Change in Surface Roughness on the Inner and Outer Surfaces of the Microtube during Hollow Sinking.

Hollow sinking experiments and tensile tests were conducted to clarify the evolution of surface roughness during hollow sinking. Stainless steel tubes (outer diameter: 1.5 mm; wall thickness: 0.045 mm) featuring a single grain spanning the wall thickness achieved via annealing as the starting material. The tube was drawn without an internal tool using a draw bench by controlling the tube drawing speed ratio of the die entrance and exit sides. The surface roughnesses of the inner and outer surfaces at the die entrance and exit sides of the drawn tube were compared with the surface roughnesses of the inner and outer surfaces under the uniaxial tensile deformation of the starting material. As a result, two major findings were revealed; the surface roughness formation behavior during the hollow sinking; the uniaxial tensile deformation exhibits a tube on both sides of the entrance and the exit of a die. Former uniaxial tensile deformation forms surface roughness of the tube at the die-entrance-side. However, hollow sinking reduces the roughness. The tube keeps its small roughness even though it is applied the later uniaxial tensile deformation behind the die exit. Furthermore, the conventional formula to predict the surface roughness of a metal sheet caused by the uniaxial tensile deformation can predict the surface roughness of a tube in the hollow sinking. At both die entrance and exit sides, the roughness of the inner surface was larger than that of the outer surface at the die entrance and exit side. The outer surface of the tube contacts the inside of a die when the tube passes through the die. The height of the convex parts decreased at that moment. Hollow sinking suppressed the increase in surface roughness of the inner surface as the outer surface was smoothed in the die. However, due to the formation of surface roughness after leaving the die, there is an overall increasing trend in inner surface roughness.

Tumor thickness as a novel risk factor for lymph node metastasis by superficial squamous cell carcinoma of head and neck.

Narrow-band imaging combined with magnified endoscopy has enabled the detection of superficial squamous cell carcinoma of the head and neck (SSCCHN) that has been resected with minimally invasive treatment, preserving vocalization and swallowing functions. However, risk factors of lymph node metastasis (LNM) must be identified, as some patients with LNM have a poor prognosis. From an initial 599 patients with 700 lesions who underwent trans-oral surgery in 27 Japanese hospitals (a nationwide registration survey), we enrolled 541 patients with 633 SSCCHNs, as indicated by central pathological diagnoses. All pathological specimens for each patient were examined using 20 pathological factors that are thought to affect the LNM of SSCCHN. In all, 24 (4.4%) of the 568 SSCCHNs exhibited LNM, and all 24 had at least one solitary nest of epithelial neoplastic cells present in the stroma, clearly separated from the intraepithelial carcinoma. Multivariate analysis also showed that tumor thickness (p = 0.0132, RR: 7.85, 95% confidence interval [CI]: 1.54-40.02), and an INFc pattern classified as infiltrating growth (INF) with unclear boundaries between tumor and non-tumor tissues (p = 0.0003, RR: 14.47, 3.46-60.46), and tumor budding (p = 0.0019, RR: 4.35, CI: 1.72-11.01) were significantly associated with LNM. Solitary nests may be indicative of LNM. In addition, tumor thickness was revealed to be a risk factor for LNM in SSCCHNs using pT factors that do not include an invasion depth element because of the anatomical absence of the muscularis mucosae.

Total laryngectomy increases the risk of chronic constipation: a cross-sectional study of 50 patients.

PURPOSE: Due to difficulties in breath holding, patients who undergo total laryngectomy may be prone to the development of chronic constipation. However, few reports have described chronic constipation in laryngectomized patients, and no report has described prevalence in patients who have undergone total pharyngolaryngectomy. METHODS: We conducted a cross-sectional study to investigate the prevalence of chronic constipation after laryngectomy and evaluated the relationship between patient characteristics and chronic constipation. Information on patient characteristics and the details of surgery were obtained from medical records and an original questionnaire survey in 50 patients. RESULTS: The prevalence of chronic constipation after laryngectomy was high, at 36%, with 18 cases. Patients who received total laryngectomy were significantly more likely to have chronic constipation than those who received total pharyngolaryngectomy (47.1% vs 12.5%, P = 0.026), who had a similar prevalence to the general public. Furthermore, the period from surgery to survey was significantly shorter in the constipation group than in the no constipation group (P = 0.043). CONCLUSIONS: The prevalence of chronic constipation in patients who had undergone laryngectomy for head and neck cancer was high, particularly in patients who received total laryngectomy and in those with only a short period since surgery.

Novel color fluorescence imaging for sentinel lymph node detection in oral and oropharyngeal cancer.

