Technological variables influencing the growth and stability of a silage inoculant based on spray-dried lactic acid bacteria.

AIMS: To investigate the influence of different culture media and fermentation conditions on growth performance and viability of three lactic acid bacteria (LAB) strains with potential as silage inoculants, and to optimize spray-drying in order to enhance survival to dehydration and storage stability. METHODS AND RESULTS: In house-formulated MRS was a suitable low-cost culture medium for Lactobacillus plantarum Hv75, Pediococcus acidilactici 3903 and L. buchneri B463. Uncontrolled pH biomass production conferred enhanced stability during storage at 4°C after spray-drying. The use of whey protein concentrate 35 (WPC)-maltodextrin (M) as matrix, inlet temperature of 145-150°C and air flow rate of 601 l h-1 was adequate for the production of dehydrated LAB. According to the desirability function, at this optimized condition, moisture content, yield and solubility were predicted to be 3·96, 73·68 and 90·36% respectively. Those conditions also showed a decrease of 0·855 log CFU per gram after drying, no loss in viability at 4°C for 6 months and 1 log CFU per gram reduction at 25°C. CONCLUSIONS: Stable and economically feasible dehydrated LAB cultures were obtained using alternative culture media, fermentation under uncontrolled pH and optimizing spray-drying process conditions through the desirability function method. SIGNIFICANCE AND IMPACT OF THE STUDY: Our results can be utilized for efficient production and commercialization of several dry LAB.

A meta-analysis on the effectiveness of homofermentative and heterofermentative lactic acid bacteria for corn silage.

AIMS: This meta-analysis aims to assess the effect of lactic acid bacteria (LAB) inoculation on fermentation parameters, microbiological composition and aerobic stability of corn silage. METHODS AND RESULTS: Databases (PubMed, ScienceDirect and Scopus) were searched from 1980 to 2017. The criteria for inclusion were: randomized and controlled experiments using corn silage and published in peer-reviewed journals. The meta-analysis showed that LAB supplementation increased pH, acetate and propionate concentrations, and decreased acid detergent fibre, water-soluble carbohydrates and ammoniacal nitrogen (NH3 -N) compared to controls in the pooled raw mean difference random effect model. In addition, inoculation reduced counts of yeasts and moulds, increased LAB counts and markedly improved aerobic stability in corn silage. However, results indicated that the effect of inoculants may differ depending on the administration of homofermentative or heterofermentative LAB. CONCLUSIONS: For the development of functional bacterial inoculants, both types of LAB should be used. SIGNIFICANCE AND IMPACT OF THE STUDY: To our knowledge, this is the first meta-analysis to compare the application of homofermentative and heterofermentative LAB for corn silage.

Impact of lyophilized Lactobacillus salivarius DSPV 001P administration on growth performance, microbial translocation, and gastrointestinal microbiota of broilers reared under low ambient temperature.

This study was undertaken with the aim of investigating the effects of dietary supplementation of probiotic strain Lactobacillus salivarius DSPV 001P on growth performance, microbial translocation, and gastrointestinal microbiota of broilers reared under low ambient temperature. Two hundred and forty, one-day-old male Cobb broilers were randomly distributed into two treatment groups, a probiotic group and a control group, with four replicates per treatment and 30 broilers per replicate. The temperature of the broiler house was maintained at 18-22°C during the first three weeks, after which the temperature was at range of 8°C to 12°C. The results showed that probiotic treatment significantly improved body weight of broilers when compared with the control group. After 42days, the weight means were 2905±365.4g and 2724±427.0g, respectively. Although there were no significant differences, dietary inclusion of L. salivarius tended to increase feed intake and to reduce feed conversion ratio during the six-week experimental period. Similarly, supplementation tended to reduce the rate of mortality, with 12 deaths occurring in the probiotic group, and 20 in the control group. However, no differences were observed in intestinal bacterial concentrations of Enterobacteriaceae, E.coli, and lactic acid bacteria in both crop and caecum among treatments. Through our study, it appears that L. salivarius DSPV 001P was non-pathogenic, safe and beneficial to broilers, which implies that it could be a promising feed additive, thus enhancing the growth performance of broilers and improving their health.

Quantification of FITC-labelled probiotic Lactobacillus salivarius DSPV 001P during gastrointestinal transit in broilers.

The knowledge related to the fate of probiotics in the complex environment of the intestinal microbiota in broilers is just beginning to be elucidated; however, it is not yet well understood. A good method to investigate the mechanisms by which probiotics mediate their effects is to mark probiotic bacteria and trace them. The aim of this research was to develop a new method to estimate in vivo fluorescein isothiocyanate (FITC)-labelled Lactobacillus salivarius DSPV 001P counts during passage through the gastrointestinal tract (GIT) of broilers. Forty-five, 1 d old Cobb broilers were used in this trial. Programmed necropsies were performed 30 min, 6 h, and 12 h after the administration of the probiotic bacterium, and samples of liver, crop, duodenum, caecum, and bursa of fabricius were collected. To determine the spatial and temporal transit of L. salivarius DSPV 001P in broilers, the number of bacteria as well as its respective fluorescent signal produced by FITC were measured. In order to observe the relationship between the variables, a logistic regression analysis was applied. The amount of fluorescence could be used as an indicator of fluorescent probiotic bacteria in the crop and duodenum 30 min after probiotic bacterium supplementation. In addition, the fluorescent signal could be used to estimate bacterial counts in caecum 6 and 12 h after L. salivarius DSPV 001P administration. To the best of our knowledge, this research is the first in vivo trial to employ the bacterial FITC-labelling technique in order to enumerate probiotic bacteria during gastrointestinal transit in broilers.

