ABSTRACT
Bitumen extraction in Alberta's oil sands region uses large volumes of water, leading to an abundance of oil sands process-affected water (OSPW). OSPW contains naphthenic acid fraction compounds (NAFCs) which have been found to contribute to OSPW toxicity. This study utilized a multistep treatment, coupling biological degradation with UV photocatalytic oxidation, and nutrient addition to boost the native microbial community's degradation capacity. OSPW initially contained 40-42 mg/L NAFCs with a toxicity of 3.8-3.9 TU. Initial biodegradation (Step 1) was used to remove the easily biodegradable NAFCs (11-25% removal), followed by a light or heavy dose of oxidation (Step 2) to breakdown the recalcitrant NAFCs (66-82% removal). Lastly, post-oxidation biodegradation with nutrients (Step 3) removed the residual bioavailable NAFCs (16-31% removal). By the end of the multistep treatment, the final NAFC concentrations and toxicity ranged from 5.3 to 6.8 mg/L and 1.1-1.2 TU. Analysis showed that OPSW was limited in phosphorus (below detection limit), and the addition of nutrients improved the degradation of NAFCs. Two treatments throughout the multistep treatment never received nutrients and showed minimal NAFC degradation post-oxidation. The native microbial community survived the stress from UV photocatalytic oxidation as seen by the post-oxidation NAFC biodegradation. Microbial community diversity was reduced considerably following oxidation, but increased with nutrient addition. The microbial community consisted predominately of Proteobacteria (Gammaproteobacteria and Alphaproteobacteria), and the composition shifted depending on the level of oxidation received. Possible NAFC-degrading microbes identified after a light oxidation dose included Pseudomonas, Acinetobacter and Xanthomonadales, while Xanthobacteracea and Rhodococcus were the dominant microbes after heavy oxidation. This experiment confirms that the microbial community is capable of degrading NAFCs and withstanding oxidative stress, and that degradation is further enhanced with the addition of nutrients.
Subject(s)
Biodegradation, Environmental , Carboxylic Acids , Oil and Gas Fields , Oxidation-Reduction , Titanium , Ultraviolet Rays , Water Pollutants, Chemical , Water Pollutants, Chemical/metabolism , Water Pollutants, Chemical/analysis , Titanium/chemistry , Carboxylic Acids/metabolism , Alberta , Catalysis , Hydrocarbons/metabolismABSTRACT
Oil sands process-affected water (OSPW) is a by-product of the extraction of bitumen, and volumes of OSPW have accumulated across the Alberta oil sands region due to the governments zero-discharge policy. Some dissolved organics in OSPW, including toxic naphthenic acids (NAs), can be biodegraded in oxic conditions, thereby reducing the toxicity of OSPW. While there has been much focus on degradation of NAs, the biodegradation of other dissolved organic chemicals by endogenous organisms remains understudied. Here, using the HPLC-ultrahigh resolution Orbitrap mass spectrometry, we examined the microbial biodegradation of dissolved organic acids in OSPW. Non-targeted analysis enabled the estimation of biodegradation rates for unique heteroatomic chemical classes detected in negative ion mode. The microcosm experiments were conducted with and without nutrient supplementation, and the changes in the microbial community over time were investigated. Without added nutrients, internal standard-adjusted intensities of all organics, including NAs, were largely unchanged. The addition of nutrients increased the biodegradation rate of O2- and SO2- chemical classes. While anoxic biodegradation can occur in tailings ponds and end pit lakes, microbial community analyses confirmed that the presence of oxygen stimulated biodegradation of the OSPW samples studied. We detected several aerobic hydrocarbon-degrading microbes (e.g., Pseudomonas and Brevundimonas), and microbes capable of degrading sulfur-containing hydrocarbons (e.g., Microbacterium). Microbial community diversity decreased over time with nutrient addition. Overall, the results from this study indicate that toxic dissolved organics beyond NAs can be biodegraded by endogenous organisms in OSPW, but reaffirms that biological treatment strategies require careful consideration of how nutrients and dissolved oxygen may impact efficacy.
