ABSTRACT
Fruit and vegetable industries face a major environmental challenge with food loss and waste. Broccoli stems, comprising 38% of the plant's total weight, are usually discarded by the industry producing fourth-range and ready-to-use products, despite being rich in antioxidants, vitamins, fiber, carotenoids, phenolic compounds, and glucosinolates. Addressing the challenge of reducing waste in this sector includes the production of stable and nutrient-concentrated powders, which can be consumed directly or used as ingredients in functional food formulation. This study investigated fermentation with lactic acid bacteria (Limosilactobacillus reuteri, Lactiplantibacillus plantarum, and Lactobacillus salivarius) as a pretreatment for enhancing antioxidant and probiotic potential in broccoli stem powders. Results showed maximum counts 24 h after inoculation, and no effect of the previous disruption intensity on microbial growth was observed. Fermenting broccoli stems for 24 h with the three microbial strains led to a significant increase in total phenols and flavonoids but to a general reduction in the samples' capacity to scavenge DPPH and ABTS free radicals. Overall, ground broccoli stems exhibited the most favorable antioxidant properties following the 24 h fermentation step. The subsequent freeze-drying and final grinding had minimal impact on the microbial population but significantly enhanced the extractability of the antioxidant compounds. This study offers a valuable reference for researchers and stakeholders exploring the development of new products and innovations from vegetable waste.
ABSTRACT
Fortification of bakery products with plant-based functional ingredients has gained interest in recent years. Low-cost fruit and vegetable waste has been proposed to replace wheat flour, but less research has been conducted on gluten-free flours. Rice is generally accepted as a gluten-free alternative to wheat flour but is poor in bioactive constituents; thus, the addition of vegetable-based functional ingredients could improve the nutritive value of gluten-free products. In the present work, IV-range carrot waste powder (CP) was incorporated into rice-based gluten-free muffin formulations in different proportions (5, 10, 20, and 30% w/w). The impact of CP addition on physicochemical and antioxidant properties was evaluated in flour blends, doughs, and baked products. Products were also evaluated in terms of water activity, hardness, and colour before and after a one-week storage period under fridge conditions. The results showed that water and oil absorption capacities increased in flour blends with CP addition, whereas the pasting properties of flour blends were affected when adding CP. Rheological measurements revealed an increase of G' and G'' modulus values with CP addition. Colour was also significantly modified by CP addition, since CP provided an orangish and brownish colour, but also due to intensified Maillard reactions during baking. Muffin hardness was reduced in enriched formulations compared to control ones, which was attributed to the fibre being incorporated with CP. It was confirmed that CP addition improved the antioxidant properties of both flour blends and muffins, with the higher the replacement, the better the antioxidant properties. The quality of gluten-free muffins was hindered after one week stored under cold conditions, so that colour was affected, hardness increased, and the antioxidant properties diminished. In conclusion, this work presents an interesting approach for the use of carrot waste flour as a functional food ingredient to improve the nutritional value of new gluten-free rice-based muffins, thus contributing to the circularity of food systems and to the development of healthier and more sustainable diets.
ABSTRACT
Valorisation of fruit and vegetable wastes by transforming residues and discards into functional powdered ingredients has gained interest in recent years. Moreover, fermentation has been recalled as an ancient technology available to increase the nutritional value of foods. In the present work, the impact of pretreatments (disruption and fermentation) on drying kinetics and functional properties of powdered broccoli stems was studied. Broccoli stems fermented with Lactiplantibacillus plantarum and non-fermented broccoli stems were freeze-dried and air-dried at different temperatures. Drying kinetics were obtained and fitted to several thin layer mathematical models. Powders were characterized in terms of physicochemical and antioxidant properties, as well as of probiotic potential. Fermentation promoted faster drying rates and increased phenols and flavonoids retention. Increasing drying temperature shortened the process and increased powders' antioxidant activity. Among the models applied, Page resulted in the best fit for all samples. Microbial survival was favoured by lower drying temperatures (air-drying at 50 °C and freeze-drying). Fermentation and drying conditions were proved to determine both drying behaviour and powders' properties.
