Enhancing surfactin production in B. velezensis Bs916 combined cumulative mutagenesis and expression key enzymes.

Surfactin is a lipopeptide which has attracted massive attention due to its versatile bioactive properties, although it has less commercial application due to its low yield in wild strains. The B. velezensis Bs916 has enable commercial production of surfactin due to its outstanding capacity to synthesize lipopeptides and amenable to genetically engineering. In this study, 20 derivatives with high surfactin production were obtained firstly by transposon mutagenesis and knockout techniques, and the surfactin yield of the derivative H5 (△GltB) was increased approximately 7-folds, reaching to 1.48 g/L. The molecular mechanism of high yielding surfactin in △GltB was investigated by the transcriptomic and KEGG pathway analysis. The results indicated that △GltB enhanced its ability to synthesize surfactin mainly by promoting transcription of the srfA gene cluster and inhibiting degradation of some key precursors such as fatty acid. Secondly, we obtained a triple mutant derivative BsC3 by cumulative mutagenesis of the negative genes GltB, RapF, and SerA, and it could increase the surfactin titer by twofold, reaching to 2.98 g/L. Thirdly, we achieved overexpression of two key rate-limiting enzyme genes, YbdT, and srfAD, and the derivative BsC5 which further increased the surfactin titer by 1.3-fold, reaching to 3.79 g/L. Finally, the yield of surfactin by derivatives was significantly increased under the optimal medium, particularly the BsC5 increased the surfactin titer to 8.37 g/L. To the best of our knowledge, this is one of the highest yields that have been reported. Our work may pave way for large scale production of surfactin by B. velezensis Bs916. KEY POINTS: • Elucidation of the molecular mechanism of surfactin high-yielding transposon mutant. • Genetically engineering of B. velezensis Bs916 surfactin titer to 8.37 g/L for large scale preparation.

Genome Sequencing and Genetic Engineering Reveal the Contribution of Bacitracin Produced by Bacillus paralicheniformis CPL618 to Anti-Staphylococcus aureus Activity.

Staphylococcus aureus is one of the important pathogens causing human diseases, especially its treatment has great challenges due to its resistance to methicillin and vancomycin. The Bacillus strains are known to be major sources of second metabolites that can function as drugs. Therefore, it is of great value to excavate metabolites with good inhibitory activity against S. aureus from Bacillus strains. In this study, a strain Bacillus paralicheniformis CPL618 with good antagonistic activity against S. aureus was isolated and genome analysis showed that the size was 4,447,938 bp and contained four gene clusters fen, bac, dhb, and lch which are potentially responsible for four cyclic peptides fengycin, bacitracin, bacillibactin, and lichenysin biosynthesis, respectively. These gene clusters were knockout by homologous recombination. The bacteriostatic experiment results showed that the antibacterial activity of ∆bac decreased 72.3% while Δfen, Δdhb, and ΔlchA did not significantly changed as that of wild type. Interestingly, the maximum bacitracin yield was up to 92 U/mL in the LB medium, which was extremely unusual in wild type strains. To further improve the production of bacitracin, transcription regulators abrB and lrp were knocked out, the bacitracin produced by ΔabrB, Δlrp, and ΔabrB + lrp was 124 U/mL, 112 U/mL, and 160 U/ml, respectively. Although no new anti-S. aureus compounds was found by using genome mining in this study, the molecular mechanisms of high yield of bacitracin and anti-S. aureus in B. paralicheniformis CPL618 were clarified. Moreover, B. paralicheniformis CPL618 was further genetically engineered for industrial production of bacitracin.

An update on the review of microbial synthesis of glucosamine and N-acetylglucosamine.

Glucosamine (GlcN) is a natural amino monosaccharide in which a hydroxyl group of glucose is substituted by an amino group. It belongs to functional amino sugar compounds. In the traditional preparation process, GlcN and GlcNAc are obtained by hydrolyzing the cell wall of shrimp and crab. There are many potential problems with this method, such as geographical and seasonal restrictions on the supply of raw materials, serious environmental pollution and potential allergic reactions. Microbial fermentation has the advantages of mild conditions, low environmental pollution, high production intensity, and product safety. It can effectively solve the problem of shrimp and crab hydrolysis process, attracting many researchers to participate in the research of microbial fermentation production of GlcN. This paper mainly summarizes the research on strain construction method, metabolic pathway design and fermentation condition optimization in microbial fermentation, which has certain guiding significance for the further production, research and production of glucosamine.

