ABSTRACT
AIM: To study the effect of growth factors and microelements in composition of ethanol-, n-hexadecane- and glycerol-containing media on antiadhesive properties of A cinetobacter calcoaceticus IMV B-7241 surfactants. METHODS: Surfactants were extracted from supernatant of cultural liquid by mixture of chloroform and methanol (2:1). The number (%) of attached cells (adhesion) was determined as a ratio of the optical density of the suspension obtained from the materials treated with surfactants to the optical density of the control samples (100 %). RESULTS: Dependence of surfactants antiadhesive properties on presence in the medium of A. calcoaceticus IMB B-7241 cultivation of growth factors and certain microelements, as well as the nature of the carbon source was established. Adhesion of bacteria (Escherichia coli IEM- 1, Bacillus subtilis BT-2) and yeast (Candida albicans D-6) on plastic, dutch tile, linoleum, and steel was a minimal (25-35 %) after surface treatment with surfactant (0.005 mg/ml) synthesized on ethanol in the presence of yeast autolysate and microelements. Replacement the yeast autolysate and microelement mixture in the composition of ethanol- and n-hexadecane-containing media by copper sulfate and iron sulfate and in the medium with glycerol by KCl, zinc sulfate and copper sulfate accompanied by decreasing antiadhesive properties of synthesized surfactants. CONCLUSIONS: The obtained data indicate that the increasing surfactant synthesis does not always the accompanied by the formation of product with the required biological properties and indicate the need for studies depending on biological properties of surfactants of the cultivation conditions of producer.
Subject(s)
Acinetobacter calcoaceticus/metabolism , Bacterial Adhesion/drug effects , Industrial Microbiology/methods , Surface-Active Agents/pharmacology , Acinetobacter calcoaceticus/cytology , Bacillus subtilis/drug effects , Candida albicans/drug effects , Culture Media/chemistry , Escherichia coli/drug effects , Surface-Active Agents/isolation & purificationABSTRACT
Aim: To study of antimicrobial and antiadhesive properties of the surface-active substances (surfactants) Nocardia vaccinii IMV B-7405 synthesized on different oil-containing substrates (refined and waste after frying meat and potatoes sunflower oil). Methods: Surfactants were extracted from supernatant of cultural liquid by mixture of chloroform and methanol (2 : 1). Antimicrobial against bacteria and yeast properties of the surfactant was determined by index of the minimum inhibitory concentration (MIC). The number (%) of attached cells (adhesion) was determined as a ratio of the optical density of the suspension obtained from the materials treated with surfactants to the optical density of the control samples (100 %). Results: It was established that surfactants synthesized N. vaccinii IMV B-7405 on fried oil, at a concentration of 0.02 - 0.04 mg/ml decreased adhesion of bacteria (Escherichia coli IEM-1, Bacillus subtilis BT-2) on plastic, dutch tile, glass and linoleum by 25-90 %, and yeast Candida albicans Ð-6 - by 15 - 65 %. The minimum inhibitory concentration with respect to studied test cultures surfactants synthesized on waste after frying potato oil was 8 - 67 mg/ml, and against phytopathogenic bacteria Pectobacterium carotovorum UCM B-1095, Pseudomonas syringae pv. atrofaciens UCM B-1015 and Xanthomonas campestris pv. campestris UCM B-1049 - 14 - 52 mg/ml. Conclusions: Replacing traditional substrates on fried oil can not only reduce cost of N. vaccinii IMV B-7405 surfactant biosynthesis, but also to obtain the final product with high antiadhesive and antimicrobial properties. The dependence of antiadhesive and antimicrobial potential of surfactants on the nature of the carbon source indicate the need for studies effect of cultivation conditions of producer on biological properties of synthesized surfactants.
