Effect of amino acids on the formation and distribution of volatile aldehydes in high oleic sunflower oil during frying.

This research aims to assess the effect of amino acids as lipid antioxidants in reducing the formation of volatile aldehydes in frying oil. Methionine, histidine, and glycine at concentrations of 2.5, 5, and 10 mM were added to high oleic sunflower oil (HOSO) to investigate their effects on the distribution and formation of saturated, monounsaturated, and polyunsaturated volatile aldehydes. The results showed that the proportion of saturated volatile aldehydes was greater than that of unsaturated ones; Methionine exhibited the best inhibitory effect, after 12 h of frying, 10 mM methionine reduced the content of saturated volatile aldehydes by 24.21 %, monounsaturated by 52.4 %, and polyunsaturated by 54.73 % compared to the control. Methionine's sulfur-containing side chain was also proven to have strong antioxidant activity. Combined with the results of this study, this can also provide insights for using amino acids as lipid antioxidants.

Effect of the dietary supplementation with sunflower oil-enriched bromoform from Asparagopsis taxiformis on lambs' growth, health, and ruminal methane production.

The red seaweed Asparagopsis taxiformis has a potent antimethanogenic effect, which has been proven both in vitro and in vivo. Vegetable oil immersions of this seaweed (hereafter Bromoil) help stabilise the bromoform (CHBr3) responsible for its antimethanogenic effect. We evaluate the effects of increasing the levels of CHBr3 in lamb diets on growth performance, methane (CH4) production, animal health and meat quality. Twenty-four Merino Branco ram lambs were fed a ground complete compound feed, supplemented with 50 mL/kg DM of sunflower oil with different CHBr3 content. The treatments were defined by the CHBr3 doses in the oil: 0 mg (control - B0), 15 mg (B15), 30 mg (B30) and 45 mg (B45) of CHBr3 per kg of feed DM. The feed was prepared daily by mixing Bromoil with the compound feed. At the end of the experiment, the lambs were sacrificed, the ruminal content was collected for in vitro fermentation to evaluate CH4 production and organic matter (OM) degradability, and the rumen mucosa was sampled for histological examination. Meat samples were collected for chemical composition and CHBr3 analysis. The half-life of CHBr3 in the air-exposed feed was 3.98 h making it very difficult to establish the practiced level of CHBr3 supplementation. Lambs-fed treatments B30 and B45 decreased DM intake by up to 28%. Average daily gain was also reduced due to CHBr3 supplementation, with B45 showing results 40% lower than B0. DM feed conversion ratio was similar for all treatments. The degradability of OM, the volume of total gas and of gas without CH4 were unaffected by the experimental treatments, evaluated by the in vitro method. However, the volume of CH4 decreased by up to 75% for treatments above 30 mg/kg DM, while the yield of CH4/g OM degraded was reduced by up to 78% with treatments above 30 mg/kg DM. Meat chemical composition was not affected by Bromoil supplementation and no traces of CHBr3 were found in meat samples. During this experiment, the animals presented normal health and behaviour. However, postslaughter examination of the rumen showed distinct lesions on the ventral region of the rumen mucosa of animals supplemented with Bromoil. These lesions were more severe in the animals receiving treatments B30 and B45. This research determined that although concentrations of CHBr3 in the diet above 30 mg/kg DM helped to reduce CH4 emissions, it negatively affected the performance and rumen wall.

Synthesis of lipophilic vitamin C and evaluation of its antioxidant performance in sunflower seed oil frying.

The present study involved the synthesis and analysis of a lipophilic form of vitamin C, namely tetrabutyryl vitamin C ester (TVCE). TVCE is synthesized by a simple one-step method, combining the advantages of VC and butyric acid. Its antioxidant efficacy on sunflower seed oil frying was evaluated by assessing lipid oxidation parameters including peroxide number (POV), carbonyl number (CV), and paraniline number (pAV). Furthermore, changes in the fatty acid composition of the oil were monitored using techniques such as infrared spectroscopy (IR), nuclear magnetic resonance (NMR), and gas chromatography (GC). The findings demonstrated that lipophilic vitamin C exhibited superior protection against oxidation during frying compared to vitamin E, suggesting that it may be an effective fat-soluble antioxidant. The study provides a new field for the utilization of vitamin C and a new idea for the development of efficient antioxidants.

