Evaluation of exogenous phytase in high-phytate diets for broiler chickens and pigs.

There is a gap in the understanding of the relationship between dietary phytate levels and the relative efficacy of phytase to improve amino acid (AA) digestibility in pigs and chickens. Two experiments were conducted to investigate the effect of exogenous phytase on standardized ileal digestibility (SID) of AA and the apparent ileal digestibility (AID) of P in both standard- (SP) and high-phytate (HP) diets for broilers and swine. There were either 40 cages of Cobb 500 male broilers or 10 crossbred barrows (35 kg) fitted with ileal T-cannulas. Both studies were allotted to five dietary treatments (8 replicates). Treatments consisted of four corn-soybean meal-based diets arranged in a 2 × 2 factorial of standard or high phytate and exogenous phytase at 0 or 1 000 phytase units (FYT)/kg; and one N-free diet. Birds were fed a common starter diet from d 0 to 20 and fed experimental diets from d 20 to 25. Birds were euthanized on d 25 via CO2 asphyxiation, and digesta were collected from the terminal ileum. Pigs were fed for a total of four 7-d periods, where digesta were collected on d 6 and 7 of each period. Diet and digesta samples were analyzed for DM, N, Ti, AA, and P to determine AA and P digestibility. The SID of AA was determined by correcting the AID of AA for the basal endogenous losses estimated using the N-free diet. Main effects of the diet type (standard or HP) and phytase (0 or 1 000 FYT/kg), and the interaction of diet type and phytase were evaluated. For both experiments, the HP diets produced lower SID of AA compared to the SP (P < 0.001). For broilers, there was a phytase effect (P < 0.001) for the SID of all AAs evaluated regardless of the diet type. For pigs, phytase improved (P < 0.05) the SID of Met, Lys, Cys, Glu and Ser and tended to improve (P < 0.10) Arg, Leu, Thr, and Tyr. There were no significant interactions for either experiment. For both experiments, AID of P was lower for the HP diets (P < 0.01), and phytase produced greater AID of P for both diet types (P < 0.01). These data indicate that phytase greatly improves the digestibility of P for broilers and pigs and has the ability to significantly increase the digestibility of amino acids for these animals, regardless of the dietary phytate P.

Ileal phosphorus digestibility of soybean meal for broiler chickens remains consistent across institutions in a collaborative study regardless of non-phytate phosphorus concentration in the pre-experimental starter diet.

The same experimental protocol was used in 4 institutions to evaluate the impact of non-phytate phosphorus (nPP) concentration in the starter diet on regression method-derived ileal P digestibility of soybean meal (SBM) during the subsequent grower phase. A total of 1,536 Ross 308 male broiler chickens on d 0 post hatching were allotted to 2 pre-experimental starter diets that contained 3.5 or 4.5 g nPP/kg (96 replicate cages per diet, 8 birds per cage) for 18 d. Subsequently, 576 birds from each starter diet were selected and allocated to 3 experimental semi-purified grower diets containing 400, 510, or 620 g SBM/kg (32 replicate cages per diet, 6 birds per cage) for 3 d until collection of ileal digesta. Statistical analysis was conducted as a randomized complete block design with the starter period as whole plot and the grower period as split-plot. The only significant 2-way interaction was between grower diet and experimental institution (P < 0.05) on BW gain and gain to feed ratio. The main effect of institution and grower diet impacted (P < 0.05) feed intake, the digestibility of DM, P, and calcium, and disappearance of inositol hexakisphosphate (InsP6) in the grower diets. Birds fed the 3.5 g nPP/kg starter diet had lower (P < 0.05) BW gain and feed intake during the grower period, but presented higher (P < 0.05) digestibility of P and disappearance of InsP6 compared with the birds that were fed the 4.5 g nPP/kg starter diet. Regression method-derived ileal P digestibility of SBM was determined to be 46 or 42% for the respective 3.5 or 4.5 g nPP/kg pre-experimental starter diet and was not affected by the nPP concentration or by the institution. In conclusion, the experimental protocol used in the current study resulted in similar estimates across multiple institutions and is thus endorsed for future application in studies that aim to expand the database of digestible P content in plant source feed ingredients.

Comparison of different protein sources on the phosphorus digestibility of soybean meal for broiler chickens determined using the regression method.

