ABSTRACT
High-touch environmental surfaces are acknowledged as potential sources of pathogen transmission, particularly in health care settings where infectious agents may be readily abundant. Methods of disinfecting these surfaces often include direct application of a chemical disinfectant or simply wiping the surface with a disinfectant pre-soaked wipe (DPW). In this study, we examine the ability of four disinfectants, ethanol (EtOH), sodium hypochlorite (NaOCl), chlorine dioxide (ClO2), and potassium monopersulfate (KMPS), to inactivate SARS-CoV-2 on a hard, non-porous surface, assessing the effects of concentration and contact time. The efficacy of DPWs to decontaminate carriers spiked with SARS-CoV-2, as well as the transferability of the virus from used DPWs to clean surfaces, is also assessed. Stainless steel carriers inoculated with approximately 6 logs of SARS-CoV-2 prepared in a soil load were disinfected within 5 min through exposure to 66.5% EtOH, 0.5% NaOCl, and 1% KMPS. The addition of mechanical wiping using DPWs impregnated with these biocides rendered the virus inactive almost immediately, with no viral transfer from the used DPW to adjacent surfaces. Carriers treated with 100 ppm of ClO2 showed a significant amount of viable virus remaining after 10 min of biocide exposure, while the virus was only completely inactivated after 10 min of treatment with 500 ppm of ClO2. Wiping SARS-CoV-2-spiked carriers with DPWs containing either concentration of ClO2 for 5 s left significant amounts of viable virus on the carriers. Furthermore, higher titers of infectious virus retained on the ClO2-infused DPWs were transferred to uninoculated carriers immediately after wiping. Overall, 66.5% EtOH, 0.5% NaOCl, and 1% KMPS appear to be highly effective biocidal agents against SARS-CoV-2, while ClO2 formulations are much less efficacious.
ABSTRACT
Shortages of personal protective equipment for use during the SARS-CoV-2 pandemic continue to be an issue among health-care workers globally. Extended and repeated use of N95 filtering facepiece respirators without adequate decontamination is of particular concern. Although several methods to decontaminate and re-use these masks have been proposed, logistic or practical issues limit adoption of these techniques. In this study, we propose and validate the use of the application of moist heat (70 °C with humidity augmented by an open pan of water) applied by commonly available hospital (blanket) warming cabinets to decontaminate N95 masks. This report shows that a variety of N95 masks can be repeatedly decontaminated of SARS-CoV-2 over 6 h moist heat exposure without compromise of their filtering function as assessed by standard fit and sodium chloride aerosol filtration efficiency testing. This approached can easily adapted to provide point-of-care N95 mask decontamination allowing for increased practical utility of mask recycling in the health care setting.
Subject(s)
Decontamination/methods , N95 Respirators/virology , SARS-CoV-2/physiology , Equipment Reuse , Hospitals , Humans , Humidity , Point-of-Care Systems , Time Factors , Virus InactivationABSTRACT
BACKGROUND: Few studies have quantified aerosol concentrations of SARS-CoV-2 in hospitals and long-term care homes, and fewer still have examined samples for viability. This information is needed to clarify transmission risks beyond close contact. METHODS: We deployed particulate air samplers in rooms with COVID-19 positive patients in hospital ward and ICU rooms, rooms in long-term care homes experiencing outbreaks, and a correctional facility experiencing an outbreak. Samplers were placed between 2 and 3 meters from the patient. Aerosol (small liquid particles suspended in air) samples were collected onto gelatin filters by Ultrasonic Personal Air Samplers (UPAS) fitted with <2.5µm (micrometer) and <10 µm size-selective inlets operated for 16 hours (total 1.92m3), and with a Coriolis Biosampler over 10 minutes (total 1.5m3). Samples were assayed for viable SARS-CoV-2 virus and for the viral genome by multiplex PCR using the E and N protein target sequences. We validated the sampling methods by inoculating gelatin filters with viable vesicular stomatitis virus (VSV), and with three concentrations of viable SARS-CoV-2, operating personal samplers for 16hrs, and quantifying viable virus recovery by TCID50 assay. RESULTS: In total, 138 samples were collected from 99 rooms. RNA samples were positive in 9.1% (6/66) of samples obtained with the UPAS 2.5µm samplers, 13.5% (7/52) with the UPAS 10µm samplers, and 10.0% (2/20) samples obtained with the Coriolis samplers. Culturable virus was not recovered in any samples. Viral RNA was detected in 15.1% of the rooms sampled. There was no significant difference in viral RNA recovery between the different room locations or samplers. Method development experiments indicated minimal loss of SARS-CoV-2 viability via the personal air sampler operation.
