Inactivation of dried cells and biofilms of Listeria monocytogenes by exposure to blue light at different wavelengths and the influence of surface materials.

Antimicrobial blue light (aBL) in the 400-470 nm wavelength range has been reported to kill multiple bacteria. This study assessed its potential for mitigating an important foodborne pathogen, Listeria monocytogenes (Lm), focusing on surface decontamination. Three wavelengths were tested, with gallic acid as a photosensitizing agent (Ps), against dried cells obtained from bacterial suspensions, and biofilms on stainless-steel (SS) coupons. Following aBL exposure, standard microbiological analysis of inoculated coupons was conducted to measure viability. Statistical analysis of variance was performed. Confocal laser scanning microscopy was used to observe the biofilm structures. Within 16 h of exposure at 405 nm, viable Lm dried cells and biofilms were reduced by approx. 3 log CFU/cm2 with doses of 2,672 J/cm2. Application of Ps resulted in an additional 1 log CFU/cm2 at 668 J/cm2, but its effect was not consistent. The highest dose (960 J/cm2) at 420 nm reduced viable counts on the biofilms by 1.9 log CFU/cm2. At 460 nm, after 800 J/cm2, biofilm counts were reduced by 1.6 log CFU/cm2. The effect of material composition on Lm viability was also investigated. Irradiation at 405 nm (668 J/cm2) of cells dried on polystyrene resulted in one of the largest viability reductions (4.0 log CFU/cm2), followed by high-density polyethylene (3.5 log CFU/cm2). Increasing the dose to 4,008 J/cm2 from 405 nm (24 h), improved its efficacy only on SS and polyvinyl chloride. Biofilm micrographs displayed a decrease in biofilm biomass due to the removal of biofilm portions from the surface and a shift from live to dead cells suggesting damage to biofilm cell membranes. These results suggest that aBL is a potential intervention to treat Lm contamination on typical material surfaces used in food production.IMPORTANCECurrent cleaning and sanitation programs are often not capable of controlling pathogen biofilms on equipment surfaces, which transmit the bacteria to ready-to-eat foods. The presence of native plant microbiota and organic matter can protect pathogenic bacteria by reducing the efficacy of sanitizers as well as promoting biofilm formation. Post-operation washing and sanitizing of produce contact surfaces might not be adequate in eliminating the presence of pathogens and commensal bacteria. The use of a dynamic and harmless light technology during downtime and close of operation could serve as a useful tool in preventing biofilm formation and persistence. Antimicrobial blue light (aBL) technology has been explored for hospital disinfection with very promising results, but its application to control foodborne pathogens remains relatively limited. The use of aBL could be a complementary strategy to inactivate surfaces in restaurant or supermarket deli settings.

Prevention of surface colonization and anti-biofilm effect of selected phytochemicals against Listeria innocua strain.

This work aimed to determine the ability of Listeria innocua (L.i.) to colonize eight materials found in food-processing and packaging settings and to evaluate the viability of the sessile cells. We also selected four commonly used phytochemicals (trans-cinnamaldehyde, eugenol, citronellol, and terpineol) to examine and compare their efficacies against L.i. on each surface. Biofilms were also deciphered in chamber slides using confocal laser scanning microscopy to learn more about how phytochemicals affect L.i. The materials tested were silicone rubber (Si), polyurethane (PU), polypropylene (PP), polytetrafluoroethylene (PTFE), stainless steel 316 L (SS), copper (Cu), polyethylene terephthalate (PET), and borosilicate glass (GL). L.i. colonized Si and SS abundantly, followed by PU, PP, Cu, PET, GL, and PTFE surfaces. The live/dead status ranged from 65/35% for Si to 20/80% for Cu, and the estimates of cells unable to grow on Cu were the highest, reaching even 43%. Cu was also characterized by the highest degree of hydrophobicity (ΔGTOT = -81.5 mJ/m2). Eventually, it was less prone to attachment, as we could not recover L.i. after treatments with control or phytochemical solutions. The PTFE surface demonstrated the least total cell densities and fewer live cells (31%) as compared to Si (65%) or SS (nearly 60%). It also scored high in hydrophobicity degree (ΔGTOT = -68.9 mJ/m2) and efficacy of phytochemical treatments (on average, biofilms were reduced by 2.1 log10 CFU/cm2). Thus, the hydrophobicity of surface materials plays a role in cell viability, biofilm formation, and then biofilm control and could be the prevailing parameter when designing preventive measures and interventions. As for phytochemical comparison, trans-cinnamaldehyde displayed greater efficacies, with the highest reductions seen on PET and Si (4.6 and 4.0 log10 CFU/cm2). The biofilms in chamber slides exposed to trans-cinnamaldehyde revealed the disrupted organization to a greater extent than other molecules. This may help establish better interventions via proper phytochemical selection for incorporation in environment-friendly disinfection approaches.