An acetate-independent pathway for isopropanol production via HMG-CoA in Escherichia coli.

Isopropanol has a good potential as a new fuel substitution. In the model biosynthesis pathway of isopropanol synthesis, acetoacetyl-CoA is converted to acetoacetate by acetoacetyl-CoA transferases, which requires an acetate molecule as a substrate. Herein, a novel isopropanol synthesis pathway based on mammalian ketone metabolic pathway was developed. In this pathway, acetoacetyl-CoA is condensed with acetyl-CoA to generate 3-hydroxy-3-methylglutaryl-CoA (HMG-CoA) by HMG-CoA synthase, and then catalyzed by HMG-CoA lyase to generate acetoacetate. This process is acetate-independent. Under the same experimental system using glycerol as carbon source, the E. coli strain MG::ISOP1 containing the novel pathway produced 11.7 times more isopropanol than the strain MG::ISOP0 containing the model pathway. The pta-ackA knockout mutant strain MG∆pta-ackA::ISOP1, which reduced the conversion of acetyl-CoA to acetate, further increased the production from 76 mg/L to 360 mg/L. In another strategy, knocking out atoDA to block the acetoacetate degradation pathway in strain MG∆atoDA::ISOP1 increased the production to 680 mg/L. By knocking out both of pta-ackA and atoDA, strain MGΔpta-ackAΔatoDA::ISOP1 produced 964 mg/L of isopropanol, which was 12.7 times that of MG::ISOP1. This study indicated that the novel pathway is competent for isopropanol synthesis, and provides a new perspective for biosynthesis of isopropanol.

A review on microbial synthesis of lactate-containing polyesters.

Degradable polylactic acids (PLA) have been widely used in agriculture, textile, medicine and degradable plastics industry, and can completely replace petroleum-based plastics in the future. At present, polylactic acid was chemically synthesized by ring-opening polymerisation or the direct polycondensation of lactic acid, which inevitably leads to chemical and heavy metal catalyst pollution. The current research focus has gradually shifted to the development of recombinant industrial strains for the efficiently production of lactate-containing polyesters from renewable resources. This review summarizes various explorations of metabolic pathway optimization and production cost control in the industrialization of lactate-containing polyesters bio-production. In particular, the effects of key enzymes, including CoA transferase, polyhydroxyalkanoate synthase, and their mutants, culture conditions, low-cost carbon sources, and recombinant strains on the yield and composition of lactate-containing polyesters are summarized and discussed. Future prospects and challenges for the industrialization of lactate-containing polyesters are also pointed out.

A gas chromatography-flame ionization detection method for direct and rapid determination of small molecule volatile organic compounds in aqueous phase.

It is still difficult to directly detect low content of volatile organic compounds (VOCs) in water samples by gas chromatography (GC) because when water is the only solvent, it would result in the instability and poor repeatability of peak retention time and peak shape. The adverse effects of water on direct GC analysis of VOCs cannot be significantly reduced or eliminated by simply changing the detection condition of GC. However, it was found that the addition of methanol in samples to a certain final proportion, such as 50 or 75% (v/v), could greatly reduce or eliminate the adverse effects of water. By using 75% (v/v) methanol as a solvent, the standard curves of ethanol, acetic acid, acetone, and isopropanol with correlation coefficient (R 2) over 0.99 were successfully plotted by gas chromatography-flame ionization detection (GC-FID) in a certain concentration range, respectively. The results showed that the retention time and peak shape stability of ethanol, acetic acid, acetone, and isopropanol in aqueous solution were greatly improved by the addition of methanol to final concertation of 75% (v/v). To verify the practical application potential of this method, the method was applied to the detection of components in isopropanol fermentation wastewater. The results showed that the method has well applicability and reliability. The key points in the application of this method were also summarized. This GC analysis method would have a wider and better application prospect in the detection of water-soluble organic matters.

