III Italian Consensus Conference on Malignant Mesothelioma of the Pleura. Epidemiology, Public Health and Occupational Medicine related issues.

The III Italian Consensus Conference on Pleural Mesothelioma (MM) convened on January 29th 2015. This report presents the conclusions of the 'Epidemiology, Public Health and Occupational Medicine' section. MM incidence in 2011 in Italy was 3.64 per 100,000 person/years in men and 1.32 in women. Incidence trends are starting to level off. Ten percent of cases are due to non-occupational exposure. Incidence among women is very high in Italy, because of both non-occupational and occupational exposure. The removal of asbestos in place is proceeding slowly, with remaining exposure. Recent literature confirms the causal role of chrysotile. Fibrous fluoro-edenite was classified as carcinogenic by IARC (Group 1) on the basis of MM data. A specific type (MWCNT-7) of Carbon Nanotubes was classified 2B. For pleural MM, after about 45 years since first exposure, the incidence trend slowed down; with more studies needed. Cumulative exposure is a proxy of the relevant exposure, but does not allow to distinguish if duration or intensity may possibly play a prominent role, neither to evaluate the temporal sequence of exposures. Studies showed that duration and intensity are independent determinants of MM. Blood related MM are less than 2.5%. The role of BAP1 germline mutations is limited to the BAP1 cancer syndrome, but negligible for sporadic cases. Correct MM diagnosis is baseline; guidelines agree on the importance of the tumor gross appearance and of the hematoxylin-eosin-based histology. Immunohistochemical markers contribute to diagnostic confirmation: the selection depends on morphology, location, and differential diagnosis. The WG suggested that 1) General Cancer Registries and ReNaM Regional Operational Centres (COR) interact and systematically compare MM cases; 2) ReNaM should report results presenting the diagnostic certainty codes and the diagnostic basis, separately; 3) General Cancer Registries and COR should interact with pathologists to assure the up-to-date methodology; 4) Necroscopy should be practiced for validation. Expert referral centres could contribute to the definition of uncertain cases. Health surveillance should aim to all asbestos effects. No diagnostic test is recommended for MM screening. Health surveillance should provide information on risks, medical perspective, and smoking cessation. The economic burden associated to MM was estimated in 250,000 Euro per case.

The role of iron impurities in the toxic effects exerted by short multiwalled carbon nanotubes (MWCNT) in murine alveolar macrophages.

Lung toxicity mediated by multiwalled carbon nanotubes (MWCNT) has been widely demonstrated and recently associated with induction of carcinogenic asbestos-like effects, but the chemical features that drive this toxic effect have still not been well elucidated. The presence of metals as trace contaminants during MWCNT preparation, in particular iron (Fe) impurities, plays an important role in determining a different cellular response to MWCNT. Our goal was to clarify the mechanisms underlying MWCNT-induced toxicity with correlation to the presence of Fe impurities by exposing murine alveolar macrophages to two different MWCNT samples, which differed only in the presence or absence of Fe. Data showed that only Fe-rich MWCNT were significantly cytotoxic and genotoxic and induced a potent cellular oxidative stress, while Fe-free MWCNT did not exert any of these adverse effects. These results confirm that Fe content represents an important key constituent in promoting MWCNT-induced toxicity, and this needs to be taken into consideration when planning new, safer preparation routes.

Physicochemical and toxicological profiling of ash from the 2010 and 2011 eruptions of Eyjafjallajökull and Grímsvötn volcanoes, Iceland using a rapid respiratory hazard assessment protocol.

