ABSTRACT
Silver nanowire ink was written on the surface of drawing paper by automatic writing method. Scanning electron microscopy was used to characterize the surface morphologies of the drawing paper before and after writing silver nanowires. The effects of fabrication parameters and measurement parameters on silver nanowires arrays were investigated. Crystal violet was selected as the probe molecule to study the SERS performance of silver nanowires arrays. The detection limit of crystal violet was as low as 10-15 mol/L. The uniformity and repeatability of the arrays were also explored, and the relative standard deviation values were about 10%. Moreover, silver nanowires arrays were also relatively stable that SERS signals were still observed after ten weeks. Detection of the crystal violet residue was further achieved on the substrates by continuously pressing nine times. In addition, silver nanowires arrays were also applied to the quantitative analyses of 2, 2'-bipyridyl.
Subject(s)
Nanowires , Silver , Gentian Violet , Nanowires/chemistry , Silver/chemistry , Spectrum Analysis, Raman/methods , WritingABSTRACT
With the widespread application of pesticide in agriculture, pesticide residues in food have posed serious health risks to human. There is an urgent requirement to detect pesticide residues in food. In this work, a sensitive and effective method was employed to measure thiram residues in fruit using surface-enhanced Raman scattering (SERS) technique. Silver ink was written on photographic paper (AgNPs-photographic paper) directly by robotic writing technique. The AgNPs-photographic paper substrates possessed good SERS activities and high stability among four months. A good linear response between the peaks intensities and the logarithmic concentrations of thiram was obtained with the limit of detection (LOD) of 0.024 ppb. The substrates also exhibited excellent reproducibility with relative standard deviation (RSD) value less than 10% from ten different substrates. SERS mapping was tested to characterize the uniformity of AgNPs-photographic paper, and the RSD value was calculated to be 14.34% at 1377 cm-1 measured by 120 points. The LOD values of apple and peach juice adulterated with thiram were 0.0024 and 0.024 ppm, respectively. The LOD values of thiram residues on apple and peach peels were both 0.25 ng/cm2. It was demonstrated that the substrates prepared by robotic writing technique had great potential for practical application in food safety inspection.
Subject(s)
Metal Nanoparticles , Robotic Surgical Procedures , Fruit , Humans , Ink , Reproducibility of Results , Silver , Thiram , WritingABSTRACT
Inspired by hand writing approach for preparing surface-enhanced Raman scattering (SERS) substrates, silver nanoparticles (AgNPs) decorated drawing paper substrates were prepared by robotic writing technique. The wettabilities and surface morphologies of the drawing paper before and after the deposition of AgNPs were characterized by contact angle analyzer and scanning electron microscope, respectively. Malachite green was employed as a probe molecule to evaluate the SERS activities of the AgNPs-drawing paper substrates. The AgNPs-drawing paper substrates exhibited extremely high sensitivity that the detection limit for malachite green was down to 10-18 mol/L and the Raman enhancement factor was calculated to be 1015. The relative standard deviation (RSD) values of the Raman peaks intensities collected from twelve points on a single substrate and fifteen substrates were used to evaluate the uniformity and reproducibility of the AgNPs-drawing paper substrates. It was found that the substrates had good reproducibility and uniformity with RSD values of 7.29% and 9.70%, respectively. Furthermore, the prepared AgNPs-drawing paper substrates exhibited long-term stability among six months.
Subject(s)
Metal Nanoparticles , Robotic Surgical Procedures , Reproducibility of Results , Silver , Spectrum Analysis, Raman , WritingABSTRACT
Silver nanoparticles coated paper (AgNPs-paper) substrates were prepared by inkjet printing Ag ink on four different wettability papers. Scanning electron microscope and contact angle analyzer were used to characterize their surface morphology and wettability. AgNPs-paper substrates were used to detect the surface-enhanced Raman scattering (SERS) spectra of thiram aqueous solution. Relationships between the surface wettability, surface morphology and SERS activities of the substrates were systematically studied. The silver nanoparticles deposited on the hydrophobic papers (photographic paper, graph paper, and weighing paper) were evenly and densely arranged. While in-homogeneous distribution was observed on the hydrophilic printing paper. It can be found that the AgNPs-photographic paper with the maximum contact angle exhibited the highest SERS enhancement. The detection limit for thiram adsorbed on the AgNPs-photographic paper was 10-10 mol/L, which was lower than the others. Good linear responses (R2 = 0.9918, 0.9897) between the SERS intensities and logarithmic concentrations were obtained from 104 to 10-10 mol/L. Moreover, the substrate had good uniformity and reproducibility with relative standard deviation values of 4.20% and 4.90% measured by eight points and ten substrates, respectively. The AgNPs-photographic paper exhibited high stability within eight months.