Stability and Bioaccessibility of Carotenoids from Sea Buckthorn Pomace Encapsulated in Alginate Hydrogel Beads.

Carotenoids, the natural pigments that confer the bright orange color of sea buckthorn berries, are also associated with several health benefits, such as antioxidant activity and skin and eye protection. Due to their lipophilic nature and localization, carotenoids are largely retained in the sea buckthorn pomace (SBP) resulting from juice production. Carotenoids from SBP (70.03 mg/100 g DW), extracted and characterized by HPLC-PDA, contained zeaxanthin (free and esterified) and beta-carotene as major compounds. The SBP carotenoids-enriched sunflower oil was further encapsulated in Ca-alginate hydrogel beads (98.4% encapsulation efficiency) using ionotropic gelation. The hydrogel beads were characterized by confocal laser scanning microscopy and scanning electron microscopy. Fairly good stability (>64%) of the encapsulated carotenoids in the alginate hydrogel beads during storage (30 days, 4 °C and 25 °C) was found, with zeaxanthin esters being the most stable compounds, for all the experimental conditions. The bioaccessibility of the total carotenoids (INFOGEST protocol) was 42.1 ± 4.6% from hydrated, and, respectively, 40.8 ± 4% from dehydrated SBP alginate hydrogel beads. The addition of yogurt to the dehydrated hydrogel beads had a positive effect on the bioaccessibility of free and esterified zeaxanthin, but not on that of the carotenes. In conclusion, SBP is a valuable source of carotenoids which can be protected by encapsulation in alginate hydrogel beads, thus still retaining a good bioaccessibility.

Encapsulation of sunflower and flaxseed oils using Opuntia (Cactaceae) mucilage as a core-shell material through coacervation methods: A study on formulation, characterization, and in vitro digestion.

Sunflower oil (SFO) and Flaxseed oil (FSO) were microencapsulated using simple and complex coacervation techniques with Opuntia (Cactaceae) mucilage (Mu) and with a combination of Mu with chitosan (Chit). The encapsulation efficiency (EE) of SFO and FSO in emulsions using Mu/Chit shells was 96.7% and 97.4%, respectively. Morphological studies indicated successful entrapment of oils in core shells with particle sizes ranging from 1396 ± 42.4 to 399.8 ± 42.3 nm. The thermogravimetric analyses demonstrated enhanced core protection with thermal stability noted for microcapsules regardless of encapsulation method. The stability of the microcapsules, during in vitro digestion was studied. The obtained results revealed that the microcapsules are intact in oral conditions and have a slow release of oil over stomach digestion and rapid release in the small intestine. The results showed that Mu and Mu/Chit coacervates can be used as effective carrier systems to encapsulate sensitive ingredients and functional oils.

Evaluation of the qualitative properties of the oil extracted from the mixture of Helianthus annuus and Nigella sativa seeds during heating.