AIM: Fluorescence imaging (FI) using indocyanine green (ICG) is a noteworthy alternative technique for sentinel lymph node (SLN) detection without radiation exposure in oral cavity and oropharynx cancer. However, conventional FI is monochrome, so the visibility is limited. This study assessed whether color FI using the HyperEye Medical System (HEMS) is feasible as an alternative for SLN detection. METHODS: Patients with previously untreated cT1-2N0 oral or oropharyngeal cancer who were to undergo primary tumor resection and elective neck dissection (END) in our hospital were enrolled from November 2012 to March 2016. The patients underwent SLN detection for biopsy via the HEMS following the injection of ICG solution around the primary lesion before neck dissection. The visibility and the diagnostic accuracy of the imaging were evaluated. RESULTS: SLNs were visualized in all eight cases; however, transcutaneous fluorescence detection was not observed in all cases. Utilizing color mode imaging simplified harvest by clearly discriminating SLNs from surrounding structures, while the monochrome mode proved to be more sensitive for detection. Two cases showed occult metastases on both sentinel and regional nodes. The identification and false negative rates were 100% and 0%, respectively. There were no complications incurred due to this method. CONCLUSION: Our results suggest that color FI with the HEMS allows for the accurate and safe harvest of SLNs with a preparatory skin incision. Although there is room for improvement of sensitivity, this easy-to-handle procedure might provide the potential to expand the role of the ICG method for SLN detection in head and neck cancer.

Preoperative S-1 Therapy for Head and Neck Carcinoma During the Waiting Period Before Surgery.

BACKGROUND/AIM: In patients with squamous cell carcinoma of the head and neck (SCCHN), delayed surgery can result in poorer postoperative function and prognosis due to the growth of the tumor and extended surgery. Further, delay may even make the tumor unresectable. To prevent tumor growth during the waiting period before surgery, S-1 has been administrated preoperatively at several facilities in Japan. To date, however, the safety and efficacy of preoperative S-1 remain unclear. PATIENTS AND METHODS: We conducted a retrospective cohort study of 118 patients with SCCHN treated with S-1 before radical surgery at 2 institutions in Japan. We evaluated the safety of S-1 therapy, which was evaluated by the incidence of grade 3 or greater adverse events (AEs). The rate of achievement of non-growth of tumors was also calculated. RESULTS: Regarding safety, 125 AEs of all grades were recorded in 71 patients (60%). Of these, grade 3 AEs were detected in 3 patients (3%), and no grade 4 or 5 AEs occurred. The nongrowth rate of primary lesions and lymph node metastases was 89% and 85%, respectively. CONCLUSION: Preoperative S-1 therapy might be useful, with acceptable toxicity, on an outpatient basis in patients with SCCHN.

Endoscopic submucosal dissection of cervical esophageal cancer with hypopharyngeal invasion using a curved laryngoscope.

Video 1Video describing the clinical course of this case, the endoscopic treatment method, and the histopathologic results.

Removal of a Giant Parapharyngeal Space Oncocytoma Without Osteotomy.

Oncocytoma arising from the parotid gland and extending into the parapharyngeal space (PPS) has not been previously reported. A 64-year-old woman presented with a large slowly growing mass extending from the parotid to the submandibular area, expanding medially to displace the pharynx across the midline. Core-needle biopsy revealed an oncocytoma in the PPS measuring 120 × 88 × 60 mm in size. Although the tumor was of an unprecedentedly large size and extended into multiple spaces, it could be removed via a cervical-parotid approach without osteotomy. The resected tumor was again diagnosed as oncocytoma. A postoperative complication was weakness of the ipsilateral facial nerve, which almost completely resolved in 6 months. No recurrence has been noted on 1 y follow-up. We were able to resect an extremely large oncocytoma arising from the parotid gland without osteotomy.

Transoral surgery for superficial head and neck cancer: National Multi-Center Survey in Japan.