Subject(s)
Aerosols/isolation & purification , Air Microbiology , COVID-19/virology , SARS-CoV-2/isolation & purification , Animals , COVID-19/epidemiology , COVID-19/transmission , Chlorocebus aethiops , Hospitals , Humans , Long-Term Care , RNA, Viral/isolation & purification , Vero CellsABSTRACT
The authors evaluated four disinfectant pre-impregnated wipes (DPW) for efficacy against Ebola virus Makona variant (EBOV) and vesicular stomatitis virus (VSV), Indiana serotype. Steel carriers were inoculated with the infectious virus and then were wiped with DPW in the Wiperator instrument per ASTM E2967-15. Following the use of J-Cloth impregnated with medium (negative control wipes) or the use of activated hydrogen peroxide (AHP)-, ethanol-, sodium hypochlorite (NaOCl)-, or single or dual quaternary ammonium compound (QAC)-based DPW, virus recovery from the carriers was assayed by titration assay and by two passages on Vero E6 cells in 6-well plates. The Wiperator also enabled the measurement of potential transfer of the virus from the inoculated carrier to a secondary carrier by the DPW or control wipes. The J-Cloth wipes wetted with medium alone (no microbicidal active) removed 1.9-3.5 log10 of virus from inoculated carriers but transferred ~4 log10 of the wiped virus to secondary carriers. DPW containing AHP, ethanol, NaOCl, or single or dual QAC as active microbicidal ingredients removed/inactivated ~6 log10 of the virus, with minimal EBOV or no VSV virus transfer to a secondary surface observed. In Ebola virus outbreaks, a DPW with demonstrated virucidal efficacy, used as directed, may help to mitigate the unintended spread of the infectious virus while performing surface cleaning.
Subject(s)
Disinfectants , Ebolavirus , Hemorrhagic Fever, Ebola , Vesicular Stomatitis , Animals , Disinfectants/pharmacology , Hemorrhagic Fever, Ebola/prevention & control , Stainless SteelABSTRACT
The spread of COVID-19 in healthcare settings is concerning, with healthcare workers representing a disproportionately high percentage of confirmed cases. Although SARS-CoV-2 virus has been found to persist on surfaces for a number of days, the extent and duration of fomites as a mode of transmission, particularly in healthcare settings, has not been fully characterized. To shed light on this critical matter, the present study provides the first comprehensive assessment of SARS-CoV-2 stability on experimentally contaminated personal protective equipment (PPE) widely used by healthcare workers and the general public. Persistence of viable virus was monitored over 21 days on eight different materials, including nitrile medical examination gloves, reinforced chemical resistant gloves, N-95 and N-100 particulate respirator masks, Tyvek, plastic, cotton, and stainless steel. Unlike previous reports, viable SARS-CoV-2 in the presence of a soil load persisted for up to 21 days on experimentally inoculated PPE, including materials from filtering facepiece respirators (N-95 and N-100 masks) and a plastic visor. Conversely, when applied to 100% cotton fabric, the virus underwent rapid degradation and became undetectable by TCID50 assay within 24 h. These findings underline the importance of appropriate handling of contaminated PPE during and following use in high-risk settings and provide interesting insight into the potential utility of cotton in limiting COVID-19 transmission.
Subject(s)
Personal Protective Equipment , SARS-CoV-2/physiology , Porosity , RNA, Viral/genetics , SARS-CoV-2/genetics , Surface PropertiesABSTRACT
The response to the COVID-19 epidemic is generating severe shortages of personal protective equipment around the world. In particular, the supply of N95 respirator masks has become severely depleted, with supplies having to be rationed and health care workers having to use masks for prolonged periods in many countries. We sought to test the ability of 7 different decontamination methods: autoclave treatment, ethylene oxide gassing (ETO), low temperature hydrogen peroxide gas plasma (LT-HPGP) treatment, vaporous hydrogen peroxide (VHP) exposure, peracetic acid dry fogging (PAF), ultraviolet C irradiation (UVCI) and moist heat (MH) treatment to decontaminate a variety of different N95 masks following experimental contamination with SARS-CoV-2 or vesicular stomatitis virus as a surrogate. In addition, we sought to determine whether masks would tolerate repeated cycles of decontamination while maintaining structural and functional integrity. All methods except for UVCI were effective in total elimination of viable virus from treated masks. We found that all respirator masks tolerated at least one cycle of all treatment modalities without structural or functional deterioration as assessed by fit testing; filtration efficiency testing results were mostly similar except that a single cycle of LT-HPGP was associated with failures in 3 of 6 masks assessed. VHP, PAF, UVCI, and MH were associated with preserved mask integrity to a minimum of 10 cycles by both fit and filtration testing. A similar result was shown with ethylene oxide gassing to the maximum 3 cycles tested. Pleated, layered non-woven fabric N95 masks retained integrity in fit testing for at least 10 cycles of autoclaving but the molded N95 masks failed after 1 cycle; filtration testing however was intact to 5 cycles for all masks. The successful application of autoclaving for layered, pleated masks may be of particular use to institutions globally due to the virtually universal accessibility of autoclaves in health care settings. Given the ability to modify widely available heating cabinets on hospital wards in well-resourced settings, the application of moist heat may allow local processing of N95 masks.