Subject(s)
Oil and Gas Fields , Water Pollutants, Chemical , Water Pollutants, Chemical/analysis , Organic Chemicals , Carboxylic Acids/chemistry , Oxygen/analysisABSTRACT
Engineering strategies to reduce greenhouse gases (GHGs) emissions by inhibiting methanogenesis in oil sands tailings have rarely been examined. In this study, we explored the potential impact of chemical treatment (lime) and biological treatment using enzymes (lysozyme and protease) on inhibiting methane emissions from tailings. Overall, treatment with protease 3%, lysozyme 3%, and lime 5000 ppm reduced CH4 production (by 52%, 28%, and 25%, respectively) and were weakly associated with the archaeal abundance. Enzymes treatment resulted in a higher reduction in CH4 production compared with lime treatment. A 3% lysozyme treatment suppressed CH4 production (the change in methane was 0.48 mmol) and reduced the degradation of hexane throughout the experiment. Similarly, 3% protease suppressed CH4 production throughout the experiment (the change in methane was 0.78 mmol), which could be attributed to the pH reduction to pH 4.9 at week 23 resulting from the formation of volatile fatty acids. Another possible mechanism could be the formation of toxic compounds, such as high nitrogen content, after protease treatment that inhibited the microbial community. The toxicity effect to Vibrio fischeri was greater with lysozyme 3% and protease 3% treatment than with lime treatment (124 TU and 76 TU, respectively). Lime treatment resulted in the highest reduction in 16S rRNA gene copies from 5.7 × 106 cells g-1 (control) to 2.7 × 105, 1.71 × 105, and 1.4 × 105 cells g-1 for 1600, 3500, and 5000 ppm treatments, respectively. This study supports further work to examine and determine the optimum conditions (e.g., enzyme and lime dosages) for CH4 inhibition.
Subject(s)
Methane , Oil and Gas Fields , Methane/metabolism , Muramidase , RNA, Ribosomal, 16S/genetics , Peptide HydrolasesABSTRACT
End pit lakes (EPLs) have been proposed as a method of reclaiming oil sands fluid fine tailings (FFT), which consist primarily of process-affected water and clay- and silt-sized particles. Base Mine Lake (BML) is the first full-scale demonstration EPL and contains thick deposits of FFT capped with water. Because of the fine-grained nature of FFT, turbidity generation and mitigation in BML are issues that may be detrimental to the development of an aquatic ecosystem in the water cap. Laboratory mixing experiments were conducted to investigate the effect of mudline biofilms made up of microbial communities indigenous to FFT on mitigating turbidity in EPLs. Four mixing speeds were tested (80, 120, 160, and 200 rpm), all of which are above the threshold velocity required to initiate erosion of FFT in BML. These mixing speeds were selected to evaluate (i) the effectiveness of biofilms in mitigating turbidity and (ii) the mixing speed required to 'break' the biofilms. The impact of biofilm age (10 weeks versus 20 weeks old) on turbidity mitigation was also evaluated. Diverse microbial communities in the biofilms included photoautotrophs, namely cyanobacteria and Chlorophyta (green algae), as well as a number of heterotrophs such as Gammaproteobacteria, Desulfobulbia, and Anaerolineae. Biofilms reduced surface water turbidity by up to 99%, depending on the biofilm age and mixing speed. Lifting and layering in the older biofilms resulted in weaker attachment to the FFT; as such, younger biofilms performed better than older biofilms. However, older biofilms still reduced turbidity by 69% to 95%, depending on the mixing speed. These results indicate that biostabilization is a promising mechanism for turbidity mitigation in EPLs.