The oil obtained from black cumin (Nigella sativa) seeds has many health-effective properties, which is used in food applications and in traditional medicine. One practical method to extract its oil is mixing with other seeds such as sunflower (Helianthus anuus) seeds before oil extraction by press. The effectiveness of the cold-press oil obtained from the mixture of black cumin seeds (BS) and sunflower seeds (SF) in different proportions 100:0, 95:5, 90:10, 85:15 and 0:100 (w/w) was studied to evaluate their qualitative properties including peroxide value (PV), acid value, p-anisidine value (AnV), pigments (carotenoid and chlorophyll) content, polyphenols, and profile of fatty acids during heating process (30-150 min at 180 °C). The results revealed that the acid and p-anisidine value of the all samples enhanced with the extension of the heating time, and the peroxide value increased at the beginning of the heating and then decreased with the prolongation of the heating time (p < .05). With the increase of temperature and heating time, the peroxide of sunflower oil increased with a higher slope and speed than that of black seed and blends oil. Changes in the PV and AnV were the fastest in sunflower oil. Blending and heating caused considerable changes in the fatty acid composition of oils, especially myristic, palmitic, and stearic acids. Moreover, the levels of certain unsaturated fatty acids, namely linoleic, oleic, and linolenic acids declined after heating. The carotenoids, chlorophyll and total phenol content decreased gradually during heating treatments. Among extracted oils, SF:BS (15%) had the good potential for stability, with total phenol content of 95.92 (Caffeic acid equivalents/100 g), PV of 2.16 (meq O2/kg), AV of 2.59 (mg KOH/g oil), and AnV of 8.08 after the heating. In conclusion, oil extracted from the mixture of SF and BS can be used as salad and cooking oils with a high content of bioactive components and positive nutritional properties.

The Essential Oils Obtained from (Lonicerae japonicae Flos) Flower Buds Could Affect the Deposition of Sunflower Oil under Common High Temperature Conditions and the Traditional Frying Process in Maye.

The essential oil extracted from the flower buds of Lonicerae japonicae (LJEO) was employed in the high-temperature (65℃) accelerated preservation of sunflower oil. In the present investigation, the addition of the essential oil at a concentration of 800 ppm significantly inhibited the decrease in the oxidative stability of sunflower oil. This positive effect was achieved by significantly hindering the reduction in acidity value (AV), peroxide value (PV), p-anisidine value (AnV), the total oxidation value (TOTOX) (p < 0.01), and the levels of thiobarbituric acid reactive substance (TBARS), the absorbance at 232/268 nm (K232/K268) and total polar compounds (TPC) (p < 0.01). Besides, it also significantly enhances the sensory attributes of Maye, including taste, flavor, and appearance, improving its overall acceptability through the addition of certain potential fragrance molecules (p < 0.01). Furthermore, one of the primary chemical compounds in LJEO, eugenol, has demonstrated significant natural antioxidant properties in the traditional deep-frying procedure for the product, Maye. Consequently, together with eugenol, the essential oil LJEO could be employed as a possible effective antioxidant for the typical long-term preservation and even the traditional deep-frying procedures, and developed as effective antioxidant extracted from plants for the whole food industry.

Bio-Based Polyurethane Networks Containing Sunflower Oil Based Polyols.

This work focused on the preparation and investigation of polyurethane (SO-PU)-containing sunflower oil glycerides. By transesterification of sunflower oil with glycerol, we synthesized a glyceride mixture with an equilibrium composition, which was used as a new diol component in polyurethanes in addition to poly(ε-caprolactone)diol (PCLD2000). The structure of the glyceride mixture was characterized by physicochemical methods, matrix-assisted laser desorption/ionization time-of-flight mass spectrometry (MALDI-TOF MS), nuclear magnetic resonance spectroscopy (NMR), and size exclusion chromatography (SEC) measurements. The synthesis of polyurethanes was performed in two steps: first the prepolymer with the isocyanate end was synthesized, followed by crosslinking with an additional amount of diisocyanate. For the synthesis of the prepolymer, 4,4'-methylene diphenyl diisocyanate (MDI) or 1,6-hexamethylene diisocyanate (HDI) were used as isocyanate components, while the crosslinking was carried out using an additional amount of MDI or HDI. The obtained SO-PU flexible polymer films were characterized by attenuated total reflectance Fourier transform infrared spectroscopy (ATR-FTIR), differential scanning calorimetry (DSC), thermogravimetric analysis (TGA), and scanning electron microscopy (SEM). The so-obtained flexible SO-PU films were proved to be suitable for the preparation of potentially biocompatible and/or biodegradable scaffolds. In addition, the stress versus strain curves for the SO-PU polymers were interpreted in terms of a mechanical model, taking into account the yield and the strain hardening.