Knockout of acetoacetate degradation pathway gene atoDA enhances the toxicity tolerance of Escherichia coli to isopropanol and acetone.

Isopropanol and acetone are important chemical products and potential high-quality new fuels. Both of them are metabolites of isopropanol synthesis pathway, but they are toxic to most bacteria. In this study, toxicity tolerance of Escherichia coli strains was evaluated by detecting their growth rates under different concentrations of isopropanol and acetone. It was showed that isopropanol was more toxic to E. coli than acetone, and the native strain MG1655 had better tolerance over DH5α to either acetone or isopropanol of 300 mM. Key genes of ethanol synthesis pathway, acetic acid metabolism pathway, and acetoacetic acid degradation pathway, including adhE, ackA-pta, and atoDA, were knocked out in MG1655 to form mutants MGΔadhE, MGΔackA-pta, and MGΔatoDA. The tolerance performances of the mutants to isopropanol and acetone were determined under various concentrations including 300 mM, 500 mM, and 700 mM, respectively. The mutant MGΔatoDA exhibited excellent tolerance to both acetone and isopropanol of 500 mM, and MGΔackA-pta could tolerate acetone at 500 mM rather than isopropanol, while the deletion of adhE in MGΔadhE resulted in a severe cell growth defection. Although isopropanol and acetone at 700 mM caused severe growth inhibition on each strain, cell growth could be restored to varying degrees with the prolongation of culture time. This phenomenon was suggested to be related to the volatilization of isopropanol and acetone based on volatilization tests. It was envisioned that MG1655 was a suitable host strain for isopropanol metabolic engineering research, and the acetoacetic acid degradation pathway gene atoDA, was probably the key optimizing point for isopropanol production.

Calcium Involved Directional Organization of Polymer Chains in Polyester Nanogranules in Bacterial Cells.

Soil bacteria accumulate polyesters (typically poly([R]-3-hydroxybutyrate (PHB), in which one end of the chain terminates with a carboxyl group) in the form of hydrated, amorphous nanogranules in cells. However, it is not clear what drives the structure of these biomaterials inside bacterial cells. Here, we determined that calcium guides intracellular formation of PHB nanogranules. Our systematic study using the surface zeta potential measurement and the carboxyl-specific SYTO-62 dye binding assay showed that the terminal carboxyl is not exposed to the granule surface but is buried inside native "unit-granules" comprising the mature granule. Extracellular Ca2+ was found to mediate the formation of these PHB unit-granules, with uptaken Ca2+ stored inside the granules. Comparative [Ca2+]-dependent fluorescence spectroscopy revealed that the native granules in Cupriavidus necator H16 act as a Ca2+ storage system, presumably for the regulation of its cytosolic Ca2+ level, but those from recombinant Escherichia coli do not. This study reveals intimate links between Ca2+ and native granule formation, and establishes a novel mechanism that intracellular PHB granules function as Ca2+ storage in order to relieve soil bacteria from Ca2+ stress.

The role of temperature and bivalent ions in preparing competent Escherichia coli.

Several factors including the culture temperature, bivalent ion, and osmotic stress were gradually optimized for preparing efficient Escherichia coli competent cells. The effect of culture temperature on the transformation efficiency (TrE) of E. coli DH5α was tested with 100 mM CaCl2. The lower culture temperature at 18 °C resulted in higher TrE of 2.5 × 106 cfu/µg, which was about 3.5 times of that obtained at 37 °C. Bivalent ions including Ca2+, Mn2+, Mg2+, and Ni2+ were tested independently or combinatorially at a total concentration of 100 mM. Ni2+ showed a significantly inhibition on the TrE, and various concentration combinations of Ca2+, Mg2+, and Mn2+ were tested. The TrE was improved up to 1.8 ± 0.4 × 108 cfu/µg, when a combination of 25 mM Ca2+, 50 mM Mg2+, and 25 mM Mn2+ was applied. Further supplement of 0.8% (w/v) PEG6000 lead to a slight decrease in the TrE, whereas supplement of 25 mM sucrose contributed to another increase in the TrE by 17% up to 2.1 ± 0.3 × 108 cfu/µg. These results indicated that the culture temperature and bivalent ion were important factors affecting the TrE of E. coli. A chemical method for preparing efficient competent cells of E. coli was provided.