SARS-CoV-2 remains infectious for at least a month on artificially-contaminated frozen berries.

The potential transmission of SARS-CoV-2 via food has been controversial since the beginning of the COVID-19 pandemic. To investigate these concerns, reliable detection methods and data on virus die-off rates in various foods are needed. Here, an FDA-standard method for the detection of enteric viruses' RNA from soft fruits was modified for the recovery of infectious SARS-CoV-2. Then, the survival of SARS-CoV-2 on berries was investigated as well as the effectiveness of washing virus-contaminated berries with water. The modified method did not significantly reduced log infectivity titers of recovered viruses, but berries did. The detection limit of the method for infectious SARS-CoV-2 was ∼2.97 log TCID50/g of berries. On SARS-CoV-2-inoculated berries that were stored at 4 °C for 7 days, significant reductions in SARS-CoV-2 infectivity were observed over time. In contrast, on frozen berries, infectious SARS-CoV-2 was recovered for 28 days without significant reductions. Washing SARS-CoV-2-inoculated berries with water removed >90% of infectious viruses within 10 min; however, infectious viruses were detected in wash water. Therefore, on fresh berries infectious viruses are markedly inactivated over time and can be largely removed by washing with water. However, the prolonged survival of SARS-CoV-2 on frozen berries suggests that the virus can potentially spread through frozen fruits.

Thermal Death Kinetics of Three Representative Salmonella enterica Strains in Toasted Oats Cereal.

Several reports have indicated that the thermal tolerance of Salmonella at low-water activity increases significantly, but information on the impact of diverse food matrices is still scarce. The goal of this research was to determine the kinetic parameters (decimal reduction time, D; time required for the first decimal reduction, δ) of thermal resistance of Salmonella in a previously cooked low water activity food. Commercial toasted oats cereal (TOC) was used as the food model, with or without sucrose (25%) addition. TOC samples were inoculated with 108 CFU/mL of a single strain of one of three Salmonella serovars (Agona, Tennessee, Typhimurium). TOC samples were ground and equilibrated to aw values of 0.11, 0.33 and 0.53, respectively. Ground TOC was heated at temperatures between 65 °C and 105 °C and viable counts were determined over time (depending on the temperature for up to 6 h). Death kinetic parameters were determined using linear and Weibull regression models. More than 70% of Weibull's adjusted regression coefficients (Radj2) and only 38% of the linear model's Radj2 had values greater than 0.8. For all serovars, both D and δ values increased consistently at a 0.11 aw compared to 0.33 and 0.53. At 0.33 aw, the δ values for Typhimurium, Tennessee and Agona were 0.55, 1.01 and 2.87, respectively, at 85 °C, but these values increased to 65, 105 and 64 min, respectively, at 0.11 aw. At 100 °C, δ values were 0.9, 5.5 and 2.3 min, respectively, at 0.11 aw. The addition of sucrose resulted in a consistent reduction of eight out of nine δ values determined at 0.11 aw at 85, 95 and 100 °C, but this trend was not consistent at 0.33 and 0.53 aw. The Z values (increase of temperature required to decrease δ-value one log) were determined with modified δ values for a fixed ß (a fitting parameter that describes the shape of the curve), and ranged between 8.9 °C and 13.4 °C; they were not influenced by aw, strain or sugar content. These findings indicated that in TOC, high thermal tolerance was consistent among serovars and thermal tolerance was inversely dependent on aw.

Heat Inactivation of Listeria monocytogenes on Pecans, Macadamia Nuts, and Sunflower Seeds.

