mediated technique for dry stabilization of mammalian cells.

Dry state preservation at ambient temperatures (lyopreservation) is a biomimetic alternative to low temperature stabilization (cryopreservation) of biological materials. Lyopreservation is hypothesized to rely upon the creation of a glassy environment, which is commonly observed in desiccation-tolerant organisms. Non-uniformities in dried samples have been indicated as one of the reasons for instability in storage outcome. The current study presents a simple, fast, and uniform surface tension based technique that can be implemented for lyopreservation of mammalian cells. The technique involves withdrawing cells attached to rigid substrates to be submerged in a solution of lyoprotectant and then withdrawing the samples at a specific rate to an inert environment. This creates a uniform thin film of desiccated lyoprotectant due to sudden change of surface tension. The residual moisture contents at different locations in the desiccated film was quantified using a spatially resolved Raman microspectroscopy technique. Post-desiccation cellular viability and growth are quantified using fluorescent microscopy and dye exclusion assays. Cellular injury following desiccation is evaluated by bioenergetic quantification of metabolic functions using extracellular flux analysis and by a Raman microspectroscopic analysis of change in membrane structure. The technique developed here addresses an important bottleneck of lyoprocessing which requires the fast and uniform desiccation of cellular samples.

A technique for lyopreservation of Clostridium ljungdahlii in a biocomposite matrix for CO absorption.

A system capable of biocatalytic conversion of distributed sources of single carbon gases such as carbon monoxide into hydrocarbons can be highly beneficial for developing commercially viable biotechnology applications in alternative energy. Several anaerobic bacterial strains can be used for such conversion. The anaerobic carbon monoxide-fixing bacteria Clostridium ljungdahlii OTA1 is a model CO assimilating microorganism that currently requires cryogenic temperature for storage of the viable strains. If these organisms can be stabilized and concentrated in thin films in advanced porous materials, it will enable development of high gas fraction, biocomposite absorbers with elevated carbon monoxide (CO) mass transfer rate, that require minimal power input and liquid, and demonstrate elevated substrate consumption rate compared to conventional suspended cell bioreactors. We report development of a technique for dry-stabilization of C. ljungdahlii OTA1 on a paper biocomposite. Bacterial samples coated onto paper were desiccated in the presence of trehalose using convective drying and stored at 4°C. Optimal dryness was ~1g H2O per gram of dry weight (gDW). CO uptake directly following biocomposite rehydration steadily increases over time indicating immediate cellular metabolic recovery. A high-resolution Raman microspectroscopic hyperspectral imaging technique was employed to spatially quantify the residual moisture content. We have demonstrated for the first time that convectively dried and stored C. ljungdahlii strains were stabilized in a desiccated state for over 38 days without a loss in CO absorbing reactivity. The Raman hyperspectral imaging technique described here is a non-invasive characterization tool to support development of dry-stabilization techniques for microorganisms on inexpensive porous support materials. The present study successfully extends and implements the principles of dry-stabilization for preservation of strictly anaerobic bacteria as an alternative to lyophilization or spray drying that could enable centralized biocomposite biocatalyst fabrication and decentralized bioprocessing of CO to liquid fuels or chemicals.

Effect of trehalose as an additive to dimethyl sulfoxide solutions on ice formation, cellular viability, and metabolism.

Cryopreservation is the only established method for long-term preservation of cells and cellular material. This technique involves preservation of cells and cellular components in the presence of cryoprotective agents (CPAs) at liquid nitrogen temperatures (-196 °C). The organic solvent dimethyl sulfoxide (Me2SO) is one of the most commonly utilized CPAs and has been used with various levels of success depending on the type of cells. In recent years, to improve cryogenic outcomes, the non-reducing disaccharide trehalose has been used as an additive to Me2SO-based freezing solutions. Trehalose is a naturally occurring non-toxic compound found in bacteria, fungi, plants, and invertebrates which has been shown to provide cellular protection during water-limited states. The mechanism by which trehalose improves cryopreservation outcomes remains not fully understood. Raman microspectroscopy is a powerful tool to provide valuable insight into the nature of interactions among water, trehalose, and Me2SO during cryopreservation. We found that the addition of trehalose to Me2SO based CPA solutions dramatically reduces the area per ice crystals while increasing the number of ice crystals formed when cooled to -40 or -80 °C. Differences in ice-formation patterns were found to have a direct impact on cellular viability. Despite the osmotic stress caused by addition of 100 mM trehalose, improvement in cellular viability was observed. However, the substantial increase in osmotic pressure caused by trehalose concentrations above 100 mM may offset the beneficial effects of changing the morphology of the ice crystals achieved by addition of this sugar.

Imaging of Scleral Collagen Deformation Using Combined Confocal Raman Microspectroscopy and Polarized Light Microscopy Techniques.

This work presents an optospectroscopic characterization technique for soft tissue microstructure using site-matched confocal Raman microspectroscopy and polarized light microscopy. Using the technique, the microstructure of soft tissue samples is directly observed by polarized light microscopy during loading while spatially correlated spectroscopic information is extracted from the same plane, verifying the orientation and arrangement of the collagen fibers. Results show the response and orientation of the collagen fiber arrangement in its native state as well as during tensile and compressive loadings in a porcine sclera model. An example is also given showing how the data can be used with a finite element program to estimate the strain in individual collagen fibers. The measurements demonstrate features that indicate microstructural reorganization and damage of the sclera's collagen fiber arrangement under loading. The site-matched confocal Raman microspectroscopic characterization of the tissue provides a qualitative measure to relate the change in fibrillar arrangement with possible chemical damage to the collagen microstructure. Tests and analyses presented here can potentially be used to determine the stress-strain behavior, and fiber reorganization of the collagen microstructure in soft tissue during viscoelastic response.

Protective effects of osmolytes in cryopreserving adherent neuroblastoma (Neuro-2a) cells.

A simple method to cryopreserve adherent monolayers of neuronal cells is currently not available, but the development of this technique could facilitate numerous applications in the field of biomedical engineering, cell line development, and drug screening. However, complex tissues of some exceptional animals survive freezing in nature. These animals are known to accumulate several small molecular weight solutes prior to freezing. Following a similar strategy, we investigated the effects of osmolytes such as trehalose, proline, and sucrose as additives to the traditional cryoprotectant dimethyl sulfoxide (Me2SO) in modulating the cryopreservation outcome of mouse neuroblastoma (Neuro-2a) cells. Neuro-2a cells adhered to cell culture plates were incubated for 24 h at varying concentrations of trehalose, proline, sucrose and combinations of these compounds. Cells were cryopreserved for 24 h and cell viability post-freezing and thawing was quantified by trypan blue exclusion assay. On average, only 13.5% of adherent cells survived freezing in the presence of 10% Me2SO alone (control). Pre-incubation of cells with medium containing both trehalose and proline severely decreased cell proliferation, but increased cell recovery to about 53% of control. Furthermore, characterization using Raman microspectroscopy revealed that the addition of both trehalose and proline to 10% Me2SO substantially increased the size, and altered the nature, of ice crystals formed during freezing. Our results suggest that pre-incubation of Neuro-2a cells with trehalose and proline in combination provides cell protection along with alterations of ice structure in order to increase cell survival post-freezing.