Subject(s)
Nocardia , Sunflower Oil , Surface-Active Agents/chemistry , Bacillus subtilis/drug effects , Bacterial Adhesion/drug effects , Candida albicans/drug effects , Escherichia coli/drug effects , Microbial Sensitivity TestsABSTRACT
Aim: To study the antimicrobial properties of the surface-active agents (surfactants) Acinetobacter calcoaceticus IMV B-7241 depending on the availability of yeast autolysate and trace elements in the composition of ethanol-, n-hexadecane- and glycerol-containing media. Methods: Antimicrobial against bacteria (Escherichia coli IEM-1, Bacillus subtilis BT-2), and yeast (Candida albicans D-6) properties of the surfactant was determined by index of the minimum inhibitory concentration (MIC). Surfactants were extracted from supernatant of cultural liquid by mixture of chloroform and methanol (2:1). Results: The removal from cultivation medium yeast autolysate and trace element mix and replacing them by copper sulfate and iron sulphate in the medium with ethanol and n-hexadecane, and in the medium with glycerol - by potassium chloride, zinc sulfate and copper sulfate accompanied by decreasing antimicrobial properties of surfactants. The most effective antimicrobial agents were surfactant synthesized on ethanol in the presence of yeast autolysate and trace elements (MIC 9-20 µ/ml), whereas the surfactant obtained under similar cultivation conditions on glycerol and n-hexadecane, inhibited growth of tested bacteria and yeast at higher (9-68 and 27-54 µ/ml, respectively) concentrations. The minimum inhibitory concentration of surfactant, synthesized in a medium with ethanol (glycerol, n-hexadecane), yeast autolysate and trace elements, correlated with the activity of NADP+-dependent glutamate dehydrogenase - a key enzyme of aminolipids biosynthesis (610 ± 30, 395 ± 24, 397 ± 24 nM min-1·mg-1 protein, respectively). Conclusions: The higher activity of NADP+-dependent glutamate dehydrogenase when growing the strain IMV B-7241 in a medium with ethanol (n-hexadecane), yeast autolysates and trace elements compared to that in a medium with copper sulfate and iron sulfate, as well as an increase enzyme activity in the presence of zinc cations suggests the possibility of increasing synthesis aminolipids by introducing Zn2+ in the medium with ethanol and n-hexadecan. The obtained data indicate the need for studies depending on biological properties of surfactants of the cultivation conditions of producer.
Subject(s)
Acinetobacter calcoaceticus/metabolism , Anti-Infective Agents/chemistry , Culture Media/chemistry , Surface-Active Agents/chemistry , Alkanes , GlycerolABSTRACT
Aim: Comparison of antimicrobial and anti-adhesive activity of Nocardia vaccinii ÐMV B-7405 surfactants synthesized on purified and technical glycerol (byproduct of biodiesel production). Methods: Surfactants were extracted from supernatant of cultural liquid by mixture of chloroform and methanol (2:1). Antimicrobial against bacteria and yeast properties of the surfactant was determined by index of the minimum inhibitory concentration (MIC). The number of attached cells was determined spectrophotometrically. Results: The dependence of surfactant antimicrobial and anti-aghesive activity on the degree of glycerol purification (purified, technical), as well as the duration of N. vaccinii IMV B-7405 cultivation on these substrates was established. MIC against studied test cultures surfactants, synthesized on technical glycerol during 5 days, was 15121 µg/ml, that lower than MIC of surfactant obtained on purified substrate (22.5−180 µg/ml). Increasing duration of N. vaccinii ÐMV B-7405 cultivation accompanied by rise the MIC against some test cultures surfactants synthesized on both technical and purified glycerol. Adhesion of the bacteria Escherichia coli ÐEM-1, Bacillus subtilis BT-2 (vegetative cells and spores) and the yeast Candida albicans Ð-6 on abiotic surfaces treated with surfactants synthesized on technical glycerol for both 5 and 7 days, was an average of 11−12 % less than after materials treatment with surfactants obtained on the purified substrate. Conclusions: Increasing activity of NADP+-dependent glutamate dehydrogenase − key enzyme of aminolipids biosynthesis (effective antimicrobial and anti-adhesion agents) in the presence of K+ and Na+ may indicate the possibility of biosynthesis intensification of these components of surfacrants complex under N. vaccinii ÐMV B-7405 cultivation on technical glycerol, which is characterized by a high content of sodium and potassium cations. Replacing refined glycerol on byproduct of biodiesel production will not only reduce the cost of N. vaccinii ÐMV B-7405 surfactant biosynthesis, but also to obtain the final product with high antiadhesive and antimicrobial activity.
Subject(s)
Biofuels , Nocardia/chemistry , Surface-Active Agents/chemistry , Bacillus subtilis/drug effects , Bacterial Adhesion/drug effects , Candida albicans/drug effects , Escherichia coli/drug effects , Glycerol , Microbial Sensitivity TestsABSTRACT
Key enzymes of glucose metabolism were detected in the cells of surfactants producer Nocardia vaccinii IMV B-7405 grown on this substrate. It has been established that glucose catabolism is performed through gluconate (FAD(+)-dependent glucose dehydrogenase activity 698 ± 35 nmol x min(-1) x mg(-1) of protein). Oxidation of gluconate to 6-phosphogluconate is catalised by gluconokinase (178 ± 9 nmol x min(-1) x mg(-1) of protein). 6-Phosphogluconate was involved into pentose phosphate cycle by constitutive NADP(+)-dependent 6-phosphogluconate dehydrogenase (activity 357 ± 17 nmol x min(-1) x mg(-1) of protein). The data obtained serve as the basis for theoretical calculations of optimal molar ratio of concentrations of energetically nonequivalent substrates for intensifying the surfactants synthesis on their mixture.