The six week eruption of Eyjafjallajökull volcano in 2010 produced heavy ash fall in a sparsely populated area of southern and south eastern Iceland and disrupted European commercial flights for at least 6 days. We adopted a protocol for the rapid analysis of volcanic ash particles, for the purpose of informing respiratory health risk assessments. Ash collected from deposits underwent a multi-laboratory physicochemical and toxicological investigation of their mineralogical parameters associated with bio-reactivity, and selected in vitro toxicology assays related to pulmonary inflammatory responses. Ash from the eruption of Grímsvötn, Iceland, in 2011 was also studied. The results were benchmarked against ash from Soufrière Hills volcano, Montserrat, which has been extensively studied since the onset of eruptive activity in 1995. For Eyjafjallajökull, the grain size distributions were variable: 2-13 vol% of the bulk samples were <4 µm, with the most explosive phases of the eruption generating abundant respirable particulate matter. In contrast, the Grímsvötn ash was almost uniformly coarse (<3.5 vol%<4 µm material). Surface area ranged from 0.3 to 7.7 m2 g(-1) for Eyjafjallajökull but was very low for Grímsvötn (<0.6 m2 g(-1)). There were few fibre-like particles (which were unrelated to asbestos) and the crystalline silica content was negligible in both eruptions, whereas Soufrière Hills ash was cristobalite-rich with a known potential to cause silicosis. All samples displayed a low ability to deplete lung antioxidant defences, showed little haemolysis and low acute cytotoxicity in human alveolar type-1 like epithelial cells (TT1). However, cell-free tests showed substantial hydroxyl radical generation in the presence of hydrogen peroxide for Grímsvötn samples, as expected for basaltic, Fe-rich ash. Cellular mediators MCP-1, IL-6, and IL-8 showed chronic pro-inflammatory responses in Eyjafjallajökull, Grímsvötn and Soufrière Hills samples, despite substantial differences in the sample mineralogy and eruptive styles. The value of the pro-inflammatory profiles in differentiating the potential respiratory health hazard of volcanic ashes remains uncertain in a protocol designed to inform public health risk assessment, and further research on their role in volcanic crises is warranted.

Lichens on asbestos-cement roofs: bioweathering and biocovering effects.

Asbestos-cement roofs, the most widespread sources of airborne, toxic and carcinogenic asbestos fibres, are often colonized by lichens. Since these latter are physical and chemical weathering agents, they have been often considered as significant responsible of disaggregation processes increasing fibre dispersion. Consequently, official guidelines for the management of asbestos often suggest their removal. Weathering and/or covering effects of lichens on asbestos-cement, however, have never been deeply investigated and available procedures to evaluate asbestos-cement aging do not take the biological colonization into account. In this study we show that a 25% lichen cover modifies physical and chemical properties of asbestos-cement sheets containing chrysotile and crocidolite fibres. By innovatively coupling pull up tests and image analysis of linear structures, we show that fibre loss is significantly lower ( approximately 30%) where lichens develop and offer a physical barrier to the fibre detachment. Below the most covering lichens (Acarospora cervina, Candelariella ssp.), chrysotile and crocidolite undergo a partial incongruent dissolution, which in laboratory assays generally determined a reduction of their surface reactivity. Because of their biocovering and bioweathering effects, lichens on asbestos-cement play a role which differs from the current public opinion and the assumptions of some official regulations, acting as effective spontaneous bioattenuation agents.

Free radical generation in the toxicity of inhaled mineral particles: the role of iron speciation at the surface of asbestos and silica.

Free radical generation at the particle/biological fluid interface is one of the chemical processes that contributes to pathogenicity. In order to investigate the role played by iron, fibres of crocidolite asbestos have been modified by thermal treatments to alter their surface iron content. Two radical mechanisms, HO* from H2O2 and cleavage of a C-H bond, which are both active on the original fibres, have been tested on the modified fibres. C-H cleavage is dependent on Fe(II) abundance and location and is suppressed by surface oxidation while HO* release appears independent of the oxidation state of iron. Quartz specimens with different levels of iron impurities have been tested in a similar manner. A commercially available quartz (Min-U-Sil 5) containing trace levels of iron is also active in both tests, but reactivity is not fully suppressed by treatment with desferrioxamine, which should remove/inactivate iron. The radical yield attained is close to the level produced by a pure quartz dust, suggesting the presence of active sites other than iron. Ascorbic acid reacts with both crocidolite and quartz, with subsequent depletion of the level of antioxidant defences when particle deposition occurs in the lung lining layer. Following treatment with ascorbic acid the radical yield increases with quartz, but decreases with asbestos. Selective removal of iron and silicon from the surface may account for the differences in behaviour of the two particulates.

Variability of biological responses to silicas: effect of origin, crystallinity, and state of surface on generation of reactive oxygen species and morphological transformation of mammalian cells.

