Effect of dry sanitizing methods on Bacillus cereus biofilm.

Bacillus cereus is a relevant foodborne pathogen and biofilm producer which can contaminate and persist in the processing environment of both high and low water activity foods. Because of this, it is crucial to understand better the resistance of this pathogen biofilm to different sanitation methods. The aim of this study was to evaluate the efficacy of dry sanitizing treatments against B. cereus biofilm formed on stainless steel (SS) and polypropylene (PP). Biofilm formation was held through the static method at 25 °C. After 4 days of incubation, coupons were exposed for up to 30 min to UV-C light, dry heat, gaseous ozone, 70% ethanol, and a commercial sanitizer. Sodium hypochlorite (200 mg/l) was also tested in two different pH values (7 and 11) for comparison purposes. In general, the surface material did not influence (p > 0.05) the performance of the treatments. From 10 min of exposure, 70% ethanol and the commercial product caused the lowest reductions on both surfaces. In addition, dry heat exhibited a poor performance on PP, with reductions < 1 log CFU/cm2. UV-C light on SS and PP and ozone on PP achieved reductions around 2 log CFU/cm2 after 30 min. The same level of reduction was obtained after 5 or 10 min using sodium hypochlorite (200 mg/l). Therefore, the results showed that dry sanitizing methods are not as effective as sodium hypochlorite against B. cereus biofilms. Further studies to evaluate the efficacy of the combination of dry methods are necessary.

Competitive and/or Cooperative Interactions of Listeria monocytogenes With Bacillus cereus in Dual-Species Biofilm Formation.

Microorganisms in dairy industries can form monospecies, dual-species, or multispecies biofilms, showing cooperative or competitive behaviors, which might contribute to the reduction of efficiency of cleaning and sanitization processes and eventually turn into a potential source of contamination. This study proposes to evaluate the behavior of Listeria monocytogenes in monospecies biofilms, cocultured with Bacillus cereus. The isolates were of dairy origin, and the selection occurred after studies of competition among species. The biofilm formations on AISI 304 stainless steel at 25°C in a stationary culture were analyzed to observe the cooperative or competitive interactions among species, as well as the effect of pre-adhered cells. Biofilm formation assays were performed in four experiments: Experiment 1: in the presence of strains of antagonistic substance producer B. cereus (+); Experiment 2: extract of the antagonistic substance of B. cereus; Experiment 3: pre-adhered cells of B. cereus; and Experiment 4: pre-adhered cells of L. monocytogenes. Subsequently, cooperative behavior was observed by scanning electron microscopy. The L. monocytogenes monospecies biofilm counts of greater than 5 log colony-forming units (CFU)/cm2 were also observed in dual-species biofilms in the presence of B. cereus (non-producers of antagonist substance), showing cooperative behavior between species. However, in the presence of antagonistic substance produced by B. cereus, the counts were lower, 1.39 and 1.70 log CFU/cm2 (p > 0.05), indicating that the antagonistic substance contributes to competitive interactions. These data are relevant for the development of new studies to control L. monocytogenes in the dairy industry.