Optimization of CO2 Supply for the Intensive Cultivation of Chlorella sorokiniana IPPAS C-1 in the Laboratory and Pilot-Scale Flat-Panel Photobioreactors.

Microalgae are increasingly being used for capturing carbon dioxide and converting it into valuable metabolites and biologically active compounds on an industrial scale. The efficient production of microalgae biomass requires the optimization of resources, including CO2. Here, we estimated the productivity of Chlorella sorokiniana IPPAS C-1 depending on CO2 concentrations and the ventilation coefficient of the gas-air mixture (GAM) in flat-panel photobioreactors (FP-PBRs) at laboratory (5 L) and pilot (18 L) scales. For the laboratory scale, the PBRs operated at 900 µmol quanta m-2 s-1 and 35.5 ± 0.5 °C; the optimal CO2 flow rate was estimated at 3 mL CO2 per 1 L of suspension per minute, which corresponds to 1.5% CO2 in the GAM and an aeration rate of 0.2 vvm. These parameters, being scaled up within the pilot PBRs, resulted in a high specific growth rate (µ ≈ 0.1 h-1) and high specific productivity (Psp ≈ 1 g dw L-1 d-1). The principles of increasing the efficiency of the intensive cultivation of C. sorokiniana IPPAS C-1 are discussed. These principles are relevant for the development of technological regimes for the industrial production of Chlorella in flat-panel PBRs of various sizes.

Cultivation of Chlorella sorokiniana IPPAS C-1 in Flat-Panel Photobioreactors: From a Laboratory to a Pilot Scale.

Flat-panel photobioreactors are effective systems for microalgae cultivation. This paper presents the growth characteristics of the microalgae Chlorella sorokiniana IPPAS C-1 as a result of three-stage scale-up cultivation in a specially designed cultivation system. First, C. sorokiniana was grown aseptically in 250 mL glass vessels; then, it was diluted and inoculated into a 5-liter flat-panel horizontal photobioreactor; and, at the last stage, the culture was diluted and inoculated into a 70-liter flat-panel vertical photobioreactor. In the presented cycle, the cultured biomass increased by 326 times in 13 days (from 0.6 to 195.6 g dw), with a final biomass concentration of 2.8 g dw L-1. The modes of semi-continuous cultivation were considered. The biomass harvest and dilution of the suspension were carried out either every day or every 3-4 days. For C. sorokiniana IPPAS C-1, a conversion coefficient of optical density values to dry biomass (g L-1) was refined through a factor of 0.33. The key parameters of the photobioreactors tested in this work are discussed.

Effect of salt stress on physiological parameters of microalgae Vischeria punctata strain IPPAS H-242, a superproducer of eicosapentaenoic acid.

The strain IPPAS H-242 is an eustigmatophycean alga with good growth characteristics and high content of the long chain polyunsaturated eicosapentaenoic fatty acid (EPA) - a very-long-chain fatty acid with high nutraceutical value. In this study, based on 18S rRNA gene and ITS1-5.8S-ITS2 sequences the strain IPPAS H-242 was identified as an authentic strain of Vischeria punctata. The effect of salt stress (0.5 M NaCl) on growth, cell morphology, ultrastructure, and biochemical composition with the emphasis on the fatty acid (FA) profile was investigated in batch cultures. Under salt stress, biomass accumulation and cell division were severely inhibited; cells were bigger, with higher chloroplast volume and numerous mitochondria, they had more proteins (73 % from the initial concentration as compared to 23 % in control) and their lipids had higher EPA proportion (13.6 % of total FA as compared to 6.4 % of total FA in control). In salt-stressed cells, thylakoid organization and photosynthetic activity were impaired, and D1 protein content decreased to trace amounts. In spite of an increase in EPA proportion in total FA, salt stress causes a decrease in total EPA productivity (49 mg/L as compared to 130 mg/L in control).

Identification and functional role of the carbonic anhydrase Cah3 in thylakoid membranes of pyrenoid of Chlamydomonas reinhardtii.