ABSTRACT
The extraction of bitumen from the Albertan oilsands produces large amounts of oil sands process-affected water (OSPW) that requires remediation. Classical naphthenic acids (NAs), a complex mixture of organic compounds containing O2- species, are present in the acid extractable organic fraction of OSPW and are a primary cause of acute toxicity. A potential remediation strategy is combining chemical oxidation and biodegradation. Persulfate as an oxidant is advantageous, as it is powerful, economical, and less harmful towards microorganisms. This is the first study to examine persulfate oxidation coupled to biodegradation for NA remediation. Merichem NAs were reacted with 100, 250, 500, and 1000 mg/L of unactivated persulfate at 21 °C and 500 and 1000 mg/L of activated persulfate at 30 °C, then inoculated with Pseudomonas fluorescens LP6a after 2 months. At 21 °C, the coupled treatment removed 52.8-98.9% of Merichem NAs, while 30 °C saw increased removals of 99.4-99.7%. Coupling persulfate oxidation with biodegradation improved removal of Merichem NAs and chemical oxidation demand by up to 1.8× and 6.7×, respectively, and microbial viability was enhanced up to 4.6×. Acute toxicity towards Vibrio fischeri was negatively impacted by synergistic interactions between the persulfate and Merichem NAs; however, it was ultimately reduced by 74.5-100%. This study supports that persulfate oxidation coupled to biodegradation is an effective and feasible treatment to remove NAs and reduce toxicity.
ABSTRACT
Surface water turbidity from dispersed clay particles can hinder the development of aquatic ecosystems. One of the primary objectives for proposed oil sands end pit lakes is that they support ecological functions and lake-specific wildlife habitat. However, high surface water turbidity has been observed in the Base Mine Lake cap water, the first full-scale demonstration oil sands end pit lake. Our previous study showed that adjusting the solution pH through carbon dioxide (CO2) addition reduced surface water turbidity in oil sands tailings. Carbonate minerals such as calcite and dolomite were also previously identified in tailings, and thus the goal of this study was to determine the effect of calcite and dolomite dissolution through CO2-mediated pH reduction on turbidity and the stability of suspended clay particles. Calcite dissolution resulted in â¼99% reduction of turbidity. The suspended clay particle stability was analyzed using DLVO (Derjaguin-Landau-Verwey-Overbeek) theory with water chemistry data from this column study. An inverse correlation was observed between the amount of dolomite and the energy barrier values on day 42 of the experiment. These results suggest CO2-mediated calcite dissolution changes the water chemistry and is the most promising treatment condition for the settlement of suspended tailings particles.
Subject(s)
Lakes , Oil and Gas Fields , Carbonates , Ecosystem , Minerals , SolubilityABSTRACT
Development of Alberta's oil sands requires large volumes of water, leading to the abundance of oil sands process affected water (OSPW) that must be remediated prior to discharge or reuse. OSPW contains a variety of dissolved organic compounds, however naphthenic acids (NAs) have been found to contribute significantly to the toxicity of OSPW. A fungus, Trichoderma harzianum, isolated directly from OSPW, has previously demonstrated a high tolerance and capacity for growth in the presence of commercial NAs. This study conducted microcosm experiments to elucidate and characterize the capacity of T. harzianum to degrade labile commercial NAs (Merichem), and OSPW-sourced naphthenic acid fraction compounds (NAFCs). Additionally, two model NA compounds, the simple single ring cyclohexane carboxylic acid (CHCA) and complex diamondoid 1-adamanatane carboxylic acid (ADA), were utilized to determine the influence of NA structure on degradation. T. harzianum degraded 14% of CHCA, 13% of ADA, and 23-47% of Merichem NAs. Additionally, Orbitrap mass spectrometry revealed a large change in Z-series within NAFCs. This removal and shift in composition correlated to a 59% and 52% drop in toxicity as per Microtox, for Merichem NAs and NAFCs respectively. This proof of concept experiment confirms that the fungal species T. harzianum can contribute to the biodegradation of complex dissolved organics found in OSPW, including cyclic and diamondoid structures.