Subject(s)
Gluconates/metabolism , Glucose/metabolism , Glycerolphosphate Dehydrogenase/metabolism , Nocardia/enzymology , Nocardia/metabolism , Carbohydrate Metabolism , Glutamate Dehydrogenase (NADP+)/metabolism , Nocardia/growth & development , Pentose Phosphate Pathway/physiology , Phosphogluconate Dehydrogenase/metabolism , Phosphotransferases (Alcohol Group Acceptor)/metabolism , Substrate SpecificityABSTRACT
It has been established that in cells of Nocardia vaccinii IMB B-7405 (surfactant producer) glucose catabolism is performed through pentose phosphate cycle as well as through gluconate (activity of NAD+-dependent glucose-6-phosphate dehydrogenase and FAD+-dependent glucose dehydrogenase 835 ± 41 and 698 ± 35 nmol.min-1.mg-1 of protein respectively). 6-Phosphogluconate formed in the gluconokinase reaction is involved in the pentose phosphate cycle (activity of constitutive NADP+-dependent 6-phosphogluconate dehydrogenase 357 ± 17 nmol.min-1.mg-1 of protein). Glycerol catabolism to dihydroxyacetonephosphate (the intermediate of glycolysis) may be performed in two ways: through glycerol-3-phosphate (glycerol kinase activity 244 ± 12 nmol.min-1.mg-1 of protein) and through dihydroxyacetone. Replenishment of the C4-dicarboxylic acids pool in N. vaccinii IMV B-7405 grown on glucose and glycerol occurs in the phosphoenolpyruvate(PEP)carboxylase reaction (714-803 nmol.min-1.mg-1 of protein). 2-Oxoglutarate was involved in tricarboxylic acid cycle by alternate pathway with the participation of 2-oxoglutarate synthase. The observed activity of both key enzymes of gluconeogenesis (PEP-carboxykinase and PEP-synthase), trehalose phosphate synthase and NADP+-dependent glutamate dehydrogenase confirmed the ability of IMV B-7405 strain to the synthesis of surface active glycoand aminolipids, respectively.
Subject(s)
Bacterial Proteins/metabolism , Glucose/metabolism , Glycerol/metabolism , Nocardia/metabolism , Citric Acid Cycle/physiology , Dihydroxyacetone/metabolism , Dihydroxyacetone Phosphate/metabolism , Gluconates/metabolism , Gluconeogenesis/physiology , Glucose 1-Dehydrogenase/metabolism , Glucosephosphate Dehydrogenase/metabolism , Glutamate Dehydrogenase (NADP+)/metabolism , Glycerophosphates/metabolism , Glycolysis/physiology , Ketoglutaric Acids/metabolism , Ketone Oxidoreductases/metabolism , Pentose Phosphate Pathway/physiology , Phosphoenolpyruvate/metabolism , Phosphoenolpyruvate Carboxykinase (ATP)/metabolism , Phosphoenolpyruvate Carboxylase/metabolism , Phosphogluconate Dehydrogenase/metabolism , Phosphotransferases (Alcohol Group Acceptor)/metabolism , Phosphotransferases (Paired Acceptors)/metabolismABSTRACT
The possibility of replacing glucose and pure glycerol in mixed substrates for surtace-active substances (SAS, biosurfactants) biosynthesis of Nocardia vaccinii IMB B-7405 on molasses (sugar production waste) and crude glycerol (by-product of biodiesel production) was established. It was established that the increasing concentration of crude glycerol to 6% in mixture with 1.0% molasses was accompanied by increase of amount of SAS synthesized more than twice, and the increasing content of molasses to 3.0% in mixture with 1.0% crude glycerol--by some decrease in the level of surfactant as compared to that in a medium containing 1.0% monosubstrates. It was shown that the increasing concentration of sodium nitrate to 2-fold in medium cultivation of N. vaccinii IMB B-7405 allowed to increase to 7.0% content of grude glycerol in mixture with 1.0% molasses. Under such conditions of cultivation concentration of exocellular SAS synthesized was 7,5 g/l, that to 1,3 fold higher than in basic medium with a lower content of nitrogen source.
