Waste Point Identification of Frying Oil Based on Gas Chromatography-Ion Mobility Spectrometry (GC-IMS).

This study described the quality detection and rapid identification of frying oil waste points based on gas chromatography-ion mobility spectrometry (GC-IMS). A total of 48 volatile substances were identified, among which the levels of 11 components, including 2-pentylfuran, 2-butylfuran, and 2-hexanone, increased with prolonged frying time after 40 h in cottonseed oil. Conversely, the levels of hexanal, heptanal, and E,E-2,4-heptadienal decreased as frying time extended. Correlation analysis revealed a significant association between volatile substances of the oil and acid value (p < 0.05) and polar components with volatile substances (p < 0.05). Furthermore, significant differences in the types and contents of flavor substances were observed in cottonseed oil at different frying times (including before and after reaching the discard point) (p < 0.05). Subsequently, principal component analysis (PCA) results clearly showed that the cottonseed oil samples at different frying times were well distinguished by the volatile compounds; moreover, discriminant model analysis indicated a model accuracy rate of 100%. These results showed the potential of GC-IMS-based approaches in discriminating the waste points of frying oil.

Performance of grazing cows fed supplements from coproducts of biodiesel industry replacing soybean meal.

The objective of the present study was to evaluate the substitution of soybean meals by biodiesel co-products on the performance and nutrient balance of lactating cows on pasture. Twelve dairy cows (7/8 Holstein-Gir) in early lactation were included in this feeding trial. These animals had an average daily milk yield of 21.1 kg and were distributed in a 4 × 4 triple Latin square experimental design. Protein supplements fed to these lactating cows contained peanut meal, cotton and sunflower as a complete replacement for soybean meal. Nutrient intake and digestibility, milk production, microbial protein synthesis, energy and protein balance were the parameters assessed in this study. Supplements containing different biodiesel co-products did not influence (P > 0.05) the level of forage intake, supplementation and nutrient by lactating cows, except for the total digestible nutrients (TDN) intake which was higher (P ≤ 0.05) in cows supplemented with cottonseed meal. The cotton meal also promoted higher digestibility of TDN (P = 0.001) and total carbohydrates (TCHO; P = 0.001) of the diet and, as a result, higher energy consumption (P = 0.01) and lower negative energy balance (P = 0.01). Cottonseed meal is a co-product of the biodiesel industry that has the ability to replace soybean meal as a source of protein in the supplement without affecting performance and promoting greater energy availability, demonstrating its ability to reduce the effects of negative energy balance in cows at the beginning of lactation kept on tropical pastures.

Effect of increasing dietary inclusion of whole cottonseed on nutrient digestibility and milk production of high-producing dairy cows.

We determined the effects of increasing the dietary inclusion of whole cottonseed (WCS) on nutrient digestibility and the milk production responses of high-producing dairy cows. Twenty-four multiparous Holstein cows (mean ± SD; 52.7 ± 2.63 kg/d milk; 104 ± 23 DIM) were randomly assigned to treatment sequences in a replicated 4 × 4 Latin square design with 21-d periods. Treatments were increasing doses of WCS at 0%, 8%, 16%, and 24% DM, with WCS replacing soybean meal and hulls to maintain similar diet nutrient composition (% DM) of NDF (32%), forage NDF (21%), starch (27%), and CP (17%). Total fatty acid (FA) content of each treatment was 1.70%, 2.96%, 4.20%, and 5.40% DM, respectively. Three preplanned contrasts were used to test the linear, quadratic, and cubic effects of increasing dietary WCS. Increasing dietary WCS from 0% to 24% DM quadratically influenced the intake of DM and NDF, with the highest value being the inclusion of 8% WCS, and intakes of 16- and 18-carbon, and total FA, with maximum values obtained up to 24% WCS. Increasing dietary WCS affected digestibility of DM (cubic) and NDF (quadratic), with the lowest values being the inclusion of 8% WCS. Increasing WCS increased 16-carbon digestibility (quadratic) but decreased digestibility of 18-carbon and total FA (both quadratic), with highest and lowest values for the inclusion of 24% WCS, respectively. Increasing dietary WCS quadratically increased absorbed 16- and 18-carbon, and total FA, with maximum values obtained for 24% WCS. Increasing dietary WCS quadratically increased yields of milk, milk fat, milk protein, milk lactose, 3.5% FCM, and ECM, and linearly increased BW gain. The source of milk FA was affected by dietary WCS, with a quadratic decrease in the yield of de novo and mixed milk FA and a quadratic increase in preformed milk FA. Increasing dietary WCS linearly increased trans-10 C18:1 milk FA content. As dietary WCS increased, plasma insulin linearly decreased, and plasma gossypol levels linearly increased. Despite the decrease in total FA digestibility, increasing dietary WCS from 0% to 24% DM increased FA absorption. Increasing the dietary inclusion of WCS up to 16% DM increased milk production responses and DM intake. Under the current dietary conditions, high-producing dairy cows benefited best from a diet containing an inclusion of 8% to 16% WCS in DM.