Subject(s)
Carboxylic Acids/metabolism , Environmental Restoration and Remediation/methods , Oil and Gas Fields , Trichoderma/metabolism , Wastewater/microbiology , Water Pollutants, Chemical/metabolism , Adamantane/chemistry , Adamantane/metabolism , Alberta , Biodegradation, Environmental , Carboxylic Acids/chemistry , Cyclohexanes/chemistry , Cyclohexanes/metabolismABSTRACT
The expansion of oil sands has made remediation of oil sands process-affected water (OSPW) critical. As naphthenic acids (NAs) are the primary contributors to toxicity, remediation is required. Bioremediation by native microorganisms is potentially effective, however, toxicity of NAs towards native microorganisms is poorly understood. The aim of this study was to isolate microorganisms from OSPW, assess tolerance to stressors, including naturally sourced NAs and examine exposure effect of NAs on cell membranes. Microorganisms were isolated from OSPW, including the first reported isolation of a fungus (Trichoderma harzianum) and yeast (Rhodotorula mucilaginosa). Isolates tolerated alkaline pH, high salinity, and NA concentrations far exceeding those typical of OSPW indicating toxic effects of OSPW are likely the result of interactions between OSPW components. Comparisons of toxicity determined that OSPW exhibited higher cytotoxicity than NAs. The fungal isolate was able to grow using commercial NAs as its sole carbon source, indicating high resistance to NAs' cytotoxic effects. Future studies will focus on the organisms' ability to degrade NAs, and subsequent effects on toxicity. Characterization of OSPW constituents should be investigated with focus on the synergistic toxic effects of dissolved compounds. A better understanding of OSPW toxicity would enable more effective and targeted bioremediation schemes by native microorganisms.
Subject(s)
Carboxylic Acids/toxicity , Oil and Gas Fields/microbiology , Water Microbiology , Water Pollutants, Chemical/toxicity , Biodegradation, EnvironmentalABSTRACT
Naphthenic acids (NAs) originate from bitumen and are considered a major contributor to acute toxicity in oil sands process-affected water (OSPW) produced from bitumen extraction processes. To reclaim oil sands tailings and remediate OSPW, in-pit fluid fine tailings can be water-capped as end pit lakes (EPL). Addressing NAs present in OSPW, either through removal, dilution or degradation, is an objective for oil sands reclamation. EPLs can remediate NAs through degradation or dilution or both. To assess and understand degradation potential, Chlorella kessleri and Botryococcus braunii were tested for their tolerance to, and ability to biodegrade, three model NAs (cyclohexanecarboxylic acid, cyclohexaneacetic acid, and cyclohexanebutyric acid). Water sourced from the industry's first EPL, the Base Mine Lake (BML), was used alone as an inoculum or co-cultured with C. kessleri to biodegrade cyclohexanecarboxylic acid and cyclohexanebutyric acid. All cultures metabolized the model compounds via ß-oxidation. Biodegradation by the co-culture of C. kessleri and BML inoculum was most effective and rapid: the cyclohexaneacetic acid generated from cyclohexanebutyric acid could be further degraded by the co-culture, while the cyclohexaneacetic acid generated could not be consumed by pure algal cultures or BML inoculum alone. Adding C. kessleri greatly increased the diversity of the microbial community in the BML inoculum; many known hydrocarbon and NA degraders were identified from the 16S rRNA gene sequencing from this co-culture. This more diverse microbial community could have potential for EPL remediation.