Subject(s)
Glucose/metabolism , Glycerol/metabolism , Industrial Microbiology , Molasses/analysis , Nocardia/metabolism , Surface-Active Agents/metabolism , Biotransformation , Culture Media/chemistry , Fermentation , Kinetics , Nitrates/metabolism , Nitrogen/metabolismABSTRACT
The effect of copper cations (0.01-1.0 mM) and surface-active agents (surfactants) of Acinetobacter calcoaceticus IMV B-7241, Rhodococcus erythropolis IMV Alc-5017 and Nocardia vaccinii IMV B-7405 in the form of culture liquid on the destruction of oil in water (3.0-6.0 g/L) and soil (20 g/kg), including in the presence of Cd2+ and Pb2+ (0.01-0.5 mM), was investigated. It was shown that the degree of oil degradation in water and soil after 20 days in the presence of low concentrations of Cu2+ (0.01-0.05 mM) and culture liquid of strains IMV B-7241, IMV Ac-5017, and IMV B-7405 was 15 - 25% higher than without copper cations. The activating effect of Cu2+ on the decomposition of complex oil and Cd2+ and Pb2+ pollution was established: after treatment with surfactant of A. calcoacelicus IMV B-7241 and R. erythropolis IMV Ac-5017 destruction of oil in water and soil was 85-95%, and after removal of the copper cations decreased to 45-70%. Intensification of oil destruction in the presence of copper cations may be due to their stimulating effect on the activity of alkane hydroxylases as in surfactant-producing strains, and natural (autochthonous) oxidizing microbiota.
Subject(s)
Acinetobacter calcoaceticus/metabolism , Copper/pharmacology , Nocardia/metabolism , Petroleum/metabolism , Rhodococcus/metabolism , Soil Pollutants/metabolism , Water Pollutants/metabolism , Acinetobacter calcoaceticus/drug effects , Biodegradation, Environmental , Cadmium/toxicity , Cations, Divalent , Copper/metabolism , Cytochrome P-450 CYP4A/metabolism , Isoenzymes/metabolism , Lead/toxicity , Nocardia/drug effects , Rhodococcus/drug effects , Surface-Active Agents/metabolismABSTRACT
AIM: To study the effect of Nocardia vaccinii IMV B-7405 surfactants on some bacteria (including pathogens of genera Proteus, Staphylococcus, Enterobacter), yeast of Candida species and fungi (Aspergillus niger R-3, Fusarium culmorum T-7). METHODS: The antimi- crobial properties of surfactant were determined in suspension culture by Koch method and also by index of the minimum inhibitory concentration. Surfactants were extracted from supernatant of cultural liquid by mixture of chloroform and methanol (2:1). RESULTS: It is shown that the antimicrobial properties of N. vaccinii IMV B-7405 surfactant depended on the degree of purification (supernatant, solution of surfactant), concentration and exposure. Survival of Escherichia coli IEM-1 and Bacillus subtilis BT-2 (both vegetative cells and spores) after treatment for 1-2 hours with surfactants solution and the supernatant (the surfactant concentration 21 µg/ml) was 3-28%. Minimum inhibitory concentrations of N. vaccinii IMV B-7405 surfactants on studied bacteria, yeast and micromycetes were 11.5-85.0; 11.5-22.5 and 165.0-325.0 µ/ml respectively. CONCLUSIONS: Minimum inhibitory concentrations of N. vaccinii IMV B-7405 surfactants are comparable to those of the known microbial surfactants. The possibility of using the supernatant of culture liquid as an effective antimicrobial agent noticeably simplifies and reduces the cost of the technology of its obtaining.
Subject(s)
Anti-Infective Agents/pharmacology , Nocardia/physiology , Surface-Active Agents/pharmacology , Anti-Infective Agents/isolation & purification , Anti-Infective Agents/metabolism , Aspergillus niger/drug effects , Aspergillus niger/growth & development , Bacillus subtilis/drug effects , Bacillus subtilis/growth & development , Candida/drug effects , Candida/growth & development , Culture Media/chemistry , Enterobacter/drug effects , Enterobacter/growth & development , Escherichia coli/drug effects , Escherichia coli/growth & development , Fusarium/drug effects , Fusarium/growth & development , Microbial Sensitivity Tests , Nocardia/chemistry , Proteus/drug effects , Proteus/growth & development , Staphylococcus/drug effects , Staphylococcus/growth & development , Surface-Active Agents/isolation & purification , Surface-Active Agents/metabolismABSTRACT
AIM: To study the synthesis of phytohormones (auxins, cytokinins, abscisic acid) under cultivation of Nocardia vaccinii IMV B-7405 (surfactants producer) in media containing different carbon sources (glycerol, refined sunflower oil, as well as waste oil after frying potatoes and meat). METHODS: Phytohormones were extracted from supernatants of culture liquid (before or after surfactant separation) by ethylacetate (auxins, abscisic acid) and n-butanol (cytokinins), concentrated and purified by thin-layer chromatography, then quantitative determination was performed using a scanning Sorbfil spectrodensitometer. RESULTS: While growing in medium with refined oil IMV B-7405 strain synthesized 1.8 ± 0.09 g/l extracellular surfactant, also maximum amount of auxins (245-770 µ/l) and cytokinins (134-348 µl). Cultivation of N. vaccini LMV B-7405 on waste oil was accompanied by decreasing amount of phytohormones to 23-84 µ/l (auxins) and 16-90 µ/l (cytokinins) and increasing surfactant concentration to 2.3-2.6 g/l. The level of abscisic acid synthesis was practically not dependent on the nature of growth substrate, was substantially lower than that of auxins and cytokinins and ranged from 2 to 12 µ/l. CONCLUSIONS: Obtained data demonstrate the possibility of using oil-containing industrial waste for the simultaneous synthesis of both surfactants and phytohormones, and indicate the need for studies of the effect of producer cultivation conditions on the biological properties of the target products of microbial synthesis.