ABSTRACT
Vegetable wastes are generated during harvesting, processing, and distribution, which implies a wastage of nutrients and evidence inefficiencies in present food systems. Vegetable residues are rich in bioactive compounds, for which their valorisation and reintroduction into the food chain are crucial towards circular economy and food systems sustainability. In this work, upcycled powdered ingredients were obtained from vegetables wastes (carrot, white cabbage, celery, and leek) through a disruption, dehydration and milling process. Disruption pre-treatment at different intensities was followed by freeze-drying or hot-air drying (60 and 70 °C), and final milling to produce fine powders. Powdered products were characterized in terms of physicochemical, antioxidant and technological properties (water and oil interaction), after processing and during four months of storage. Antioxidant properties were generally favoured by hot-air drying, particularly at 70 °C, attributed to new compounds formation combined to less exposure time to drying conditions. The powders showed good water interaction properties, especially freeze-dried ones. Storage had a negative impact on the quality of powders: moisture increased, antioxidant compounds generally diminished, and colour changes were evidenced. Upcycled vegetable waste powders are proposed as ingredients to fortify foods, both processing and storage conditions having an impact on their properties.
Subject(s)
Antioxidants , Vegetables , Antioxidants/analysis , Desiccation , Freeze Drying , WaterABSTRACT
Daucus carota L. is an important food crop utilized worldwide and a rich source of bioactive compounds. Carrot processing generates residues which are discarded or underused, for which using them as a source for obtaining new ingredients or products is an opportunity for the development of healthier and more sustainable diets. In the present study, the impact of different milling and drying procedures and in vitro digestion on the functional properties of carrot waste powders was evaluated. Carrot waste was transformed into powders by disruption (grinding vs. chopping), drying (freeze-drying or air-drying at 60 or 70 °C) and final milling. Powders were characterized in terms of physicochemical properties (water activity, moisture content, total soluble solids and particle size) nutraceuticals (total phenol content, total flavonoid content antioxidant activity by DPPH and ABTS methods, as well as carotenoid content (α-carotene, ß-carotene, lutein, lycopene). Antioxidants and carotenoid content during in vitro gastrointestinal digestion were also evaluated; the latter in different matrices (directly, in water, in oil, and in oil-in-water emulsion). Processing allowed to reduce water activity of samples and obtain powders rich in antioxidant compounds and carotenoids. Both disruption and drying had a significant impact on powders' properties freeze-drying led to finer powders with higher carotenoid content but lower antioxidant values, whereas air-drying implied chopped air-dried powders exhibited higher phenols content and improved antioxidant activity. Simulated in vitro digestion studies revealed that digestion helps release bioactive compounds which are bound to the powder structure. The solubilization of carotenoids in oil was low, but fat co-ingestion notably increased their recovery. According to the results, carrot waste powders containing bioactive compounds could be proposed as functional ingredients to increase the nutritional value of foods, thus contributing to the concepts of more sustainable food systems and sustainable healthy diets.
ABSTRACT
Reintroducing waste products into the food chain, thus contributing to circular economy, is a key goal towards sustainable food systems. Fruit and vegetable processing generates large amounts of residual organic matter, rich in bioactive compounds. In Brassicaceae, glucosinolates are present as secondary metabolites involved in the biotic stress response. They are hydrolysed by the enzyme myrosinase when plant tissue is damaged, releasing new products (isothiocyanates) of great interest to human health. In this work, the process for obtaining powdered products from broccoli and white cabbage by-products, to be used as food ingredients, was developed. Residues produced during primary processing of these vegetables were transformed into powders by a process consisting of disruption (chopping or grinding), drying (hot-air drying at 50, 60 or 70 °C, or freeze drying) and final milling. The impact of processing on powders' physicochemical and functional properties was assessed in terms of their physicochemical, technological and antioxidant properties. The matrix response to drying conditions (drying kinetics), as well as the isothiocyanate (sulforaphane) content of the powders obtained were also evaluated. The different combinations applied produced powdered products, the properties of which were determined by the techniques and conditions used. Freeze drying better preserved the characteristics of the raw materials; nevertheless, antioxidant characteristics were favoured by air drying at higher temperatures and by applying a lower intensity of disruption prior to drying. Sulforaphane was identified in all samples, although processing implied a reduction in this bioactive compound. The results of the present work suggest Brassica residues may be transformed into powdered ingredients that might be used to provide additional nutritional value while contributing to sustainable development.