Human milk fat substitutes rich in 1,3-dioleoyl-2-palmitoylglycerol and 1-oleoyl-2-palmitoyl-3-linoleoylglycerol simultaneously: Preparation strategy and simulated infant in vitro digestion.

In this study, fractionated palm stearin, oleic acid, and linoleic acid were selected as the base materials to prepare human milk fat substitutes (HMFS) rich in OPO and OPL by enzymatic acidolysis combined with physical blending. Under optimum conditions, contents of OPO, OPL, and sn-2 palmitic acid in the OPO and OPL-rich triacylglycerols (TAGs) were higher than that in commercial OPO-rich TAGs, with values of 37.25%, 28.12%, and 79.44%, respectively. Physical blending the OPO and OPL-rich TAGs (47%), bovine milk fat (18%), sunflower oil (13%), coconut oil (13%), corn oil (8%), and palm oil (1%) can obtain HMFS with a fat composition that like HMF. The fatty acid, sn-2 saturated fatty acid, and TAG contents of HMFS were within the lower and upper limit of HMF. The lipolysis degree of infant formula (IF) with HMFS as fat source is 9.0% higher than that of commercial plant oil-based infant formula (PIF), and 3.4% lower than that of human milk. IF with HMFS as fat source released less saturated free fatty acids and more saturated monoacylglycerols during digestion than that of PIF, which would help improve the IF fat utilization by infants.

Ultrasonic extraction of Inula viscosa: Enhancing antioxidant bioactivity and its application in sunflower oil as an antioxidant.

The objective of this study was to optimize the ultrasound-assisted extraction (UAE) of Inula viscosa, focusing on the extraction yield, total phenolic content (TPC), total flavonoid content (TFC), and antioxidant capacity and to evaluate its antioxidant effect in sunflower oil (SFO) storage. A water-ethanol binary solvent system was applied to extract bioactive components sustainably. Extraction parameters (temperature, time, ethanol concentration, and solvent-to-solid ratio) were optimized using a central composite rotatable design, achieving high accuracy (R2 > 0.974). Optimum conditions were 54 % (v/v) ethanol concentration, 60 °C, 31 min, and a 15 (mL/g) solvent-to-solid ratio resulting in a yield of 24.72 g/g (%), TPC of 489.54 mg gallic acid/g, TFC of 149.81 mg quercetin/g, and IC50 of 18.21 µg/mL. UAE outperformed Soxhlet extraction in yield, bioactive compound composition, and antioxidant capacity. Strong correlations were found between TPC, TFC, and antioxidant capacity, with TFC having a more significant impact. I. viscosa extract was found to be a potent antioxidant and delay the oxidation of SFO during accelerated storage due to peroxide value and oxidative induction time analysis. Microstructural analysis illuminated the structural changes induced by the extraction methods. In conclusion, this study not only optimized UAE of I.viscosa, showing superior efficiency and antioxidant capacity, but also demonstrated the practical application of I.viscosa in enhancing sunflower oil shelf life, thereby providing valuable insights for the field of food engineering and antioxidant research.

Effect of different materials used in the removal of orogastric catheter adhesive on the skin in premature babies in Turkey.