Subject(s)
Abscisic Acid/biosynthesis , Cytokinins/biosynthesis , Indoleacetic Acids/metabolism , Nocardia/metabolism , Plant Growth Regulators/metabolism , Surface-Active Agents/metabolism , 1-Butanol , Abscisic Acid/isolation & purification , Acetates , Culture Media/chemistry , Cytokinins/isolation & purification , Fermentation , Glycerol/metabolism , Indoleacetic Acids/isolation & purification , Industrial Microbiology , Industrial Oils/analysis , Industrial Waste/analysis , Plant Growth Regulators/isolation & purification , Plant Oils/metabolism , Solvents , Sunflower Oil , Surface-Active Agents/isolation & purificationABSTRACT
The production of surfactants by Nocardia vaccinii IMV B-7405 in glycerol -and hydrocarbon-containing medium after addition Cd(3+) Pb(2+) and Cu(2+) was investigated. It was established that the introduction of 0.1 mM Cu(2+) in the exponential growth phase of IMV B-7405 strain or simultaneous addition of Cu(2+) (0.1 mM) and Cd(2+) (0.3 mM), Cu(2+) (0.1 mM) and Pb(2+) (0.3 mM) in stationary phase was accompanied by the increase of conditional concentration of the surfactant (by 53 and 20-26%, respectively) compared with indexes in the medium without metals cations. It was established that the surfactants of N. vaccinii IMV B-7405 possessed protective functions from heavy metals influence. After surfactants elimination the survival of cells of strain IMV B-7405 in the presence of Cu(2+) (1.5-2.5 mM), Cd(2+) or Pb(2+) (0.1-0.3 mM) decreased a few times (to 5-45%). The inhibition action of Cu(2+) on alkane hydroxylase activity (the first enzyme of hydrocarbon catabolism) and stimulation--on phosphoenolpyruvate synthetase (enzyme of surface-active glycolipids biosynthesis) in MB B-7405 have been established.
Subject(s)
Cadmium/pharmacology , Copper/pharmacology , Industrial Microbiology , Lead/pharmacology , Nocardia/drug effects , Surface-Active Agents/metabolism , Alkanes/metabolism , Culture Media , Glycerol/metabolism , Mineral Oil/metabolism , Nocardia/growth & development , Nocardia/metabolismABSTRACT
The synthesis of surfactants by Rhodococcus erythropolis IMV Ac-5017, Acinetobacter calcoaceticus IMV B-7241 and Nocardia vaccinii IMV B-7405 on industrial waste (food and oil-processing industry, production of biodiesel) was investigated. The possibility of replacing the expensive substrates (n-hexadecane and ethanol) by industrial waste (oil and fat industry, fried sunflower oil, glycerol, liquid paraffin) for the surfactant biosynthesis was established. The conditional concentration of surfactants was maximal on oil containing substrates and exceeded those on n-hexadecane and ethanol 2-3 times. The highest rates of surfactants synthesis were observed on fried sunflower oil with the use of inoculum grown on carbohydrate substrates (glucose, molasses). It was established that the addition of glucose (0.1%) was accompanied by 2-4-fold intensification of surfactants synthesis by R. erythropolis IMV Ac-5017 and N. vaccinii IMV B-7405 on fried sunflower oil (2%).