Variously modified quartz dusts and one amorphous diatomaceous earth have been compared in their potential to release HO* radicals and in their activity in the Syrian hamster embryo (SHE) cell transformation assay. Both original dusts, made up by well-crystallized quartz particles, or by mostly amorphous, variously shaped, silica particles, were active in HO* release, were cytotoxic, and induced morphological transformation in SHE cells. The cristobalite dust, obtained by heating quartz above the phase transition temperature, lost any activity in free radical release, cytotoxicity, and transforming potency. Surface-modified quartz dusts were obtained by a mild etching with HF, by depriving the surface of trace iron with deferoxamine, or by enriching it with iron. The chemical and biological activity decreased in all cases. Both iron-deprived and iron-enriched quartz were nearly inactive. A linear correlation was found between the amount of HO* released by the particles and the transformation frequency. When the SHE cell assay was performed in the presence of mannitol or antioxidant enzymes (superoxide dismutase [SOD] or catalase), the number of transformed cells markedly decreased. This effect was more pronounced for catalase and mannitol than for SOD. HO* release was reduced, but not suppressed, by deferoxamine. All the above results are consistent with the presence of two kinds of surface sites active in HO* release and cell transformation: (1) silicon-based radicals, abundant on freshly ground dusts, which generate the HO* radicals without the superoxide ion as intermediate; and (2) isolated iron centers where the Haber-Weiss cycle takes place, with the superoxide ion as intermediate. The activities of both sites are inhibited by mannitol or catalase, whereas only the last one is inhibited by SOD.

Silica and renal diseases: no longer a problem in the 21st century?

Silicosis and other occupational diseases are still important even in the most developed countries. In fact, at present, silica exposure may be a risk factor for human health not only for workers but also for consumers. Furthermore, this exposure is associated with many other different disorders besides pulmonary silicosis, such as progressive systemic sclerosis, systemic lupus erythematosus, rheumatoid arthritis, dermatomyositis, glomerulonephritis and vasculitis. The relationships between these silica-related diseases need to be clarified, but pathogenic responses to silica are likely to be mediated by interaction of silica particles with the immune system, mainly by activation of macrophages. As regards renal pathology, there is no single specific clinical or laboratory finding of silica-induced nephropathy: renal involvement may occur as a toxic effect or in a context of autoimmune disease, and silica damage may act as an additive factor on an existing, well-established renal disease. An occupational history must be obtained for all renal patients, checking particularly for exposure to silica, heavy metals, and solvents.

Iron inhibits the nitric oxide synthesis elicited by asbestos in murine macrophages.

Crocidolite fibers stimulated nitric oxide synthase (NOS) activity and expression in glial and alveolar murine macrophages: this effect was inhibited by iron supplementation and enhanced by iron chelation. We suggest that in these cells crocidolite stimulates NOS expression by decreasing the iron bioavailability and activating an iron-sensitive transcription factor.

The role of metals in autoimmune vasculitis: epidemiological and pathogenic study.