Subject(s)
Decontamination/methods , Equipment Reuse , N95 Respirators/virology , COVID-19/pathology , COVID-19/virology , Ethylene Oxide/pharmacology , Humans , Hydrogen Peroxide/pharmacology , Peracetic Acid/pharmacology , Plasma Gases/pharmacology , SARS-CoV-2/drug effects , SARS-CoV-2/isolation & purification , SARS-CoV-2/radiation effects , Ultraviolet Rays , Vesiculovirus/drug effects , Vesiculovirus/radiation effectsABSTRACT
Microbicides play critical roles in infection prevention and control of Ebola virus by decontaminating high-touch environmental surfaces (HITES), interrupting the virus-HITES-hands nexus. We evaluated the efficacy of formulations containing different microbicidal actives for inactivating Ebola virus-Makona strain (EBOV/Mak) on stainless-steel carriers per ASTM E2197-11. Formulations of sodium hypochlorite (NaOCl) (0.05-1%), ethanol (70%), chloroxylenol (PCMX) (0.12-0.48% by weight) in hard water, and a ready-to-use disinfectant spray with 58% ethanol (EDS), were tested at contact times of 0, or 0.5 to 10 min at ambient temperature. EBOV/Mak was inactivated (> 6 log10) by 70% ethanol after contact times ≥ 2.5 min, by 0.5% and 1% NaOCl or EDS (> 4 log10) at contact times ≥ 5 min, and by 0.12-0.48% PCMX (> 4.2 log10) at contact times ≥ 5 min. Residual infectious virus in neutralized samples was assessed by passage on cells and evaluation for viral cytopathic effect. No infectious virus was detected in cells inoculated with EBOV/Mak exposed to NaOCl (0.5% or 1%), PCMX (0.12% to 0.48%), or EDS for ≥ 5 min. These results demonstrate ≥ 6 log10 inactivation of EBOV/Mak dried on prototypic surfaces by EDS or formulations of NaOCl (≥ 0.5%), PCMX (≥ 0.12%), or 70% ethanol at contact times ≥ 5 min.
Subject(s)
Anti-Infective Agents/pharmacology , Ebolavirus/drug effects , Hemorrhagic Fever, Ebola/prevention & control , Virus Inactivation/drug effects , Animals , Chlorocebus aethiops , Cytopathogenic Effect, Viral/drug effects , Disinfectants/pharmacology , Ebolavirus/pathogenicity , Environmental Microbiology , Ethanol/pharmacology , Hemorrhagic Fever, Ebola/transmission , Hemorrhagic Fever, Ebola/virology , Humans , In Vitro Techniques , Porosity , Sodium Hypochlorite/pharmacology , Surface Properties , Vero Cells , Xylenes/pharmacologyABSTRACT
Disinfectant pre-soaked wipes (DPW) containing activated hydrogen peroxide (AHP) or quaternary ammonium compounds (QAC) were tested using ASTM E2967-15 to determine removal, transfer, and inactivation of Ebola virus Makona variant (EBOV/Mak) and vesicular stomatitis virus (VSV) from contaminated stainless steel prototypic environmental surfaces. The infectious virus-contaminated carriers were subjected to wiping in the Wiperator per the standard. Following the use of negative control (J-Cloth)-, AHP-, or QAC-based wipes, recovery of residual infectious virus was assayed. In the case of the J-Cloth wipes (negative control), although removal of virus from inoculated carriers was extensive i.e., ~99% (1.9-3.5 log10) transfer of virus by these wipes to a secondary surface amounted to ≤ 2% (~3.8 log10) of the initial virus load. In the case of each DPW, >6 log10 removal/inactivation of virus was observed, with limited (EBOV/Mak) or no (VSV) virus transfer observed. The efficacy of wipes for decontaminating high-touch environmental surfaces spiked with EBOV/Mak or VSV is discussed. In summary, removal of EBOV/Mak and VSV using wipes was extensive in this study. In the absence of a sufficient concentration and contact time of an appropriate microbicidal active in DPW (such as the AHP- and QAC-based DPW tested), transfer of a low, albeit significant (from an infectious unit/infectious dose perspective), quantity of infectious virus from the inoculated surface to a secondary surface was observed. In the case of Ebola virus, it is essential that a DPW with an appropriate microbicidal active, following the appropriate contact time, be used to prevent unintended transfer of infectious virus to a clean secondary surface (as observed in negative control /J-Cloth). Otherwise, there exists the possibility of dissemination of Ebola virus and the associated risk of transmission of Ebola virus disease.