Subject(s)
Acinetobacter calcoaceticus/metabolism , Industrial Microbiology , Industrial Waste , Nocardia/metabolism , Rhodococcus/metabolism , Surface-Active Agents/metabolism , Acinetobacter calcoaceticus/growth & development , Alkanes/metabolism , Ethanol/metabolism , Glucose/metabolism , Glycerol/metabolism , Industrial Oils , Mineral Oil/metabolism , Molasses , Nocardia/growth & development , Plant Oils/metabolism , Rhodococcus/growth & development , Sunflower Oil , UkraineABSTRACT
Attachment of the cells of some bacteria, yeasts, and micromycetes to various surfaces (catheters, dentures, plastic, polyvinyl chloride, tiles, and steel) treated with the surfactants fromAcinetobacter calcoace- ticus IMB B-7241, Rhodococcus erythropolis IMB Ac-5017, and Nocardia vaccinii IMB B-7405 was studied. Adhesion of microorganisms to all the studied surfaces depended on the surfactant concentration and purity, kind of surface, and the test culture. Treatment with the surfactants from N. vaccinii IMB B-7405 (0.005- 0.05 mg/mL), A. calcoaceticus IMB B-7241 (0.003-0.036 mg/mL), and R. erythropolis IMB Ac-5017 (0.03- 0.12 mg/mL) resulted in adhesion decreased respectively by 35-75, 60-75, and 25-90% for bacteria (Es- cherichia coli IEM-1, Bacillus subtilis BT-2, etc.), by 80-85, 55-90, and 15-60% for yeasts Candida albicans D-6, and by 40-50, 35-45, and 10-20% for micromycetes (Aspergillus niger P-3 and Fusarium culmorum T-7).
Subject(s)
Acinetobacter calcoaceticus/chemistry , Bacterial Adhesion/drug effects , Nocardia/chemistry , Rhodococcus/chemistry , Surface-Active Agents/pharmacology , Aspergillus niger/drug effects , Bacillus subtilis/drug effects , Biofilms/drug effects , Candida albicans/drug effects , Dental Prosthesis/microbiology , Drug Evaluation, Preclinical/methods , Enterobacter/drug effects , Escherichia coli/drug effects , Fusarium/drug effects , Polyvinyl Chloride , Pseudomonas/drug effects , SteelABSTRACT
The effect of Rhodococcus erythropolis IMB Ac-5017 biosurfactants (surface-active substances, SAS) with different degree of purification on attachment of bacteria (Escherichia coli IEM-1, Bacillus subtilis BT-2, Proteus vulgaris BT-1, Staphylococcus aureus BMC-1, Pseudomonas aeruginosa P-55, Enterobacter cloacae AC-22, Erwinia aroidaeae B-433), yeasts (Candida albicans D-6) and fungi (Aspergillus niger P-3, Fusarium culmorum T-7) to the abiotic surfaces (glass, plastic, ceramics, steel, linoleum) was studied. The dependence of microorganisms adhesion on degree of SAS purification (supernatant, purified SAS solution), SAS concentration (0,04-1,25 mg/ml), type of surface and test-cultures was established. The adhesion of majority investigated bacterial cells after treatment of abiotic surfaces with supernatant of cultural liquid with SAS concentration 0,06-0,25 mg/ml was on the average 20-45, yeasts C. albicans D-6--30-75% and was less than that purified SAS solution with the same concentration. Higher antiadhesive activity of supernatant as compared to purified SAS solution testifies to possibility of exception of the expensive stage of isolation and purification at obtaining of preparations with antiadhesive properties.
Subject(s)
Bacterial Adhesion/drug effects , Culture Media, Conditioned/pharmacology , Rhodococcus/chemistry , Surface-Active Agents/pharmacology , Aspergillus niger/drug effects , Aspergillus niger/physiology , Bacillus subtilis/drug effects , Bacillus subtilis/physiology , Candida albicans/drug effects , Candida albicans/physiology , Dose-Response Relationship, Drug , Enterobacter cloacae/drug effects , Enterobacter cloacae/physiology , Erwinia/drug effects , Erwinia/physiology , Escherichia coli/drug effects , Escherichia coli/physiology , Fusarium/drug effects , Fusarium/physiology , Proteus vulgaris/drug effects , Proteus vulgaris/physiology , Pseudomonas aeruginosa/drug effects , Pseudomonas aeruginosa/physiology , Rhodococcus/metabolism , Staphylococcus aureus/drug effects , Staphylococcus aureus/physiology , Surface Properties , Surface-Active Agents/isolation & purification , Surface-Active Agents/metabolismABSTRACT
The authors studied the effect of components of crude glycerol (potassium and sodium salts, ethanol, methanol) - the by-products of biodiesel production on formation of surfactants (surface-active substances, SAS) by Nocardia vaccinii K-8, as well as possibility to intensify the SAS synthesis by the strain K-8 on crude glycerol in the presence ofbiosynthesis precursors (glucose, sun-flower oil, organic substances). It has been established that the introduction of potassium (sodium) chloride in concentration 2.5 % and ethanol (methanol) in concentration 0.3 % into the medium with refined glycerol (1 %) was accompanied by the 14-1.7-fold increase of conditional SAS concentration as compared with indices on the medium without adding salts and alcohols. Under cultivation conditions of strain K-8 on the medium with crude glycerol the conditional SAS concentration was 3-fold higher than on the medium with refined substrate. Introduction of glucose (0.05 %), sun-flower oil (0.05 %), fumarate and citrate (0.1 %) during the stationary growth phase of N. vaccinii K-8 into the medium with crude glycerol (2.2%) was accompanied by the increase in the amount of synthesized SAS h by 17-44 % compared with cultivation of bacteria on the medium without precursors.