Subject(s)
Biodegradation, Environmental , Carboxylic Acids/metabolism , Lakes/microbiology , Microalgae/metabolism , Oil and Gas Fields/microbiology , Acetates/metabolism , Agricultural Inoculants/metabolism , Butyrates/metabolism , Chlorella/metabolism , Cyclohexanes/metabolismABSTRACT
OBJECTIVES: Critical care medicine is a medical specialty where women remain underrepresented relative to men. The purpose of this study was to explore perceived drivers (i.e., influencing factors) and implications (i.e., associated consequences) of gender inequity in critical care medicine and determine strategies to attract and retain women. DESIGN: Qualitative interview-based study. SETTING: We recruited participants from the 13 Canadian Universities with adult critical care medicine training programs. PARTICIPANTS: We invited all faculty members (clinical and academic) and trainees to participate in a semistructured telephone interview and purposely aimed to recruit two faculty members (one woman and one man) and one trainee from each site. Interviews were transcribed verbatim, and two investigators conducted thematic analysis. INTERVENTIONS: Not applicable. MEASUREMENTS AND MAIN RESULTS: Three-hundred seventy-one faculty members (20% women, 80% men) and 105 trainees (28% women, 72% men) were invited to participate, 48 participants were required to achieve saturation. Participants unanimously described critical care medicine as a specialty practiced predominantly by men. Most women described experiences of being personally or professionally impacted by gender inequity in their group. Postulated drivers of the gender gap included institutional and interpersonal factors. Mentorship programs that span institutions, targeted policies to support family planning, and opportunities for modified role descriptions were common strategies suggested to attract and retain women. CONCLUSIONS: Participants identified a gender gap in critical care medicine and provided important insight into the impact for personal, professional, and group dynamics. Recommended improvement strategies are feasible, map broadly onto reported drivers and implications, and are applicable to critical care medicine and more broadly throughout medical specialties.
Subject(s)
Career Choice , Emergency Medicine/organization & administration , Physicians, Women/organization & administration , Workforce/organization & administration , Adult , Canada , Critical Care/organization & administration , Female , Humans , Leadership , Male , Qualitative Research , Sex Factors , Sexism/statistics & numerical dataABSTRACT
The purpose of this study was to determine the capacity of indigenous microbes in tailings to degrade bitumen aerobically, and if acetate biostimulation further improved degradation. Fluid fine tailings, from Base Mine Lake (BML), were used as microbial inocula, and bitumen in the tailings served as a potential carbon source during the experiment. The tailings were capped with 0.22⯵m-filtered BML surface water with or without BML bitumen and acetate addition and incubated for 100 days at 20⯰C. CO2 production and petroleum hydrocarbon reductions (50-70% for the biostimulation treatment) in the tailings were observed. DNA was extracted directly from the tailings, and increased bacterial density was observed by qPCR targeting the rpoB gene in the biostimulated group. 16â¯S rRNA sequencing was used to determine microbial composition profiles in each treatment group. The microbial communities indigenous to the tailings shifted after the bitumen was added. Acidovorax, Rhodoferax, Pseudomonas and Pseudoxanthomonas spp. significantly increased compared to the original microbial community and demonstrated tolerance to bitumen-based toxicity. The first three genera showed more potential for biostimulation treatment with acetate and may be important bitumen/hydrocarbon-degraders in an oil sands end pit lake environment.
Subject(s)
Bacteria/metabolism , Biodegradation, Environmental , Hydrocarbons/chemistry , Hydrocarbons/metabolism , Oil and Gas Fields/microbiology , Petroleum/metabolism , LakesABSTRACT
The long-term storage of oil sands tailings has resulted in the evolution of greenhouse gases (CH4 and CO2) as a result of residual organics biodegradation. Recent studies have identified black, sulfidic zones below the tailings-water interface, which may be producing toxic sulfur-containing gases. An anaerobic mesocosm study was conducted over an 11-week period to characterize the evolution of CH4, CO2 and reduced sulfur compounds (RSCs) (including H2S) in tailings as it relates to naphtha-containing diluent concentrations (0.2, 0.8, and 1.5% w/v) and microbial activity. Our results showed that RSCs were produced first at 0.12µmol°RSCs/mL MFT (1.5% w/v diluent treatment). RSCs contribution (from highest to lowest) was H2S and 2-methylthiophene>2.5-dimethylthiophene>3-methylthiophene>thiofuran>butyl mercaptan>carbonyl sulfide, where H2S and 2-methylthiophene contributed 81% of the gas produced. CH4 and CO2 production occurred after week 5 at 40.7µmolCH4/mL MFT and 5.9µmolCO2/mL MFT (1.5% w/v diluent treatment). The amount of H2S and CH4 generated is correlated to the amount of diluent present and to microbial activity as shown by corresponding increases in sulfate-reducers' Dissimilatory sulfite reductase (DsrAB) gene and methanogens' methyl-coenzyme M reductase (MCR) gene.