This project was undertaken to determine the kinetic parameters of thermal inactivation of Listeria monocytogenes on pecans, macadamia nuts, and sunflower seeds subjected to heat treatments simulating industry processes. Five strains were grown in nonselective medium, mixed, and resuspended before inoculating macadamia nuts, pecans, and sunflower seeds (6 to 9 Log CFU/g). Redried inoculated pecans and macadamia nuts were heated in an oven at a temperature range of 90 to 140°C. Unshelled sunflower seeds were heated in sunflower seed oil. The thermal inactivation was determined by measuring viable cell counts using standard microbiological methods. Average count data were fit to the log-linear model, and thermal-death kinetics were calculated. On pecans, the viable Listeria counts were reduced by 3 and 3.5 Log CFU/g after 40 min at 110°C and 8 min at 140°C, respectively. On macadamia nuts, the L. monocytogenes population was reduced by 5 Log CFU/g after 20 min at 120°C. Unshelled sunflower seeds were subjected to heat treatment via a hot-oil bath. On sunflower seeds, >7 Log CFU/g reductions were observed after 15 min at 120°C. The thermal resistance (D value) for inactivation on pecans at 140°C was 3.1 min and on macadamia nuts at 120°C was 4.4 min. The inactivation of L. monocytogenes was influenced by the kind of nut or seed. These results suggest that L. monocytogenes has a relatively high thermal tolerance. The findings from this study will contribute to the assessment of the effectiveness of heat treatment for control of this pathogen on nuts and seeds. IMPORTANCE Listeria monocytogenes is a major concern for the food industry in ready-to-eat (RTE) foods. In recent years, large-scale recalls have occurred with contaminated sunflower seeds and macadamia nuts that triggered product withdrawals. These events stress the importance of understanding Listeria's ability to survive heat treatments in these low-water activity foods. Nuts and seeds are subjected to a variety of thermal treatments typically referred as roasting. To date, no listeriosis outbreak has been linked to nuts and seeds, but the recent recognition that this pathogen can be detected in commercial products stresses the need for research on thermal treatments. The characterization of heat inactivation kinetics at temperatures typically used during roasting processes will be very beneficial for validation studies. This manuscript reports inactivation rates of L. monocytogenes strains inoculated onto macadamia nuts, sunflower seeds, and pecan halves subjected to temperatures between 90 and 140°C.

Characterization of Binary Biofilms of Listeria monocytogenes and Lactobacillus and Their Response to Chlorine Treatment.

In nature, Listeria may interact competitively and cooperatively with other organisms, resulting in unique spatial organization and functions for cells within the community. This study was undertaken to characterize the biofilm architecture of binary biofilms of Listeria monocytogenes and Lactobacillus species and to assess their effect on the survival of Listeria during exposure to hypochlorite. Three L. monocytogenes strains, ATCC 19115 (Lm5), ATCC 19117 (Lm7), and Coleslaw (LmC), were selected and combined individually with three Lactobacillus strains: L. fermentum (Lf), L. bavaricus (Lb), and L. plantarum (Lp). In binary Lm-Lp biofilms, the Lm cell counts were similar to single-species biofilms (8.5 log CFU/well), and the Lp cell numbers declined by 1.0 log CFU/well. In the presence of Lb, the Lm cell counts were reduced by 1.5 log CFU/well (p < 0.05), whereas the Lf cell counts increased at least by 3.5 log CFU/well. Confocal laser scanning microscopy (CLSM) determined that interspecies interactions significantly affected the spatial organization of three binary biofilms. Biofilm surface-to-volume ratio increased from 0.8 µm2/µm3 for Lm5 in the monoculture to 2.1 µm2/µm3 for Lm5-Lp in the dual-species model (p < 0.05), and was characterized by a thicker structure with a largely increased surface area. Biofilm roughness increased from 0.2 for Lm7 to 1.0 for Lm7-Lb biofilms (p < 0.05), which appeared as interspecific segregation. Biofilm thickness increased from 34.2 µm for LmC to 46.3 µm for LmC-Lf (p < 0.05), which produced flat and compact structures that covered the entire surface available. The biomass of the extracellular matrix was higher in the case of some binary biofilms (p < 0.05); however, this effect was dependent upon the species pair. When treated with hypochlorite, Lm5 in binary biofilms had an approximately 1.5 log CFU/well greater survival than individually. The unique spatial organization and greater protein production may explain the protective effect of Lp after hypochlorite exposure.

Selection and application of natural antimicrobials to control Clostridium perfringens in sous-vide chicken breasts inhibition of C. perfringens in sous-vide chicken.

Current consumer preferences for both clean label food ingredients and convenience-based foods has provided a unique opportunity to explore the application of novel natural food preservatives in sous vide products. The anaerobic environment and relatively low thermal processing of the sous vide process creates a favorable environment for the survival, germination, and outgrowth of spore-forming bacterium Clostridium perfringens. The aim of this study was to identify effective novel natural ingredient formulations against C. perfringens and apply them within a vacuum-sealed sous vide chicken model exposed to abusive storage and chilling conditions. Among six commercial vinegar-based formulations, liquid vinegar with citrus extract (CE; 1.0%) and with lemon juice concentrate (LJC; 1.5%) were identified as the most effective at inhibiting three individual C. perfringens strains. Both reduced viable cell counts by 5 log CFU/mL (P < 0.05), whereas reductions in spore counts ranged from 2 to 4 log CFU/mL depending on formulation and concentration used. Once incorporated to chicken meat 1.0% CE and 1.5% LJC before sous-vide cooking, completely inhibited the growth of mixed C. perfringens strains (P < 0.05) during storage for 16 days at 12 and 16 °C. Exponential cooling from 54 to 4 °C was performed for 18 h to imitate abusive storage conditions. CE and LJC at 3.0% inhibited growth and reduced counts by 3.4 and 2.9 log CFU/g compared to respective controls. Treatments CE and LJC could be implemented within the formulation of a sous vide chicken product to provide an effective protection against C. perfringens meeting clean label expectations.