BACKGROUND: A possible relationship between Silica (Si) exposure and antineutrophil cytoplasm antibodies (ANCA)-associated vasculitis has been reported. Furthermore, tuberculosis (TBC) has been frequently described in patients with silicosis, and TBC infection shares with ANCA-associated vasculitis the formation of granulomas. Therefore, an intriguing network including Silica, Vasculitis, TBC and ANCA might be hypothesized. The aim of this work was to further investigate these correlations using both epidemiological and pathogenic approaches. METHODS: Study I--epidemiological study. A case-control study to compare the occupational histories of 31 cases of biopsy proven vasculitis (18 pauci-immune crescentic glomerulonephritis, 9 microscopic polyangitis, 4 Wegener's granulomatosis) with those of 58 age, sex and residence-matched controls (affected by other kidney diseases), was performed. Occupational Health physicians designed an appropriate questionnaire in order to evaluate a wide spread of exposures and calculate their entity by the product of Intensity x Frequency x Duration. Study II--tuberculosis association. A case-control study to evaluate the frequency of a previous history of tuberculosis (TBC) in 45 patients with vasculitis and 45 controls were performed. Study III--ANCA positivity. A case-control study to evaluate the presence of ANCA was performed by testing blood samples of 64 people with previous professional exposure and 65 sex/age matched patients hospitalized in a General Medicine Unit. Furthermore, the same evaluation was made in a pilot study in 16 patients with ongoing or previous TBC. Study IV--experimental study. The oxygen free radicals (OFR) and IL-12 production (both involved in the pathogenesis of vasculitis) from human phagocytic cells stimulated with an amorphous (diatomaceous earth) and a crystalline (quartz) form of Si at the doses of 10 and 100 microg ml(-1) was evaluated. RESULTS: Study I--a positive history of exposure to Si resulted in significantly more present in cases (14/31 = 45%) than in controls (14/58 = 24%, P = 0.04, OR = 2.4) and no other significant exposure association was found (including asbestos, mineral oil, formaldehyde, diesel and welding fumes, grain and wood dust, leather, solvents, fungicides, bitumen, lead and paint). Study II--past TBC infection was significantly more present in patients with vasculitis (12/45 = 26%) than in controls (4/45 = 8%, P < 0.05). Study III--ANCA was present in 2/64 exposed people (vs. 0/65 controls, P = NS) and 0/16 patients with TBC. Study IV--both amorphous and crystalline Si forms represented a stimulus for OFR and IL-12 production, but quartz resulted as a greater inductor. CONCLUSIONS: We conclude that Si exposure might be a risk factor for ANCA-associated vasculitis, possibly enhancing endothelial damage by phagocyte generation of oxygen free radicals and Th1 differentiation by an excessive IL-12 phagocyte production. Frequency of TBC was significantly higher in vasculitis patients. ANCA was not frequent in the preliminary examination of people with previous professional exposure or patients with TBC, but the number of samples evaluated is too small to allow conclusions.

Free radical activity of natural and heat treated amphibole asbestos.

The amphibole minerals amosite and crocidolite were subjected to calcination and to hydrothermal treatment in order to study the effect of these heat treatments on the ability of the minerals to trigger formation of free radicals, which is known to be a main factor causing asbestosis and other asbestos-induced diseases. Free radical activity of the natural and heat treated minerals was studied by using supercoiled DNA (pUC18 plasmid) as a target molecule, and also by means of EPR spectroscopy. It was shown that after calcination of the natural minerals at 1073 K their free radical activity was strongly decreased These results, which may have relevant consequences for asbestos technology, were correlated with concomitant alteration of the structure and surface chemistry of the minerals during calcination.

Spontaneous polymerisation on amphibole asbestos: relevance to asbestos removal.

Taking advantage of the spontaneous polymerisation of eugenol to lignin-like species catalysed by the surface of crocidolite fibres, a procedure is proposed, possibly useful in asbestos removal and disposal, where the polymer avoids the release of airborne fibres and also scavenges ROS (reactive oxygen species).

Possible role of ascorbic acid in the oxidative damage induced by inhaled crystalline silica particles.

The selective interaction of ascorbic acid with crystalline silica (quartz) has been studied by measuring the ascorbic acid consumption (by means of UV/vis and IR spectroscopy) and the release of silicon when quartz particles or amorphous silica (Aerosil 50) is incubated in ascorbic acid solution. At a physiological ascorbic acid concentration, quartz, and not amorphous silica, reacts, suggesting the formation of a 1:1 silicon-ascorbate complex, while at higher concentrations, the reacting amount of ascorbic acid exceeds the amount of silicon that is released. Silicon tetrahedra bearing free silanols at the quartz surface are selectively attached by ascorbic acid. The particle-derived hydroxyl radical yield in the presence of hydrogen peroxide is increased on ascorbic acid-treated quartz in comparison with the original sample. The results presented herein are relevant because the depletion of ascorbic acid from the lung lining layer and the increased potential in particle-derived free radical generation may both contribute to the oxidative damage following inhalation of crystalline silica.

Cytotoxic and transforming effects of silica particles with different surface properties in Syrian hamster embryo (SHE) cells.