ABSTRACT
In Canada, the Athabasca oil sands deposits are a source of bitumen-derived contaminants, reaching the aquatic environment via various natural and anthropogenic pathways. The ecological effects of these contaminants are under debate. To quantify the effects of bitumen-derived contaminants we monitored the aquatic exposure of polycyclic aromatic hydrocarbons (PAHs), metals, and naphthenic acids as well as the invertebrate community in the Athabasca River and its tributaries. PAH concentrations over 3 consecutive years were related to discharge and were highest in the year with high autumn rainfall. In the year with the highest PAH concentrations, these were linked with adverse effects on the aquatic invertebrate communities. We observed relative effects of the composition and concentration of contaminants on the invertebrate fauna. This is reflected by the composition and abundance of invertebrate species via the use of the species' traits "physiological sensitivity" and "generation time". Applying the SPEAR approach we observed alterations of community structure in terms of an increased physiological sensitivity and a decrease of generation time for the average species. These effects were apparent at concentrations 100 times below the acute sensitivity of the standard test organism Daphnia magna. To rapidly identify oil sands related effects in the field we designed a biological indicator system, SPEARoil, applicable for future routine monitoring.
Subject(s)
Environmental Monitoring/methods , Hydrocarbons/analysis , Invertebrates , Oil and Gas Fields , Polycyclic Aromatic Hydrocarbons/analysis , Water Pollutants, Chemical/analysis , Alberta , Animals , RiversABSTRACT
The influence of solution chemistry on microbial transport was examined using the strictly anaerobic trichloroethene (TCE) bioaugmentation culture KB-1(®). A column was employed to determine transport behaviors and deposition kinetics of three distinct functional species in KB-1(®), Dehalococcoides, Geobacter, and Methanomethylovorans, over a range of ionic strengths under a well-controlled anaerobic condition. A quantitative polymerase chain reaction (qPCR) was utilized to enumerate cell concentration and complementary techniques were implemented to evaluate cell surface electrokinetic potentials. Solution chemistry was found to positively affect the deposition rates, which was consistent with calculated Derjaguin-Landau-Verwey-Overbeek (DLVO) interaction energies. Retained microbial profiles showed spatially constant colloid deposition rate coefficients, in agreement with classical colloid filtration theory (CFT). It was interesting to note that the three KB-1(®) species displayed similar transport and retention behaviors under the defined experimental conditions despite their different cell electrokinetic properties. A deeper analysis of cell characteristics showed that factors, such as cell size and shape, concentration, and motility were involved in determining adhesion behavior.
Subject(s)
Chloroflexi/metabolism , Geobacter/metabolism , Methanosarcinaceae/metabolism , Trichloroethylene/metabolism , Anaerobiosis , Biodegradation, Environmental , Biological Transport , Chlorine/metabolism , Chloroflexi/genetics , Chloroflexi/growth & development , Culture Media/chemistry , DNA, Archaeal/genetics , DNA, Archaeal/metabolism , DNA, Bacterial/genetics , DNA, Bacterial/metabolism , Geobacter/genetics , Geobacter/growth & development , Kinetics , Methanosarcinaceae/genetics , Methanosarcinaceae/growth & development , Microbiological Techniques/methods , Porosity , Species SpecificityABSTRACT
In this study, the biodegradation of total acid-extractable organics (TAOs), commonly called naphthenic acids (NAs), was investigated. An indigenous microbial culture containing algae and bacteria was taken from the surface of a tailings pond and incubated over the course of 120days. The influence of light, oxygen and the presence of indigenous algae and bacteria, and a diatom (Navicula pelliculosa) on the TAO removal rate were elucidated. The highest biodegradation rate was observed with bacteria growth only (without light exposure) with a half-life (t(1/2)) of 203days. The algae-bacteria consortium enhanced the detoxification process, however, bacterial biomass played the main role in toxicity reduction. Principal component analysis (PCA) conducted on FT-IR spectra, identified functional groups and bonds (representing potential markers for biotransformation of TAOs) as follows: hydroxyl, carboxyl and amide groups along with CH, arylH, arylOH and NH bonds.