Critical Food Safety Issues Facing the Food Industry: A Delphi Analysis.

ABSTRACT: The topic of food safety continues to receive increased attention and has ramifications on various human, environmental, policy, and economic levels worldwide. By garnering feedback from 30 food industry experts, this study was undertaken to identify the most critical issues facing the food industry in relation to food safety. According to expert opinion and after three rounds of Delphi inquiry, food contamination detection, outbreaks, and prevention along with governmental oversight, education for and communication with consumers and employees, and globalization were identified as the main areas at the forefront of food safety. Delphi and constant comparative research methods are explained, and suggestions on how to make meaning from the results to progress in this area are discussed.

Salmonella enterica and Escherichia coli in Wheat Flour: Detection and Serotyping by a Quasimetagenomic Approach Assisted by Magnetic Capture, Multiple-Displacement Amplification, and Real-Time Sequencing.

Food safety is a new area for novel applications of metagenomics analysis, which not only can detect and subtype foodborne pathogens in a single workflow but may also produce additional information with in-depth analysis capabilities. In this study, we applied a quasimetagenomic approach by combining short-term enrichment, immunomagnetic separation (IMS), multiple-displacement amplification (MDA), and nanopore sequencing real-time analysis for simultaneous detection of Salmonella and Escherichia coli in wheat flour. Tryptic soy broth was selected for the 12-h enrichment of samples at 42°C. Enrichments were subjected to IMS using beads capable of capturing both Salmonella and E. coli MDA was performed on harvested beads, and amplified DNA fragments were subjected to DNA library preparation for sequencing. Sequencing was performed on a portable device with real-time basecalling adaptability, and resulting sequences were subjected to two parallel pipelines for further analysis. After 1 h of sequencing, the quasimetagenomic approach could detect all targets inoculated at approximately 1 CFU/g flour to the species level. Discriminatory power was determined by simultaneous detection of dual inoculums of Salmonella and E. coli, absence of detection in control samples, and consistency in microbial flora composition of the same flour samples over several rounds of experiments. The total turnaround time for detection was approximately 20 h. Longer sequencing for up to 15 h enabled serotyping for many of the samples with more than 99% genome coverage, which could be subjected to other appropriate genetic analysis pipelines in less than a total of 36 h.IMPORTANCE Enterohemorrhagic Escherichia coli (EHEC) and Salmonella are of serious concern in low-moisture foods, including wheat flour and its related products, causing illnesses, outbreaks, and recalls. The development of advanced detection methods based on molecular principles of analysis is essential to incorporate into interventions intended to reduce the risk from these pathogens. In this work, a quasimetagenomic method based on real-time sequencing analysis and assisted by magnetic capture and DNA amplification was developed. This protocol is capable of detecting multiple Salmonella and/or E. coli organisms in the sample within less than a day, and it can also generate sufficient whole-genome sequences of the target organisms suitable for subsequent bioinformatics analysis. Multiplex detection and identification were accomplished in less than 20 h and additional whole-genome analyses of different nature were attained within 36 h, in contrast to the several days required in previous sequencing pipelines.

Evaluation of single and combined antimicrobial treatments to inhibit Salmonella in queso fresco.

Hispanic style soft non-fermented cheeses, such as queso fresco (QF) have been linked to outbreaks and recalls. Salmonella is one of the main causes of these incidents. Due to lack of ripening or post-processing antimicrobial treatments, incorporating GRAS antimicrobials to production process may be a suitable approach to minimize microbial risk in QF. The aim of this study was to evaluate the efficiency of nisin (N), caprylic acid (CA) and trans-cinnamaldehyde (CN) as single or combined treatments to reduce Salmonella populations in QF during storage. Batches of QF were inoculated after curding with approx. 4 Log CFU/g of 5-strain cocktails of Salmonella and stored at 8 °C for 20 days. The final Salmonella counts in control samples ranged from 6.96 to 7.14 Log CFU/g. Application of CN at 0.6 g/kg inhibited Salmonella growth during storage, resulting in at least 3 Log CFU/g difference with the untreated controls (p < 0.05). Addition of N (0.5 g/kg) and CA (0.4 g/kg) with CN (0.3 and 0.6 g/kg) further enhanced the antimicrobial activity resulting in complete suppression of growth and even caused a 1 Log CFU/g reduction by the end of the experimental period compared to initial counts. Samples treated with the combined treatment (N, CA, CN) were evaluated in a consumer panel (n = 112). Participants preferred the control and commercial QF to the treated samples. However, treated samples with 0.3 g/kg CN were still within the acceptable range of neutral to like slightly. Results obtained, revealed that combined treatment of N, CA and CN can provide a solution to reduce the count of Salmonella in QF, whether in process or during storage.