Effects of fermented cottonseed meal inclusions on growth performance, serum biochemical parameters and hepatic lipid metabolism of geese during 28-70 d of age.

The aim of this study was to investigate the effects of solid-state fermented cottonseed meal (FCSM) inclusion levels on the growth performance, serum biochemical parameters and hepatic lipid metabolism in geese from 28 to 70 d of age. A total of 288 twenty-eight-d-old male geese were randomly divided into 4 treatments with FCSM levels of 0, 5, 15 and 25% including 0, 22.74, 67.33, 111.27 mg FG/kg diet, respectively. Each treatment contained 6 replicates and 12 birds per replicate. Treatments of FCSM inclusions from 0 to 25% had no effect on growth rate and feed intake in geese during d 28 to 70. The F/G ratio was increased (P < 0.05) in geese fed the diet with 25% FCSM compared with birds fed the diet with 0% FCSM. Treatment with 25% FCSM levels had no effect on the contents of TC, TG, HDL-C, LDL-C, but increased (P < 0.05) AST and ALT activities in serum of geese at d 70. Treatment with 25% FCSM increased the contents of FG, HDL-C, TC, C18:2n6, C20:4n6 and PUFA and decreased (P < 0.05) the contents of NEFA, SFA, MUFA in liver compared with treatment of 0% FCSM inclusion. Additionally, treatment with 25% FCSM decreased (P < 0.05) the PPARα, AMPK, and LXR mRNA expression related to lipid deposition, and increased (P < 0.05) PPARγ and ACC mRNA expression related to lipolysis in liver compared with birds fed the diet with 0% FCSM. Overall, treatment with 0 to 15% FCSM (<=67.33 mg FG/kg diet) had no adverse effects on the growth performance and lipid metabolism of geese. However, treatment fed 25% FCSM (111.27 mg FG/kg diet) decreased feed efficiency and promoted hepatic lipid deposition associated with the alteration of related gene expression in geese at 28 to 70 d of age.

Carcass and meat characteristics of Nellore young bulls fed diet using cottonseed cake as a replacer of the forage fiber source.

The aim of this study was to assess the effects of substituting traditional forage fiber sources with cottonseed cake in the diet on both the quantitative and qualitative characteristics of carcass and meat in Nelore young bulls. Twenty-four Nelore steers starting with an average weight of 377.8 ± 43.5 kg, were individually housed in stalls and provided with individualized feeding over a 112-day confinement period. The study followed a completely randomized design with two treatments and 12 replications. The diets incorporated either whole plant corn silage (WPCS) and, cottonseed cake (CSC) as fiber sources, at a rate of 300 g/kg of dry matter. The CSC diet promoted higher carcass weight. Aging animal meat for seven days significantly decreased the shear force from 83.4 to 71.6 N. Although diets did not influence meat composition, WPCS diet provided higher concentrations of C16:1, C18:1n9c, C18:3n3, and C22:2 acid, and CSC diet higher concentrations of C15:0, C18:1n9t, C18:2n6c, and 20:3n3. The WPCS diet provided higher concentrations of monounsaturated fatty acids and ω9, and the CSC diet had higher concentrations of ω6 and ω6:ω3 ratio in meat. Cottonseed cake used as a fiber source increases the concentration of polyunsaturated fatty acids and ω6 fatty acids in the meat of young bulls finished in feedlot.

An investigation into the influence of fermented cottonseed meal on the productive performance, egg quality, and gut health in laying hens.

