Microbial dynamics and vertical transmission of Escherichia coli across consecutive life stages of the black soldier fly (Hermetia illucens).

BACKGROUND: The black soldier fly (BSF, Hermetia illucens L.) is one of the most promising insects for bioconversion of organic waste, which often carry a high microbial load with potential foodborne pathogens. Although horizontal transmission (from rearing substrate to larvae) has been extensively studied, less is known about vertical transmission of microorganisms, and particularly of foodborne pathogens, across different BSF life stages. RESULTS: This study investigated the microbial dynamics and vertical transmission of Escherichia coli across different life stages (larvae, prepupae, pupae and adults) of one BSF life cycle and its associated substrate (chicken feed) and frass, based on a combination of general microbial counts (based on culture-dependent techniques) and the bacterial community composition (based on 16S rRNA gene sequencing). Multiple interactions between the microbiota of the substrate, frass and BSF larvae were affirmed. The larvae showed relative consistency among both the microbial counts and bacterial community composition. Diversification of the bacterial communities started during the pupal stage, while most notable changes of the microbial counts and bacterial community compositions occurred during metamorphosis to adults. Furthermore, vertical transmission of E. coli was investigated after substrate inoculation with approximately 7.0 log cfu/g of kanamycin-resistant E. coli, and monitoring E. coli counts from larval to adult stage. Although the frass still contained substantial levels of E. coli (> 4.5 log cfu/g) and E. coli was taken up by the larvae, limited vertical transmission of E. coli was observed with a decreasing trend until the prepupal stage. E. coli counts were below the detection limit (1.0 log cfu/g) for all BSF samples from the end of the pupal stage and the adult stage. Additionally, substrate inoculation of E. coli did not have a substantial impact on the bacterial community composition of the substrate, frass or different BSF life stages. CONCLUSIONS: The fluctuating microbial counts and bacterial community composition underscored the dynamic character of the microbiota of BSF life stages. Additionally, vertical transmission throughout one BSF life cycle was not observed for E. coli. Hence, these findings paved the way for future case studies on vertical transmission of foodborne pathogens across consecutive BSF life stages or other insect species.

Effect of heat treatment on microbiological safety of supermarket food waste as substrate for black soldier fly larvae (Hermetia illucens).

Supermarket food waste, constituting 13% of global food waste, can be upcycled as substrate for black soldier fly larvae (BSFL) and converted into larval biomass. Since presence of food pathogens in supermarket food waste is likely, microbiological safety should be ensured when using waste as insect substrate. Heat treatment provides a suitable pre-treatment to reduce microbiological contaminations. This study investigated the effect of different temperature-time combinations on the microbiological safety of supermarket food waste as BSFL substrate. Artificial supermarket food waste without meat and fish (SFW) was inoculated with both Salmonella and Staphylococcus aureus (7.0log cfu/g) and treated at 50 and 60 °C for 10, 20 and 30 min. While 50 °C was insufficient for adequate pathogen reduction, 60 °C only required 10 min to reduce the Enterobacteriaceae and S.aureus counts to < 1.0logcfu/g and for absence of Salmonella in 25 g. Heat-treated SFW could be stored for two days at ambient temperature or refrigerated without pathogen growth. Treatment of supermarket food waste containing meat and fish at 60 °C for 10 min caused similar results as for SFW, but S.aureus persisted (2.4logcfu/g), possibly by protective effects of fat and/or proteins. Finally, BSFL rearing experiments on SFW revealed significantly higher larval mass, bioconversion efficiency and waste reduction than on Gainesville diet, with no notable differences between untreated and heat-treated SFW. Rearing BSFL on supermarket food waste is possible, and unsafe food waste can be heated to obtain safety without eliminating nutrients necessary for rearing.

Impact of Heat Treatment on the Microbiological Quality of Frass Originating from Black Soldier Fly Larvae (Hermetia illucens).

Since black soldier fly larvae (BSFL, Hermetia illucens) are being produced at substantial volumes, concomitantly large amounts of the resulting by-product, called frass, are generated. This frass can potentially be applied as valuable plant fertilizer or soil improver. Since frass carries high microbial counts, potentially including foodborne pathogens, safety problems for consumers should be prevented. A heat treatment of 70 °C for 60 min is proposed to reduce harmful organisms in insect frass, based on EU regulations ((EU) No. 2021/1925). This study evaluated for the first time the impact of the proposed heat treatment on BSFL frass. This was done by applying the treatment on uninoculated frass as well as on frass inoculated with Salmonella or Clostridium perfringens at 5.0 log cfu/g. The heat treatment resulted in a reduction (maximum one log-cycle) of total viable counts and did not noticeably reduce bacterial endospores. In contrast, Enterobacteriaceae counts were reduced to below the detection limit (10 cfu/g). Heat treatment of inoculated frass resulted in absence of Salmonella in 25 g of frass and reduction of vegetative C. perfringens to below the detection limit (1 cfu/g). The proposed heat treatment appears to be appropriate to meet the microbiological regulations for insect frass.

Molecular and rheological characterization of different cell wall fractions of Porphyridium cruentum.

Cell wall related polysaccharides of the red microalga Porphyridium sp. were shown to be a promising source of new sustainable thickening agents. Isolated extracellular polysaccharides (EPS) consisted of high molecular weight polymers, showing a higher intrinsic viscosity compared to several commercially used hydrocolloids. Aqueous solutions of EPS (2% w/w) were characterized by substantial viscosities and weak gel behavior. Even though the extracted water soluble cell wall polysaccharides exhibited the same monosaccharide profile as EPS (composed of galactose, glucose, xylose and glucuronic acid), a lower molecular weight and intrinsic viscosity was observed for this fraction, resulting in poor rheological properties. Therefore, it was hypothesized that the physicochemical properties were related with a different molecular structural organization of these monosaccharides and sulfate groups. The main challenge for commercialization of extracellular polysaccharides of Porphyridium sp. remains the purification of these fractions to obtain polysaccharide extracts with low protein and salt contents.