Development of a human milk protein concentrate from donor milk: Impact of the pasteurization method on static in vitro digestion in a preterm newborn model.

The impact of high temperature short time (HTST, 72 °C, 15 s), Holder pasteurization- (63 °C, 30 min) and high hydrostatic pressure (HHP, 600 MPa-10 min) was evaluated on the digestibility of human milk protein concentrate (HMPC) by using a static in vitro gastrointestinal digestion system. The results showed that the processing steps used to produce the HMPC induced a decrease in readily available nitrogen (non-protein nitrogen and peptides). Overall, digestibility was similar between pasteurized and raw HMPC (degree of hydrolysis ranged from 26 to 34 %). Lactoferrin was more susceptible to gastric and intestinal digestion after thermal pasteurization. Additionally, the resistance of ß-casein to digestion increased after HHP and Holder pasteurization due to aggregation and changes in protein structure. During intestinal digestion, Holder pasteurization induced a higher release of arginine, phenylalanine and tyrosine from HMPC compared to raw and HHP-treated HMPC. Overall, protein structural changes induced by human milk (HM) processing (freeze-thawing and filtration) and pasteurization treatments affected HMPC proteolysis during in vitro digestion. However, protein digestion behaviors were quite similar for raw and HHP-treated HMPC compared to the thermal-treated HMPC, with no effect on lactoferrin digestion. Consequently, pasteurization of HMPC by HHP represents an interesting non-thermal process that preserves the HM bioactive proteins during digestion.

Impact of holder, high temperature short time and high hydrostatic pressure pasteurization methods on protein structure and aggregation in a human milk protein concentrate.

This work evaluated the impact of high temperature short time (HTST, 72 °C, 15 s), high hydrostatic pressure (HHP, 400-600 MPa at 5 and 10 min) and Holder pasteurization (HoP, 62.5 °C, 30 min) on protein profile and aggregation in a human milk protein concentrate (HMPC). The structural changes induced in milk proteins were investigated in HMPC as well as in sedimentable and non-sedimentable fractions recovered after ultracentrifugation. The results showed that heat treatments induced more protein denaturation and aggregation than did HHP treatments. Indeed, heat-induced protein aggregates observed in HMPC and the sedimentable fraction were mainly composed of lactoferrin and α-lactalbumin. More specifically, the concentration of lactoferrin in HMPC decreased by 86% after HTST and HoP whereas no effect was observed after HHP treatment. These results show the potential of HHP processing as a pasteurization method for HMPC since it minimizes the impact on protein structure, which generally correlates to protein quality and bioactivity.

Occurrence of Peptide-Peptide Interactions during the Purification of Self-Assembling Peptide f1-8 from a ß-Lactoglobulin Tryptic Hydrolysate.

Self-assembling peptides have gained attention because of their nanotechnological applications. Previous work demonstrated that the self-assembling peptide f1-8 (Pf1-8) that is generated from the tryptic hydrolysis of ß-lactoglobulin can form a hydrogel after several purification steps, including membrane filtration and consecutive washes. This study evaluates the impact of each processing step on peptide profile, purity, and gelation capacity of each fraction to understand the purification process of Pf1-8 and the peptide-peptide interactions involved. We showed that peptide-peptide interactions mainly occurred through electrostatic and hydrophobic interactions, influencing the fraction compositions. Indeed, the purity of Pf1-8 did not correlate with the number of wash steps. In addition to Pf1-8, two other hydrophobic peptides were identified, peptide f15-20, and peptide f41-60. The gelation observed could be induced either through peptide-peptide interactions or through self-assembling, both being driven by non-covalent bond and more specifically hydrophobic interactions.

A Human Milk-Based Protein Concentrate Developed for Preterm Infants Retains Bioactive Proteins and Supports Growth of Weanling Rats.