Head and neck cancers, especially in hypopharynx and oropharynx, are often detected at advanced stage with poor prognosis. Narrow band imaging enables detection of superficial cancers and transoral surgery is performed with curative intent. However, pathological evaluation and real-world safety and clinical outcomes have not been clearly understood. The aim of this nationwide multicenter study was to investigate the safety and efficacy of transoral surgery for superficial head and neck cancer. We collected the patients with superficial head and neck squamous cell carcinoma who were treated by transoral surgery from 27 hospitals in Japan. Central pathology review was undertaken on all of the resected specimens. The primary objective was effectiveness of transoral surgery, and the secondary objective was safety including incidence and severity of adverse events. Among the 568 patients, a total of 662 lesions were primarily treated by 575 sessions of transoral surgery. The median tumor diameter was 12 mm (range 1-75) endoscopically. Among the lesions, 57.4% were diagnosed as squamous cell carcinoma in situ. The median procedure time was 48 minutes (range 2-357). Adverse events occurred in 12.7%. Life-threatening complications occurred in 0.5%, but there were no treatment-related deaths. During a median follow-up period of 46.1 months (range 1-113), the 3-year overall survival rate, relapse-free survival rate, cause-specific survival rate, and larynx-preservation survival rate were 88.1%, 84.4%, 99.6%, and 87.5%, respectively. Transoral surgery for superficial head and neck cancer offers effective minimally invasive treatment. Clinical trials registry number: UMIN000008276.

Evaluation of the usefulness of upper gastrointestinal endoscopy and the ValsamouthⓇ by an otolaryngologist in patients with Hypopharyngeal cancer.

OBJECTIVE: The aim of this retrospective study is to evaluate the usefulness of upper gastrointestinal endoscopy and the ValsamouthⓇ by an otolaryngologist in patients with hypopharyngeal cancer to assess the risk. METHODS: The study group comprised 41 patients with untreated hypopharyngeal cancer that was precisely diagnosed by an otolaryngologist using upper gastrointestinal endoscopy and the ValsamouthⓇ at our hospital from January 2016 to December 2017. With upper gastrointestinal endoscopy and the ValsamouthⓇ, the oral cavity, oropharynx, larynx, hypopharynx, and esophagus were observed in this order. Narrow-band imaging, and subsequently, white-light observation were performed. At the hypopharynx, vocalization, and subsequently, the Valsalva maneuver were performed. After observing the esophagus, Lugol chromoendoscopy of the esophagus was performed. RESULTS: The mean age of the 38 men and 3 women included in the study was 69.7 ± 10.0 years (range, 51-94 years). As for the T category of hypopharyngeal cancer, T1 cancer was observed in 9 patients, T2 cancer in 14, T3 cancer in 11, and T4 cancer in 7. With vocalization, the grade of visualization in the hypopharynx was 1 in 30 patients (73.2%), 2 in 11 patients (26.8%), and 3 or more in 0 patients (0.0%). With the Valsalva maneuver, the grade of visualization in the hypopharynx was 1 in 1 patient (2.4%), 2 in 15 patients (36.6%), 3 in 8 patients (19.5%), 4 in 11 patients (26.8%), and 5 in 6 patients (14.6%). The grade of visualization in the hypopharynx on average was 1.27 after vocalization and 3.15 after the Valsalva maneuver (p < 0.001). With vocalization, the percentage of patients in whom the entire image of hypopharyngeal cancer could be observed was 0.0% for grade 1 and 18.2% for grade 2. With the Valsalva maneuver, the percentage of patients in whom the entire image of hypopharyngeal cancer could be observed was 0.0% for grade 1, 40.0% for grade 2, 50.0% for grade 3, 86.1% for grade 4, and 100% for grade 5. Synchronous esophageal cancers were detected in 17.1% (7/41) of the patients. The grade of Lugol-voiding lesions was A in 5.6%, B in 52.8%, and C in 41.7%. CONCLUSION: The examination with upper gastrointestinal endoscopy and the ValsamouthⓇ by an otolaryngologist is feasible in patients with hypopharyngeal cancer. This procedure can detect synchronous esophageal cancer, allowing the risk of metachronous cancer in the head and neck or the esophagus to be recognized after the treatment.

Prediction of lymph-node metastasis and lymphatic invasion of superficial pharyngeal cancer on narrow band imaging with magnifying endoscopy.

OBJECTIVE: We studied factors related to lymphatic invasion and lymph-node metastasis in patients with superficial pharyngeal cancer who underwent transoral surgery. METHODS: The study group comprised 67 patients with superficial pharyngeal cancer (92 lesions) in whom squamous cell carcinoma was histopathologically diagnosed. The primary endpoint was clinicopathological findings according to the presence or absence of lymph-node metastasis, lymphatic invasion, or both. The secondary endpoints were (1) endoscopic findings according to the presence or absence of subepithelial invasion and (2) tumor thickness according to the endoscopic findings. RESULTS: Lymph-node metastasis, lymphatic invasion, or both were related to the white light findings of the main macroscopic type (p = 0.006), the NBI magnifying endoscopy findings of the classification of type B vessels (p = 0.005) and avascular area (AVA) (p = 0.003), and the histopathological findings of subepithelial invasion (p = 0.027), solitary nests (p = 0.013), venous invasion (p = 0.003), and tumor thickness (p = 0.028). The white light findings of white coat (p = 0.027), main macroscopic type (p = 0.005), and protruding type (p = 0.027) and the NBI magnifying endoscopy findings of the classification of type B vessels (p = 0.0002) were significantly related to subepithelial invasion. Tumor thickness was significantly related to the white light findings of white coat (p = 0.0002), main macroscopic type (p < 0.0001), protruding type (p < 0.0001), and mixed type (p = 0.017) and the NBI magnifying endoscopy findings of the classification of type B vessels (p < 0.0001) and AVA (p = 0.005). CONCLUSION: Detailed assessment by means of NBI magnifying endoscopy at the time of transoral surgery may contribute to the prediction of lymphatic invasion and lymph-node metastasis in patients with superficial pharyngeal cancer.

