A modified indirect mathematical model for evaluation of ethanol production efficiency in industrial-scale continuous fermentation processes.

AIMS: To calculate fermentation efficiency in a continuous ethanol production process, we aimed to develop a robust mathematical method based on the analysis of metabolic by-product formation. METHODS AND RESULTS: This method is in contrast to the traditional way of calculating ethanol fermentation efficiency, where the ratio between the ethanol produced and the sugar consumed is expressed as a percentage of the theoretical conversion yield. Comparison between the two methods, at industrial scale and in sensitivity studies, showed that the indirect method was more robust and gave slightly higher fermentation efficiency values, although fermentation efficiency of the industrial process was found to be low (~75%). CONCLUSIONS: The traditional calculation method is simpler than the indirect method as it only requires a few chemical determinations in samples collected. However, a minor error in any measured parameter will have an important impact on the calculated efficiency. In contrast, the indirect method of calculation requires a greater number of determinations but is much more robust since an error in any parameter will only have a minor effect on the fermentation efficiency value. SIGNIFICANCE AND IMPACT OF THE STUDY: The application of the indirect calculation methodology in order to evaluate the real situation of the process and to reach an optimum fermentation yield for an industrial-scale ethanol production is recommended. Once a high fermentation yield has been reached the traditional method should be used to maintain the control of the process. Upon detection of lower yields in an optimized process the indirect method should be employed as it permits a more accurate diagnosis of causes of yield losses in order to correct the problem rapidly. The low fermentation efficiency obtained in this study shows an urgent need for industrial process optimization where the indirect calculation methodology will be an important tool to determine process losses.

A Study of the Sugarcane Yellow Leaf Disease in Argentina.

Yellow leaf disease, caused by Sugarcane yellow leaf virus (SCYLV), is widespread around the world but very little information is available on this viral disease in Argentina. Therefore, the aims of the study were to assess the presence of SCYLV, analyze its distribution in the main sugarcane production areas of Argentina, characterize the virus, and determine histological alterations caused by its presence. For this purpose, 148 sugarcane samples with and without symptoms were collected in 2011 and 2012 from the province of Tucumán. One additional sample was collected in Salta, a different geographical, agroecological, and producing region. Results showed that SCYLV is widely distributed in commercial varieties of sugarcane throughout Tucumán in both symptomatic and asymptomatic leaves. A low but statistically significant positive correlation with virus detection and disease symptoms was found. BRA-PER was the only genotype detected by reverse-transcription polymerase chain reaction and sequence analysis of the SCYLV capsid protein gene. SCYLV-positive samples showed high starch levels in bundle sheath cells, whereas the asymptomatic ones, probably in an early stage of infection, were found to contain more chloroplasts. Symptomatic noninfected samples presented crystal formation probably associated with phytoplasma infection.

Stress-induced accumulation and tissue-specific localization of dehydrins in Arabidopsis thaliana.

Stress-induced accumulation of five (COR47, LTI29, ERD14, LTI30 and RAB18) and tissue localization of four (LTI29, ERD14, LTI30 and RAB18) dehydrins in Arabidopsis were characterized immunologically with protein-specific antibodies. The five dehydrins exhibited clear differences in their accumulation patterns in response to low temperature, ABA and salinity. ERD14 accumulated in unstressed plants, although the protein level was up-regulated by ABA, salinity and low temperature. LTI29 mainly accumulated in response to low temperature, but was also found in ABA- and salt-treated plants. LTI30 and COR47 accumulated primarily in response to low temperature, whereas RAB18 was only found in ABA-treated plants and was the only dehydrin in this study that accumulated in dry seeds. Immunohistochemical localization of LTI29, ERD14 and RAB18 demonstrated tissue and cell type specificity in unstressed plants. ERD14 was present in the vascular tissue and bordering parenchymal cells, LTI29 and ERD14 accumulated in the root tip, and RAB18 was localized to stomatal guard cells. LTI30 was not detected in unstressed plants. The localization of LTI29, ERD14 and RAB18 in stress-treated plants was not restricted to certain tissues or cell types. Instead these proteins accumulated in most cells, although cells within and surrounding the vascular tissue showed more intense staining. LTI30 accumulated primarily in vascular tissue and anthers of cold-treated plants. This study supports a physiological function for dehydrins in certain plant cells during optimal growth conditions and in most cell types during ABA or cold treatment. The differences in stress specificity and spatial distribution of dehydrins in Arabidopsis suggest a functional specialization for the members of this protein family.

The low-temperature- and salt-induced RCI2A gene of Arabidopsis complements the sodium sensitivity caused by a deletion of the homologous yeast gene SNA1.