The present study investigates the effects of replacing soybean meal (SBM) with either cottonseed meal (CSM) or fermented cottonseed meal (FCSM) on the productive performance, egg quality, blood biochemistry parameters, gut bacterial population, and small intestinal morphology of laying hens. A total of 648 Hy-Line W36 laying hens aged 40 weeks were randomly assigned to 9 treatments, with 6 replicates each and 12 birds per replicate. The feeding trial lasted 12 weeks. The treatments consisted of a control diet based on corn and SBM, as well as 8 experimental diets in which 7.5, 15, 22.5, and 30% of the SBM in the control diet was replaced with either CSM or FCSM. Laying hens fed diets with different levels of FCSM had higher egg production and egg mass than those fed with CSM diets at weeks 46 to 51 (P < 0.05). Diets containing FCSM also significantly improved the feed conversion ratio at weeks 40 to 45 and 46 to 51 (P < 0.05). Eggshell strength was significantly greater in birds fed diets containing FCSM than those fed other dietary treatments at 51 weeks of age (P < 0.05). Hens fed diets containing FCSM had higher calcium and lower cholesterol in serum than those on other diets (P < 0.05). Replacing SBM with FCSM decreased the egg yolk cholesterol content (P < 0.05). Additionally, feeding diets containing different levels of FCSM increased villus height and villus height to crypt depth in the jejunum (P < 0.05). Diets containing FCSM also reduced pH and coliform population in the ileum, and ceca and increased lactic acid bacteria count in the crop and ceca (P < 0.05). Overall, the present data showed that including FCSM in the diet of laying hens can positively affect productive performance compared to CSM. Moreover, substituting SBM with FCSM, can improve eggshell quality, promote gut health, and reduce egg yolk cholesterol concentration.

Multiresponsive luminescent metal-organic framework for cooking oil adulteration detection and gallium(III) sensing.

A new 3D metal-organic framework {[Cd16(tr2btd)10(dcdps)16(H2O)3(EtOH)]∙15DMF}n (MOF 1, tr2btd = 4,7-di(1,2,4-triazol-1-yl)benzo-2,1,3-thiadiazole, H2dcdps = 4,4'-sulfonyldibenzoic acid) was obtained and its luminescent properties were studied. MOF 1 exhibited bright blue-green luminescence with a high quantum yield of 74 % and luminescence quenching response to a toxic natural polyphenol gossypol and luminescence enhancement response to some trivalent metal cations (Fe3+, Cr3+, Al3+ and Ga3+). The limit of gossypol detection was 0.20 µM and the determination was not interfered by the components of the cottonseed oil. The limit of detection of gallium(III) was 1.1 µM. It was demonstrated that MOF 1 may be used for distinguishing between the genuine sunflower oil and oil adulterated by crude cottonseed oil through qualitative luminescent and quantitative visual gossypol determination.

Effects of crude protease produced by Bacillus subtilis (MAFIC Y7) on growth performance, immune indices, and anti-inflammatory responses of broilers fed soybean meal- or cottonseed meal-based diets.

A strain of Bacillus subtilis (MAFIC Y7) was isolated from the intestine of Tibetan pigs and was able to express high protease activity. The aim of this study was to characterize the proteases produced by MAFIC Y7, and to investigate the effects of protease addition on growth performance, ileal amino acid digestibility, and serum immunoglobulin and immune factors of broilers fed SBM-based diets, or on growth performance, carcass characteristics, and intestinal morphology of broilers fed CSM-based diets. B. subtilis (MAFIC Y7) expressed protease showed its optimal enzyme activity at 50 °C and pH 7.0. The coated crude enzyme (CCE) showed greater stability at pH 3.0 than its uncoated counterpart. Experiment 1 was conducted with six diets based on three levels of crude protein (CP)-CPlow, CPmedium, and CPhigh-with or without CCE. In CPlow, CCE increased gain:feed (G:F) (days 1 to 21, days 1 to 42) by 8%, 3%, respectively, and enhanced apparent ileal digestibility (AID) of crude protein and lysine (on day 42) by 8.8%, 4.6%, respectively, compared with diets containing no CCE (P < 0.05). CCE increased G:F from days 1 to 21 from 0.63 to 0.68, improved G:F and average daily gain (ADG) during days 1 to 42, and enhanced AID of crude protein, lysine, cysteine, and isoleucine on day 42 compared with the unsupplemented treatments (in CPmedium, P < 0.05). CCE increased serum IgA (on day 21), serum IgA and IgG and increased serum IL-10 (on day 42), but decreased serum tumor necrosis factor-α (TNF-α; on day 21), and serum IL-8 and TNF-α (on day 42) compared with unsupplemented treatments. At CPhigh, CCE decreased serum levels of IL-6 and TNF-α (on day 21), and IL-8 and TNF-α (on day 42) compared with unsupplemented treatments (in CPhigh, P < 0.05). In experiment 2, CSM-based diets with two lysine-to-protein ratios (5.2% or 5.5%) with or without CCE. In the high Lys diet (5.5% Lys:protein), CCE increased ADG and G:F, increased carcass, but decreased abdominal fat compared with the unsupplemented treatment (P < 0.05). In the 5.2% Lys:protein dietary treatment, CCE improved duodenal villus height compared with the unsupplemented treatment (P < 0.05). Supplementation of protease produced by MAFIC Y7 was associated with lower inflammatory responses in SBM diets (CPmedium or CPhigh) and improved ADG in broilers fed CPmedium or CPhigh. The proteases improved ADG and the efficiency of CSM use when the ratio of Lys to protein was 5.5%.

