Converting Bulk Sugars into Functional Fibers: Discovery and Application of a Thermostable ß-1,3-Oligoglucan Phosphorylase.

Despite their broad application potential, the widespread use of ß-1,3-glucans has been hampered by the high cost and heterogeneity associated with current production methods. To address this challenge, scalable and economically viable processes are needed for the production of ß-1,3-glucans with tailorable molecular mass distributions. Glycoside phosphorylases have shown to be promising catalysts for the bottom-up synthesis of ß-1,3-(oligo)glucans since they combine strict regioselectivity with a cheap donor substrate (i.e., α-glucose 1-phosphate). However, the need for an expensive priming substrate (e.g., laminaribiose) and the tendency to produce shorter oligosaccharides still form major bottlenecks. Here, we report the discovery and application of a thermostable ß-1,3-oligoglucan phosphorylase originating from Anaerolinea thermophila (AtßOGP). This enzyme combines a superior catalytic efficiency toward glucose as a priming substrate, high thermostability, and the ability to synthesize high molecular mass ß-1,3-glucans up to DP 75. Coupling of AtßOGP with a thermostable variant of Bifidobacterium adolescentis sucrose phosphorylase enabled the efficient production of tailorable ß-1,3-(oligo)glucans from sucrose, with a near-complete conversion of >99 mol %. This cost-efficient process for the conversion of renewable bulk sugar into ß-1,3-(oligo)glucans should facilitate the widespread application of these versatile functional fibers across various industries.

Engineering of a Thermostable Biocatalyst for the Synthesis of 2-O-Glucosylglycerol.

2-O-Glucosylglycerol is accumulated by various bacteria and plants in response to environmental stress. It is widely applied as a bioactive moisturising ingredient in skin care products, for which it is manufactured via enzymatic glucosylation of glycerol by the sucrose phosphorylase from Leuconostoc mesenteroides. This industrial process is operated at room temperature due to the mediocre stability of the biocatalyst, often leading to microbial contamination. The highly thermostable sucrose phosphorylase from Bifidobacterium adolescentis could be a better alternative in that regard, but this enzyme is not fit for production of 2-O-glucosylglycerol due to its low regioselectivity and poor affinity for glycerol. In this work, the thermostable phosphorylase was engineered to alleviate these problems. Several engineering approaches were explored, ranging from site-directed mutagenesis to conventional, binary, iterative or combinatorial randomisation of the active site, resulting in the screening of ∼3,900 variants. Variant P134Q displayed a 21-fold increase in catalytic efficiency for glycerol, as well as a threefold improvement in regioselectivity towards the 2-position of the substrate, while retaining its activity for several days at elevated temperatures.

On the donor substrate dependence of group-transfer reactions by hydrolytic enzymes: Insight from kinetic analysis of sucrose phosphorylase-catalyzed transglycosylation.

Chemical group-transfer reactions by hydrolytic enzymes have considerable importance in biocatalytic synthesis and are exploited broadly in commercial-scale chemical production. Mechanistically, these reactions have in common the involvement of a covalent enzyme intermediate which is formed upon enzyme reaction with the donor substrate and is subsequently intercepted by a suitable acceptor. Here, we studied the glycosylation of glycerol from sucrose by sucrose phosphorylase (SucP) to clarify a peculiar, yet generally important characteristic of this reaction: partitioning between glycosylation of glycerol and hydrolysis depends on the type and the concentration of the donor substrate used (here: sucrose, α-d-glucose 1-phosphate (G1P)). We develop a kinetic framework to analyze the effect and provide evidence that, when G1P is used as donor substrate, hydrolysis occurs not only from the ß-glucosyl-enzyme intermediate (E-Glc), but additionally from a noncovalent complex of E-Glc and substrate which unlike E-Glc is unreactive to glycerol. Depending on the relative rates of hydrolysis of free and substrate-bound E-Glc, inhibition (Leuconostoc mesenteroides SucP) or apparent activation (Bifidobacterium adolescentis SucP) is observed at high donor substrate concentration. At a G1P concentration that excludes the substrate-bound E-Glc, the transfer/hydrolysis ratio changes to a value consistent with reaction exclusively through E-Glc, independent of the donor substrate used. Collectively, these results give explanation for a kinetic behavior of SucP not previously accounted for, provide essential basis for design and optimization of the synthetic reaction, and establish a theoretical framework for the analysis of kinetically analogous group-transfer reactions by hydrolytic enzymes.

The presence of resistant starch-degrading amylases in Bifidobacterium adolescentis of the human gut.