Poultry blood from slaughterhouses: development of a biopreservation system to improve microbiological quality prior to transforming blood into by-products.

The aim of this study was to investigate the use of indigenous lactic acid bacteria (LAB) with specific additives as a Biopreservation System (BS) for poultry blood during its storage in slaughterhouses. The BS consisted of two LAB (Enterococcus faecalis DSPV 008SA or Lactobacillus salivarius DSPV 032SA) with 4 additives (lactose 2 g/l, yeast extract 0.4 g/l, ammonium citrate 0.4 g/l and NaCl 1 g/l). After 24 h storage at 30ºC, lower counts of enterobacteria, coliforms, Pseudomonas spp. and Staphylococcus aureus were evident in blood treated with the BS than in untreated blood. The ability of LAB to prevent haemolysis was evident. A decrease in pH was associated with control of spoilage microorganisms but it needed to be regulated to prevent coagulation of proteins. On the basis of these results it is recommended to supplement blood with a BS to avoid undesirable changes during blood storage before processing.

Probiotic effect on calves infected with Salmonella Dublin: haematological parameters and serum biochemical profile.

The aim of this study was to evaluate the effect of a probiotic/lactose inoculum on haematological and immunological parameters and renal and hepatic biochemical profiles before and during a Salmonella Dublin DSPV 595T challenge in young calves. Twenty eight calves, divided into a control and probiotic group were used. The probiotic group was supplemented with 100 g lactose/calf/d and 1010 cfu/calf/d of each strain of a probiotic inoculum composed of Lactobacillus casei DSPV318T, Lactobacillus salivarius DSPV315T and Pediococcus acidilactici DSPV006T throughout the experiment. The pathogen was administered on day 11 of the experiment, at an oral dose of 109 cfu/animal (LD50). Aspartate aminotransferase (AST), gamma glutamyl transpeptidase (GGT), urea, red blood cells, haemoglobin, haematocrit, mean cell haemoglobin (MCH), mean corpuscular volume, mean corpuscular haemoglobin concentration (MCHC), white blood cells, lymphocytes, neutrophils, band neutrophils, monocytes, eosinophils, basophils and the neutrophils/lymphocytes ratio were measured on days 1, 10, 20 and 27 of the experiment. In addition, animals were necropsied to evaluate immunoglobulin A (IgA) production in the jejunal mucosa. The most significant differences caused by the administration of the inoculum/lactose were found during the acute phase of Salmonella challenge (9 days after challenge), when a difference between groups in neutrophils/lymphocytes ratio were detected. These results suggest that the probiotic/lactose inoculum administration increases the calf's ability to respond to the disease increasing the systemic immune response specific. No differences were found in haemoglobin, haematocrit, MCH, MCHC, AST, urea, GGT, band neutrophils, eosinophils, monocytes and IgA in the jejunum between the two groups of calves under the experimental conditions of this study. Further studies must be conducted to evaluate different probiotic/pathogens doses and different sampling times, to achieve a greater understanding of the effects of this inoculum on intestinal infections in young calves and of its mechanism of action.

Quantitative Risk Assessment of Human Trichinellosis Caused by Consumption of Pork Meat Sausages in Argentina.

In Argentina, there are three known species of genus Trichinella; however, Trichinella spiralis is most commonly associated with domestic pigs and it is recognized as the main cause of human trichinellosis by the consumption of products made with raw or insufficiently cooked pork meat. In some areas of Argentina, this disease is endemic and it is thus necessary to develop a more effective programme of prevention and control. Here, we developed a quantitative risk assessment of human trichinellosis following pork meat sausage consumption, which may be used to identify the stages with greater impact on the probability of acquiring the disease. The quantitative model was designed to describe the conditions in which the meat is produced, processed, transported, stored, sold and consumed in Argentina. The model predicted a risk of human trichinellosis of 4.88 × 10(-6) and an estimated annual number of trichinellosis cases of 109. The risk of human trichinellosis was sensitive to the number of Trichinella larvae that effectively survived the storage period (r = 0.89), the average probability of infection (PPinf ) (r = 0.44) and the storage time (Storage) (r = 0.08). This model allowed assessing the impact of different factors influencing the risk of acquiring trichinellosis. The model may thus help to select possible strategies to reduce the risk in the chain of by-products of pork production.

Probiotics and broiler growth performance: a meta-analysis of randomised controlled trials.

1. The aim of this meta-analysis was to investigate the effects of probiotics on the growth performance of broilers. PubMed, Scopus and Scholar Google databases were searched in all languages from 1980 to 2012. The studies in the meta-analysis were only selected if they were randomised and controlled experiments using broilers without apparent disease and the results were published in peer-reviewed journals. 2. A total of 48 and 46 studies were included to assess probiotic effects on body weight gain (BWG) and feed efficiency (FE), respectively. Probiotics increased BWG compared to controls (SMD = 0.661, 95% CI 0.499 to 0.822) and improved FE (SMD = - 0.281, 95% CI -0.404 to -0.157) in the pooled standardised mean difference random effect model, considering the source of heterogeneity and publication biases. However, there are evidences of publication bias and heterogeneity, so the results of this meta-analysis should be considered with caution. Applying the Duval and Tweedie's trim-and-fill methods, the adjusted value for BWG was 0.0594 (95% CI -0.122 to 0.242), and the adjusted value for FE did not show any modifications. 3. The meta-analysis showed that application of probiotics via water resulted in greater BGW and FE than administration through the feed. The effect was not related to the use of mono-strain or multi-strain probiotics, although it may depend on the strain used. The number of broilers and the duration of the experiments had an impact on the outcomes. 4. Additional studies should be conducted with the aim to identify the covariates which can explain the differences in the estimated effect sizes.