BACKGROUND: Bovine milk-based protein modulars are currently available to nutrient-enrich enteral feedings; however, they have limitations for use in very-low-birth-weight infants. OBJECTIVES: Our objectives were to develop a human milk-based protein (HMP) concentrate and to conduct a preclinical assessment of the HMP concentrate in weanling rats. METHODS: An HMP concentrate was produced from donor milk using pressure-driven membrane filtration processes and high hydrostatic pressure processing. Protein and lactoferrin concentrations and lysozyme activity were determined by Kjeldahl, HPLC, and turbidimetric assay, respectively. Male Sprague Dawley rats 24 d old (n = 30) were randomly assigned to 1 of 3 isocaloric AIN-93G diets for 4 wk containing 100% casein (control) or with 50% of the casein replaced with the HMP concentrate (treatment) or a bovine whey protein isolate (treatment). Body weight, food intake, fat mass, plasma amino acid profiles, and organ weights were measured. Data were analyzed using linear regression models. RESULTS: Raw donor milk contained (mean ± SD) 101 ± 6 g protein/kg and 5 ± 1 g lactoferrin/kg of milk solids. Postprocessing, protein and lactoferrin concentrations were 589 ± 3 g/kg and 29 ± 10 g/kg, respectively. Lysozyme activity was initially 209 ± 4 U/kg and increased to 959 ± 39 U/kg in the HMP concentrate. There were no statistically significant differences in body weight, food intake, fat mass, or plasma amino acid profiles between rats fed diets containing the HMP concentrate and the control diet. Full cecum weights were higher in rats fed the HMP concentrate than in those fed control diets (mean difference: 5.59 g; 95% CI: 4.50, 6.68 g; P < 0.0001), likely reflecting the concentration of human milk oligosaccharides. No differences were found for other organ weights. CONCLUSIONS: The HMP concentrate retained important bioactive proteins and supported normal rat growth in the preclinical assessment.

The ultrafiltration molecular weight cut-off has a limited effect on the concentration and protein profile during preparation of human milk protein concentrates.

Optimizing protein intake for very low birth weight (<1,500 g) infants is fundamental to prevent faltering postnatal growth with the potential association of impaired neurodevelopment. The protein content of human milk is not sufficient to support the growth of very low birth weight infants. To meet their elevated protein requirements, human milk is currently fortified using typically bovine milk-based protein isolates (>85% on a dry basis). However, these products have several limitations for use in this vulnerable population. To overcome the shortcomings of bovine milk-based protein supplement, a human milk protein concentrate (HMPC) was developed. In preliminary attempts using 10 kDa ultrafiltration (UF) membranes, it was not possible to reach the protein content of commercial protein isolates, presumably due to the retention of human milk oligosaccharides (HMO). Consequently, it was hypothesized that the use of a UF membrane with a higher molecular weight cut-off (50 kDa rather than 10 kDa) could improve the transmission of carbohydrates, including HMO, in the permeate, thus increasing the protein purity of the subsequent HMPC. The results showed that permeate fluxes during the concentration step were similar to either UF molecular weight cut-off, but the 50-kDa membrane had a higher permeate flux during the diafiltration sequence. However, it was not sufficient to increase the protein purity of the human milk retentate, as both membranes generated HMPC with similar protein contents of 48.8% (10 kDa) and 50% (50 kDa) on a dry basis. This result was related to the high retention of HMO, mainly during the concentration step, although the diafiltration step was efficient to decrease their content in the HMPC. As the major bioactive proteins (lactoferrin, lysozyme, bile salt stimulated lipase, and α1-antitrypsin) in human milk were detected in both HMPC, the 50-kDa membrane seems the most appropriate to the preparation of HMPC in terms of permeation flux values. However, improving the separation of HMO from proteins is essential to increase the protein purity of HMPC.

Production of highly purified fractions of α-lactalbumin and ß-lactoglobulin from cheese whey using high hydrostatic pressure.

Despite extensive research on the topic, valorization of dairy by-products remains challenging. Cheese whey is of particular interest because it contains valuable proteins such as α-lactalbumin (α-LA) and ß-lactoglobulin (ß-LG). However, selective fractionation of these 2 proteins into pure fractions is complex because of their similar molecular weights. In this study, we proposed an innovative protein separation strategy based on coupling high hydrostatic pressure (HHP) with acidification of whey at pH 4.6. We investigated the effect of single-cycle HHP (600 MPa) for 5, 10, and 15 min and multiple-cycle HHP (1-3 cycles of 5 min at 600 MPa) on α-LA and ß-LG fractionation from cheese whey at initial pH (control, pH 6.66) and acidified to pH 4.6. All pressurization conditions with acidified whey induced a drastic aggregation of ß-LG compared with control whey. The highest degrees of purification (75 and 98%, respectively) and yields (95 and 88%, respectively) of α-LA and ß-LG were obtained with the application of single-cycle HHP treatment of acidified whey at pH 4.6 at 600 MPa for 5 min. Our results showed the strong potential of using HHP as an innovative tool for the fractionation of valuable proteins such as α-LA from cheese whey.