Purpose To compare the effectiveness of sunflower oil and silicone-based spray used to remove medical adhesives from the orogastric catheter in preventing the skin injury of premature infants in the neonatal intensive care unit. METHODS: This randomized controlled experimental study was conducted on premature infants, born between 32 and 36 weeks, hospitalized in the Neonatal Intensive Care Unit located in the city center of the Black Sea region. There were 86 participants in the study; 43 were in the control group (silicone-based spray), and 43 were in the intervention group (sunflower oil). The "Neonatal Skin Condition Score Scale" evaluated premature infants' skin. RESULTS: Mean skin condition score of premature infants for whom silicone-based adhesive remover spray was applied was 3.63 ± 0.78, whereas the mean skin condition score measured three hours later was 3.17 ± 0.37. Mean skin condition score of premature infants for whom sunflower oil was applied as a medical adhesive remover was 3.40 ± 0.62, whereas the mean skin condition score measured three hours later was 3.07 ± 0.25. No statistically significant difference was determined between the mean skin condition scores of premature infants in both groups evaluated immediately after removing the medical adhesive and 3 h there after (p>0.05). CONCLUSIONS: There is no difference between the skin condition of premature infants for whom silicone-based medical adhesive remover spray is used and the skin condition of premature infants for whom sunflower oil is used to remove the orogastric tube adhesive. PRACTICE IMPLICATIONS: Pediatric nurses should use medical supplies suitable for the skin condition of premature infants and should frequently evaluate the baby's skin condition. Since silicone-based adhesive remover sprays have a risk of toxicity by being absorbed by the skin, it is recommended to use herbal, cost-effective, non-toxic products. CLINICAL TRIAL NUMBER: NCT06280326.

Liver phospholipid fatty acid composition in response to chronic high-fat diets.

Liver phospholipid fatty acid composition depends on the dietary lipid intake and the efficiency of hepatic enzymatic activity. Our study aimed to simultaneously investigate the liver phospholipid fatty acid composition in response to chronic linseed, palm, or sunflower oil diets. We used adult female C57/BL6 mice and randomly divided them into control and three groups treated with 25 % dietary oils. Prior to treatment, we analyzed the fatty acid profiles in dietary oils and hepatocytes and, after 100 days, the fatty acid composition in the liver using gas-liquid chromatography. Linseed oil treatment elevated alpha-linolenic, eicosapentaenoic, and docosapentaenoic acids and reduced arachidonic and docosatetraenoic acids, consequently lowering the n-6/n-3 ratio. Palm oil treatment increased linoleic acid and decreased docosahexaenoic acid, contributing to an elevated n-6/n-3 ratio. Sunflower oil treatment elevated total monounsaturated fatty acids by increasing palmitoleic, oleic, and vaccenic acids. The estimated activity of Δ9 desaturase was significantly elevated in the sunflower oil group, while Δ5 desaturase was the highest, and Δ6 desaturase was the lowest after the linseed oil diet. Our findings demonstrate that chronic consumption of linseed, palm, or sunflower oil alters the distribution of liver phospholipid fatty acids differently. Sunflower oil diet elevated total monounsaturated fatty acids, proposing potential benefits for liver tissue health. Considering these outcomes, a substantial recommendation emerges to elevate linseed oil intake, recognized as the principal ALA source, thereby aiding in reducing the n-6/n-3 ratio. Moreover, modifying dietary habits to incorporate specific vegetable oils in daily consumption could substantially enhance overall health.

Investigation of formation of AGEs precursors, hydroxymethylfurfural and malondialdehyde in oleogel added cakes using an in vitro simulated gastrointestinal digestive system.

The baking process has the potential to generate health-risk compounds, including products from lipid oxidation and Maillard reaction. Pre- and post-digestion levels of hydroxymethylfurfural (HMF), malondialdehyde (MDA), glyoxal (GO), and methylglyoxal (MGO) were studied in cakes formulated with hazelnut and sunflower oil, along with their oleogels as margarine substitutes. The concentration of HMF in oil and oleogel-formulated cakes increased after digestion compared to cakes formulated with margarine. The MDA values were between 82 and 120 µg/100 g in oil and oleogel formulated cakes before digestion and a decrease was observed after digestion. The substitution of margarine with oil and oleogels resulted in the production of high amounts of GO and MGO in cakes. However, the highest bioaccessibility as 318.2% was found in cakes formulated by margarine for GO. Oleogels may not pose a potential health benefit compared to margarines due to the formation of HMF, MDA, GO, and MGO.