ABSTRACT
To benefit the health of consumers, bioactive compounds must reach an adequate concentration at the end of the digestive process. This involves both an effective release from the food matrix where they are contained and a high resistance to exposure to gastrointestinal conditions. Accordingly, this study evaluates the impact of trehalose addition (10% w/w) and homogenization (100 MPa), together with the structural changes induced in vacuum impregnated apple slices (VI) by air-drying (AD) and freeze-drying (FD), on Lactobacillus salivarius spp. salivarius (CECT 4063) survival and the bioaccessibility of antioxidants during in vitro digestion. Vacuum impregnated apple slices conferred maximum protection to the lactobacillus strain during its passage through the gastrointestinal tract, whereas drying with air reduced the final content of the living cells to values below 10 cfu/g. The bioaccessibility of antioxidants also reached the highest values in the VI samples, in which the release of both the total phenols and total flavonoids to the liquid phase increased with in vitro digestion. The addition of trehalose and homogenization at 100 MPa increased the total bioaccessibility of antioxidants in FD and AD apples and the total bioaccessibility of flavonoids in the VI samples. Homogenizing at 100 MPa also increased the survival of L. salivarius during in vitro digestion in FD samples.
ABSTRACT
Lulo (Solanum quitoense Lam.) is a Colombian fruit that is mostly used in the preparation of homemade juice as well as natural remedy for hypertension. The aim of this study was to determine physicochemical and antioxidant properties (antioxidant capacity, total phenols, flavonoids and spermidine content, and polyphenolic compounds profile by liquid chromatography-mass spectrometry (LC-MS)) of the lulo fruit and its juice. Additionally, vacuum impregnation (VI) properties of the fruit and the effect of high homogenization pressure (50, 100, and 150 MPa) on the juice properties were studied. The results revealed a good availability and impregnation capacity of the pores in fruits with similar maturity index. The main differences observed between the juice and fruit derive from removing solids and bioactive components in the filtering operation. However, the effect of high-pressure homogenization (HPH) on particle size and bioactive compounds increases the antiradical capacity of the juice and the diversity in polyphenolics when increasing the homogenization pressure.
ABSTRACT
Globalization of fruit and vegetable markets generates overproduction, surpluses, and potentially valuable residues. The valorization of these byproducts constitutes a challenge, to ensure sustainability and reintroduce them into the food chain. This work focuses on blueberry and persimmon residues, rich in polyphenols and carotenoids, to obtain powders with high added value to be used as ingredients in food formulation. These powders have been characterized, and the changes in the bioactive compounds in in vitro gastrointestinal digestion have been evaluated. The results indicated that the type of residue, the drying process, as well as the content and type of fiber determine the release of antioxidants during digestion. In vitro colonic fermentations were also performed, and it was observed that the characteristics of digested powders had an effect on the composition of the growing microbial community. Thus, carotenoids and anthocyanins maintain an interplay with microbiota that could be beneficial for human health.
Subject(s)
Blueberry Plants/chemistry , Diospyros/chemistry , Gastrointestinal Microbiome , Plant Preparations/chemistry , Bacteria/metabolism , Blueberry Plants/metabolism , Diospyros/metabolism , Fermentation , Fruit/chemistry , Fruit/metabolism , Gastrointestinal Tract/metabolism , Gastrointestinal Tract/microbiology , Humans , Models, Biological , Plant Preparations/metabolism , Powders/analysis , Powders/metabolism , Waste Products/analysisABSTRACT
Survival of probiotic microorganisms in dried foods is optimal for water activity (aw) values between 0.1 and 0.3. Encapsulating and adding low-molecular weight additives can enhance probiotic viability in intermediate aw food products, but the effectiveness of sub-lethal homogenization is still not proven. This study evaluates the effect of 10% (w/w) trehalose addition and/or 100 MPa homogenization on Lactobacillus salivarius CECT 4063 counts and antioxidant properties of apple slices dried to different water activity values (freeze-drying to a aw of 0.25 and air-drying at 40 °C to a aw of 0.35 and 0.45) during four-week storage. Optical and mechanical properties of dried samples were also analyzed. Freeze-drying had the least effect on the microbial counts and air drying at 40 °C to a aw of 0.35 had the greatest effect. Antioxidant properties improved with drying, especially with convective drying. Decreases in both microbial and antioxidant content during storage were favored in samples with higher water activity values. Adding trehalose improved cell survival during storage in samples with a water activity of 0.35, but 100 MPa homogenization increased the loss of viability in all cases. Air-dried samples became more translucent and reddish, rather rubbery and less crispy than freeze-dried ones.