The aim of this study was to investigate the effects of Bacillus subtilis (MAFIC Y7)-expressed protease on reducing inflammatory responses of soybean meal (SBM) diets and improving the efficiency of cottonseed meal (CSM) in broilers. Experiment 1 was conducted with six dietary treatments based on three levels of crude protein (CP)­CPlow, CPmedium, and CPhigh­without or with proteases (0 or 4,000 U/kg). Supplementation of proteases significantly improved growth performance, gain:feed (G:F), and apparent ileal digestibility of crude protein and amino acids (cysteine, isoleucine, and histidine) in broilers fed CPmedium treatment (P < 0.05). Proteases inhibited inflammatory responses in SBM-based diets by decreasing serum tumor necrosis factor-α (TNF-α) (in CPmedium and CPhigh), and interleukin (IL)-6 (in CPhigh); and IL-8 and TNF-α (in CPmedium and CPhigh) on day 21. In experiment 2, broilers were fed with CSM-based diets with two ratios of lysine-to-protein (5.2% or 5.5%) with or without proteases. Proteases in the diet of 5.5% Lys to protein ratio increased growth performance and G:F compared to diets without proteases (P < 0.05). Proteases produced by MAFIC Y7 improved growth performance and G:F in CPmedium. Supplementation of protease was associated with lower inflammatory responses of broilers fed SBM-based diets (CPmedium or CPhigh) and improved the efficiency of CSM use when the ratio of lysine-to-protein was 5.5%.

Wheat germ meal replaces cottonseed meal at different levels in diets of Ossimi lambs: Impact on growth performance, feed utilization and economic efficiency.

This experiment aimed to evaluate the replacement of cottonseed meal (CSM) with wheat germ meal (WGM) in diets of growing lambs on feed utilization and growth performance. Twenty-eight Ossimi male lambs (38 ± 0.8 kg weight), and 180 ± 5 days were divided randomly into four experimental groups in a complete randomized design for 105 days. Cottonseed meal was replaced with WGM at 0 (WGM0 treatment), 50 (WGM50 treatment), 75 (WGM75 treatment) and 100% (WGM100 treatment). The chemical analysis of the total essential and non-essential amino acids showed an increase at the WGM diet compared to CSM. The replacement of CSM with WGM linearly and quadratically improved (p ˂ 0.05) lambs' growth performance and feed conversion. The WGM50 and WGM100 treatments lowered (p ˂ 0.05) feed intake, without affecting nutrient digestibility or diets' nutritive. Feeding WGM increased (p ˂ 0.05) total protein, albumin, and urea-N concentrations in blood of lambs. The WGM100 treatment showed the highest relative percentage of net revenue compared to the other treatments. It is concluded that the complete replacement of CSM with WGM showed positive effects on lambs' performance and economic efficiency.

Fractionation and Lability of Phosphorus Species in Cottonseed Meal-Derived Biochars as Influenced by Pyrolysis Temperature.

Defatted cottonseed meal (CSM), the residue of cottonseeds after oil extraction, is a major byproduct of the cotton industry. Converting CSM to biochar and utilizing the goods in agricultural and environmental applications may be a value-added, sustainable approach to recycling this byproduct. In this study, raw CSM was transformed into biochar via complete batch slow pyrolysis at 300, 350, 400, 450, 500, 550, and 600 °C. Thermochemical transformation of phosphorus (P) in CSM during pyrolysis was explored. Fractionation, lability, and potential bioavailability of total P (TP) in CSM-derived biochars were evaluated using sequential and batch chemical extraction techniques. The recovery of feed P in biochar was nearly 100% at ≤550 °C and was reduced to <88% at 600 °C. During pyrolysis, the organic P (OP) molecules predominant in CSM were transformed into inorganic P (IP) forms, first to polyphosphates and subsequently to orthophosphates as promoted by a higher pyrolysis temperature. Conversion to biochar greatly reduced the mobility, lability, and bioavailability of TP in CSM. The biochar TP consisted of 9.3-17.9% of readily labile (water-extractable) P, 10.3-24.1% of generally labile (sequentially NaHCO3-extractable) P, 0.5-2.8% of moderately labile (sequentially NaOH-extractable) P, 17.0-53.8% of low labile (sequentially HCl-extractable) P, and 17.8-47.5% of residual (unextractable) P. Mehlich-3 and 1 M HCl were effective batch extraction reagents for estimating the "readily to mid-term" available and the "overall" available P pools of CSM-derived biochars, respectively. The biochar generated at 450 °C exhibited the lowest proportions of readily labile P and residual P compounds, suggesting 450 °C as the optimal pyrolysis temperature to convert CSM to biochar with maximal P bioavailability and minimal runoff risk.