In-situ enzyme-initiated production of hexanal from sunflower oil and its release from double emulsion electrospun bio-active membranes.

The aim of the presented study was to evaluate the release of the enzymatically initiated production of hexanal from double emulsion electrospun bio-active membranes at a temperature of fruit storage. Among different formulations of water-in-oil (W1/O) primary emulsions, the emulsion composed of 12% w/v Tween20 and 0.1 M NaCl in water (W1) and 6% of poly(glycerol) poly(ricinoleate) dissolved in sunflower oil (O) using W1/O ratio of 80/20 (w/w) (Tween20-NaCl/6% PGPR) was selected, for further incorporation of enzymes, based on the lowest average droplet size (391.0 ± 15.6 nm), low polydispersity index (0.255 ± 0.07), and good gravitational stability also after 14 days. Both enzymes, lipase and lipoxygenase are needed to produce hexanal (up to 58 mg/L). Additionally, double emulsions were prepared with sufficient conductivity and viscosity using different W1/O to W2 ratios for electrospinning. From the selected electrospun membrane, up to 4.5 mg/L of hexanal was released even after 92 days.

Biophysical studies of modified PVC sheet based on sunflower oil for antistatic and blood bags applications.

In this work, the surface of polyvinyl chloride PVC sheet was modified by blending it with sunflower seed oil SSO to obtain PVC sheet/SSO films of ratios 100/0, 90/10, 80/20, 70/30, 60/40, and 50/50 (v/v)% using the solution casting method. Various techniques were used to characterize the prepared films, besides the use of hemolysis assays and blood clot formation tests. FTIR spectra revealed that there was a good interaction between the PVC sheet and the oil. The dielectric measurement indicated that SSO addition enhanced the dielectric properties of the sheet. The study of dielectric relaxation times confirmed the interaction between SSO and the sheet. DC conductivity increased to 6 × 10-6 S/m, so it could be applied in antistatic applications. Also, SSO addition increased the value of the thermal stability. According to SEM micrographs, the film was roughened at a ratio of 60/40 and smoothed out at 50/50. This behavior was confirmed with roughness and contact angle measurement results, in which the film of ratio 60/40 had the highest value equal to (72.03°) and then decreased at 50/50 to (59.62°). These results were confirmed by XRD measurement as the crystallinity increased at the film ratio of 60/40 and decreased again at 50/50. Also, the ratio of 60/40 demonstrated a large decrease in thrombus weights along with a slight increase in hemolysis, which is within the acceptable range and has a high degree of biocompatibility, so this concentration is recommended to be used in blood bags applications.

Long-term Supplementation of Deep-fried Oil Consumption Impairs Oxidative Stress, Colon Histology and Increases Neurodegeneration.