Subject(s)
Bacteria/metabolism , Carboxylic Acids/metabolism , Microbial Consortia/physiology , Ponds/microbiology , Wastewater/microbiology , Water Purification/methods , Biodegradation, Environmental , Carboxylic Acids/isolation & purification , Industrial Waste/prevention & control , Mining/methods , Soil/chemistryABSTRACT
The Alberta oil sands contain one of the world's largest reserves of oil - over 169 billion barrels of bitumen are economically recoverable with current extraction technologies. Surface mining and subsequent hot water extraction of bitumen from the ore generates about nine cubic meters of raw tailings per cubic meter of oil. Oil sands facilities are required to operate under a policy of zero water discharge, resulting in ponds containing more than one billion cubic meters of tailings, a mixture of sand, fines and process-affected water. Process-affected water contains numerous organic compounds, including naphthenic acids (NAs), which have been identified as the primary source of acute toxicity of process-affected water. Developments in analytical techniques, aerobic biodegradability, and treatment via chemical oxidation (ozone) of NAs are reviewed. The field continues to be challenged by the lack of a cost-effective, accurate analytical technique for NAs or an understanding of all the organic constituents in process-affected water that may be contributing to observed toxicity and thus requiring treatment.
Subject(s)
Carboxylic Acids/analysis , Oil and Gas Fields , Water Pollutants, Chemical/analysis , Alberta , Animals , Biodegradation, Environmental , Carboxylic Acids/chemistry , Carboxylic Acids/toxicity , Mining , Molecular Structure , Water Pollutants, Chemical/chemistry , Water Pollutants, Chemical/toxicityABSTRACT
The oil sands industry faces significant challenges in developing effective remediation technologies for process-affected water stored in tailings ponds. Naphthenic acids, a complex mixture of cycloaliphatic carboxylic acids, have been of particular concern because they concentrate in tailings ponds and are a component of the acutely toxic fraction of process water. Ozone treatment has been demonstrated as an effective means of rapidly degrading naphthenic acids, reducing process water toxicity, and increasing its biodegradability following seeding with the endogenous process water bacteria. This study is the first to examine subsequent in situ biodegradation following ozone pretreatment. Two aged oil sands process-affected waters from experimental reclamation tailings ponds were ozonated to reduce the dissolved organic carbon, to which naphthenic acids contributed minimally (<1mgL(-1)). Treatment with an ozone dose of 50mgL(-1) improved the 84d biodegradability of remaining dissolved organic carbon during subsequent aerobic incubation (11-13mgL(-1) removed from aged process-affected waters versus 5mgL(-1) when not pretreated with ozone). The ozone-treated indigenous microbial communities were as capable of degrading organic matter as the same community not exposed to ozone. This supports ozonation coupled with biodegradation as an effective and feasible treatment option.