Assessment of Pediococcus acidilactici ATCC 8042 as potential Salmonella surrogate for thermal treatments of toasted oats cereal and peanut butter.

The control of Salmonella in low water activity foods poses a challenge for the food industry because of its thermal resistance. The use of surrogate bacteria in a food plant is considered a critical component to validate processing steps. The objective of this study was to evaluate the use of Pediococcus acidilactici ATCC 8042, a generally recognized as safe bacterium (GRAS), as potential surrogate for Salmonella in commercial toasted oats cereal (TOC) and peanut butter. P. acidilactici was compared to a five-serovar cocktail of Salmonella and Enterococcus faecium NRRL-B2354, separately. Cultures were inoculated into TOC and thermal kinetic parameters (δ, ß) were determined at 80, 85, 90, and 95 °C using the Weibull model. In peanut butter, δ and ß parameters were obtained at 63, 68, 73, and 77 °C. In TOC, the δ values (initial decimal reduction time) of P. acidilactici were 63 and 7 min at 80 and 95 °C, respectively, and at all four temperatures they were not significantly different from δ values of E. faecium. The δ value of Salmonella at 80 °C (139 min) was two-fold greater than the other two bacteria's values (p < 0.05). In peanut butter, δ values of P. acidilactici ranged from 31 min at 63 °C to 2.6 min at 77 °C, and at all temperatures they were not significantly different from E. faecium's δ values. In peanut butter, all Salmonella cocktail's δ values were significantly smaller than P. acidilactici's with values of 2 min at 63 °C and 0.4 min at 77 °C. These results indicated that P. acidilactici was as heat tolerant as E. faecium in these food matrices. However, the thermal inactivation kinetic parameters suggested that P. acidilactici can only be considered a Salmonella surrogate in TOC at temperatures above 85 °C. Because of its greater thermal tolerance in peanut butter, P. acidilactici may be used as Salmonella surrogate if an additional safety factor is recommended.

Salmonella and Enterohemorrhagic Escherichia coli Serogroups O45, O121, O145 in Wheat Flour: Effects of Long-Term Storage and Thermal Treatments.

Salmonella and enterohemorrhagic Escherichia coli (EHEC) are of serious concern in wheat flour and its related products but little is known on their survival and thermal death kinetics. This study was undertaken to determine their long-term viability and thermal inactivation kinetics in flour. Inoculation was performed using mixtures of EHEC serogroups O45, O121, O145 and Salmonella followed by storage at room temperature (23°C) or 35°C (for Salmonella). Plate counting on tryptic soy agar (TSA) and enrichment were used to assess long-term survival. For thermal studies, wheat flour samples were heated at 55, 60, 65, and 70°C and cell counts of EHEC and Salmonella were determined by plating. The δ-values were calculated using the Weibull model. At room temperature, EHEC serovars and Salmonella were quantifiable for 84 and 112 days, and were detectable for the duration of the experiment after 168 and 365 days, respectively. The δ-values were 2.0, 5.54, and 9.3 days, for EHEC O121, O45, and O145, respectively, and 9.7 days for Salmonella. However, the only significant difference among all values was the δ-value for Salmonella and serogroup O121 (p ≤ 0.05). At 35°C, Salmonella counts declined to unquantifiable levels after a week and were not detected upon enrichment after 98 days. Heat treatment of inoculated wheat flour at 55, 60, 65, and 70°C resulted in δ-value ranges of 20.0-42.9, 4.9-10.0, 2.4-3.2, and 0.2-1.6 min, respectively, for EHEC. The δ-values for Salmonella at those temperatures were 152.2, 40.8, 17.9, and 17.4 min, respectively. The δ-values obtained for Salmonella at each temperature were significantly longer than for EHEC (p ≤ 0.05). Weibull model was a good fit to describe the thermal death kinetics of Salmonella and EHEC O45, O121 and O145 in wheat flour. HIGHLIGHTS -EHEC and Salmonella can survive for extended periods of time in wheat flour.-Long-term storage inactivation curves of EHEC and Salmonella were similar.-EHEC was more sensitive to heat than Salmonella.-Weibull model was a good fit to describe thermal death kinetics of EHEC and Salmonella.-Flour storage at 35°C may be a feasible method for microbial reduction.