BACKGROUND: Sesame oil and sunflower oil are popular cooking oils in southern India. Deep-frying is a frequent method of food preparation. Deep-frying at high temperatures has been linked with several disorders, including cancer, diabetes, and unknown metabolic problems. There have been no long-term investigations on the influence of deep-fried oils on PUFA metabolism and pathogenesis. As a result, the current study aimed to explore the effect of deep-fried frying oil on Wistar rats by continuous treatment. Furthermore, the pathophysiology of MSG-induced neurotoxicity in Wistar rats was investigated. METHODS: Wistar rats weighing 200-260 g were used in this study. Female rats were divided into five groups fed with (1) standard chow (control group), (2) unheated sesame oil (UHSO) along with standard chow, and (3) reheated sesame oil (RHSO) along with standard chow, (4) unheated sunflower oil (UHSFO) along with standard chow, and (5) reheated sunflower oil (RHSFO) along with standard chow and continued up to F1 generation. Furthermore, F1 male rats were treated with MSG of 2 g/kg body weight for 10 alternative days and were sacrificed for major tissues. RESULTS: We found that rats treated with RHSO and RHSFO showed increased body weight. Deep-fried oil-fed rats (RHSO and RHSFO) showed a significant increase in total cholesterol- 100 mg/dl, LDL- 23 mg/dl, & TAG-100 mg/dl, when compared to unheated oil rats. Liver function tests revealed that AST and ALT levels were significantly elevated in RHSO and RHSFO when compared to unheated oils and the control group. Inflammatory markers revealed that Hs-CRP (0.35 mg/dl) and LDH levels (6000 U/L) were significantly elevated in RHSO and RHSFO when compared to the unheated oils and control group. RT-PCR results showed significant elevation in the antioxidant genes SOD (twofold) and GPX (3-fold) when compared to UHSO and UHSFO groups. Liver and colon histology showed significant damage in the cell structure of RHSO and RHSFO-treated rats. Further, rats treated with unheated oils and MSG showed statistically significantly higher mRNA expression of neuroplasticity genes CREB, BDNF and reduced NMDA levels (UHSO, UHSFO) when compared to reheated oil groups (RHSO & RHSFO). Proinflammatory marker TNF-α expression was significantly elevated in RHSFO-treated rats when compared to control. Brain histology showed focal damage in glial cell degeneration in rats treated with RHSO and RHSFO when compared to other groups. CONCLUSION: The results from the present study proved that continuous supplementation deep-fried reheated oil consumption increased serum TGL and oxidative stress markers. Impaired liver metabolism and the involvement of the gut-liver-brain axis increased the risk of neurodegeneration.

Systematic screening for the biocatalytic hydration of fatty acids from different oily substrates by Elizabethkingia meningoseptica oleate hydratase through a Design-of-experiments approach.

The edible plant oils production is associated with the release of different types of by-products. The latter represent cheap and available substrates to produce valuable compounds, such as flavours and fragrances, biologically active compounds and bio-based polymers. Elizabethkingia meningoseptica Oleate hydratases (Em_OhyA) can selectively catalyze the conversion of unsaturated fatty acids, specifically oleic acid, into hydroxy fatty acids, which find different industrial applications. In this study, Design-of-experiment (DoE) strategy was used to screen and identify conditions for reaching high yields in the reaction carried out by Escherichia coli whole-cell carrying the recombinant enzyme Em_OhyA using Waste Cooking Oils (WCO)-derived free fatty acids (FFA) as substrate. The identified reaction conditions for high oleic acid conversion were also tested on untreated triglycerides-containing substrates, such as pomace oil, sunflower oil, olive oil and oil mill wastewater (OMW), combining the triglyceride hydrolysis by the lipase from Candida rugosa and the E. coli whole-cell containing Em_OhyA for the production of hydroxy fatty acids. When WCO, sunflower oil and OMW were used as substrate, the one-pot bioconversion led to an increase of oleic acid conversion compared to the standard reaction. This work highlights the efficiency of the DoE approach to screen and identify conditions for an enzymatic reaction for the production of industrially-relevant products.

Unveiling the formation capacity of multicomponent oleogels: Performance of lecithin interacting with monostearate derivatives.

Oleogels have been explored as fat substitutes due to their healthier composition compared to trans and saturated fats, also presenting interesting technological perspectives. The aim of this study was to investigate the compositional perspective of multicomponent oleogels. Structuring ability of lecithin (LEC) (20 or 90 wt% of phosphatidylcholine - PC) combined with glycerol monostearate (GMS), sorbitan monostearate (SMS) or sucrose monostearate (SAC) in sunflower oil was evaluated from oleogels properties. The thermal and rheological properties, microstructure and stability of the oleogels were affected by the difference in the chemical composition of LEC and the ratio between LEC and different surfactants. Interestingly, low-phosphatidylcholine LEC (L20) performed better, although systems formed with reduced amounts of LEC tended to be softer (LEC-GMS) and present high oil holding capacity (LEC-SMS). The mixtures of LEC and monostearate-based surfactants showed different behaviors, depending on the surfactant polar head. In LEC-GMS systems, LEC hindered the self-assembly of GMS in sunflower oil, compromising mechanical properties and increasing oil release. When combined with SMS, LEC acted as a crystal habit modifier of SMS, forming a more homogeneous microstructure and producing stronger oleogels with greater oil binding capacity. However, above the threshold concentration, LEC prevented SMS self-assembly, resulting in a weaker gel. A positive interaction was found in LEC-SAC formulations in specific ratios, since SAC cannot act as a single oleogelator. Results show the impact of solubility balance played by LEC and fatty-acid derivatives surfactant when combined and used as oleogelators. This knowledge can contribute to a rational perspective in the preparation and modulation of the properties of edible oleogels.