Two closely related, tandemly arranged, low-temperature- and salt-induced Arabidopsis genes, corresponding to the previously isolated cDNAs RCI2A and RCI2B, were isolated and characterized. The RCI2A transcript accumulated primarily in response to low temperature or high salinity, and to a lesser extent in response to ABA treatment or water deficit stress. The RCI2B transcript was present at much lower levels than RCI2A, and could only be detected by reverse transcription-PCR amplification. The predicted 6 kDa RCI2 proteins are highly hydrophobic and contain two putative membrane-spanning regions. The polypeptides exhibit extensive similarity to deduced low-temperature- and/or salt-induced proteins from barley, wheat grass and strawberry, and to predicted proteins from bacteria, fungi, nematodes and yeast. Interestingly, we found that a deletion of the RCI2 homologous gene, SNA1 (YRD276c), in yeast causes a salt-sensitive phenotype. This effect is specific for sodium, since no growth defect was observed for the sna1 mutant on 1.7 M sorbitol, 1 M KCl or 0.6 M LiCl. Finally, we found that the Arabidopsis RCI2A cDNA can complement the sna1 mutant when expressed in yeast, indicating that the plant and yeast proteins have similar functions during high salt stress.

Purification of recombinant Arabidopsis thaliana dehydrins by metal ion affinity chromatography.

In this study we describe a novel method for purification of Arabidopsis thaliana dehydrins overproduced in Escherichia coli. The cDNAs corresponding to the four dehydrin genes RAB18, LTI29, LTI30, and COR47 were inserted into a bacterial expression vector under an isopropyl beta-d-thiogalactopyranoside (IPTG) inducible bacterial promoter. After IPTG induction all four proteins accumulated in high amounts. The recombinant proteins were efficiently purified to over 95% purity with a three-step purification scheme: heat fractionation, immobilized metal ion affinity chromatography (IMAC), and ion exchange chromatography. In this study we introduce the novel use of IMAC as an efficient purification method for native dehydrins. Characterization of the purified proteins was done by Edman degradation, mass spectrometry, reverse-phase chromatography, and analytical gel filtration under native and denaturing conditions. Yields of purified proteins were between 2.8 and 12.5 mg per liter of bacterial culture, sufficient for further biochemical studies.

Improved tolerance to salinity and low temperature in transgenic tobacco producing glycine betaine.

Glycine betaine is an osmoprotectant found in many organisms, including bacteria and higher plants. The bacterium Escherichia coli produces glycine betaine by a two-step pathway where choline dehydrogenase (CDH), encoded by betA, oxidizes choline to betaine aldehyde which is further oxidized to glycine betaine by the same enzyme. The second step, conversion of betaine aldehyde into glycine betaine, can also be performed by the second enzyme in the pathway, betaine aldehyde dehydrogenase (BADH), encoded by betB. Transformation of tobacco (Nicotiana tabacum), a species not accumulating glycine betaine, with the E. coli genes for glycine betaine biosynthesis, resulted in transgenic plants accumulating glycine betaine. Plants producing CDH were found to accumulate glycine betaine as did F1 progeny from crosses between CDH- and BADH-producing lines. Plants producing both CDH and BADH generally accumulated higher amounts of glycine betaine than plants producing CDH alone, as determined by 1H NMR analysis. Transgenic tobacco lines accumulating glycine betaine exhibited increased tolerance to salt stress as measured by biomass production of greenhouse-grown intact plants. Furthermore, experiments conducted with leaf discs from glycine betaine-accumulating plants indicated enhanced recovery from photoinhibition caused by high light and salt stress as well as improved tolerance to photoinhibition under low temperature conditions. In conclusion, introduction of glycine betaine production into tobacco is associated with increased stress tolerance probably partly due to improved protection of the photosynthetic apparatus.

Structure and organization of two closely related low-temperature-induced dhn/lea/rab-like genes in Arabidopsis thaliana L. Heynh.

We have isolated a 7 kb EcoRI genomic fragment from Arabidopsis thaliana which contains, in a tandem arrangement, two closely related dhn/lea/rab-like genes, lti29 (formerly named lti45) and cor47, corresponding to previously isolated cDNA clones. Both transcripts have been shown to accumulate in response to low temperature (LT), abscisic acid (ABA) and dehydration. Alignment of the amino acid sequences of the deduced polypeptides showed that they are 67% identical. The calculated molecular masses of the two polypeptides were 29 kDa for LTI29 and 30 kDa for COR47. Both polypeptides contain one conserved serine-stretch and three lysine-rich repeats characteristic of DHN/LEA/RAB-like proteins. In addition, both LTI29 and COR47 harbour and N-terminal acidic repeat only found in a few members amongst the DHN/LEA/RAB proteins. The close distance between the two genes (separated by 2.7 kb) and their tandem organization in the A. thaliana genome as well as the overall homology at the nucleotide sequence level of the coding region suggest that the two genes have evolved through a duplication event. This seems to be a common feature among A. thaliana LT-responsive genes.

Production of the Escherichia coli betaine-aldehyde dehydrogenase, an enzyme required for the synthesis of the osmoprotectant glycine betaine, in transgenic plants.