Subject(s)
Disinfectants , Ebolavirus , Hemorrhagic Fever, Ebola , Vesicular Stomatitis , Animals , Hemorrhagic Fever, Ebola/prevention & control , VesiculovirusABSTRACT
The importance of pigs in interspecies transmission of influenza A viruses has been repeatedly demonstrated over the last century. Eleven influenza A viruses from avian, human and swine hosts were evaluated for replication phenotypes at three physiologically relevant temperatures (41°C, 37°C, 33°C) in an immortalized swine pulmonary alveolar macrophage cell line (IPAM 3D4/31) to determine whether this system would allow for their efficient replication. All isolates replicated well in IPAMs at 37°C while clear distinctions were observed at 41°C and 33°C, correlating to species of origin of the PB2, reflected in distinct amino acid residue profiles rather than in one particular PB2 residue. A strong TNF-α response was induced by some mammalian but not avian IAVs, while other selected cytokines remained below detection levels. Porcine IPAMs represent a natural host cell model for influenza virus replication where the only condition requiring modification for optimal IAV replication, regardless of virus origin.
Subject(s)
Influenza A virus/physiology , Influenza in Birds/virology , Influenza, Human/virology , Macrophages, Alveolar/virology , Orthomyxoviridae Infections/veterinary , Swine Diseases/virology , Virus Replication , Animals , Birds , Humans , Influenza A virus/genetics , Influenza A virus/isolation & purification , Influenza in Birds/immunology , Macrophages, Alveolar/immunology , Orthomyxoviridae Infections/immunology , Orthomyxoviridae Infections/virology , Swine , Swine Diseases/immunology , Tumor Necrosis Factor-alpha/immunology , Virus CultivationABSTRACT
UNLABELLED: Pancreatic ductal adenocarcinoma (PDA) is the most lethal form of human cancer, with dismal survival rates due to late-stage diagnoses and a lack of efficacious therapies. Building on the observation that avian influenza A viruses (IAVs) have a tropism for the pancreas in vivo, the present study was aimed at testing the efficacy of IAVs as oncolytic agents for killing human PDA cell lines. Receptor characterization confirmed that human PDA cell lines express the alpha-2,3- and the alpha-2,6-linked glycan receptor for avian and human IAVs, respectively. PDA cell lines were sensitive to infection by human and avian IAV isolates, which is consistent with this finding. Growth kinetic experiments showed preferential virus replication in PDA cells over that in a nontransformed pancreatic ductal cell line. Finally, at early time points posttreatment, infection with IAVs caused higher levels of apoptosis in PDA cells than gemcitabine and cisplatin, which are the cornerstone of current therapies for PDA. In the BxPC-3 PDA cell line, apoptosis resulted from the engagement of the intrinsic mitochondrial pathway. Importantly, IAVs did not induce apoptosis in nontransformed pancreatic ductal HPDE6 cells. Using a model based on the growth of a PDA cell line as a xenograft in SCID mice, we also show that a slightly pathogenic avian IAV significantly inhibited tumor growth following intratumoral injection. Taken together, these results are the first to suggest that IAVs may hold promise as future agents of oncolytic virotherapy against pancreatic ductal adenocarcinomas. IMPORTANCE: Despite intensive studies aimed at designing new therapeutic approaches, PDA still retains the most dismal prognosis among human cancers. In the present study, we provide the first evidence indicating that avian IAVs of low pathogenicity display a tropism for human PDA cells, resulting in viral RNA replication and a potent induction of apoptosis in vitro and antitumor effects in vivo. These results suggest that slightly pathogenic IAVs may prove to be effective for oncolytic virotherapy of PDA and provide grounds for further studies to develop specific and targeted viruses, with the aim of testing their efficacy in clinical contexts.