Trypsin inhibitor content and activity of soaking water whey as waste in soy milk processing.

Soybean soaking water whey (SWW) is obtained as the waste of soy milk production and mostly represents an environmental problem. The aim of this study was to assess the content of proteins and content and activity of trypsin inhibitors of fresh SWW, obtained during soy milk production. Two zones of Bowman-Birk trypsin inhibitors (BBI) were detected. One was identified as a monomeric form of BBI (0.61-2.93%) and the other one was identified as a polymeric form of BBI (0.45-3.33%). The degree of BBI extraction (1.88-5.49%) was influenced by the soybean genotype and the grain size, i.e. it increased with increasing grain size. Kunitz trypsin inhibitor was not detected. Total proteins were found in traces in SWW (0.03-0.06%). Low residual trypsin inhibitor activity (0.32-0.55%) suggested that SWW can potentially be applied for preparing food or feed. In that case it will not be waste but a cheap functional supplement with BBI as a biologically active component.

Bovine pancreatic trypsin inhibitor immobilized onto sepharose as a new strategy to purify a thermostable alkaline peptidase from cobia (Rachycentron canadum) processing waste.

A thermostable alkaline peptidase was purified from the processing waste of cobia (Rachycentron canadum) using bovine pancreatic trypsin inhibitor (BPTI) immobilized onto Sepharose. The purified enzyme had an apparent molecular mass of 24kDa by both sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE) and mass spectrometry. Its optimal temperature and pH were 50°C and 8.5, respectively. The enzyme was thermostable until 55°C and its activity was strongly inhibited by the classic trypsin inhibitors N-ρ-tosyl-l-lysine chloromethyl ketone (TLCK) and benzamidine. BPTI column allowed at least 15 assays without loss of efficacy. The purified enzyme was identified as a trypsin and the N-terminal amino acid sequence of this trypsin was IVGGYECTPHSQAHQVSLNSGYHFC, which was highly homologous to trypsin from cold water fish species. Using Nα-benzoyl-dl-arginine ρ-nitroanilide hydrochloride (BApNA) as substrate, the apparent km value of the purified trypsin was 0.38mM, kcat value was 3.14s(-1), and kcat/km was 8.26s(-1)mM(-1). The catalytic proficiency of the purified enzyme was 2.75×10(12)M(-1) showing higher affinity for the substrate at the transition state than other fish trypsin. The activation energy (AE) of the BApNA hydrolysis catalyzed by this enzyme was estimated to be 11.93kcalmol(-1) while the resulting rate enhancement of this reaction was found to be approximately in a range from 10(9) to 10(10)-fold evidencing its efficiency in comparison to other trypsin. This new purification strategy showed to be appropriate to obtain an alkaline peptidase from cobia processing waste with high purification degree. According with N-terminal homology and kinetic parameters, R. canadum trypsin may gathers desirable properties of psychrophilic and thermostable enzymes.

Affinity purification of aprotinin from bovine lung.

An affinity protocol for the purification of aprotinin from bovine lung was developed. To simulate the structure of sucrose octasulfate, a natural specific probe for aprotinin, the affinity ligand was composed of an acidic head and a hydrophobic stick, and was then linked with Sepharose. The sorbent was then subjected to adsorption analysis with pure aprotinin. The purification process consisted of one step of affinity chromatography and another step of ultrafiltration. Then purified aprotinin was subjected to sodium dodecyl sulfate polyacrylamide gel electrophoresis, trypsin inhibitor activity, gel-filtration, and thin-layer chromatography analysis. As calculated, the theoretical maximum adsorption (Qmax ) of the affinity sorbent was 25,476.0 ± 184.8 kallikrein inactivator unit/g wet gel; the dissociation constant of the complex "immobilized ligand-aprotinin" (Kd ) was 4.6 ± 0.1 kallikrein inactivator unit/mL. After the affinity separation of bovine lung aprotinin, reducing sodium dodecyl sulfate polyacrylamide gel electrophoresis analysis and gel-filtration chromatography revealed that the protein was a single polypeptide, and the purities were ∼ 97 and 100%, respectively; the purified peptide was also confirmed with aprotinin standard by gel-filtration chromatography and thin-layer chromatography. After the whole purification process, protein, and bioactivity recoveries were 2.2 and 92.6%, respectively; and the specific activity was up to 15,907.1 ± 10.2 kallikrein inactivator unit/mg.