Subject(s)
Environmental Restoration and Remediation/methods , Oil and Gas Fields , Water Microbiology , Water Pollutants, Chemical/analysis , Biodegradation, Environmental , Industrial Waste/analysis , Ozone/chemistry , Petroleum , Waste Disposal, Fluid , Water Pollutants, Chemical/toxicityABSTRACT
The South Tailings Pond (STP) is a ~2300-ha tailing pond operated by Suncor Energy Inc. that has received oil sand process-affected (PA) water and mature fine tailings since 2006. The STP is underlain by a clay till, which is in turn underlain by the Wood Creek Sand Channel (WCSC). The sandy deposits of the WCSC provide greater geotechnical stability but could act as a potential flow pathway for PA water to migrate off site and into the Athabasca River. Preliminary modeling of the STP suggests that PA water from the pond will infiltrate into the underlying sand channel, but the extent and development of this impact is still poorly understood. Suncor Energy Inc. built interception wells and a cut-off-wall to control any potential seepage. Here we present the results of an investigation of the fate and transport of PA water in clay till underlying a 10 m × 10 m infiltration pond that was constructed on the southeastern portion of the STP. The geochemistry of pore water in the till underlying the infiltration pond was determined prior to filling with process-affected water (2008) and two years after the infiltration pond was filled with PA waters (2010). Pore water was analyzed for metals, cations, anions, and isotopes ((2)H and (18)O). The distribution of conservative tracers ((18)O and chloride) indicated migration of the PA waters to approximately 0.9 m, but the migrations of major ions and metals were significantly delayed relative to this depth. Uptake of Na and Mo and release of Ca, Mg, Mn, Ba, and Sr suggest that adsorption and ion exchange reactions are the foremost attenuation processes controlling inorganic solutes transport.
Subject(s)
Industrial Waste , Metals/analysis , Petroleum , Water Pollutants, Chemical/analysis , Aluminum Silicates/chemistry , Chlorides/analysis , Clay , Extraction and Processing Industry , Ion Exchange , Oxygen Isotopes , Sulfates/analysis , Water MovementsABSTRACT
In this study, four dual-chambered microbial fuel cells (MFC1-4) were constructed and filled with different ratios of mature fine tailings and oil sands process-affected water to test the feasibility of MFCs to simultaneously generate electricity and treat oil sands tailings. After 800 h of operation, the maximum voltage was observed in MFC4 at 0.726 V with 1.2kΩ external resistance loaded. The maximum power density reached 392 ± 15 mW/m(2) during the 1,700 h of MFC4 operation. With continuous electricity generation, MFC4 removed 27.8% of the total COD, 81.8% of the soluble COD and 32.9% of the total acid extractable organics. Moreover, effective removal of eight heavy metals, includes 97.8% of (78)Se, 96.8% of Ba, 94.7% of (88)Sr, 81.3% for (66)Zn, 77.1% of (95)Mo, 66.9% of (63)Cu, 44.9% of (53)Cr and 32.5% of Pb, was achieved.
Subject(s)
Bioelectric Energy Sources , Electricity , Oils/chemistry , Silicon Dioxide/chemistry , Waste Products/analysis , Water Purification/methods , Bioelectric Energy Sources/microbiology , Biofilms , Biological Oxygen Demand Analysis , Feasibility Studies , Metals, Heavy/isolation & purification , Waste Disposal, Fluid , Water Pollutants, Chemical/isolation & purificationABSTRACT
This paper studies the partitioning and bioaccumulation of ten target metals ((53)Cr, Mn, Co, (60)Ni, (65)Cu, (66)Zn, As, (88)Sr, (95)Mo and Ba) from oil sands tailings pond water (TPW) by indigenous Parachlorella kessleri. To determine the role of extracellular and intracellular bioaccumulation in metal removal by P. kessleri, TPW samples taken from two oil sands operators (Syncrude Canada Ltd. and Albian Sands Energy Inc.) were enriched with nutrient supplements. Results indicate that intracellular bioaccumulation played the main role in metal removal from TPW; whereas extracellular bioaccumulation was only observed to some extent for Mn, Co, (60)Ni, (65)Cu, (88)Sr, (95)Mo and Ba. The FTIR scan and titration of functional groups on the cell surface indicated low metal binding capacity by indigenous P. kessleri. However, it is believed that the dissolved cations and organic ligand content in TPW (such as naphthenic acids) may interfere with metal binding on the cell surface and lower extracellular bioaccumulation. In addition, the total bioaccumulation and bioconcentration factor (BCF) varied during the cultivation period in different growth regimes.