Room Temperature Growth of Salmonella enterica Serovar Saintpaul in Fresh Mexican Salsa.

Salsa-associated outbreaks, including the large multistate outbreak in the United States in 2008 caused by jalapeño and serrano peppers contaminated with Salmonella Saintpaul, have raised concerns about salsa as a potential vehicle for transmission. Despite these events, there has been relatively limited research on the potential growth of pathogenic bacteria in salsa. The aim of this study was to characterize the survival and growth of Salmonella, including the outbreak strain of Salmonella Saintpaul (E2003001236), in freshly made salsa and its main ingredients. Chopped tomatoes, jalapeño peppers, cilantro, and onions were tested individually or mixed according to different salsa recipes. Samples were inoculated with five Salmonella serotypes at 3 log CFU/g: Saintpaul (various strains), Typhimurium, Montevideo, Newport, or Enteritidis. Samples were then stored at room temperature (23°C) for up to 12 h or 3 days. The Salmonella Saintpaul levels reached approximately 9 log CFU/g after 2 days in tomato, jalapeño pepper, and cilantro. Growth was slower in onions, reaching 6 log CFU/g by day 3. Salsa recipes, with or without lime juice, supported the growth of Salmonella Saintpaul, and final levels were approximately 7 log CFU/g after 3 days at 23°C. In contrast, the counts of Salmonella Typhimurium, Salmonella Montevideo, Salmonella Newport, and Salmonella Enteritidis increased only 2 log CFU/g after 3 days in any of the salsas. Other Salmonella Saintpaul strains were able to grow in salsas containing 10% lime juice, but their final levels were less than 5 log CFU/g. These findings indicate the enhanced ability of the Salmonella Saintpaul outbreak strain to grow in salsa compared with other Salmonella strains. Recipe modifications including but not limited to adding lime juice (at least 10%) and keeping fresh salsa at room temperature for less than 12 h before consumption are strategies that can help mitigate the growth of Salmonella in salsa.

Prevalence and Molecular Characteristics of Clostridium difficile in Retail Meats, Food-Producing and Companion Animals, and Humans in Minnesota.

Community-associated Clostridium difficile infection (CA-CDI) now accounts for approximately 50% of CDI cases in central Minnesota; animals and meat products are potential sources. From November 2011 to July 2013, we cultured retail meat products and fecal samples from food-producing and companion animals in central Minnesota for C. difficile by using standard methods. The resulting 51 C. difficile isolates, plus 30 archived local veterinary C. difficile isolates and 208 human CA-CDI case isolates from central Minnesota (from 2012) from the Minnesota Department of Health, were characterized molecularly, and source groups were compared using discriminant analysis. C. difficile was recovered from 0 (0%) of 342 retail meat samples and 51 (9%) of 559 animal fecal samples. Overall, the 81 animal source isolates and 208 human source isolates were highly diverse genetically. Molecular traits segregated extensively in relation to animal versus human origin. Discriminant analysis classified 95% of isolates correctly by source group; only five (2.5%) human source isolates were classified as animal source. These data do not support meat products or food-producing and companion animals as important sources of CA-CDI in the central Minnesota study region.

iTRAQ-Based Global Proteomic Analysis of Salmonella enterica Serovar Typhimurium in Response to Desiccation, Low Water Activity, and Thermal Treatment.

In this study, the changes in the global proteome of Salmonella in response to desiccation and thermal treatment were investigated by using an iTRAQ multiplex technique. A Salmonella enterica serovar Typhimurium strain was dried, equilibrated at high (1.0) and low (0.11) water activity (aw), and thermally treated at 75°C. The proteomes were characterized after every treatment. The proteomes of the different treatments differed in the expression of 175 proteins. On the basis of their proteomic expression profiles, the samples were clustered into two major groups, namely, "dry" samples and "moist" samples. The groups had different levels of proteins involved in DNA synthesis and transcription and in metabolic reactions, indicating that cells under either of the aw conditions need to strictly control energy metabolism, the rate of replication, and protein synthesis. The proteins with higher expression levels in moist samples were flagellar proteins (FlgEFGH), membrane proteins, and export systems (SecF, SecD, the Bam complex), as well as stress response proteins, suggesting that rehydration can trigger stress responses in moist cells. Dry samples had higher levels of ribosomal proteins, indicating that ribosomal proteins might be important for additional regulation of the cellular response, even when the synthesis of proteins is slowed down. At both aws, no differences in protein expression were observed between the thermally treated samples and the nonheated cells. In conclusion, our study indicates that the preadaptation to a dry condition was linked to increased thermal tolerance, while reversion from a dry state to a moist state induced a significant change in protein expression, possibly linked to the observed loss of thermal tolerance.IMPORTANCESalmonella enterica is able to survive in dry environments for very long periods. While it is well known that the initial exposure to desiccation is fundamental to trigger thermal tolerance in this organism, the specific physiological and molecular processes involved in this cross-protection phenomenon have not been fully characterized. Several studies have focused on the low-aw transcriptome of this pathogen when inoculated in different food matrices or on abiotic surfaces, but proteomic analyses have not been reported in the literature. Our study investigated the changes in proteomic expression in Salmonella enterica serovar Typhimurium during desiccation, exposure to low aw, and thermal treatment. A better knowledge of the systems involved in the response to desiccation and thermal tolerance, as well as a better understanding of their interplay, is fundamental to identify the most effective combination of interventions to prevent Salmonella's contamination of foods.