Purification and characterization of a stable Kunitz trypsin inhibitor from Trigonella foenum-graecum (fenugreek) seeds.

Kunitz trypsin inhibitor was purified from the seeds of Trigonella foenum-graecum (TfgKTI) belonging to fabaceae family by ammonium sulphate precipitation, cation exchange, gel filtration and hydrophobic chromatography. Purity of the protein was analyzed by RP-HPLC and native-PAGE. SDS-PAGE analysis under reducing and non-reducing conditions showed that protein consists of a single polypeptide chain with molecular mass of approximately 20 kDa. Mass spectroscopy analysis revealed that the intact mass of purified inhibitor is 19,842.154 Da. One dimensional SDS gel was tryptically digested, resulting peptides were subjected to MALDI-TOF-MS analysis, and peptide mass fingerprinting (PMF) analysis of TfgKTI shows sequence similarity with Kunitz trypsin inhibitor in database search. Two dimensional electrophoresis identified presence of four isoinhibitors (pI values of 5.1, 5.4, 5.7 and 6.1). Kinetic studies showed that the protein is a competitive inhibitor and has high binding affinity with trypsin (Ki 3.01×10(-9)M) and chymotrypsin (Ki 0.52×10(-9)M). The TfgKTI retained the inhibitory activity over a broad range of pH (pH 3-10), temperature (37-100°C) and salt concentration (up to 3.5%). Far-UV circular dichroism measurements revealed that TfgKTI is predominantly composed of ß-sheets (39%) and unordered structures (48%) with slight helical content (13%). TfgKTI retained over 90% trypsin inhibition upon storage at 4°C for over a period of six months.

Wanted and wanting: antibody against methionine sulfoxide.

Methionine residues in protein can be oxidized by reactive oxygen or nitrogen species to generate methionine sulfoxide. This covalent modification has been implicated in processes ranging from normal cell signaling to neurodegenerative diseases. A general method for detecting methionine sulfoxide in proteins would be of great value in studying these processes, but development of a chemical or immunochemical technique has been elusive. Recently, an antiserum raised against an oxidized corn protein, DZS18, was reported to be specific for methionine sulfoxide in proteins (Arch. Biochem. Biophys. 485:35-40; 2009). However, data included in that report indicate that the antiserum is not specific. Utilizing well-characterized native and methionine-oxidized glutamine synthetase and aprotinin, we confirm that the antiserum does not possess specificity for methionine sulfoxide.

A novel approach for secretion of heterologous proteins with correct n-terminal processing by using α-factor pre sequence in Pichia pastoris.

Numerous proteins have been secreted in P. pastoris by fusing the target gene with α-factor pre-pro sequence at Kex2 endopeptidase cleavage site. However, in some instances the product cannot be correctly processed due to aberrant cleavage by Kex2 endopeptidase such as aprotinin. In this study, an aprotinin gene was cloned into pPIC9K at the signal peptidase cleavage site through a single NheI restriction site designed at the 3'end of the α-factor signal sequence preregion, and transformed into GS115 host cell. By G418 resistance and ELISA assay, a high-yield recombinant was selected. After fed-batch cultivation in a 7-L bioreactor, the product was efficiently secreted into culture medium and accumulated up to ~4.7 mg L⁻¹. MALDI-TOF/MS and N-terminal analyses confirmed its authenticity. Thus, a novel cloning strategy for secretion of aprotinin with correct N-terminal processing in P. pastoris has been developed which can be potentially applied to other proteins.