The distribution of the luminal carbonic anhydrase Cah3 associated with thylakoid membranes in the chloroplast and pyrenoid was studied in wild-type cells of Chlamydomonas reinhardtii and in its cia3 mutant deficient in the activity of the Cah3 protein. In addition, the effect of CO(2) concentration on fatty acid composition of photosynthetic membranes was examined in wild-type cells and in the cia3 mutant. In the cia3 mutant, the rate of growth was lower as compared to wild-type, especially in the cells grown at 0.03% CO(2). This might indicate a participation of thylakoid Cah3 in the CO(2)-concentrating mechanism (CCM) of chloroplast and reflect the dysfunction of the CCM in the cia3 mutant. In both strains, a decrease in the CO(2) concentration from 2% to 0.03% caused an increase in the content of polyunsaturated fatty acids in membrane lipids. At the same time, in the cia3 mutant, the increase in the majority of polyunsaturated fatty acids was less pronounced as compared to wild-type cells, whereas the amount of 16:4ω3 did not increase at all. Immunoelectron microscopy demonstrated that luminal Cah3 is mostly located in the thylakoid membranes that pass through the pyrenoid. In the cells of CCM-mutant, cia3, the Cah3 protein was much less abundant, and it was evenly distributed throughout the pyrenoid matrix. The results support our hypothesis that CO(2) might be generated from HCO(3)(-) by Cah3 in the thylakoid lumen with the following CO(2) diffusion into the pyrenoid, where the CO(2) fixing Rubisco is located. This ensures the maintenance of active photosynthesis under CO(2)-limiting conditions, and, as a result, the active growth of cells. The relationships between the induction of CCM and restructuring of the photosynthetic membranes, as well as the involvement of the Cah3 of the pyrenoid in these events, are discussed. This article is part of a Special Issue entitled: Photosynthesis Research for Sustainability: from Natural to Artificial.

Extracellular ß-class carbonic anhydrase of the alkaliphilic cyanobacterium Microcoleus chthonoplastes.

The gene for ß-class carbonic anhydrase (CA), which was designated as cahB1, was cloned from the genomic library of the alkaliphilic cyanobacterium Microcoleus chthonoplastes. The product of the cahB1 gene was expressed in Escherichia coli. The protein revealed high specific activity of CA, which was inhibited with ethoxyzolamide. The maximum activity of the recombinant CA was detected at alkaline pH (∼9.0) and its minimum - at neutral pH (∼7.0). Western blotting analysis with the antibodies raised against the recombinant CahB1 protein revealed its localization in cell envelopes of M. chthonoplastes. Immunocytochemical localization of the CahB1 in cells confirmed its extracellular location. The newly characterized CahB1 of Microcoleus was similar in amino acid and nucleotide sequences to well known ß-CAs of Synechococcus sp. PCC 7942 (IcfA) and Synechocystis sp. PCC 6803 (CcaA), although those CAs were attributed to the carboxysomal shells of cyanobacteria. Previously we have reported ß-class CA which was associated with PS II of alkaliphilic cyanobacteria. Here we first report extracellular localization of ß-class CA and provide a scheme for its possible involvement in the maintenance of a balance between external sources of inorganic carbon and photosynthesis in extreme environments of soda lakes.

The thylakoid carbonic anhydrase associated with photosystem II is the component of inorganic carbon accumulating system in cells of halo- and alkaliphilic cyanobacterium Rhabdoderma lineare.

The organization of carbonic anhydrase (CA) system in halo- and alkaliphilic cyanobacterium Rhabdoderma lineare was studied by Western blot analysis and immunocytochemical electron microscopy. The presence of putative extracellular alpha-CA of 60 kDa in the glycocalyx, forming a tight sheath around the cell, and of two intracellular beta-CA is reported. We show for the first time that the beta-CA of 60 kDa is expressed constitutively and associated with polypeptides of photosystem II (beta-CA-PS II). Another soluble beta-CA of 25 kDa was induced in low-bicarbonate medium. Induction of synthesis of the latter beta-CA was accompanied by an increase in the intracellular pool of inorganic carbon, which suggests an important role of this enzyme in the functioning of a CO(2)-concentrating mechanism.