A study was conducted to evaluate the P digestibility in soybean meal (SBM) using the regression method with different basal diet that varied in protein sources. The treatments were organized in a 4 × 3 factorial arrangement, where 4 semipurified diets were formulated with varying source of protein (no protein supplement, or added casein, potato protein isolate (PPI), or dried egg albumen (DEA) at 60 g/kg) and 3 dietary levels of SBM (290, 370, or 450 g/kg). The study was a randomized complete block design with 8 replicate cages of 6 birds per cage. The experimental diets were fed from d 19 to 22 posthatching, excreta samples were collected from d 20 to 22, and ileal digesta samples were collected on d 22. Data were analyzed as a 2-way ANOVA using the GLM procedure. The digestibility and total tract utilization of DM, P, Ca, and N were affected by protein source (P < 0.05). Diets with casein presented the highest (P < 0.05) digestibility of N. Increasing SBM level in all dietary protein sources reduced (P < 0.001) the digestibility and total tract utilization of DM. The regression-derived ileal digestibility of P in SBM was 57.8 (SE = 3.78), 63.2 (SE = 5.02), 58.8 (SE = 4.53), and 35.3% (SE = 5.27) for diets without protein supplement, with casein, PPI, or DEA, respectively; the corresponding P retention were 52.2 (SE = 11.09), 83.4 (SE = 14.89), 42.6 (SE = 15.88), and 51.9% (SE = 14.67). The protein source affected (P < 0.05) the slope and intercept of P digestibility in SBM. A comparison of the coefficients using confidence intervals demonstrated that the ileal digestibility of P in SBM determined in diets with DEA was lower (P < 0.05) than the other protein sources, which did not differ from one another. These results indicate that the selection of dietary protein supplements may affect P digestibility assays using the regression method.

Regression-derived phosphorus digestibility responses of broiler chickens to heat treatment of soybean meal and poultry meal.

Two studies were conducted to evaluate the effects of autoclaving soybean meal (SBM) or poultry meal (PM) on their respective regression-derived phosphorus (P) ileal digestibility and utilization coefficients. On day 19 post hatching 384 or 320 Cobb 500 male broiler chickens were individually weighed and allotted into 6 or 5 treatments in Experiment 1 or 2, respectively. Both experiments consisted of 8 replicate cages with 8 birds per cage in a randomized complete block design. In the first study, 6 diets were formulated with either non-autoclaved or autoclaved soybean meal at 380, 480, or 580 g/kg in a 2 × 3 factorial. The second consisted of 5 diets including one corn-soybean meal and cornstarch based basal diet and 4 diets with 40 or 80 g/kg of non-autoclaved PM or autoclaved PM (APM). Chromic oxide was added as an indigestible index to determine the ileal digestibility and retention of nutrients. Birds received the experimental diets for 3 d and excreta collection was conducted during the last 2 d. At the end of the experiments all birds were euthanized by CO2 asphyxiation and ileal digesta samples were collected. Data were analyzed by ANOVA using the GLM procedure. In both studies autoclaving decreased (P < 0.05) DM digestibility and retention. Increasing the inclusion level of test ingredients caused a linear increase (P < 0.05) in intake of digestible and utilizable P in both studies, and linear reductions in the digestibility and retention of DM and P in the soybean meal study. Inclusion of autoclaved SBM resulted in higher (P < 0.01) ileal digestibility of P and retention of P and Ca. The estimated ileal digestibility of P in SBM, autoclaved SBM, PM and APM were 45, 53.6, 61.2, and 61.2%, respectively, the corresponding retention were 40.6, 45, 51.7, and 59.2%, respectively. Comparison of the regression coefficients revealed that autoclaved SBM tended (P = 0.058) to have higher P digestibility than non-autoclaved while no effect was noted with PM.

Optimizing cost, growth performance, and nutrient absorption with a bio-emulsifier based on lysophospholipids for broiler chickens.

Two experiments (Exp.) were conducted to evaluate effects of a lysophospholipid-based bio-emulsifier (LPL) on growth performance, nutrient digestibility and energy utilization of broilers as well as the return on investment (ROI). In Exp. 1, 392 chicks were housed in battery cages in a completely randomized design with 8 treatments and 7 replicates of 7 birds each from d 0 to 21 posthatch. In Exp. 2, 1,400 chicks were allocated in floor pens and fed the same 8 treatments, with 7 replicates and 25 birds each from d 0 to 43 posthatch. Treatments consisted of 6 degummed soybean oil-based diets: positive control (PC1); PC1 formulated with 500 g/ton LPL (PC1+LPL on top); PC1 formulated with 60 kcal LPL matrix (PC1+LPL60); PC1 formulated with 100 kcal LPL matrix (PC1+LPL100); and two negative controls NC-60 and NC-100 with reductions of 60 and 100 kcal/kg ME, respectively. Two other diets were formulated with acid soybean oil: positive control (PC2) and PC2 formulated with 60 kcal LPL matrix (PC2+LPL60). In Exp. 1, performance was evaluated from d 0 to 21, ME and ileal digestibility of DM, CP and energy were determined on d 21. In Exp. 2, growth performance was evaluated from d 0 to 42, and on d 43 carcass and abdominal fat yields were calculated. There were no effects of soybean oil sources in any parameter. Inclusion of LPL increased (P < 0.05) BW gain and ileal digestibility of DM, fat and CP. Broilers fed the PC1+LPL on top diet had increased (P < 0.05) performance, ileal digestibility and energy utilization as well as decreased abdominal fat compared to NC-60 or NC-100. The use of LPL on top had a ROI of 8:1 vs. PC1, considering the gains in revenue of the slaughtered broilers in relation to the investment with LPL in feed. In conclusion, a lysophospholipid-based bio-emulsifier increased performance, digestibility and return on investment of broilers fed standard or reformulated diets.