Long-Term Survival and Thermal Death Kinetics of Enterohemorrhagic Escherichia coli Serogroups O26, O103, O111, and O157 in Wheat Flour.

Wheat flour has been associated with outbreaks of enterohemorrhagic Escherichia coli (EHEC), but little is known on EHEC's survival during storage and thermal processing. The objective of this study was to determine long-term viability and thermal inactivation kinetics of EHEC serogroups O26, O103, O111, and O157. Wheat flour samples were inoculated with a cocktail of five strains of a single serogroup and stored at 23 and 35°C. Inoculated samples were heated at 55, 60, 65, and 70°C. Viability was determined by plate counting. Decimal reduction time (D) and first decimal reduction time (δ) values were calculated with log-linear and Weibull models, respectively. At 23°C, EHEC counts declined gradually for 84 days and samples tested positive from 84 to 280 days. The thermal resistance (D and δ) values ranged from 7.5 to 8.2 and 3.1 to 5.3 days, respectively, but there were no significant differences among serogroups (P ≤ 0.05). At 35°C, no EHEC was quantifiable by day 7 and no positive samples were detected after 49 days. Heating at 55 and 65°C resulted in δ-value ranges of 15.6 to 39.7 min and 3.0 to 3.9 min, respectively, with no significant difference among serogroups either. Z values were 12.6, 6.7, 10.2, and 13.4°C for O26, O103, O111, and O157, respectively. Thermal death kinetics of EHEC in flour were better described using the Weibull model. Survival and inactivation rates of four serogroups were remarkably similar. These findings indicated that all EHEC serovars tested remained viable for at least 9 months at room temperature and survived for up to 60 min at 70°C in wheat flour.IMPORTANCE Enterohemorrhagic Escherichia coli (EHEC) and Salmonella have recently caused several gastroenteritis outbreaks and recalls of wheat flour. Because EHEC can cause illness with very low doses and there is very scarce information regarding their ability to survive storage and heating in flour, the present study was undertaken to assess the long-term survival of EHEC serogroups O26, O103, O111, and O157 in flour. These findings are relevant, as we report that EHEC can survive for more than 9 months in wheat flour during storage. In addition, results obtained suggest that thermal inactivation at 65°C for 30 min or 2 months of storage at 35°C may be feasible strategies to mitigate the risk of most EHEC serovars in wheat flour.

General response of Salmonella enterica serovar Typhimurium to desiccation: A new role for the virulence factors sopD and sseD in survival.

Salmonella can survive for long periods under extreme desiccation conditions. This stress tolerance poses a risk for food safety, but relatively little is known about the molecular and cellular regulation of this adaptation mechanism. To determine the genetic components involved in Salmonella's cellular response to desiccation, we performed a global transcriptomic analysis comparing S. enterica serovar Typhimurium cells equilibrated to low water activity (aw 0.11) and cells equilibrated to high water activity (aw 1.0). The analysis revealed that 719 genes were differentially regulated between the two conditions, of which 290 genes were up-regulated at aw 0.11. Most of these genes were involved in metabolic pathways, transporter regulation, DNA replication/repair, transcription and translation, and, more importantly, virulence genes. Among these, we decided to focus on the role of sopD and sseD. Deletion mutants were created and their ability to survive desiccation and exposure to aw 0.11 was compared to the wild-type strain and to an E. coli O157:H7 strain. The sopD and sseD mutants exhibited significant cell viability reductions of 2.5 and 1.3 Log (CFU/g), respectively, compared to the wild-type after desiccation for 4 days on glass beads. Additional viability differences of the mutants were observed after exposure to aw 0.11 for 7 days. E. coli O157:H7 lost viability similarly to the mutants. Scanning electron microscopy showed that both mutants displayed a different morphology compared to the wild-type and differences in production of the extracellular matrix under the same conditions. These findings suggested that sopD and sseD are required for Salmonella's survival during desiccation.