Recombinant bovine pancreatic trypsin inhibitor protects the liver from carbon tetrachloride-induced acute injury in mice.

OBJECTIVES: Toxicity caused by pharmacological and chemical substances, including carbon tetrachloride (CCl(4)), is a major pathological factor for liver injury. Therefore, strategies to prevent toxicity are needed for maintaining a healthy liver. This study was designed to determine whether recombinant bovine pancreatic trypsin inhibitor (rBPTI), a non-specific serine protease inhibitor, prevents CCl(4)-induced liver injury in mice. METHODS: Mice were treated with CCl(4) in the presence or absence of co-treatment with rBPTI. Liver sections were prepared for histopathological assessment. Liver function was evaluated by detecting serum levels of alanine aminotransferase (ALT) and aspartate aminotransferase (AST) and liver index. Liver oxidative stress and inflammation were examined by detecting the liver malondialdehyde level and glutathione and superoxide dismutase activity, and serum tumour necrosis factor-alpha level, respectively. KEY FINDINGS: CCl(4) induced hepatocyte necrosis, inflammatory cell infiltration and fatty degeneration, which were ameliorated by co-treatment with rBPTI in a concentration-dependent manner. Furthermore, rBPTI prevented CCl(4)-induced disruption of liver function. Importantly, rBPTI reduced CCl(4)-induced liver oxidative stress response and pro-inflammatory cytokine production. CONCLUSIONS: These results indicated that rBPTI exerted a protective effect on CCl(4)-induced liver injury in mice. Thus, rBPTI may have potential application for prevention of liver injury induced by metabolism of drugs and toxic substances.

Physico-chemical and antifungal properties of protease inhibitors from Acacia plumosa.

This study was aimed at investigating the purification, biological activity, and some structural properties of three serine protease inhibitors isoforms, denoted ApTIA, ApTIB, and ApTIC from Acacia plumosa Lowe seeds. They were purified from the saline extract of the seeds, using Superdex-75 gel filtration and Mono-S ion exchange chromatography. They were further investigated by mass spectrometry, spectroscopic measurements, surface plasmon resonance, and inhibition assays with proteases and phytopathogenic fungi. The molecular mass of each isoform was estimated at ca. 20 kDa. Each contained two polypeptide chains linked by a disulfide bridge, with different isoelectric points that are acidic in nature. The N-terminal sequences of both chains indicated that they were Kunitz-type inhibitors. Circular dichroism (CD) analyses suggested the predominance of both disordered and beta-strands on ApTI isoforms secondary structure, as expected for beta-II proteins. In addition, it was observed that the proteins were very stable, even at either extreme pH values or at high temperature, with denaturation midpoints close to 75 degrees C. The isoinhibitors could delay, up to 10 times, the blood coagulation time in vitro and inhibited action of trypsin (Ki 1.8 nM), alpha-chymotrypsin (Ki 10.3 nM) and kallikrein (Ki 0.58 microM). The binding of ApTIA, ApTIB, and ApTIC to trypsin and alpha-chymotrypsin, was investigated by surface plasmon resonance (SPR), this giving dissociation constants of 0.39, 0.56 and 0.56 nM with trypsin and 7.5, 6.9 and 3.5 nM with alpha-chymotrypsin, respectively. The growth profiles of Aspergillus niger, Thielaviopsis paradoxa and Colletotrichum sp. P10 were also inhibited by each isoforms. These three potent inhibitors from A. plumosa may therefore be of great interest as specific inhibitors to regulate proteolytic processes.

High-yield production and characterization of biologically active recombinant aprotinin expressed in Saccharomyces cerevisiae.