Usefulness of narrow band imaging with magnifying endoscopy for the differential diagnosis of cancerous and noncancerous laryngeal lesions.

BACKGROUND: We evaluated the accuracy of endoscopic findings observed by narrow band imaging (NBI) combined with magnifying gastrointestinal endoscopy (GIE) for the differential diagnosis of cancerous and noncancerous laryngeal lesions. METHODS: A total of 166 vocal cord lesions for which good images were obtained on NBI with magnifying GIE were evaluated with respect to the following 6 variables: macroscopic type, tumor location, color, white coat, keratinization, and abnormal microvessels. RESULTS: Multivariate analysis showed that white coat (odds ratio [OR], 2.95, P = 0.05), keratosis (OR, 3.14, P = 0.02) and abnormal microvessels (OR, 31.1, P < 0.0001) were significantly related to laryngeal cancer. In the diagnosis of laryngeal cancer, the sensitivity, specificity, positive predictive value, negative predictive value, and diagnostic accuracy of abnormal microvessels were 84.4%, 88.6%, 91%, 80.5%, and 86.1%, respectively. CONCLUSION: The abnormal microvessels on NBI combined with magnifying GIE are useful for the differential diagnosis of laryngeal lesions.

A retrospective study of treatment for curative synchronous double primary cancers of the head and neck and the esophagus.

OBJECTIVE: Curative synchronous double primary cancers of the head and neck and the esophagus (CSC-HE) are frequently detected, but a standard treatment remains to be established. We studied the clinical course to explore appropriate treatment strategies. METHODS: We retrospectively studied consecutive 33 patients who had CSC-HE. The disease stage was classified into 4 groups: group A, early head and neck cancer (HNC) and early esophageal cancer (EC); group B, early HNC and advanced EC; group C, advanced HNC and early EC; and group D, advanced HNC and advanced EC. As induction chemotherapy, the patients received 3 courses of TPF therapy (docetaxel 75mg/m2 on day 1, cisplatin 75mg/m2 on day 1, and 5-fluorouracil 750mg/m2 on days 1-5) at 3-week intervals. The clinical courses and treatment outcomes were studied according to the disease stage of CSC-HE. RESULTS: The disease stage of CSC-HE was group A in 1 patient (3%), group B in 9 patients (27.3%), group C in 3 patients (9.1%), and group D in 20 patients (60.6%). The median follow-up was 26months, and the 2-year overall survival rate was 67.4%. In groups A, B, and C, the 2-year overall survival rate was 83.3%. In group D, the 2-year overall survival rate was 62.6%. Ten of 20 patients in group D received induction chemotherapy with TPF, and 6 patients were alive and disease free at the time of this writing. CONCLUSION: The treatment outcomes of patients with CSC-HE were relatively good. TPF induction chemotherapy might be an effective treatment for patients with advanced HNC and advanced EC.

One hundred supracricoid laryngectomies with cricohyoidoepiglottopexy: do we achieve better local control?