Resistant starch (RS) is a complex prebiotic carbohydrate beneficial to the human gut. In the present study, four genes encoding for putative amylolytic enzymes, likely to be responsible for RS-degradation, were identified in the genome of Bifidobacterium adolescentis P2P3 by comparative genomic analysis. Our results showed that only three enzymes (RSD1, RSD2, and RSD3) exhibited non-gelatinized high amylose corn starch (HACS)-degrading activity in addition to typical α-amylase activity. These three RS-degrading enzymes (RSD) were composed of multiple domains, including signal peptide, catalytic domain, carbohydrate binding domains, and putative cell wall-anchoring domains. Typical catalytic domains were conserved by exhibiting seven typical conserved regions (I-VII) found mostly in α-amylases. Analysis of enzymatic activity revealed that RSD2 displayed stronger activity toward HACS-granules than RSD1 and RSD3. Comparative genomics in combination with enzymatic experiments confirmed that RSDs might be the key enzymes used by RS-degrading bifidobacteria to degrade RS in a particular ecological niche, such as the human gut.

Identification of a Key Enzyme for the Hydrolysis of ß-(1→3)-Xylosyl Linkage in Red Alga Dulse Xylooligosaccharide from Bifidobacterium Adolescentis.

Red alga dulse possesses a unique xylan, which is composed of a linear ß-(1→3)/ß-(1→4)-xylosyl linkage. We previously prepared characteristic xylooligosaccharide (DX3, (ß-(1→3)-xylosyl-xylobiose)) from dulse. In this study, we evaluated the prebiotic effect of DX3 on enteric bacterium. Although DX3 was utilized by Bacteroides sp. and Bifidobacterium adolescentis, Bacteroides Ksp. grew slowly as compared with ß-(1→4)-xylotriose (X3) but B. adolescentis grew similar to X3. Therefore, we aimed to find the key DX3 hydrolysis enzymes in B. adolescentis. From bioinformatics analysis, two enzymes from the glycoside hydrolase family 43 (BAD0423: subfamily 12 and BAD0428: subfamily 11) were selected and expressed in Escherichia coli. BAD0423 hydrolyzed ß-(1→3)-xylosyl linkage in DX3 with the specific activity of 2988 mU/mg producing xylose (X1) and xylobiose (X2), and showed low activity on X2 and X3. BAD0428 showed high activity on X2 and X3 producing X1, and the activity of BAD0428 on DX3 was 1298 mU/mg producing X1. Cooperative hydrolysis of DX3 was found in the combination of BAD0423 and BAD0428 producing X1 as the main product. From enzymatic character, hydrolysis of X3 was completed by one enzyme BAD0428, whereas hydrolysis of DX3 needed more than two enzymes.

Production of isofloridoside from galactose and glycerol using α-galactosidase from Alicyclobacillus hesperidum.

Isofloridoside (D-isofloridoside and L-isofloridoside) is the main photosynthetic product in red algae. Here, given the importance of isofloridoside, a potentially effective method to produce isofloridoside from galactose and glycerol using whole-cell biocatalysts harboring α-galactosidase was developed. α-Galactosidase-encoding genes from Alicyclobacillus hesperidum, Lactobacillus plantarum, and Bifidobacterium adolescentis were cloned and the proteins were overproduced in Escherichia coli. The α-galactosidase from A. hesperidum (AHGLA) was chosen to synthesize isofloridoside. The effects of reaction pH, temperature, and substrate concentration were investigated. In the optimum biotransformation conditions, the final isofloridoside concentration reached 0.45 M (galactose conversion 23 %). The reaction mixtures were purified using activated charcoal and calcined Celite, and the purified product was identified as a mixture of D- and L-isofloridoside by liquid chromatography-mass spectrometry and nuclear magnetic resonance. This study provides a possible feasible method for the biosynthesis of isofloridoside from low-cost glycerol and galactose.

Growth-coupled evolution of phosphoketolase to improve L-glutamate production by Corynebacterium glutamicum.