The rumen-derived Lact. mucosae LLK-XR1 exhibited greater free gossypol degradation capacity during solid-state fermentation of cottonseed meal and probiotic potential.

BACKGROUND: This study aimed to isolate the rumen-derived bacteria with the ability to degrade free gossypol (FG), and to evaluate the probiotic potential in vitro for ensuring safe utilization. METHODS: The strains were anaerobically isolated from fresh rumen fluid of sheep with long-term fed cottonseed meal (CSM) with the screening agar medium containing gossypol as the sole carbon source. Afterwards, the isolated strain incubated with CSM was subjected to the determination of the FG degradation and in vitro evaluation of probiotic characteristics. RESULTS: The target strain labeled Lact. mucosae LLK-XR1 [Accession number: OQ652016.1] was obtained, and its growth on MRS Liquid medium exhibited degradation efficiency of FG up to 69.5% which was significantly greater than its growth on Man-Rogosa-Sharpe medium with glucose free for 24 h (p < 0.01). Meanwhile, LLK-XR1 showed 40.652% degradation rate of FG for unautoclaved, non-pulverized, and no additional nutrients supplementation CSM. Furthermore, LLK-XR1 presented good survivability at pH 3.0 (above 88.6%), and 0.3% bile (78.5%). LLK-XR1 showed sensitivity to broad-spectrum antibiotics except Sulfamethoxazole, Ciprofloxacin and Gentamycin and significantly inhibited E. coli CICC 10,899, Staph. aureus CICC 21,600, and Salmonella. Typhimurium CICC 21,483. LLK-XR1 demonstrated good cell surface hydrophobicity and auto-aggregation ability. CONCLUSIONS: Taken together, this study for the first time noted that rumen-originated Lact. mucosae LLK-XR1 with probiotic properties exhibited substantial FG degradation capacity when it was applied to the solid-state fermentation of CSM.

Eight weeks of daily cottonseed oil intake attenuates postprandial angiopoietin-like proteins 3 and 4 responses compared to olive oil in adults with hypercholesterolemia: A secondary analysis of a randomized clinical trial.

Angiopoietin-like proteins (ANGPTLs) -3, -4, and -8 are regulators of lipid metabolism and have been shown to respond to changes in dietary fats. It is unknown how ANGPTLs respond to cottonseed oil (CSO) and olive oil (OO) consumption in a population with hypercholesterolemia. The purpose of this study was to determine the impact of CSO vs. OO consumption on fasting and postprandial ANGPTL responses in adults with hypercholesterolemia. We hypothesized that CSO would have lower fasting and postprandial ANGPTL responses compared with OO. Forty-two adults with high cholesterol completed a single-blind, randomized trial comparing CSO (n = 21) vs. OO (n = 21) diet enrichment. An 8-week partial outpatient feeding intervention provided ∼60% of the volunteers' total energy expenditure (∼30% of total energy expenditure as CSO or OO). The remaining 40% was not controlled. Fasting blood draws were taken at pre-, mid-, and postintervention visits. Volunteers consumed a high saturated fat meal followed by 5 hours of blood draws pre- and postvisits. Fasting ANGPTL3 had a marginally significant treatment by visit interaction (P = .06) showing an increase from pre- to postintervention in CSO vs. OO (CSO: 385.1 ± 27.7 to 440.3 ± 33.9 ng/mL; OO: 468.2 ± 38.3 to 449.2 ± 49.5 ng/mL). Both postprandial ANGPTL3 (P = .02) and ANGPTL4 (P < .01) had treatment by visit interactions suggesting increases from pre- to postintervention in OO vs. CSO with no differences between groups in ANGPTL8. These data show a worsening (increase) of postprandial ANGPTLs after the OO, but not CSO, intervention. This aligns with previously reported data in which postprandial triglycerides were protected from increases compared with OO. ANGPTLs may mediate protective effects of CSO consumption on lipid control. This trial was registered at clinicaltrials.gov (NCT04397055).