Several crystalline and amorphous silica dusts (two quartz of natural origin, one cristobalite of natural and two of biogenic origin, three amorphous diatomite earths and one pyrogenic amorphous silica) were studied in the SHE cell transformation assay, in order to compare their cytotoxic and transforming potencies and examine the role of the structure and of the state of the surface on these effects. Some samples were modified by grinding, etching and heating with the aim of establishing relationships between single surface properties and biological responses. The results showed that some quartz and cristobalite dusts (crystalline) as well as the diatomaceous earths (amorphous), but not the pyrogenic amorphous silica, were cytotoxic and induced morphological transformation of SHE cells in a concentration-dependent manner. The ranking in cytotoxicity was different from that in transforming potency, suggesting two separate molecular mechanisms for the two effects. The cytotoxic and transforming potencies were different from one dust to another, even among the same structural silicas. The type of crystalline structure (quartz vs cristobalite) and the crystalline vs biogenic amorphous form did not correlate with cytotoxic or transforming potency of silica dusts. Comparison of cellular effects induced by original and surface modified samples revealed that several surface functionalities modulate cytotoxic and transforming potencies. The cytotoxic effects appeared to be related to the distribution and abundance of silanol groups and to the presence of trace amounts of iron on the silica surface. Silica particles with fractured surfaces and/or iron-active sites, able to generate reactive oxygen species, induced SHE cell transformation. The results show that the activity of silica at the cellular level is sensitive to the composition and structure of surface functionalities and confirm that the biological response to silica is a surface originated phenomenon.

Pure-silica zeolites (Porosils) as model solids for the evaluation of the physicochemical features determining silica toxicity to macrophages.

The interaction between inhaled particles and alveolar macrophages plays a key role in silica-related diseases. It has been previously shown [Fubini, B., et al. (1999) Chem. Res. Toxicol. 12, 737-745] that a monocyte-macrophage cell line (J774) may be employed in the evaluation of the degree of cytotoxicity to alveolar macrophages of various silica dusts. In this paper, pure-silica zeolites (porosils) in microcrystalline form have been employed as "model solids" in an effort to show which physicochemical properties of the silica particle are playing a major role in the toxicity to macrophages. The samples employed covered four different porosil crystal structures (MFI, FAU, TON, and MTT) and also include a synthetic rodlike cristobalite (CRIS-rd). When compared at equal weight, the samples cover a wide range of cytotoxicity from inert to toxic as unheated mineral cristobalite [Fubini, B., et al. (1999) Chem. Res. Toxicol. 12, 737-745]. Mild grinding did not affect cytotoxicity. Calcined (open pores) and uncalcined (pore filled with template) TON exhibited the same cytotoxicity, indicating that only the outer surface is implied. The hydrophobic and/or hydrophilic character of TON, evaluated by adsorption calorimetry, is close to what has been previously found for silicalite and is consistent with a hydrophilic outer surface and hydrophobic pore walls. The potential for generating hydroxyl radicals from hydrogen peroxide varies among the various porosils that have been studied. A model is proposed for the correlation between inhibition of growth on proliferating cells and physicochemical properties varying from one to the other sample. The extent of external surface and the aspect ratio were related to the intensity of the cytotoxic effect, while the level of radical release was not. This suggests, on one hand, that comparison of toxicity among various dusts should be made at equal particle surface and, on the other, that in the model studied, free radical release does not play a crucial role in the primary event of toxicity to alveolar macrophages.

In vitro cleavage by asbestos fibers of the fifth component of human complement through free-radical generation and kallikrein activation.

Chrysotile and crocidolite fibers incubated in normal human plasma (NHP) generated from the C5 component of complement C5a-type fragments that stimulated polymorphonuclear leukocyte (PMN) chemotaxis. Absorption of NHP with antiserum against C5a totally abolished neutrophil chemotactic activity. Asbestos fibers also produced C5a small peptides in the presence of ethylene glycol bis(beta-aminoethyl ether) N,N,N'N'-tetraacetic acid (EGTA) but not ethylene diamine tetraacetic acid (EDTA). Activation of C5 was significantly inhibited when asbestos fibers were pretreated with iron chelators such as sodium dithionite (DTN), deferoxamine (DFX), or ascorbate (AA). Concentration-related inhibition of C5 activation was also observed when asbestos fibers were added concurrently to plasma in the presence of DFX, 1,3-dimethyl-2-thiourea (DMTU), a strong hydroxyl scavenger, or aprotinin (APR), a specific protease inhibitor. Further, chrysotile and crocidolite significantly increased plasma kallikrein activity. Data demonstrate that asbestos-induced C5 activation plays a role in inflammatory reactions characteristic of asbestosis through mechanisms involving iron ions, hydroxyl radicals, and oxidized C5-ike fragments. The ferrous ions present at the asbestos fiber surface trigger this activation and catalyze, via Fenton reaction, the production of hydroxyl radicals, which in turn convert native C5 to an oxidized C5-like form. This product is then cleaved by kallikrein, activated by the same asbestos fibers, yielding an oxidized C5a with the same functional properties as C5a.

