Use of Mixed Microbial Cultures to Protect Recycled Concrete Surfaces: A Preliminary Study.

One approach to tackle the problems created by the vast amounts of construction and demolition waste (CDW) generated worldwide while at the same time lengthening concrete durability and service life is to foster the use of recycled aggregate (RA) rather than natural aggregate (NA). This article discusses the use of polyhydroxyalkanoates (PHAs)-producing mixed microbial cultures (MMCs) to treat the surface of recycled concrete with a view to increase its resistance to water-mediated deterioration. The microorganisms were cultured in a minimal medium using waste pinewood bio-oil as a carbon source. Post-application variations in substrate permeability were determined with the water drop absorption and penetration by water under pressure tests. The significant reduction in water absorption recorded reveals that this bioproduct is a promising surface treatment for recycled concrete.

Use of Bioproducts Derived from Mixed Microbial Cultures Grown with Crude Glycerol to Protect Recycled Concrete Surfaces.

The large increase in the world population has resulted in a very large amount of construction waste, as well as a large amount of waste glycerol from transesterification reactions of acyl glycerides from oils and fats, in particular from the production of biodiesel. Only a limited percentage of these two residues are recycled, which generates a large management problem worldwide. For that reason, in this study, we used crude glycerol as a carbon source to cultivate polyhydroxyalkanoates (PHA)-producing mixed microbial cultures (MMC). Two bioproducts derived from these cultures were applied on the surface of concrete with recycled aggregate to create a protective layer. To evaluate the effect of the treatments, tests of water absorption by capillarity and under low pressure with Karsten tubes were performed. Furthermore, SEM-EDS analysis showed the physical barrier caused by biotreatments that produced a reduction on capillarity water absorption of up to 20% and improved the impermeability of recycled concrete against the penetration of water under pressure up to 2.7 times relative to the reference. Therefore, this bioproduct shown to be a promising treatment to protect against penetration of water to concrete surfaces increasing its durability and useful life.

Ethylenediamine-N,N'-diglutaric acid (EDDG) as a promising biodegradable chelator: quantification, complexation and biodegradation.

[S,S]-ethylenediamine-N,N'-diglutaric acid (EDDG) has been gaining interest in the industrial sector as a promising chelator. In this study, the effective metal complexing capacity of EDDG over a wide pH range was modelled and its biodegradability assessed. Results showed that EDDG could effectively bind to several metallic ions in a wide pH range and was completely biodegraded after approximately 15 days by un-acclimatized sludge. To confirm its biodegradability, an accurate quantification method based on the combination of liquid chromatography and tandem quadrupole mass spectrometry (LC-MS/MS) was developed. Good linearity of the detector response was found for EDDG at concentrations ranging from 0.15 to 1.2 mg/L.

Desulfovibrio marrakechensis sp. nov., a 1,4-tyrosol-oxidizing, sulfate-reducing bacterium isolated from olive mill wastewater.

A novel mesophilic sulfate-reducing bacterium, EMSSDQ(4)(T), was isolated from olive mill wastewater in the semi-arid region of Morocco (Marrakech). Cells were Gram-negative, catalase-positive, straight rods that were non-motile and non-spore-forming and contained cytochrome c(3) and desulfoviridin. The DNA G+C content was 65.1 mol%. Phylogenetic analysis based on 16S rRNA gene sequences revealed that the isolate was a member of the genus Desulfovibrio with Desulfovibrio carbinoliphilus D41(T), Desulfovibrio alcoholivorans SPSN(T), Desulfovibrio fructosivorans JJ(T) and Desulfovibrio carbinolicus EDK82(T) as the most closely related strains with validly published names. In addition to the classical substrates used by Desulfovibrio species, the isolate oxidized 1,4-tyrosol, one of the most abundant phenolic compounds occurring in olive mill wastewater, to 4-hydroxyphenylacetate without ring cleavage. D. alcoholivorans SPSN(T) was also found to carry out this reaction. Under air, strain EMSSDQ(4)(T) exhibited limited growth on lactate and yeast extract in the absence of sulfate. On the basis of genotypic and phenotypic characteristics, it is proposed that the isolate represents a novel species, Desulfovibrio marrakechensis sp. nov. The type strain is EMSSDQ(4)(T) (=DSM 19337(T) =ATCC BAA-1562(T)).