Genomic and co-expression network analyses reveal candidate genes for oil accumulation based on an introgression population in Upland cotton (Gossypium hirsutum).

KEY MESSAGE: Integrated QTL mapping and WGCNA condense the potential gene regulatory network involved in oil accumulation. A glycosyl hydrolases gene (GhHSD1) for oil biosynthesis was confirmed in Arabidopsis, which will provide useful knowledge to understand the functional mechanism of oil biosynthesis in cotton. Cotton is an economical source of edible oil for the food industry. The genetic mechanism that regulates oil biosynthesis in cottonseeds is essential for the genetic enhancement of oil content (OC). To explore the functional genomics of OC, this study utilized an interspecific backcross inbred line population to dissect the quantitative trait locus (QTL) interlinked with OC. In total, nine OC QTLs were identified, four of which were novel, and each QTL explained 3.62-34.73% of the phenotypic variation of OC. The comprehensive transcript profiling of developing cottonseeds revealed 3,646 core genes differentially expressed in both inbred parents. Functional enrichment analysis determined 43 genes were annotated with oil biosynthesis processes. Implementation of weighted gene co-expression network analysis showed that 803 differential genes had a significant correlation with the OC phenotype. Further integrated analysis identified seven important genes located in OC QTLs. Of which, the GhHSD1 gene located in stable QTL qOC-Dt3-1 exhibited the highest functional linkages with the other network genes. Phylogenetic analysis showed significant evolutionary differences in the HSD1 sequences between oilseed- and starch- crops. Furthermore, the overexpression of GhHSD1 in Arabidopsis yielded almost 6.78% higher seed oil. This study not only uncovers important genetic loci for oil accumulation in cottonseed, but also provides a set of new candidate genes that potentially influence the oil biosynthesis pathway in cottonseed.

Improvements in markers of inflammation and coagulation potential following a 5-day high-fat diet rich in cottonseed oil vs. Olive oil in healthy males.

Low-grade inflammation is believed to be a risk factor for chronic diseases and is nutritionally responsive. Cottonseed oil (CSO), which is rich in n-6 polyunsaturated fats, has been shown to lower cholesterol and other chronic disease risk factors. The purpose of this secondary analysis was to determine the comparative responses of markers of inflammation and coagulation potential of healthy adult males consuming diets rich in CSO vs. olive oil (OO). METHODS: Fifteen normal-weight males, ages 21.7 ± 2.58y, completed a randomized crossover trial. Each intervention consisted of a 3-day lead-in diet and a 5-day outpatient, controlled feeding intervention (CSO or OO). There was a 2 to 4-week washout period between interventions. The 5-day intervention diets were 35 % carbohydrate, 15 % protein, and 50 % fat, enriched with either CSO or OO (44 % of total energy from oil). At pre- and post- diet intervention visits, a fasting blood draw was collected for analysis of markers of inflammation (Tumor Necrosis Factor Alpha (TNF-α), Interleukin-6 (IL-6), C-Reactive Protein (CRP)) and coagulation potential (Tissue Factor (TF), Plasminogen Activator Inhibitor-1 (PAI-1)). RESULTS: The CSO-enriched diets reduced TNF-α (CSO: -0.12 ± 0.02 pg/ml, OO: -0.01 ± 0.05 pg/ml; p < 0.01) and TF (CSO: -0.59 ± 0.68 pg/ml, OO: 1.13 ± 0.83 pg/ml; p = 0.02) compared to OO diets. There were no differences in IL-6, CRP, or PAI-1 between diets. CONCLUSION: A 5-day, CSO-enriched diet may be sufficient to reduce inflammation and coagulation potential compared to OO-enriched diets in a healthy male population which could have implications in chronic disease prevention.

Nutrient intake, productive and metabolic parameters of Nellore bulls feed a forage free diet using cottonseed cake as a fiber source.