Subject(s)
Glycerol/metabolism , Nocardia/metabolism , Surface-Active Agents/metabolism , Citrates , Culture Media/chemistry , Ethanol/metabolism , Fermentation , Fumarates , Glucose/metabolism , Methanol/metabolism , Plant Oils/metabolism , Potassium Chloride , Sodium Chloride , Sunflower OilABSTRACT
Synthesis of extracellular metabolites with surface-active and emulsifying properties, pH being maintained at the level of 5.8-8.0, in the process of cultivation of Acinetobacter calcoaceticus IMV B-7241 in the medium with ethanol (2%, volume part) was investigated. It is established that the neutral value of pH is optimal for synthesis of surface-active substances (SAS, biosurfactants) of A. calcoaceticus IMV B-7241. The maintenance of pH at the level of 7.0 with the help of KOH solution was accompanied by the 1.8-fold increase of the amount of synthesized SAS as compared with the process indicators without regulation of pH. The substitution of KOH by NaOH to maintain pH at the optimal level led to the 1.2-1.5-fold decrease of SAS concentration that is determined by the inhibiting effect of sodium cations on activity of biosynthesis enzymes of surface-active amino- and glycolipids of A. calcoaceticus IMV B-7241. The medium neutralization by KOH solution in the process of cultivation of the strain IMV B-7241 with further introduction of fumarate (0.01%) and citrate (0.01%) at the end of the exponential phase was accompanied by the 1.2-fold increase of the amount of synthesized SAS compared with the indicators of the analogous process without neutralization and by the 3 5-fold increase compared with bacteria cultivation on ethanol without organic acids and pH regulation.
Subject(s)
Acinetobacter calcoaceticus/metabolism , Biotechnology/methods , Surface-Active Agents/metabolism , Acinetobacter calcoaceticus/enzymology , Acinetobacter calcoaceticus/growth & development , Biomass , Chromatography, Thin Layer , Citric Acid/chemistry , Culture Media , Ethanol/chemistry , Fumarates/chemistry , Hydrogen-Ion Concentration , Hydroxides/chemistry , Potassium Compounds/chemistryABSTRACT
The effect of univalent cations on activity of key enzymes of C2-metabolism has been investigated in the producer of biosurfactants, Acinetibacter calcoaceticus IMV B-7241 grown on ethanol. It was established that potassium cations are inhibitors of pyroquinolinequinone-dependent alcohol- and acetaldehyde dehydrogenases, the enzymes of biosynthesis of surface-active aminolipids (NADP-dependent glutamate dehydrogenase) and glycolipids (phosphoenopyruvate (PhEP)-carboxikinase), while ammonium cations are activators of these enzymes and PhEP-carboxylase. A decrease of potassium cations concentration in the cultivation medium to 1 mM and increase of the content of amine nitrogen to 10 mM as a result of potassium nitrate substitution by equimolar, as to nitrogen, urea concentration were accompanied by the increase of activity of enzymes of ethanol metabolism and SAS biosynthesis, as well as by the 2-fold increase of conditional concentration of the biosurfactants.
Subject(s)
Acinetobacter calcoaceticus/drug effects , Acinetobacter calcoaceticus/enzymology , Ammonia/pharmacology , Potassium/pharmacology , Surface-Active Agents/metabolism , Acinetobacter calcoaceticus/growth & development , Alcohol Oxidoreductases/antagonists & inhibitors , Alcohol Oxidoreductases/metabolism , Ammonia/metabolism , Cations, Monovalent , Culture Media , Enzyme Activation/drug effects , Ethanol/metabolism , Glutamate Dehydrogenase (NADP+)/antagonists & inhibitors , Glutamate Dehydrogenase (NADP+)/metabolism , Phosphoenolpyruvate Carboxykinase (ATP)/antagonists & inhibitors , Phosphoenolpyruvate Carboxykinase (ATP)/metabolism , Phosphoenolpyruvate Carboxylase/antagonists & inhibitors , Phosphoenolpyruvate Carboxylase/metabolism , Potassium/metabolism , Substrate Specificity , Urea/metabolismABSTRACT
Synthesis of biosurfactants (surface-active substances, SAS) was investigated under the conditions of growth of Rhodococcus erythropolis IMV Ac-5017 and Acinetobacter calcoaceticus IMV B-7241 on hydrophobic (n-hexadecane, liquid paraffins, sunflower oil) and hydrophilic (ethanol) substrates depending on concentration (0.01-0.5 mM) and time of copper cations introduction in the medium. It is established that Cu2+ addition in the exponential phase of growth of the strains IMV B-7241 and IMV Ac-5017 on all studied substrates was accompanied by the increase of conventional concentration of SAS by 25-140% as compared with the indices in the medium without copper cations. Maximum synthesis intensification of SAS of A. calcoaceticus IMV B-7241 and R. erythropolis IMV Ac-5017 was observed in the case of Cu2+ introduction in the medium with hydrocarbons. The increase of SAS synthesis in the presence of copper cations is determined by their activating effect on activity of alkane hydroxylase of the both strains, as well as 4-nitroso-N,N-dimethylaniline-dependent alcohol dehydrogenase and enzymes of biosynthesis of surface active glyco-(phosphoenolpyruvate-synthetase) and aminolipids (NADP(+)-dependent glutamate dehydrogenase) in A. calcoaceticus IMV B-7241.