The introduction of the key non-oxidative glycolytic (NOG) pathway enzyme, phosphoketolases (PKTs), into heterologous hosts can improve the yield of a variety of acetyl CoA-derived products of interest. However, the low specific activity of existing PKTs compared with that of 6-phosphofructokinase (PFK), the key EMP pathway enzyme, largely limits their potential applications. To improve PKT activity, previous attempts have focused on increasing intracellular PKT concentration via the use of strong promoters. Herein, we report the establishment of a growth-coupled evolution strategy for the enrichment and selection of PKT mutants with improved specific activity in Corynebacterium glutamicum hosts with defective PFK. Five mutants from 9 Bifidobacterium adolescentis-source PKT (BA-PKT) mutant libraries were obtained. Site-directed mutagenesis analysis revealed 11 mutant sites which contributed to improved BA-PKT specific activity. Further structural analysis revealed that the mutant sites were located far away from the enzyme active site, which makes them almost unpredictable using a rational design approach. Mutant site recombination led to the construction of a novel mutant, PKTT2A/I6T/H260Y, with Vmax 29.77 ± 1.58 U/mg and Kcat/Km 0.32 ± 0.01 s-1/mM, which corresponds to 73.27 ± 3.25% and 80.16 ± 3.38% improvements, respectively, compared with the wildtype (Vmax; 17.17 ± 0.59 U/mg, Kcat/Km; 0.17 ± 0.01 s-1/mM). Expression of PKTT2A/I6T/H260 in C. glutamicum Z188 resulted in 16.67 ± 2.24% and 18.19 ± 0.53% improvement in L-glutamate titer and yield, respectively, compared with the wildtype BA-PKT. Our findings provide an efficient approach for improving the activity of PKTs. Furthermore, the novel mutants could serve as useful tools in improving the yield of L-glutamate and other acetyl CoA-associated products.

Structural and biochemical characterization of 20ß-hydroxysteroid dehydrogenase from Bifidobacterium adolescentis strain L2-32.

Anaerobic bacteria inhabiting the human gastrointestinal tract have evolved various enzymes that modify host-derived steroids. The bacterial steroid-17,20-desmolase pathway cleaves the cortisol side chain, forming pro-androgens predicted to impact host physiology. Bacterial 20ß-hydroxysteroid dehydrogenase (20ß-HSDH) regulates cortisol side-chain cleavage by reducing the C-20 carboxyl group on cortisol, yielding 20ß-dihydrocortisol. Recently, the gene encoding 20ß-HSDH in Butyricicoccus desmolans ATCC 43058 was reported, and a nonredundant protein search yielded a candidate 20ß-HSDH gene in Bifidobacterium adolescentis strain L2-32. B. adolescentis 20ß-HSDH could regulate cortisol side-chain cleavage by limiting pro-androgen formation in bacteria such as Clostridium scindens and 21-dehydroxylation by Eggerthella lenta Here, the putative B. adolescentis 20ß-HSDH was cloned, overexpressed, and purified. 20ß-HSDH activity was confirmed through whole-cell and pure enzymatic assays, and it is specific for cortisol. Next, we solved the structures of recombinant 20ß-HSDH in both the apo- and holo-forms at 2.0-2.2 Å resolutions, revealing close overlap except for rearrangements near the active site. Interestingly, the structures contain a large, flexible N-terminal region that was investigated by gel-filtration chromatography and CD spectroscopy. This extended N terminus is important for protein stability because deletions of varying lengths caused structural changes and reduced enzymatic activity. A nonconserved extended N terminus was also observed in several short-chain dehydrogenase/reductase family members. B. adolescentis strains capable of 20ß-HSDH activity could alter glucocorticoid metabolism in the gut and thereby serve as potential probiotics for the management of androgen-dependent diseases.

Analysis of the substrate specificity of α-L-arabinofuranosidases by DNA sequencer-aided fluorophore-assisted carbohydrate electrophoresis.

Carbohydrate-active enzyme discovery is often not accompanied by experimental validation, demonstrating the need for techniques to analyze substrate specificities of carbohydrate-active enzymes in an efficient manner. DNA sequencer-aided fluorophore-assisted carbohydrate electrophoresis (DSA-FACE) is utmost appropriate for the analysis of glycoside hydrolases that have complex substrate specificities. DSA-FACE is demonstrated here to be a highly convenient method for the precise identification of the specificity of different α-L-arabinofuranosidases for (arabino)xylo-oligosaccharides ((A)XOS). The method was validated with two α-L-arabinofuranosidases (EC 3.2.1.55) with well-known specificity, specifically a GH62 α-L-arabinofuranosidase from Aspergillus nidulans (AnAbf62A-m2,3) and a GH43 α-L-arabinofuranosidase from Bifidobacterium adolescentis (BaAXH-d3). Subsequently, application of DSA-FACE revealed the AXOS specificity of two α-L-arabinofuranosidases with previously unknown AXOS specificities. PaAbf62A, a GH62 α-L-arabinofuranosidase from Podospora anserina strain S mat+, was shown to target the O-2 and the O-3 arabinofuranosyl monomers as side chain from mono-substituted ß-D-xylosyl residues, whereas a GH43 α-L-arabinofuranosidase from a metagenomic sample (AGphAbf43) only removes an arabinofuranosyl monomer from the smallest AXOS tested. DSA-FACE excels ionic chromatography in terms of detection limit for (A)XOS (picomolar sensitivity), hands-on and analysis time, and the analysis of the degree of polymerization and binding site of the arabinofuranosyl substituent.