We hypothesized that cottonseed cake in confined Nellore young bulls' diet as fiber source, could maintain or improve the nutrient intake, and productive and metabolic parameters. It was evaluated the total replacement of whole plant corn silage (WPCS) by cottonseed cake (CSC) as a source of fiber in the diet. A completely randomized design with two treatments and 12 replications was used. The treatments were two experimental diets containing 300 g/kg of WPCS or CSC as roughage. All animals at 0, 15, 30, 60 and 112 days were weighed to monitor productive performance and nutrient intake. Dry matter intakes, organic matter, neutral detergent fiber, physically effective neutral detergent fiber, crude protein and non-fiber carbohydrates of the WPCS treatment cattle were higher (p < 0.05), and the ethereal extract intake of cattle fed CSC diet was higher. The BW of cattle fed WPCS was higher in the two initial periods of confinement (p < 0.05). Animals from both treatments showed linear growth during the confinement period. There was a fiber source × period interaction for total weight gain (TWG), average daily gain (ADG) and feed efficiency (FE) (p < 0.05), with the lowest in the first 15 days and the highest at 30 days, reflecting a compensatory gain in animals fed with CSC. Bulls fed with CSC showed negative TWG and ADG in the first period (p < 0.05), but recovered in the following periods, surpassing that of the SC treatment in the last two periods. There was negative EF of bulls fed with CSC in the first period (P < 0.05), but in the following periods the CSC diet did not differ from the WPCS diet. The animals fed CSC diet showed a higher concentration of cholesterol and glucose in the blood plasma (p < 0.05). The forage-free diet containing cottonseed cake as a source of fiber replacing corn silage promoted better animal performance.

Improvement of qualitative and quantitative traits in cotton under normal and stressed environments using genomics and biotechnological tools: A review.

Due to the increasing demand for high-quality and high fiber-yielding cotton (Gossypium spp.), research into the development of stress-resilient cotton cultivars has acquired greater significance. Various biotic and abiotic stressors greatly affect cotton production and productivity, posing challenges to the future of the textile industry. Moreover, the content and quality of cottonseed oil can also potentially be influenced by future environmental conditions. Apart from conventional methods, genetic engineering has emerged as a potential tool to improve cotton fiber quality and productivity. Identification and modification of genome sequences and the expression levels of yield-related genes using genetic engineering approaches have enabled to increase both the quality and yields of cotton fiber and cottonseed oil. Herein, we evaluate the significance and molecular mechanisms associated with the regulation of cotton agronomic traits under both normal and stressful environmental conditions. In addition, the importance of gossypol, a toxic phenolic compound in cottonseed that can limit consumption by animals and humans, is reviewed and discussed.

Growth performance, nutrient digestion, rumen fermentation and blood biochemistry in response to partially replacing cottonseed cake with sesame meal in a lamb feedlot diet.

Recently, it is necessary to formulate high-quality, balanced and low-cost rations for ruminants from nontraditional sources. The present study conducted to investigate the impact of partially replacing corticated cottonseed (CS) cake with sesame meal (SM) in a lamb feedlot diet on growth performance, nutrient digestion, rumen fermentation and blood biochemistry. Fifteen growing lambs with an initial body weight of 27.4 ± 1.2 kg (6-7 months old) were randomly assigned into three equal groups (n = 5). Lambs in control group (CS) fed a basal diet, while 8% and 16% SM were used to replace an equal portion of corticated CS cake in the second (8SM) and third (16SM) groups respectively. Results showed that most parameters of growth performance and nutrient digestibility were significantly improved (p < 0.05) with the partial replacement of SM (8SM and/or 16SM). Regarding ruminal parameters, ruminal pH and total volatile fatty acids concentration increased (p < 0.05), while ammonia level and total protozoa count decreased with the partial replacement of SM. Moreover, blood parameters showed variant responses to SM partial replacement. Total protein increased, and glucose decreased significantly with 16SM, while cholesterol showed a significant decreasing with both SM replacement levels. SM may substitute CS cake in lamb diet without detrimental effects on performance, digestibility and ruminal fermentation.

Effect of feeding increasing levels of whole cottonseed on milk and milk components, milk fatty acid profile, and total-tract digestibility in lactating dairy cows.