Factors influencing the Salmonella internalization into seedpods and whole plants of Arachis hypogaea (L.).

Here we investigated whether Salmonella enterica serovar Typhimurium ATCC 14028 was capable of internalizing in peanut seedpods and plants when exposed to inoculated soil and the edaphic factors that influenced uptake. Intact dry Virginia (DV) and fresh green Virginia (GV) seedpods were exposed to soil containing 6.5 Log (CFU/g) Salmonella under different soil moisture conditions. Internalization of S. Typhimurium into peanut plants germinated in inoculated soil was also examined with and without Bradyrhizobium (Arachis) sp.NC92. Salmonella counts recovered from GV seedpods were on average of 2.0 Log (CFU/pod) less than those recovered from DV seedpods. The internalization in DV pods was only observed at soil water content of 15% or greater in a loamy sand soil. S. Typhimurium was detected inside peanut plant tissues during most testing times. Cells were recovered from stem samples (3.5 Log CFU/g) at greater levels than it was observed for root (2.6 Log CFU/g) and leaf (1.7 Log CFU/g) samples. Overall, recovery of Salmonella from stem, root, and leaf samples were lower when B. NC92 was inoculated on seeds before sowing, but this trend was not significant. Our observations suggest possible routes of contamination of Salmonella into peanut products from soil.

Antimicrobial treatments to control Listeria monocytogenes in queso fresco.

Queso fresco, is a Hispanic non-fermented cheese highly susceptible to contamination with L. monocytogenes. This research was aimed to determine the effect of GRAS antimicrobial ingredients to control L. monocytogenes. Antimicrobials included caprylic acid (CA), Nisaplin® (N, 2.5% nisin), a mixture of sodium lactate and sodium diacetate (SL/SD), Lactococcus lactis sbp. lactis DPC 3147, monolaurin, and lactic acid (LA). Batches of queso fresco curds were inoculated with 104 CFU/g and stored at 4 °C for three weeks. During storage the count of L. monocytogenes reached 7 to 8 Log CFU/g in control samples. Most individual antimicrobial treatments resulted in less than 1 Log CFU/g reductions in final counts, with the exception of N (0.5 g/kg) and CA (2.9 g/kg) that caused more than 3 and 5 Log CFU/g differences with controls, respectively. Mixtures of ingredients were more effective in inhibiting L. monocytogenes growth, and treatments with N and CA consistently delivered 6 Log CFU/g less counts than controls. Supplementation of 12 g/kg LA to treatments with SL/SD (3%/0.22%) caused differences of more than 4 Log CFU/g in final Listeria populations. Samples treated with the binary mixtures of N and CA (0.5 and 0.7 g/kg, respectively) were evaluated in a consumer panel (n = 67). Panelists slightly preferred control and commercial over treated samples, but all samples were in average rated between "slightly liking" and "moderately liking." These experiments indicated that combined use of antimicrobial ingredients may be an effective way to control the population of Listeria monocytogenes in queso fresco.

Validation of good agricultural practices (GAP) on Minnesota vegetable farms.

The United States Food and Drug Administration and the Department of Agriculture jointly published the "Guide to Minimize Microbial Food Safety Hazards for Fresh Fruits and Vegetables," which is used as a basis for Good Agricultural Practices (GAP) audits. To understand barriers to incorporation of GAP by Minnesota vegetable farmers, a mail survey completed in 2008 was validated with visits to a subset of the farms. This was done to determine the extent to which actual practices matched perceived practices. Two hundred forty-six producers completed the mail survey, and 27 participated in the on-farm survey. Over 75% of the on-farm survey respondents produced vegetables on 10 acres or less and had 10 or fewer employees. Of 14 questions, excellent agreement between on-farm interviews and mail survey responses was observed on two questions, four questions had poor or slight agreement, and eight questions had no agreement. Ninety-two percent of respondents by mail said "they took measures to keep animals and pests out of packing and storage buildings." However, with the on-site visit only 45% met this requirement. Similarly, 81% of respondents by mail said "measures were taken to reduce the risk of wild and/or domestic animals entering into fruit and vegetable growing areas." With direct observation, 70% of farms actually had taken measures to keep animals out of the growing areas. Additional, on-farm assessments were done regarding employee hygiene, training, presence of animals, water sources, and composting practices. This validation study demonstrated the challenge of creating nonleading and concise questions that are not open to broad interpretation from the respondents. If mail surveys are used to assess GAP, they should include open-ended questions and ranking systems to better assess farm practices. To provide the most accurate survey data for educational purposes or GAP audits, on-farm visits are recommended.