High hydrostatic pressure induced extraction and selective transfer of ß-phosvitin from the egg yolk granule to plasma fractions.

Egg yolk phosvitin is of particular interest due to its functional and biological properties. Recently, it was demonstrated that high hydrostatic pressure (HHP) (400 MPa for 5 min) induced the transfer of folic acid and phosvitin from the egg yolk granule to the plasma fraction. A granule fraction (Gin) produced by egg yolk centrifugation was pressure-treated at 400 and 600 MPa for 5 and 10 min, and centrifuged to generate granule fractions (GP1 to GP4) and plasmas (PP1 to PP4). Iron and phosphorus contents were also increased in PP1 to PP4 fractions, confirming the transfer of phosvitins from pressure-treated granule to plasma. Pressurization drastically improved phosvitin recovery in PP fractions, specifically at 600 MPa for 10 min, which had the highest value of phosvitin/100 mg of dry plasma at 33.3 ± 4.39 mg. Consequently, HHP represents an alternative approach for phosvitin transfer and recovery in the egg yolk soluble fraction.

Evaluation of casein as a binding ligand protein for purification of alpha-lactalbumin from beta-lactoglobulin under high hydrostatic pressure.

Fractionation of ß-lactoglubulin (ß-lg) and α-lactalbumin (α-la) using conventional separation technologies remains challenging mainly due to similar molecular weight. Herein, casein (CN) was used as ligand protein to specifically aggregate ß-lg under high hydrostatic pressure (HHP) in order to separate α-la after acidification to pH 4.6. Specifically, we studied the effect of different concentration of CN on α-la purity and recovery. Model solutions of α-la, ß-lg and CN (from 0 to 5 mg/mL) were pressurized (600 MPa-5 min). After acidification and centrifugation of pressure-treated solutions, purity of α-la was increased up to 78% with a recovery of 88% for solution without CN. In contrast with our initial hypothesis, the presence of CN decreased ß-lg pressure-induced aggregation and co-precipitation upon acidification and significantly reduced purity (∼71%). Therefore, our results suggest a chaperone-like activity of CN on ß-lg pressure-induced aggregation which needs further investigation.

High hydrostatic pressure-assisted enzymatic hydrolysis improved protein digestion of flaxseed protein isolate and generation of peptides with antioxidant activity.

Exploration of innovative high hydrostatic pressure (HHP)-assisted enzymatic hydrolysis of plant based food proteins may help improve peptide yield and bioactivity of hydrolysates. In this study, we performed enzymatic hydrolysis of flaxseed proteins using trypsin under HHP (100 and 300 MPa for 5 and 10 min) to evaluate the effect of presurization on protein denaturation, degree of hydrolysis (DH), and peptide profile and bioactivity of hydrolysate. Spectrofluorimetric analyses showed that 300 MPa induced the maximum destablization of flaxseed protein structures. The same pressure level drastically improved the DH by 1.7 times as compared to that of control. Applying HHP did not modify the peptide profiles of flaxseed protein hydrolysates but their concentrations increased with severity of treatment. Similarly, peptide molecular weight distributions were affected by pressurization parameters, increasing mainly the relative abundance of 500-1500 Da peptides. Finally, pressurization at 300 MPa for 5 and 10 min improved the antioxidant activity of flaxseed protein hydrolysates by 39 and 55%, respectively, compared to the control.

Formation of Stable Supramolecular Structure with ß-Lactoglobulin-Derived Self-Assembling Peptide f1-8 and Bovine Micellar Caseins.

The development of stable macromolecular structures with tailored functional properties in the dairy industry using innovative stabilizers is of great interest. The self-assembling peptide f1-8 (Pf1-8) derived from ß-lactoglobulin was found to interact with whey proteins, consequently changing their physicochemical properties. The objective of the present work was to evaluate the interaction between Pf1-8 and micellar casein (CN) and the changes in their physicochemical properties and stability at different pH values (6.6-2.6) on model solutions containing CN and Pf1-8 at various ratios (1:1, 5:1, and 10:1) using spectrofluorimetry, TEM, SEC-HPLC, and SDS-PAGE analyses. No CN precipitation occurred for the solution at the 1:1 ratio even at pH values below 4.6. In all samples, CN was completely dissociated to primary casein particles (PCP) to form stable supramolecular structures strongly bound to peptide gels via hydrophobic interactions. Thus, a novel milk-protein-derived peptide responsible for stabilizing complex structures composed of CN was discovered.