Aprotinin is a polypeptide composed of 58 amino acid residues and has a molecular weight of 6512Da. The 58 amino acid residues are arranged in a single polypeptide chain, which is cross-linked by three disulfide bridges and folded to form a pear-shaped molecule. To express recombinant aprotinin in Saccharomyces cerevisiae, a synthetic gene encoding aprotinin was constructed and fused in frame with the pre-sequence of the S. cerevisiae MATalpha1 gene at the cleavage site of signal peptidase. The expression of aprotinin in S. cerevisiae was carried out using the PRB1 promoter. Aprotinin was secreted as a biologically active protein at a concentration of 426 mg/L into high cell density fermentation medium of 70.9 g/L cell dry weight. The purification process consisted of only three major steps and provided consistent yields of recombinant aprotinin using gel filtration high-pressure liquid chromatographic (HPLC) with a purity level higher than 99% and was free of non-aprotinin-related impurities. The recombinant aprotinin had the same characteristics as bovine aprotinin in a number of analytical methods, including alpha2-plasmin inhibition assay, amino acid composition, N-terminal amino acid sequence determination, and mass spectrum analysis. With further optimization of the purification process and culture conditions for high-yield production by S. cerevisiae, this source of recombinant aprotinin may be a promising approach for the commercial manufacture of aprotinin for pharmaceutical use instead of bovine aprotinin.

Expression, purification and characterization of aprotinin and a human analogue of aprotinin.

Aprotinin is a Kunitz-type inhibitor with a relatively broad specificity. It has been shown to be clinically useful for the management of hemorrhagic complications. In this report, small ubiquitin-related modifier (SUMO) linked with a hexa-histidine tag was used as a fusion partner for the production of recombinant aprotinin and a human aprotinin analogue (cloned form human cDNA library). Both fusion proteins were overexpressed mainly as inclusion bodies in Escherichia coli and accounted for approximately 28% of the total cell proteins. After purification by Ni-Sepharose affinity chromatography and renaturation, the fusion proteins were cleaved with SUMO protease 1. Aprotinin and its analogue were separated from the fusion partner by the subtractive chromatography using Ni-Sepharose and then further purified with CM-cellulose. Kinetic studies demonstrated that the amidolytic activity of plasmin was competitively inhibited by recombinant aprotinin with a K(i) of 8.6+/-2.4 nM, which was similar to the K(i) (7.5+/-2.7 nM) of natural aprotinin. The K(i) of human aprotinin analogue was 22.7+/-6.5 nM. The expression strategy described in this study allows convenient high yield and easy purification of small recombinant protease inhibitors with complete native sequences.

Expression and purification of natural N-terminal recombinant bovine pancreatic trypsin inhibitor from Pichia pastoris.

Bovine pancreatic trypsin inhibitor (BPTI) is a natural non-specific serine protease inhibitor and possesses the ability to inhibit trypsin, chymotrypsin, plasmin and plasma kallikrein. The expression of BPTI in Escherichia coli and other systems has been reported. However, the preparation of recombinant BPTI (rBPTI) with correct N-terminus in Pichia pastoris has not been successful. A previous study showed that the preBPTI with the prepro leader sequence of alpha mating factor (AMF) was not processed into natural BPTI in P. pastoris. Now, we introduce a new method to prepare rBPTI, which carries a natural N-terminal amino acid residue, Arg-Pro-Asp, in P. pastoris using human serum albumin signal peptide corresponding to the pre sequence. The concentration of rBPTI in an 80 l fermentor reached 900 mg/l. We also explored a rapid and simple purification protocol for rBPTI and the purity of rBPTI reached 95-98% as evaluated by SDS-PAGE analysis. The sequencing results showed that the sequence of N-terminal 15 amino acids of rBPTI was consistent with that of natural BPTI. The inhibitory activity of rBPTI against trypsin was the same as natural BPTI and its K(i) was 2.6+/-0.1 x 10(-9). The therapeutic effect of rBPTI on acute pancreatitis was identified in rats.

[Expression of a shrimp Kunitz-type protease inhibitor in Pichia pastoris and activity analysis].

