Carry-over of veterinary drugs from medicated to non-medicated feeds in commercial feed manufacturing plants.

Different compound feeds have to be manufactured in the same production line. As a consequence, traces of the first produced feed may remain in the production and get mixed with the next feed batches. This "carry-over" is unavoidable, and so non-medicated feed can be contaminated with veterinary drugs like antibiotics added to the previous batch of medicated feed. To monitor the carry-over of antibiotics in the Netherlands, 21 feed mills were visited and 140 samples of flushing feeds were collected and analysed for containing residues of antibiotics. Results show that 87% of all samples contain concentrations of antibiotics in the range of 0.1-154 mg/kg. It is expected that these levels - which are in the same range as previously found for the nowadays banned antimicrobial growth promoters (AMGPs) - have an effect on the occurrence of microbial resistance. Analysis of a second set of samples collected at four different feed mills directly after the production of oxytetracycline-medicated feed demonstrated that the first part of a flushing feed has much higher contamination than the last part of the batch. Furthermore, it was demonstrated that the carry-over percentage shows no correlation with the carry-over determined by one of the standard GMP+ procedures. These observations, unavoidable carry-over, inhomogeneous batches of feed with antibiotics and difficulties to predict the carry-over levels, together with the awareness of the increasing problem of microbial resistance, motivated the NEVEDI, association of Dutch Feed Producers, to announce that they will voluntarily stop the production of medicated feed in 2011. The alternatives for medicated feed are for example water or milk medication or the use of top-dressings at the farm. The consequences and possible new risks of carry-over at the farm are not completely clear yet.

Tracing and analytical results of the dioxin contamination incident in 2008 originating from the Republic of Ireland.

High levels of dioxins (PCDD/Fs) in pork were discovered in France and the Netherlands at the end of 2008. The contamination was rapidly traced back to a feed stock in the Republic of Ireland (RoI). Burning oil, used for the drying of bakery waste, appeared to be contaminated with PCBs. Consequently, very high levels up to 500 pg TEQ g⁻¹ fat were found in pork. The congener pattern clearly pointed to PCB-oil as a source, but the ratio between the non-dioxin-like indicator PCBs (PCBs 28, 52, 101, 138, 152 and 180) and PCDD/Fs was much lower than observed during the Belgian incident, thereby limiting the suitability of indicator PCBs as a marker for the presence of dioxins and dioxin-like PCBs. This paper describes the tracking and tracing of the incident, the public-private cooperation, the surveillance activities and its results. A major lesson to be learned from this incident is the importance of good private food safety systems. In this incident, it was the private surveillance systems that identified the origin of contamination within 10 days after the first signal of increased dioxin levels in a product. On the other hand, retrospective analyses showed that signals were missed that could have led to an earlier detection of the incident and the source. Above all, the incident would not have occurred when food safety assurance systems had been effectively implemented in the involved feed chain. It is discussed that besides primary responsibility for effective private food safety systems, the competent authorities have to supervise whether the food safety procedures are capable of coping with these kinds of complex food safety issues, while private food companies need to implement the law, and public authorities should supervise and enforce them. Finally, it is discussed whether the health risks derived from consumption of the contaminated batches of meat may have been underestimated during the incident due to the unusually high intake of dioxins.

A novel source for dioxins present in recycled fat from gelatin production.

Within a survey on dioxins in animal fat used as feed ingredient, a sample originating from pigs offal was shown to contain 50 ng Toxic Equivalents (TEQ) PCDD/PCDFs kg(-1) fat. Further investigation revealed fat samples with levels as high as 440 ng TEQ kg(-1) fat and contaminated feed with a highest level of 8.4 ng TEQ kg(-1) feed. The congener pattern was dominated by 1,2,3,7,8-PeCDD and 2,3,7,8-TCDD, and was not recognized from any previous incident or known dioxin source. Remarkably, 2,3,7,8-substituted congeners were much more abundant than their non-2,3,7,8-substituted counterparts. The sampled fat was derived from a gelatin production plant. Broken filters, used to clean the hydrochloric acid (HCl) used in the process, caused the dioxin contamination. The fat was primarily used for pig feed. A new physiologically-based pharmacokinetic (PBPK) model for lipophilic contaminants in growing slaughter pigs predicted levels at slaughter varying between 40 pg TEQ g(-1) fat (worst-case) and 2.5-7pgTEQ g(-1) fat under more realistic scenarios. Almost 300 farms were temporarily blocked. Many fat samples of pigs were analyzed using a combined approach of DR CALUX and GC/HRMS. Levels in contaminated pig fat were around the EU-limit of 1 pg TEQ g(-1) fat, with some samples up to 2-3 pg TEQ g(-1) fat. Of 80 negative samples analyzed by DR CALUX and GC/HRMS no false-negatives were obtained, whereas 36 and 62 of the 80 samples classified suspected with the bioassay had GC/HRMS levels above respectively the tolerance and action limits. It is concluded that novel and unexpected dioxin sources remain a threat to the food chain and require the proper evaluation and monitoring of production processes, including chemicals used therein.

[The weakest link: medroxyprogesterone acetate in pig feed]. / De Zwakste Schakel: Medroxyprogesteron-acetaat in varkensvoeder.