Subject(s)
Acinetobacter calcoaceticus/metabolism , Copper/metabolism , Rhodococcus/metabolism , Surface-Active Agents/metabolism , Acinetobacter calcoaceticus/drug effects , Alcohol Dehydrogenase/metabolism , Alkanes/metabolism , Cations, Divalent , Copper/pharmacology , Culture Media , Cytochrome P-450 CYP4A/metabolism , Ethanol/metabolism , Glutamate Dehydrogenase (NADP+) , Mineral Oil/metabolism , Phosphotransferases (Paired Acceptors) , Plant Oils/metabolism , Rhodococcus/drug effects , Sunflower OilABSTRACT
The effect of surface-active substances (SAS's) of Acinetobacter calcoaceticus IMV B-7241, Rhodococcus erythropolis IMV Ac-5017, and Nocardia vaccinii K-8 on phytopathogenic bacteria has been studied. It was shown that the survival of cells (10(5)-10(7) in a milliliter) of the Pseudomonas and Xanthomonas phytopathogenic bacteria was found to be 0-33% after treatment with SAS preparations of the IMV Ac-5017 and IMV B-7241 strains for 2 h (0.15-0.4 mg/mL). In the presence of N. vaccinii K-8 SAS preparations (0.085-0.85 mg/mL), the number of cells of the majority of the studied phytopathogenic bacteria decreased by 95-100%. These data show prospects for using microbial SAS's for the construction of ecologically friendly drugs for regulating the number of phytopathogenic bacteria.
Subject(s)
Acinetobacter calcoaceticus/metabolism , Anti-Bacterial Agents/pharmacology , Nocardia/metabolism , Rhodococcus/metabolism , Surface-Active Agents/pharmacology , Acinetobacter calcoaceticus/chemistry , Acinetobacter calcoaceticus/growth & development , Anti-Bacterial Agents/isolation & purification , Culture Media , Microbial Sensitivity Tests , Nocardia/chemistry , Nocardia/growth & development , Pectobacterium carotovorum/drug effects , Pectobacterium carotovorum/growth & development , Plant Diseases/microbiology , Plant Diseases/therapy , Pseudomonas syringae/drug effects , Pseudomonas syringae/growth & development , Rhodococcus/chemistry , Rhodococcus/growth & development , Surface-Active Agents/isolation & purification , Xanthomonas campestris/drug effects , Xanthomonas campestris/growth & developmentABSTRACT
The effect of yeast autolysate and microelements on synthesis of surface-active substances (SAS, biosurfactants) was investigated under cultivation of Acinetobacter calcoaceticus IMV B-7241 on various carbon substrates (n-hexadecane, ethanol, glycerol). The authors have shown a possibility to substitute the yeast autolysate and microelement mixture in the composition of ethanol- and n-hexadecane-containing media by copper sulfate (0.16 micromol/l) and iron sulfate (3.6 micromol/l), and in the medium with glycerol by 0.21 mmol/l of KCl, 38 micromol/l of zinc sulfate and 0.16 micromol/l of copper sulfate. Under such conditions of cultivation of the strain IMV B-7241 the SAS concentration exceeded that on the initial media, which contained the yeast autolysate and microelements, 1.2-1.6 times. The authors have also established the activating effect of low (0.01 mM) concentrations of Fe2+ on activity of the enzymes of biosynthesis of surface-active amino- (NADP-dependent glutamate dehydrogenase) and glycolipids (phosphoenolpyruvate(PhEP)-synthetase, PhEP-carboxykinase), as well as of anaplerotic reaction(PhEP-carboxylase). A necessity to introduce zinc cations into glycerol-containing medium is determined by their stimulating effect on activity of 4-dinitroso-N,N-dimethylaniline-dependent alcohol dehydrogenase--one of the enzymes of this substrate catabolism in A. calcoaceticus IMV B-7241.