OBJECTIVE: Supracricoid laryngectomy with cricohyoidoepiglottopexy has been known to be able to cope with tumor excisions with minimal margins. Extended resection may result in a limited margin and may impair the prognosis. We conducted a clinicopathologic analysis of local recurrence in supracricoid laryngectomy with cricohyoidoepiglottopexy patients. METHODS: Between 1997 and 2013, 100 patients with glottic cancers underwent supracricoid laryngectomy with cricohyoidoepiglottopexy. The clinicopathologic findings were evaluated. We also analyzed: (i) cancer-specific and overall survival rates, (ii) the correlation between locoregional recurrence and overall survival, (iii) T staging and larynx preservation rates and (iv) previous radiation history and larynx preservation rates. RESULTS: Local recurrence was recognized in eight of the 100 patients (8%); all were initially staged as T3 or T4. Recurrence was identified in the submucosal regions of the ipsilateral arytenoid and/or infraglottis. Six patients were salvaged by completion total laryngectomy except two. Cancer-specific survival at 5 years was 93%; overall survival at 5 years was 89%. There was no significant difference between overall survival and locoregional recurrence. There was a significant difference between larynx preservation in T1-2 and T3-4 patients. There was no significant difference between larynx preservation and the previous radiation therapy status. CONCLUSIONS: Our experience convinced us of the clinical potential of supracricoid laryngectomy with cricohyoidoepiglottopexy as one of the effective options for functional larynx preservation. Supracricoid laryngectomy with cricohyoidoepiglottopexy is the most suitable for unfavorable T2 and T3a cases and is applicable for appropriately selected radiation-failed patients. Thorough pre-operative evaluation, proper surgical techniques and careful follow-up are prerequisites for the success of supracricoid laryngectomy with cricohyoidoepiglottopexy.

Clinical outcomes of 849 laryngeal cancers treated in the past 40 years: are we succeeding?

OBJECTIVE: We analyzed the clinical outcomes of 849 laryngeal cancers treated in the past 40 years, which overlapped with the era of the global treatment shift. METHODS: To compare the chronological outcomes, patients were divided into four groups according to their registration year as 1972-82, 1983-92, 1993-2002 and 2003-12; treatment trends, larynx preservation rate and overall survival rate were compared. RESULTS: There were 104, 173, 253 and 319 patients registered in 1972-82, 1983-92, 1993-2002 and 2003-12, respectively. Five-year overall survival rates were 74, 76.5, 75.6 and 82.2% in 1972-82, 1983-92, 1993-2002 and 2003-12, respectively. The five-year larynx preservation rates were 65.5, 75.7, 75.4 and 80.9% in 1972-82, 1983-92, 1993-2002 and 2003-12, respectively. CONCLUSIONS: The number of patients treated at our institute increased, and the overall survival and larynx preservation rates exhibited favorable improvements over the past four decades. In the analysis of nonsurgical options, S1 combined radiotherapy showed superiority over concurrent chemoradiotherapy and radiotherapy in larynx preservation, and S1 combined radiotherapy, concurrent chemoradiotherapy and Tegafur Uracil combined radiotherapy showed superiority over radiotherapy in overall survival. In nonsurgical approaches, proper case selection is the key to success and may be much more important than pursuing radiotherapy dose escalation. In the analysis of surgical options, laser and supracricoid laryngectomy with cricohyoidoepiglottopexy contributed to larynx preservation in early- and intermediate-stage cancers, respectively. Supracricoid laryngectomy with cricohyoidoepiglottopexy demonstrated overall survival not worse than total laryngectomy, which is the prerequisite treatment basis for larynx preservation options. We must make extra efforts in pursuing an ideal balance between nonsurgical and surgical larynx preservation options.

A clinical study of transoral pharyngectomies to treat superficial hypopharyngeal cancers.

BACKGROUND: For years, it has been a major interest for surgeons and oncologists to develop a novel technique to detect hypopharyngeal cancers at an early stage and to treat the lesions in a less invasive manner. The advent of the narrow band imaging system combined endoscopy and various endoscopic approaches shed light on the new era of the minimum invasive management of superficial cancers in hypopharyngeal regions. METHODS: Three endoscopic approaches, endoscopic mucosal resection, endoscopic submucosal dissection and endoscopic laryngopharyngeal surgery, were chronologically introduced at our institute. In this study, we focused on the clinical outcomes, advantages and limitations of each procedure. RESULTS: A total of 30 patients (42 procedures) received transoral pharyngectomies between June 2006 and May 2012. Tracheotomy was performed in 9 of 42 (21%) patients. Three patients developed local recurrence and were subsequently controlled by additional transoral pharyngectomies. The 2- and 5-year local control rates were 92.8 and 83.5%. The 2- and 5-year overall survival rates were 82.1%. CONCLUSIONS: Endoscopic mucosal resection, endoscopic submucosal dissection and endoscopic laryngopharyngeal surgery-transoral pharyngectomies are useful procedures for treating superficial hypopharyngeal cancers. Endoscopic mucosal resection manifested the least invasiveness and may be beneficial for resecting small superficial lesions, endoscopic submucosal dissection may be advantageous for patients with difficult laryngopharyngeal exposure and endoscopic laryngopharyngeal surgery has shown the optimal effectiveness and minimal complications and can be applied to most of the hypopharyngeal sub-sites. All three procedures require a high level of technical skill and close collaboration between otolaryngologists and gastroenterologists.