In several organisms osmotic stress tolerance is mediated by the accumulation of the osmoprotective compound glycine betaine. With the ambition to transfer the betaine biosynthetic pathway into plants not capable of synthesizing this osmoprotectant, the Escherichia coli gene betB encoding the second enzyme in the pathway, betaine-aldehyde dehydrogenase was introduced into Nicotiana tabacum. The betB structural gene was fused to the promoter of ats1a, a gene coding for the small subunit of Rubisco in Arabidopsis thaliana. Two types of constructs were made, either encoding the N-terminal transit peptide for chloroplast targeting or without the targeting signal for cytoplasmic localization of the BetB polypeptide. Analysis of transgenic N. tabacum plants harboring these constructs showed that in both cases the transgenes were expressed. Northern analysis of the plants demonstrated the accumulation of betB-related mRNA of the correct size. The production and processing of the corresponding polypeptides could be demonstrated by immunoblotting using polyclonal antisera raised against the BetB polypeptide. The transit peptide encoded by ats1a was able to direct BetB to the chloroplast, as suggested by the presence of the correctly processed BetB polypeptide in the chloroplast fraction. High betaine-aldehyde dehydrogenase activity was detected in transgenic plants, both in those where the chimeric gene product was targeted to the chloroplast and those where it remained in the cytoplasm. The transgenic tobacco acquired resistance to the toxic intermediate, betaine aldehyde, in the betaine biosynthetic pathway indicating that the bacterial enzyme is biologically active in its new host. Furthermore, these transgenic plants were able to convert exogenously supplied betaine aldehyde efficiently to glycine betaine.

Characterization and differential expression of dhn/lea/rab-like genes during cold acclimation and drought stress in Arabidopsis thaliana.

We have characterized cDNAs for two new dhn/lea/rab (dehydrin, late embryogenesis-abundant, responsive to ABA)-related genes from Arabidopsis thaliana. The two genes were strongly induced in plants exposed to low temperature (4 degrees C) and were accordingly designated lti45 and lti30 (low temperature-induced). The lti45 gene product contains the conserved serine stretch and three lysine-rich repeats characteristic of DHN/LEA/RAB proteins and is very similar to another low temperature-responsive protein of A. thaliana, COR47 [17]. Both proteins have the same repeat structure and an overall amino acid identity of 64%. This structural similarity of the proteins and the tandem array of the genes suggest that this gene pair arose through a duplication. The other polypeptide, LTI30, consists of several lysine-rich repeats, a structure found in CAP85, a low temperature- and water stress-responsive protein in spinach [41] and similar proteins found in wheat [20]. The expression pattern of the five dhn/lea/rab-related genes (cor47, dhnX, lti30, lti45 and rab18) identified so far in A. thaliana, was characterized in plants exposed to low temperature, drought and abscisic acid (ABA). Expression of both lti30 and lti45 was mainly responsive to low temperature similar to cor47. The lti45 and lti30 genes show only a weak response to ABA in contrast to cor47, which is moderately induced by this hormone. The three genes were also induced in severely water-stressed plants although the expression of lti30 and lti45 was rather low. In contrast to these mainly low temperature-induced genes, the expression of rab18 was strongly induced both in water-stressed and ABA-treated plants but was only slightly responsive to cold. The dhnX gene showed a very different expression pattern. It was not induced with any of the treatments tested but exhibited a significant constitutive expression. The low-temperature induction of the genes in the first group, lti30 and lti45, is ABA-independent, deduced from experiments with the ABA-deficient (aba-1) and ABA-insensitive (abil) mutants of A. thaliana, whereas the induction of rab18 is ABA-mediated. The expression of dhnX was not significantly affected in the ABA mutants.

Alterations in Water Status, Endogenous Abscisic Acid Content, and Expression of rab18 Gene during the Development of Freezing Tolerance in Arabidopsis thaliana.

Treatments as diverse as exposure to low temperature (LT), exogenous abscisic acid (ABA), or drought resulted in a 4 to 5[deg]C increase in freezing tolerance of the annual herbaceous plant Arabidopsis thaliana. To correlate the increase in freezing tolerance with the physiological changes that occur in response to these treatments, we studied the alterations in water status, endogenous ABA levels, and accumulation of rab18 (V. Lang and E.T. Palva [1992] Plant Mol Biol 20: 951-962) mRNA. Exposure to LT and exogenous ABA caused only a minor decline in total water potential ([psi]w), in contrast to a dramatic decrease in [psi]w during drought stress. Similarly, the endogenous ABA levels were only slightly and transiently increased in LT-treated plants in contrast to a massive increase in ABA levels in drought-stressed plants. The expression of the ABA-responsive rab18 gene was low during the LT treatment but could be induced to high levels by exogenous ABA and drought stress. Taken together, these results suggest that the moderate increases in freezing tolerance of A. thaliana might be achieved by different mechanisms. However, ABA-deficient and ABA-insensitive mutants of A. thaliana have impaired freezing tolerance, suggesting that ABA is, at least indirectly, required for the development of full freezing tolerance.