SKPI (shrimp Kunitz-type protease inhibitor) from Marsupenaeus japonicus is a member of serine protease inhibitors which play an important role in the arthropod immunity. To fully understand its function in the innate immunity of shrimp, the skpi gene was cloned into a modified pPIC9K vector with a 6-His tag and expressed by Pichia pastoris GS115. The secretory SKPI was purified from the medium with high purity by using Ni Sepharose High Performance. This results also indicated that the purified SKPI could inhibit the activity of trypsin specifically.

An affinity-based strategy for the design of selective displacers for the chromatographic separation of proteins.

We describe an affinity-based strategy for designing selective protein displacers for the chromatographic purification of proteins. To design a displacer that is selective for a target protein, we attached a component with affinity for the target protein to a resin-binding component; we then tested the ability of such displacers to selectively retain the target protein on a resin relative to another protein having a similar retention time. In particular, we synthesized displacers based on biotin, which selectively retained avidin as compared to aprotinin on SP Sepharose high performance resin. In addition, we have extended this approach to develop an affinity-peptide-based displacer that discriminates between lysozyme and cytochrome c. Here, a selective displacer was designed from a lysozyme-binding peptide that had been identified and optimized previously using phage-display technology. Our results suggest a general strategy for designing highly selective affinity-based displacers by identifying molecules (e.g., peptides) that bind to a protein of interest and using an appropriate linker to attach these molecules to a moiety that binds to the stationary phase.

Kunitz-type protease inhibitors from acrorhagi of three species of sea anemones.

Sea anemones are rich in biologically active polypeptides such as toxins and protease inhibitors. These polypeptides have so far been isolated from whole bodies, tentacles or secreted mucus. Recently, two novel peptide toxins with crab lethality have been isolated from acrorhagi (specialized aggressive organs elaborated by only certain species of sea anemones belonging to the family Actiniidae) of Actinia equina. This prompted us to survey biologically active polypeptides in the acrorhagi of two species of sea anemones, Anthopleura aff. xanthogrammica and Anthopleura fuscoviridis. No potent crab lethality was displayed by the acrorhagial extracts of both species. However, significantly high protease inhibitory activity was instead detected in the acrorhagial extracts of the two species and also in that of A. equina. From the acrorhagi of A. equina, A. aff. xanthogrammica and A. fuscoviridis, one (AEAPI), one (AXAPI) and two (AFAPI-I and AFAPI-III) protease inhibitors were isolated, respectively. The complete amino acid sequences of the four inhibitors were elucidated by N-terminal sequencing and sequencing of the C-terminal peptide fragment produced upon asparaginylendopeptidase digestion. The determined amino acid sequences revealed that all the four inhibitors are new members of the Kunitz-type protease inhibitor family.

Purification and characterization of aprotinin from porcine lungs.

Aprotinin, the most studied serine proteinase inhibitor, was isolated from porcine lung for the first time. The purified porcine aprotinin had an Mr value of approximately 7 kDa. It cross-reacted with polyclonal serum anti-commercial aprotinin. About 1 microg porcine aprotinin inhibited 6 microg trypsin whereas 1 microg commercial soybean inhibitor inhibited only 1 microg trypsin. The aprotinin gene was also isolated from porcine lung: the deduced amino acid sequence showed 74% identity to bovine aprotinin.

Purification of recombinant aprotinin from transgenic corn germ fraction using ion exchange and hydrophobic interaction chromatography.

