Safety and Immunogenicity of Inactivated Whole Virion COVID-19 Vaccine CoviVac in Clinical Trials in 18-60 and 60+ Age Cohorts.

We present the results of a randomized, double-blind, placebo-controlled, multi-center clinical trial phase I/II of the tolerability, safety, and immunogenicity of the inactivated whole virion concentrated purified coronavirus vaccine CoviVac in volunteers aged 18-60 and open multi-center comparative phase IIb clinical trial in volunteers aged 60 years and older. The safety of the vaccine was assessed in 400 volunteers in the 18-60 age cohort who received two doses of the vaccine (n = 300) or placebo (n = 100) and in 200 volunteers in 60+ age cohort all of whom received three doses of the vaccine. The studied vaccine has shown good tolerability and safety. No deaths, serious adverse events (AEs), or other significant AEs related to vaccination have been detected. The most common AE in vaccinated participants was pain at the injection site (p < 0.05). Immunogenicity assessment in stage 3 of Phase II was performed on 167 volunteers (122 vaccinated and 45 in Placebo Group) separately for the participants who were anti-SARS-CoV-2 nAB negative (69/122 in Vaccine Group and 28/45 in Placebo Group) or positive (53/122 in Vaccine Group and 17/45 in Placebo Group) at screening. On Day 42 after the 1st vaccination, the seroconversion rate in participants who were seronegative at screening was 86.9%, with the average geometric mean neutralizing antibody (nAB) titer of 1:20. A statistically significant (p < 0.05) increase in IFN-γ production by peptide-stimulated T-cells was observed at Days 14 and 21 after the 1st vaccination. In participants who were seropositive at screening but had nAB titers below 1:256, the rate of fourfold increase in nAB levels was 85.2%, while in the participants with nAB titers > 1:256, the rate of fourfold increase in nAB levels was below 45%; the participants who were seropositive at screening of the 2nd vaccination did not lead to a significant increase in nAB titers. In conclusion, inactivated vaccine CoviVac has shown good tolerability and safety, with over 85% NT seroconversion rates after complete vaccination course in participants who were seronegative at screening in both age groups: 18-60 and 60+. In participants who were seropositive at screening and had nAB titers below 1:256, a single vaccination led to a fourfold increase in nAB levels in 85.2% of cases. These findings indicate that CoviVac can be successfully used both for primary vaccination in a two-dose regimen and for booster vaccination as a single dose in individuals with reduced neutralizing antibody levels.

Methodology of Purification of Inactivated Cell-Culture-Grown SARS-CoV-2 Using Size-Exclusion Chromatography.

Various types of COVID-19 vaccines, including adenovirus, mRNA, and inactivated ones, have been developed and approved for clinical use worldwide. Inactivated vaccines are produced using a proven technology that is widely used for the production of vaccines for the prevention and control of infectious diseases, including influenza and poliomyelitis. The development of inactivated whole-virion vaccines commonly includes several stages: the production of cellular and viral biomass in cell culture; inactivation of the virus; filtration and ultrafiltration; chromatographic purification of the viral antigen; and formulation with stabilizers and adjuvants. In this study, the suitability of four resins for Size-Exclusion Chromatography was investigated for the purification of a viral antigen for the human COVID-19 vaccine.

Vaccination With Oral Polio Vaccine Reduces COVID-19 Incidence.

Background: Effective response to emerging pandemic threats is complicated by the need to develop specific vaccines and other medical products. The availability of broadly specific countermeasures that could be deployed early in the pandemic could significantly alter its course and save countless lives. Live attenuated vaccines (LAVs) were shown to induce non-specific protection against a broad spectrum of off-target pathogens by stimulating innate immune responses. The purpose of this study was to evaluate the effect of immunization with bivalent Oral Poliovirus Vaccine (bOPV) on the incidence of COVID-19 and other acute respiratory infections (ARIs). Methods and Findings: A randomized parallel-group comparative study was conducted in Kirov Medical University. 1115 healthy volunteers aged 18 to 65 were randomized into two equal groups, one of which was immunized orally with a single dose of bOPV "BiVac Polio" and another with placebo. The study participants were monitored for three months for respiratory illnesses including COVID-19. The endpoint was the incidence of acute respiratory infections and laboratory confirmed COVID-19 in both groups during 3 months after immunization. The number of laboratory-confirmed cases of COVID-19 was significantly lower in the vaccinated group than in placebo (25 cases vs. 44, p=0.036). The difference between the overall number of clinically diagnosed respiratory illnesses in the two groups was not statistically significant. Conclusions: Immunization with bOPV reduced the number of laboratory-confirmed COVID-19 cases, consistent with the original hypothesis that LAVs induce non-specific protection against off-target infections. The findings are in line with previous observations of the protective effects of OPV against seasonal influenza and other viral and bacterial pathogens. The absence of a statistically significant effect on the total number of ARIs may be due to the insufficient number of participants and heterogeneous etiology of ARIs. OPV could be used to complement specific coronavirus vaccines, especially in regions of the world where the vaccines are unavailable, and as a stopgap measure for urgent response to future emerging infections. Clinical trial registration number NCT05083039 at clinicaltrals.gov https://clinicaltrials.gov/ct2/show/NCT05083039?term=NCT05083039&draw=2&rank=1.

Structural characterization of ß-propiolactone inactivated severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) particles.

The severe COVID-19 pandemic drives the research toward the SARS-CoV-2 virion structure and the possible therapies against it. Here, we characterized the ß-propiolactone inactivated SARS-CoV-2 virions using transmission electron microscopy (TEM) and atomic force microscopy (AFM). We compared the SARS-CoV-2 samples purified by two consecutive chromatographic procedures (size exclusion chromatography [SEC], followed by ion-exchange chromatography [IEC]) with samples purified by ultracentrifugation. The samples prepared using SEC and IEC retained more spikes on the surface than the ones prepared using ultracentrifugation, as confirmed by TEM and AFM. TEM showed that the spike (S) proteins were in the pre-fusion conformation. Notably, the S proteins could be recognized by specific monoclonal antibodies. Analytical TEM showed that the inactivated virions retained nucleic acid. Altogether, we demonstrated that the inactivated SARS-CoV-2 virions retain the structural features of native viruses and provide a prospective vaccine candidate.

Long-term humoral immunogenicity, safety and protective efficacy of inactivated vaccine against COVID-19 (CoviVac) in preclinical studies.

The unprecedented in recent history global COVID-19 pandemic urged the implementation of all existing vaccine platforms to ensure the availability of the vaccines against COVID-19 to every country in the world. Despite the multitude of high-quality papers describing clinical trials of different vaccine products, basic detailed data on general toxicity, reproductive toxicity, immunogenicity, protective efficacy and durability of immune response in animal models are scarce. Here, we developed a ß-propiolactone-inactivated whole virion vaccine CoviVac and assessed its safety, protective efficacy, immunogenicity and stability of the immune response in rodents and non-human primates. The vaccine showed no signs of acute/chronic, reproductive, embryo- and fetotoxicity, or teratogenic effects, as well as no allergenic properties in studied animal species. The vaccine induced stable and robust humoral immune response both in form of specific anti-SARS-CoV-2 IgG and NAbs in mice, Syrian hamsters, and common marmosets. The NAb levels did not decrease significantly over the course of one year. The course of two immunizations protected Syrian hamsters from severe pneumonia upon intranasal challenge with the live virus. Robustness of the vaccine manufacturing process was demonstrated as well. These data encouraged further evaluation of CoviVac in clinical trials.