Surface Properties of Vitreous Fibers.

The surface properties of various vitreous fibers, suspected to be toxic to humans and animals, were investigated by means of paramagnetic labels covalently linked to the surface. Computer-aided analysis of the electron paramagnetic resonance (EPR) spectra provided structural and dynamic information on the label and its environment. Calorimetric measurements provided information on the hydration mechanism. The results were analyzed in terms of (a) different polarity and interaction abilities of surface regions, (b) presence of ions at the surface, (c) silica contents, (d) vicinity of the interacting sites, (e) fiber dimension and morphology of the surfaces, and (f) water hydration. The mobility of the labels decreased due to interaction of the fibers with ions or ionic and polar groups at the surface. Close interacting sites were identified on the basis of spin-spin effects and were distinguished and quantified in strongly and weakly interacting sites. The spin-labeling technique indicated decreased ability of the surface to interact with decreased silicon concentration and in the presence of contaminants at the surface. The interaction with water revealed in all cases a substantial heterogeneity in hydrophilicity of surface sites. The labels were not easily hydrated. Vitreous fibers of various compositions adsorbed much more water than crystalline or amorphous silica; water coordinated to surface cations played a major role in the overall adsorption. The surface reaction mechanisms were the same on fibers of different compositions, but the surface composition affected the extent of adsorption. Glass wool exhibited a much higher adsorption capacity than rock wool under the same experimental conditions. In conclusion, the combination of EPR and calorimetric measurements provided insight into the surface properties of silica-based fibers. Copyright 2000 Academic Press.

Effect of Micromorphology and Surface Reactivity of Several Unusual forms of Crystalline Silica on the toxicity to a Monocyte-Macrophage Tumor Cell Line.

The fibrogenic or carcinogenic response to the inhalation of crystalline silica dusts is strictly related to the physicochemical properties of the particles, which, in turn, are mostly determined by the "origin" and the history of the dust. Several physicochemical properties have been reported to modulate silica pathogenicity. None of them simply correlate with the reported toxicity in all the systems used to study silica pathogenicity. This confirms, on the one hand, that several properties are implicated at the same time, and on the other that pathogenicity is the result of a multistage process. There is a general consensus on the key role played by alveolar macrophages in silica-related diseases. For this article the cytotoxicity of a large variety of silicas, including rather unusual forms, with controlled micromorphology and surface properties, has been studied on a mouse monocyte-machrophage tumor cell line successfully employed in previous studies on cristobalite (Fubini et al., 1999). When compared on a per unit surface basis, crystalline silicas were more cytotoxic than amorphous ones, with the notable exception of stishovite, the nonpathogenic crystalline polymorph, with octahedrally coordinated silicon atoms. Among the amorphous ones, a diatomaceous earth and a powdered silica glass exhibited an intermediate toxicity, higher than what was elicited by a pyrogenic silica. In this study a new class of crystalline silicas have been considered, pure-silica zeolites, which constitute a new morphological entity with which cells may be confronted. The cytotoxicity of these samples varies from inert to highly cytotoxic, covering all the range of toxicity covered by the traditional silica dusts. We discuss the influence of morphological properties and surface reactivity on the cytotoxicity of several pure-silica zeolites. The extent of exposed surface and the shape of the particles correlate with cell toxicity. The lower cytotoxicity of one "non-pathogenic quartz" and of an aluminum-coated Min-U-Sil quartz, compared with the original pathogenic Min-U-Sil quartz, suggest a depressive effect of the aluminum ions present at the surface of both quartzes. The extreme variability in the biological response to crystalline silicas is confirmed and a new class of materials is brought to the study of the mechanisms of silica pathogenicity.

In vitro effects of coal fly ashes: hydroxyl radical generation, iron release, and DNA damage and toxicity in rat lung epithelial cells.