Plants have attracted interest as hosts for protein expression because of the promise of a large production capacity and a low production cost. However, recovery costs remain a challenge as illustrated for recovery of recombinant aprotinin, a trypsin inhibitor, with removal of native corn trypsin inhibitor from transgenic corn (Azzoni et al. in Biotechnol Bioeng 80:268-276, 2002). When expression is targeted to corn grain fractions, dry milling can separate germ and endosperm fractions. Hence, only the product-containing fraction needs to be extracted, reducing the cost of extraction and the impurity level of the extract. Selective extraction conditions can reduce impurity levels to the point that low-cost adsorbents can result in relatively high purity levels. In this work, we attempted to achieve comparable purity with these lower cost methods. We replaced whole grain extraction and purification of recombinant aprotinin with sequential trypsin affinity and IMAC steps with an alternative of germ fraction extraction and purification with ion exchange and hydrophobic interaction chromatography (HIC). Using germ extraction at acidic pH supplemented with heat precipitation to remove additional host proteins resulted in a higher specific activity feed to the chromatographic steps. The cation exchange step provided 7.6x purification with 76.4% yield and no sodium dodecyl sulfate-polyacrylamide gel electrophoresis detectable native corn trypsin inhibitor. After the HIC step (2.7x step purification with 44.0% yield), the final product had a specific activity that was 75.3% of that of the affinity-purified aprotinin.

Mechanical and microstructural properties of hybrid poly(ethylene glycol)-soy protein hydrogels for wound dressing applications.

Biomimetic hydrogel made of poly(ethylene glycol) and soy protein with a water content of 96% has been developed for moist wound dressing applications. In this study, such hybrid hydrogels were investigated by both tensile and unconfined compression measurements in order to understand the relationships between structural parameters of the network, its mechanical properties and protein absorption in vitro. Elastic moduli were found to vary from 1 to 17 kPa depending on the composition, while the Poisson's ratio (approximately 0.18) and deformation at break (approximately 300%) showed no dependence on this parameter. Further calculations yielded the crosslinking concentration, the average molecular weight between crosslinks (M(C)) and the mesh size. The results show that reactions between PEG and protein create polymeric chains comprising molecules of PEG and protein fragments between crosslinks. M(C) is three times higher than that expected for a "theoretical network." On the basis of this data, we propose a model for the 3D network of the hydrogel, which is found to be useful for understanding drug release properties and biomedical potential of the studied material.

Purification and characterization of aprotinin from porcine lungs

Aprotinin, the most studied serine proteinase inhibitor, was isolated from porcine lung for the first time. The purified porcine aprotinin had an Mr value of ¡­7 kDa. It cross-reacted with polyclonal serum anti-commercial aprotinin. About 1 ¥ìg porcine aprotinin inhibited 6 ¥ìg trypsin whereas 1 ¥ìg commercial soybean inhibitor inhibited only 1 ¥ìg trypsin. The aprotinin gene was also isolated from porcine lung: the deduced amino acid sequence showed 74% identity to bovine aprotinin.

Aprotinin in cardiac surgery.

Aprotinin is a naturally occurring serine protease inhibitor that is being used with increasing frequency in cardiac surgery and beyond to reduce blood loss and the need for perioperative blood transfusion. Through inhibition of serine proteases such as plasmin, aprotinin significantly reduces fibrinolysis, thereby aiding hemostasis during surgical procedures. In addition, aprotinin interacts with other factors in the coagulation and fibrinolytic cascade, creating a hemostatic balance, without increasing the risk of thrombosis. These proven benefits are supplemented by the anti-inflammatory properties of aprotinin, which may help curb some of the deleterious effects of cardiopulmonary bypass. This article will review the discovery of aprotinin, its mechanism of action, dosing and adverse effects, and highlight the major recent trials demonstrating its efficacy.

Implementation of a crystallization step into the purification process of a recombinant protein.

Identification of crystallization conditions of new proteins is still regarded as a tedious trial-and-error work, especially when the crystallization step has to meet the requirements of a given purification process. The traditional screening kit method and a multifactorial approach were compared against each other with regard to their ability to find new crystallization conditions that are compatible to the purification process of a recombinant aprotinin variant. Overall, the multifactorial approach turned out to be 10-fold more efficient. The new crystallization conditions were scaled up and implemented into the purification process as a bulk storage step. The aprotinin variant derived from this process was fully characterized biochemically.