Simultaneous inhibition of rhamnolipid and polyhydroxyalkanoic acid synthesis and biofilm formation in Pseudomonas aeruginosa by 2-bromoalkanoic acids: effect of inhibitor alkyl-chain-length.

Pseudomonas aeruginosa, an opportunistic human pathogen is known to synthesize rhamnolipid and polyhydroxyalkanoic acid (PHA) of which the acyl-group precursors (e.g., (R)-3-hydroxydecanoic acid) are provided through RhlA and PhaG enzyme, respectively, which have 57% gene sequence homology. The inhibitory effect of three 2-bromo-fatty acids of 2-bromohexanoic acid (2-BrHA), 2-bromooctanoic acid (2-BrOA) and 2-bromodecanoic acid (2-BrDA) was compared to get an insight into the biochemical nature of their probable dual inhibition against the two enzymes. The 2-bromo-compounds were found to inhibit rhamnolipid and PHA synthesis simultaneously in alkyl-chain-length dependent manner at several millimolar concentrations. The separate and dual inhibition of the RhlA and PhaG pathway by the 2-bromo-compounds in the wild-type cells was verified by investigating their inhibitory effects on the rhamnolipid and PHA synthesis in P. aeruginosa ΔphaG and ΔrhlA mutants. Unexpectedly, the order of inhibition strength was found 2-BrHA (≥90% at 2 mM) > 2-BrOA > 2-BrDA, equally for all of the rhamnolipids and PHA synthesis, swarming motility and biofilm formation. We suggest that the novel strongest inhibitor 2-BrHA could be potentially exploited to control the rhamnolipid-associated group behaviors of this pathogen as well as for its utilization as a lead compound in screening for antimicrobial agents based on new antimicrobial targets.

A Brassica napus lipase locates at the membrane contact sites involved in chloroplast development.

BACKGROUND: Fatty acids synthesized in chloroplast are transported to endoplasmic reticulum (ER) for triacylglycerols (TAGs) resembling. The development of chloroplast also requires lipids trafficking from ER to chloroplast. The membrane contact sites (MCSs) between ER and chloroplast has been demonstrated to be involved for the trafficking of lipids and proteins. Lipids trafficking between ER and chloroplast is often accompanied by lipids interconversion. However, it is rarely known how lipids interconversion happens during their trafficking. METHODOLOGY/PRINCIPAL FINDINGS: We cloned a lipase gene from Brassica napus L., designated as BnCLIP1. Green fluorescence protein (GFP)-tagged BnCLIP1 was shown to locate at the MCSs between ER and chloroplasts in tobacco leaves. Heterogeneous expression of BnCLIP1 in Saccharomyces cerevisiae (pep4) reduced the total amount of fatty acid. Gas chromatography-mass spectrometry (GC-MS) analysis revealed that the truncated BnCLIP1 had a substrate preference for C16:0 lipids in Saccharomyces cerevisiae (pep4). To probe the physiological function of BnCLIP1, two Brassica napus lines with different oil-content were introduced to investigate the transcript patterns of BnCLIP1 during seed development. Intriguingly, the transcript level of BnCLIP1 was found to be immediately up-regulated during the natural seed senescence of both lines; the transcription response of BnCLIP1 in the high oil-content seeds was faster than the lower ones, suggesting a potential role of BnCLIP1 in affecting seed oil synthesis via regulating chloroplast integrity. Further researches showed that chemical disruption of leaf chloroplast also activated the transcription of BnCLIP1. CONCLUSIONS/SIGNIFICANCE: The findings of this study show that BnCLIP1 encodes a lipase, localizes at the MCSs and involves in chloroplast development.