Medroxyprogesterone acetate (MPA)-contaminated feed arrested the onset of farrowing, and induced post-lactational anoestrus in sows. Sixty percent of the sows developed cystic ovaries after weaning following exposure to pharmaceutical waste of MPA in glucose syrup. This waste ended up in acidified feed of by-products of a sow farm, and proved to be the cause of the disorders. Analysis by thin layer chromatography and Gas Chromatography/Mass Spectrometry of renal fat from 10 slaughter sows demonstrated residues of 2.5-8 ppb of MPA. Within the European Union use of MPA is illegal as growth promoter in production animals, and therefore MPA-exposed farms were placed under official control by the general inspection service. Clinical signs and diagnostic procedures of the initial case are presented and the role of the veterinary practitioner in detecting potential food safety hazards is discussed.

Occurrence of verocytotoxin-producing Escherichia coli O157 on Dutch dairy farms.

During the period from September 1996 through November 1996, 10 Dutch dairy farms were visited to collect fecal samples from all cattle present. The samples were examined for the presence of verocytotoxin (VT)-producing Escherichia coli (VTEC) of serogroup O157 (O157 VTEC) by immunomagnetic separation following selective enrichment. Cattle on 7 of the 10 dairy farms tested positive for O157 VTEC, with the proportion of cattle infected varying from 0.8 to 22.4%. On the seven farms positive for O157 VTEC, the excretion rate was highest in calves ages 4 to 12 months (21.2%). In a follow-up study, two O157 VTEC-positive farms and two O157 VTEC-negative farms identified in the prevalence study were revisited five times at intervals of approximately 3 months. Cattle on each farm tested positive at least once. The proportion of cattle infected varied from 0 to 61.0%. Excretion rates peaked in summer and were lowest in winter. Again, the highest prevalence was observed in calves ages 4 to 12 months (11.8%). O157 VTEC strains were also isolated from fecal samples from horses, ponies, and sheep and from milk filters and stable flies. O157 VTEC isolates were characterized by VT production and type, the presence of the E. coli attaching-and-effacing gene, phage type, and pulsed-field gel electrophoretic genotype. No overlapping strain types were identified among isolates from different farms except one. The predominance of a single type at each sampling suggests that horizontal transmission is an important factor in dissemination of O157 VTEC within a farm. The presence of more than one strain type, both simultaneously and over time, suggests that there was more than one source of O157 VTEC on the farms. Furthermore, this study demonstrated that the O157 VTEC status of a farm cannot be ascertained from a single visit testing a small number of cattle.

Isolation and characterization of verocytotoxin-producing Escherichia coli O157 strains from Dutch cattle and sheep.

In the periods from July to November 1995 and 1996, fecal samples from Dutch cattle and sheep were collected at the main slaughterhouses of The Netherlands, located at different geographic sites. The samples were examined for the presence of verocytotoxin (VT)-producing Escherichia coli (VTEC) of serogroup 0157. E. coli O157 strains could be isolated from 57 (10.6%) of 540 adult cattle, 2 (0.5%) of 397 veal calves, 2 (3.8%) of 52 ewes, and 2 (4.1%) of 49 lambs. Immunomagnetic separation with O157-specific-antibody-coated beads appeared to be significantly more sensitive than conventional plating for detection of the organism in feces. With the exception of two isolates from adult cattle which appeared to be negative for VT genes, all animal isolates were positive for both VT (VT1 and/or VT2) and E. coli attaching-and-effacing gene sequences, and therefore, they were regarded as potential human pathogens. Although genomic typing by pulsed-field gel electrophoresis revealed a wide variety of distinct restriction patterns, comparison of the 63 animal isolates with 33 fecal O157 VTEC strains previously isolated from humans with the diarrhea-associated form of the hemolytic-uremic syndrome by their phage types and VT genotypes showed a marked similarity between animal and human isolates: 30 (90.9%) of the 33 human isolates appeared to be of E. coli O157 strain types also isolated from cattle and sheep. It was concluded that Dutch cattle and sheep are an important reservoir of E. coli O157 strains that are potentially pathogenic for humans.

Detection of four species of Borrelia burgdorferi sensu lato in Ixodes ricinus ticks collected from roe deer (Capreolus capreolus) in The Netherlands.

Roe deer (Capreolus capreolus) were investigated for their value as sentinel animals for Lyme borreliosis in the Netherlands. Serum was obtained from 114 roe deer, and 513 Ixodes ricinus, predominantly females (72%), were obtained from 47 animals (41%). The polymerase chain reaction was used to detect DNA of Borrelia burgdorferi sensu lato in a total of 190 ticks, comprising 106 engorged ticks and 84 non-engorged ticks. Borrelia DNA was detected in 24 engorged ticks (23%) and 26 non-engorged ticks (31%). This difference was not significant (P = 0.25). Four species of B. burgdorferi sensu lato were identified in the ticks. B. burgdorferi sensu stricto, Borrelia garinii, Borrelia afzelii and group VS116. B. afzelii was most commonly found and present in 13 mixed infections, and in 28 single infections. Fifteen sera (13%) contained antibodies to Borrelia spp. Ticks are more appropriate sentinel animals for Lyme borreliosis than roe deer, an important host for I. ricinus. Although the viability of borrelia spirochaetes in engorged ticks collected from roe deer was not assessed, a bloodmeal taken from roe deer did not eliminate borrelia spirochaetes from the tick. The relevance of this finding for transovarial transmission of borrelia spirochaetes in ticks is discussed.