ABSTRACT
BACKGROUND AND OBJECTIVES: Our previous report showed that parvovirus B19 genotype 1 in different solutions derived from plasma preparations showed different heat-sensitivity patterns during liquid-heating. In this study, we similarly examined B19 genotype 2. MATERIALS AND METHODS: Two plasma samples one containing B19 genotype 1 and the other genotype 2 DNA were used. Four process samples collected immediately before the heat treatment step in the manufacture of albumin, immunoglobulin, haptoglobin and antithrombin preparations were spiked with B19 and subsequently treated at 60°C for 10 h. A low pH immunoglobulin solution was also spiked with B19 and treated at room temperature for 14 days. Infectivity was then measured. RESULTS: B19 genotype 2, similar to genotype 1, showed three patterns of inactivation: (i) a rapid inactivation in the albumin and immunoglobulin preparations, (ii) a slow inactivation in the haptoglobin preparation and (iii) only limited inactivation in the antithrombin preparation. Its sensitivity in the low pH immunoglobulin solutions also resembled that of genotype 1. CONCLUSION: Both genotypes 1 and 2 of B19 varied in sensitivity to liquid-heating and low pH among different plasma preparations.
Subject(s)
Blood Safety/methods , Parvovirus B19, Human/physiology , Plasma/virology , Virus Inactivation , Cloning, Molecular , Electrophoresis, Polyacrylamide Gel , Genotype , Heating , Hot Temperature , Humans , Immunoglobulins, Intravenous/pharmacology , Microscopy, Electron , Parvovirus B19, Human/drug effects , Parvovirus B19, Human/geneticsABSTRACT
BACKGROUND AND OBJECTIVE: To investigate the physico-chemical properties of hepatitis E virus (HEV) with regard to inactivation/removal, we have studied four isolates with respect to sensitivity to heat during liquid/dry-heating as well as removal by nanofiltration. MATERIALS AND METHODS: Hepatitis E virus in an albumin solution or phosphate-buffered saline (PBS) was liquid-heated at 60 degrees C for a preset time. HEV in a freeze-dried fibrinogen containing stabilizers was also dry-heated at 60 or 80 degrees C for a preset time. In addition, to clarify the removal of HEV, the purified virus in PBS was filtered using several types of virus-removal filter (nanofilters) that have different pore sizes. HEV infectivity or genome equivalents before and after the treatments were assayed by a semiquantitative cell-based infectivity assay or quantitative polymerase chain reaction assay, respectively. RESULTS: Hepatitis E virus isolates in albumin solutions were inactivated slowly at 60 degrees C for 5 h and the resultant log reduction factor (LRF) was from 1.0 to > or = 2.2, whereas the virus in PBS was inactivated quickly to below the detection limit and the LRF was > or = 2.4 to > or = 3.7. The virus in a freeze dried fibrinogen containing trisodium citrate dihydrate and l-arginine hydrochloride as stabilizers was inactivated slowly and the LRF was 2.0 and 3.0, respectively, of the 72 h at 60 degrees C, but inactivated to below the detection limit within 24 h at 80 degrees C with an LRF of > or = 4.0. The virus in PBS was also confirmed as to be approximately 35 nm in diameter by nanofiltration. These results are useful for evaluating viral safety against HEV contamination in blood products. CONCLUSION: The sensitivity of HEV to heat was shown to vary greatly depending on the heating conditions. On the other hand, the HEV particles were completely removed using 20-nm nanofilters. However, each inactivation/removal step should be carefully evaluated with respect to the HEV inactivation/removal capacity, which may be influenced by processing conditions such as the stabilizers used for blood products.