Oxygen radical generation due to surface radicals, inflammation, and iron release has been suggested as the mechanism of adverse effects of quartz, such as emphysema, fibrosis, and carcinogenic effects. Therefore, we measured iron release, acellular generation of hydroxyl radicals, and oxidative DNA damage and cytotoxicity in rat lung epithelial (RLE) cells by different coal fly ashes (CFA) that contain both quartz and iron. Seven samples of CFA with different particle size and quartz content (up to 14.1%) were tested along with silica (alpha-quartz), ground coal, and coal mine dust (respirable) as positive control particles, and fine TiO(2) (anatase) as a negative control. Five test samples were pulverized fuel ashes (PFA), two samples were coal gasification (SCG) ashes (quartz content <0.1%), and one sample was a ground coal. No marked differences between SCG and PFA fly ashes were observed, and toxicity did not correlate with physicochemical characteristics or effect parameters. Stable surface radicals were only detected in the reference particles silica and coal mine dust, but not in CFA. On the other hand, hydroxyl radical generation by all fly ashes was observed in the presence of hydrogen peroxide, which was positively correlated with iron mobilization and inhibited by deferoxamine, but not correlated with iron or quartz content. Also a relationship between acellular hydroxyl radical generation and oxidative DNA damage in RLE cells by CFA was observed. Differences in hydroxyl radical generation and oxidative damage by the CFA were not related to iron and quartz content, but the respirable ashes (MAT023, 38, and 41) showed a very extensive level of hydroxyl radical generation in comparison to nonrespirable fly ashes and respirable references. This radical generation was clearly related to the iron mobilization from these particles. In conclusion, the mechanisms by which CFA and the positive references (silica, coal mine dust) affect rat lung epithelial cells seem to be different, and the data suggest that quartz in CFA does not act the same as quartz in silica or coal mine dust. On the other hand, the results indicate an important role for size and iron release in generation and subsequent effects of reactive oxygen species caused by CFA.

Relationship between surface properties and cellular responses to crystalline silica: studies with heat-treated cristobalite.

A fibrogenic sample of cristobalite dust, CRIS (crystalline silica of mineral origin), was heated to 1300 degrees C (CRIS-1300) to relate induced physicochemical modifications to cytotoxicity. Heating did not affect dust micromorphology and crystallinity, except for limited sintering and decreased surface area of CRIS-1300. Thermal treatments deeply affected surface properties. Electron paramagnetic resonance showed surface radicals progressively annealed by heating, mostly disappearing at >/=800 degrees C. Surface hydrophilicity or hydrophobicity, evaluated with water vapor adsorption, still showed some hydrophilic patches in CRIS-800, but CRIS-1300 was fully hydrophobic. Heating modified the biological activity of cristobalite. Cytotoxicity, tested on proliferating cells of the mouse monocyte macrophage cell line J774, showed that CRIS was cytotoxic and CRIS-800 was still cytotoxic, but CRIS-1300 was substantially inert. Cytotoxicity of CRIS to the rat lung alveolar epithelial cell line, AE6, as measured by colony forming efficiency, was greatly reduced for CRIS-800 and eliminated for CRIS-1300. The rate of lactate dehydrogenase release by rat alveolar macrophages was lowered for CRIS-800, and release was completely inactivated for CRIS-1300. The absence of surface radicals and the onset of hydrophobicity may both account for the loss of cytotoxicity upon heating. Differences observed between CRIS-800 and CRIS-1300, both fully deprived of surface radicals, indicate that hydrophobicity is at least one of the surface properties determining the cytotoxic potential of a dust.

Surface chemistry and quartz hazard.

The variability of quartz hazard is related to the characteristics of particulate toxicants. Although these have the same chemical composition, they exist in various forms and surface states, each one eliciting different biological responses. On the basis of data from the literature, surface chemical properties are associated to the subsequent stages reported by Donaldson and Borm (1998) in the mechanistic model proposed for quartz carcinogenicity. Surface radicals and iron-derived reactive oxygen species (ROS) are implicated in oxidative stress, considered to be the key event in the development of fibrosis and lung cancer. Other chemical functionalities related to cytotoxicity, however, modulate the overall pathogenicity by regulating transport and clearance. The chemical features deriving from the intrinsic characteristics of a silica dust--e.g. its origin--as well as those generated by external factors--e.g. contaminants, associated minerals--are discussed in relation to their possible role in the pathogenic mechanism.