ABSTRACT
Interest in high homogenization pressure technology has grown over the years. It is a green technology with low energy consumption that does not generate high CO2 emissions or polluting effluents. Its main food applications derive from its effect on particle size, causing a more homogeneous distribution of fluid elements (particles, globules, droplets, aggregates, etc.) and favoring the release of intracellular components, and from its effect on the structure and configuration of chemical components such as polyphenols and macromolecules such as carbohydrates (fibers) and proteins (also microorganisms and enzymes). The challenges of the 21st century are leading the processed food industry towards the creation of food of high nutritional quality and the use of waste to obtain ingredients with specific properties. For this purpose, soft and nonthermal technologies such as high pressure homogenization have huge potential. The objective of this work is to review how the need to combine safety, functionality and sustainability in the food industry has conditioned the application of high-pressure homogenization technology in the last decade.
Subject(s)
Food Handling/methods , Carbohydrates/chemistry , Color , Food Contamination , Food Industry , Food Microbiology , Food Quality , Hot Temperature , Humans , Particle Size , Polyphenols/chemistry , Pressure , Proteins/chemistry , ViscosityABSTRACT
The stabilization of fruit bagasse by drying and milling technology is a valuable processing technology to improve its durability and preserve its valuable biologically active components. The objective of this study was to evaluate the effect of lyophilization and air temperature (60 °C and 70 °C) in hot air-drying as well as grinding conditions (coarse or fine granulometry) on physico-chemical properties; water interaction capacity; antioxidant properties; and carotenoid content of powdered lulo bagasse. Air-drying kinetics at 60 °C and 70 °C and sorption isotherms at 20 °C were also determined. Results showed that drying conditions influence antioxidant properties and carotenoid content while granulometry slightly influenced fiber and water interaction properties. Fiber content was near 50% and carotenoid content was higher than 60 µg/g dry matter in lyophilized powder. This ß-carotene content is comparable to that provided by carrot juice. Air-drying at 60 °C only reduced carotenoids content by 10%.
ABSTRACT
Electrochemical impedance spectroscopy (EIS) has been used for monitoring the enzymatic pineapple waste hydrolysis process. The system employed consists of a device called Advanced Voltammetry, Impedance Spectroscopy & Potentiometry Analyzer (AVISPA) equipped with a specific software application and a stainless steel double needle electrode. EIS measurements were conducted at different saccharification time intervals: 0, 0.75, 1.5, 6, 12 and 24 h. Partial least squares (PLS) were used to model the relationship between the EIS measurements and the sugar determination by HPAEC-PAD. On the other hand, artificial neural networks: (multilayer feed forward architecture with quick propagation training algorithm and logistic-type transfer functions) gave the best results as predictive models for glucose, fructose, sucrose and total sugars. Coefficients of determination (R²) and root mean square errors of prediction (RMSEP) were determined as R² > 0.944 and RMSEP < 1.782 for PLS and R² > 0.973 and RMSEP < 0.486 for artificial neural networks (ANNs), respectively. Therefore, a combination of both an EIS-based technique and ANN models is suggested as a promising alternative to the traditional laboratory techniques for monitoring the pineapple waste saccharification step.
Subject(s)
Ananas/chemistry , Carbohydrates/chemistry , Dielectric Spectroscopy , Algorithms , Fructose/chemistry , Glucose/chemistry , Hydrolysis , Refuse Disposal , Sucrose/chemistryABSTRACT
Electrochemical Impedance Spectroscopy (EIS) has been used to develop a methodology able to identify and quantify fermentable sugars present in the enzymatic hydrolysis phase of second-generation bioethanol production from pineapple waste. Thus, a low-cost non-destructive system consisting of a stainless double needle electrode associated to an electronic equipment that allows the implementation of EIS was developed. In order to validate the system, different concentrations of glucose, fructose and sucrose were added to the pineapple waste and analyzed both individually and in combination. Next, statistical data treatment enabled the design of specific Artificial Neural Networks-based mathematical models for each one of the studied sugars and their respective combinations. The obtained prediction models are robust and reliable and they are considered statistically valid (CCR% > 93.443%). These results allow us to introduce this EIS-based technique as an easy, fast, non-destructive, and in-situ alternative to the traditional laboratory methods for enzymatic hydrolysis monitoring.