Dietary fat is fed to increase energy intake and provide fatty acids (FA) to support milk fat production. Oilseeds contain unsaturated FA that increase the risk for biohydrogenation-induced milk fat depression, but FA in whole cottonseed (WCS) are expected to be slowly released in the rumen and thus have a lower risk for biohydrogenation-induced milk fat depression. Our hypothesis was that increasing dietary WCS would increase milk fat yield by providing additional dietary FA without induction of milk fat depression. Four primiparous and 8 multiparous lactating Holstein cows, 136 ± 35 and 127 ± 4 DIM, respectively, were arranged in a replicated 4 × 4 Latin square design with 21-d periods. Treatments were WCS provided at 0%, 3.4%, 6.8%, and 9.9% of dietary dry matter, and WCS was substituted for cottonseed hulls and soybean meal to maintain dietary fiber and protein. Treatment did not change milk yield. There was a treatment-by-parity interaction for milk fat percent and yield with a quadratic decreased in primiparous cows but no effect of WCS in multiparous cows. Cottonseed linearly increased milk fat trans-10 18:1 in primiparous cows but not in multiparous cows. Increasing WCS increased milk preformed (18C) FA yield and partially overcame the trans-10 18:1 inhibition of de novo FA synthesis in the primiparous cows. Apparent transfer of 18C FA from feed to milk decreased in all cows as WCS increased, but the magnitude of the change was greater in primiparous cows. Increasing WCS decreased total-tract apparent dry matter, organic matter, and neutral detergent fiber digestibility. There was no change in total FA digestibility. However, 18C FA digestibility tended to be decreased in both parities and 16C FA digestibility was quadratically increased in multiparous cows but not changed in primiparous cows. Total fecal flow of intact WCS increased as WCS level increased, but fecal flow of intact seeds as a percentage consumed was similar across treatments. Fecal flow of intact seeds was greater in multiparous cows (4.3% vs. 1.1% of consumed). Plasma concentrations of glucose, nonesterified FA, triglycerides, and insulin were not changed. However, plasma urea-N increased with increasing WCS. Plasma gossypol increased with WCS (0.08-1.15 µg/mL) but was well below expected toxic levels. In conclusion, WCS maintained milk and milk component yield when fed at up to 9.9% of the diet to multiparous cows without concerns of gossypol toxicity, but primiparous cows were more susceptible to biohydrogenation-induced milk fat depression in the current trial. This highlights the interactions of parity with diet composition when feeding rumen-available unsaturated fat to dairy cows.

Cottonseed meal derived porous carbon prepared via the protease pretreatment and reduced activator dosage carbonization for supercapacitor.

The high catalytic activity and specificity of enzymes can be used to pretreat biomass. Herein, the resourceful, reproducible, cheap, and crude protein-rich cottonseed meal (CM) is selected as a precursor and the protease in the K2CO3-KHCO3 buffer solution is used as the enzyme degradation substance to pretreat CM. The crude protein content is significantly reduced by the protease degradation, and, meanwhile, it results in a looser and porous structure of CM. What is more, it significantly reduces the amount of activator. In the subsequent carbonization process, the K2CO3-KHCO3 in the buffer solution is also used as an activating agent (the mass ratio of CM to activator is 2:1), and after carbonization, the O, S, and N doped porous carbon is obtained. The optimized PCM-800-4 exhibits high heteroatom contents and a hierarchical porous structure. The specific capacitance of the prepared porous carbon reaches up to 233 F g-1 in 6M KOH even when 10 mg of active material is loaded. In addition, a K2CO3-KHCO3/EG based gel electrolyte is prepared and the fabricated flexible capacitor exhibits an energy density of 15.6 Wh kg-1 and a wide temperature range (-25 to 100 °C). This study presents a simple enzymatic degradation and reduced activator dosage strategy to prepare a cottonseed meal derived carbon material and looks forward to preparing porous carbon using other biomass.

Hub Genes in Stable QTLs Orchestrate the Accumulation of Cottonseed Oil in Upland Cotton via Catalyzing Key Steps of Lipid-Related Pathways.

Upland cotton is the fifth-largest oil crop in the world, with an average supply of nearly 20% of vegetable oil production. Cottonseed oil is also an ideal alternative raw material to be efficiently converted into biodiesel. However, the improvement in kernel oil content (KOC) of cottonseed has not received sufficient attention from researchers for a long time, due to the fact that the main product of cotton planting is fiber. Previous studies have tagged QTLs and identified individual candidate genes that regulate KOC of cottonseed. The regulatory mechanism of oil metabolism and accumulation of cottonseed are still elusive. In the current study, two high-density genetic maps (HDGMs), which were constructed based on a recombinant inbred line (RIL) population consisting of 231 individuals, were used to identify KOC QTLs. A total of forty-three stable QTLs were detected via these two HDGM strategies. Bioinformatic analysis of all the genes harbored in the marker intervals of the stable QTLs revealed that a total of fifty-one genes were involved in the pathways related to lipid biosynthesis. Functional analysis via coexpression network and RNA-seq revealed that the hub genes in the co-expression network that also catalyze the key steps of fatty acid synthesis, lipid metabolism and oil body formation pathways (ACX4, LACS4, KCR1, and SQD1) could jointly orchestrate oil accumulation in cottonseed. This study will strengthen our understanding of oil metabolism and accumulation in cottonseed and contribute to KOC improvement in cottonseed in the future, enhancing the security and stability of worldwide food supply.