Reversibility of a Point Mutation Induced Domain Shift: Expanding the Conformational Space of a Sucrose Phosphorylase.

Despite their popularity as enzyme engineering targets structural information about Sucrose Phosphorylases remains scarce. We recently clarified that the Q345F variant of Bifidobacterium adolescentis Sucrose Phosphorylase is able to accept large polyphenolic substrates like resveratrol via a domain shift. Here we present a crystal structure of this variant in a conformation suitable for the accommodation of the donor substrate sucrose in excellent agreement with the wild type structure. Remarkably, this conformation does not feature the previously observed domain shift which is therefore reversible and part of a dynamic process rather than a static phenomenon. This crystallographic snapshot completes our understanding of the catalytic cycle of this useful variant and will allow for a more rational design of further generations of Sucrose Phosphorylase variants.

Structural and biochemical characterization of a GH3 ß-glucosidase from the probiotic bacteria Bifidobacterium adolescentis.

Bifidobacterium is an important genus of probiotic bacteria colonizing the human gut. These bacteria can uptake oligosaccharides for the fermentative metabolism of hexoses and pentoses, producing lactate, acetate as well as short-chain fatty acids and propionate. These end-products are known to have important effects on human health. ß-glucosidases (EC 3.2.1.21) are pivotal enzymes for the metabolism and homeostasis of Bifidobacterium, since they hydrolyze small and soluble saccharides, typically producing glucose. Here we describe the cloning, expression, biochemical characterization and the first X-ray structure of a GH3 ß-glucosidase from the probiotic bacteria Bifidobacterium adolescentis (BaBgl3). The purified BaBgl3 showed a maximal activity at 45 °C and pH 6.5. Under the optimum conditions, BaBgl3 is highly active on 4-nitrophenyl-ß-d-glucopyranoside (pNPG) and, at a lesser degree, on 4-nitrophenyl-ß-d-xylopyranoside (pNPX, about 32% of the activity observed for pNPG). The 2.4 Šresolution crystal structure of BaBgl3 revealed a three-domain structure composed of a TIM barrel domain, which together with α/ß sandwich domain accommodate the active site and a third C-terminal fibronectin type III (FnIII) domain with unknown function. Modeling of the substrate in the active site indicates that an aspartate interacts with the hydroxyl group of the C6 present in pNPG but absent in pNPX, which explains the substrate preference. Finally, the enzyme is significantly stabilized by glycerol and galactose, resulting in considerable increase in the enzyme activity and its lifetime. The structural and biochemical studies presented here provide a deeper understanding of the molecular mechanisms of complex carbohydrates degradation utilized by probiotic bacteria as well as for the development of new prebiotic oligosaccharides.

Modular pathway engineering of Corynebacterium glutamicum to improve xylose utilization and succinate production.

Xylose-negative Corynebacterium glutamicum has been engineered to utilize xylose as the sole carbon source via either the xylose isomerase (XI) pathway or the Weimberg pathway. Heterologous expression of xylose isomerase and overexpression of a gene encoding for xylulose kinase enabled efficient xylose utilization. In this study, we show that two functionally-redundant transcriptional regulators (GntR1 and GntR2) present on xylose repress the pentose phosphate pathway genes. For efficient xylose utilization, pentose phosphate pathway genes and a phosphoketolase gene were overexpressed with the XI pathway in C. glutamicum. Overexpression of the genes encoding for transaldolase (Tal), 6-phosphogluconate dehydrogenase (Gnd), or phosphoketolase (XpkA) enhanced the growth and xylose consumption rates compared to the wild-type with the XI pathway alone. However, co-expression of these genes did not have a synergetic effect on xylose utilization. For the succinate production from xylose, overexpression of the tal gene with the XI pathway in a succinate-producing strain improved xylose utilization and increased the specific succinate production rate by 2.5-fold compared to wild-type with the XI pathway alone. Thus, overexpression of the tal, gnd, or xpkA gene could be helpful for engineering C. glutamicum toward production of value-added chemicals with efficient xylose utilization.