Comprehensive analysis of oxidative stability and nutritional values of germinated linseed and sunflower seed oil.

Germination of seeds is known to affect the nutritional composition of cold-pressed oils. This study focused on the effects of germination on the antioxidants and oxidative stability of linseed and sunflower seed oil. As hypothesized, germination led to increased antioxidant activities and tocopherol, chlorophyll and carotenoid content. Analysis revealed a 37.2 ± 3.5-fold and 11.6 ± 1.5-fold increase in polyphenol content in linseed and sunflower seed oil from germinated seeds, respectively. Using LC-HRMS/MS, profiles with up to 69 polyphenolic substances were identified in germinated seed oils for the first time. Germination promoted lipid hydrolysis, as evidenced by NMR, with overall significant decreases in triacylglycerol content leading to increased diacylglycerol and free fatty acid values. Rancimat measurements predicted a 4.10 ± 0.52-fold longer shelf-life for germinated linseed oil. This study successfully demonstrated the potential of germination to develop PUFA-rich oils with enhanced antioxidant capacity and oxidative stability.

Performance of ß-carotene-loaded nanostructured lipid carriers under dynamic in vitro digestion system: Influence of the emulsifier type.

A better understanding of how emulsifier type could differently influence the behavior of nanostructured lipid carriers (NLC) under the gastrointestinal digestion process, as well as at the cellular level, is of utmost importance for the NLC-based formulations' optimization and risk assessment in the food field. In this study, NLC composed by fully hydrogenated soybean and high-oleic sunflower oils were prepared using soy lecithin (NLC Lß) or Tween 80 (NLC Tß) as an emulsifier. ß-Carotene was entrapped within NLC developed as a promising strategy to overcome ß-carotene's low bioavailability and stability. The effect of emulsifier type on the digestibility of ß-carotene-loaded NLC was evaluated using an in vitro dynamic digestion model mimicking peristalsis motion. The influence of ß-carotene-loaded NLC on cell viability was assessed using Caco-2 cells in vitro. NLC Tß remained stable in the gastric compartment, presenting particle size (PS) similar to the initial NLC (PS: 245.68 and 218.18 nm, respectively), while NLC Lß showed lower stability (PS > 1000 nm) in stomach and duodenum phases. NLC Tß also provided high ß-carotene protection and delivery capacity (i.e., ß-carotene bioaccessibility increased 10-fold). Based on the results of digestion studies, NLC Tß has shown better physical stability during the passage through the in vitro dynamic gastrointestinal system than NLC Lß. Moreover, the developed NLC did not compromise cell viability up to 25 µg/mL of ß-carotene. Thus, the NLC developed proved to be a biocompatible structure and able to incorporate and protect ß-carotene for further food applications. PRACTICAL APPLICATION: The findings of this study hold significant implications for industrial applications in terms of developing nanostructured lipid carriers from natural raw materials widely available and used to produce other lipid-based products in the food industry, as an alternative to synthetic ones. In this respect, the ß-carotene-loaded NLC developed in this study would find a great industrial application in the food industry, which is in constant search to develop functional foods capable of increasing the bioavailability of bioactive compounds.