Sustained delivery of bioactive cytokine using a dense collagen gel vehicle collagen gel delivery of bioactive cytokine.

OBJECTIVE: The use of cytokines as localized therapeutic agents is limited by the lack of a satisfactory delivery system. The aim of the current investigation was to determine the release kinetics and bioactivity of a simplified cytokine/collagen gel system designed to achieve extended, local delivery of bioactive cytokines at sites of premature cranial suture fusion (craniosynostosis). DESIGN: Cytokine release was determined by ELISA measurements of Tgf-beta3 collected in media. Cytokine bioactivity was determined by measuring the effect of conditioned media, containing released Tgf-beta3, on mink lung epithelial cell proliferation and osteoblast alkaline phosphatase activity. Osteoblast response was evaluated by measuring proliferation of cells cultured on collagen gel containing Tgf-beta3 using an AlamarBlue assay. RESULTS: Gels loaded with 100 and 500 ng of Tgf-beta3 produced a sustained release over 14 days with a pattern of initial large release followed by a gradual reduction in the amount released over the time. The reduced release over time was correlated to the amount initially loaded. Mink lung epithelial cell assay results indicated that Tgf-beta3 released from the collagen gel retained its bioactivity following incorporation into the collagen gel and release into the media. This bioactivity was further illustrated by a decreased alkaline phosphatase activity measured in osteoblasts cultured on the gels loaded with Tgf-beta3. Osteoblast proliferation assays demonstrated that the collagen gel has an inherent inhibitory effect on osteoblast cell number. CONCLUSIONS: This collagen gel/cytokine delivery system can retain and release bioactive cytokine over a prolonged period. These results will allow for better optimization of future in vitro and in vivo studies directed at improving the treatment of craniosynostosis.

Microstructural disassembly of calcium phosphates.

Microstructural factors may play a role in the osseointegration of calcium phosphates. In this paper, direct microstructural interactions between crystalline calcium phosphates and the biological milieu are reported. Degradation via exposure to osteoblast culture closely resembles in vivo interactions with subcutaneous tissues in a bovine model at early time periods. That these interactions were common to both experiments constitutes one of the few known examples of in vitro-in vivo correspondence. Interestingly, the degradation of phase pure hydroxyapatite (HA) in vitro was more rapid than that of biphasic HA in vivo. In both cases, grain extraction/pullout was frequently observed. This suggests a connection to smaller-scale observations of epitaxial CHA nucleation and growth on pre-existing HA grains. A microstructure in which the grain boundary is dissolving/corroding can apparently be disassembled by forces transmitted through biological structures. These observations are distinct from those of simple non-biological solutions and prove that biological environments can interact with the material beneath the ceramic-cell/ceramic-tissue interface. Many often ignored microstructural factors-grain size, shape, grain boundary strength and the presence of impurity phases-may in fact control degradation. We also suggest that even relatively modest initial grain sizes will, in combination with the mild/absent foreign body response to calcium phosphates, result in lengthy in vivo particle resistence.

Rescue of coronal suture fusion using transforming growth factor-beta 3 (Tgf-beta 3) in rabbits with delayed-onset craniosynostosis.

Craniosynostosis results in cranial deformities and increased intracranial pressure, which pose extensive and recurrent surgical management problems. Developmental studies in rodents have shown that low levels of transforming growth factor-beta 3 (Tgf-beta 3) are associated with normal fusion of the interfrontal (IF) suture, and that Tgf-beta 3 prevents IF suture fusion in a dose-dependent fashion. The present study was designed to test the hypothesis that Tgf-beta 3 can also prevent or "rescue" fusing sutures in a rabbit model with familial craniosynostosis. One hundred coronal sutures from 50 rabbits with delayed-onset, coronal suture synostosis were examined in the present study. The rabbits were divided into five groups of 10 rabbits each: 1) sham controls, 2) bovine serum albumin (BSA, 500 ng) low-dose protein controls, 3) low-dose Tgf-beta 3 (500 ng), 4) high-dose BSA (1,000 ng) controls, and 5) high-dose Tgf-beta 3 (1,000 ng). At 10 days of age, radiopaque amalgam markers were implanted in all of the rabbits on either side of the coronal suture to monitor sutural growth. At 25 days of age, the BSA or Tgf-beta 3 was combined with a slow-absorbing collagen vehicle and injected subperiosteally above the coronal suture. Radiographic results revealed that high-dose Tgf-beta 3 rabbits had significantly greater (P < 0.05) coronal suture marker separation than the other groups. Histomorphometric analysis revealed that high-dose Tgf-beta 3 rabbits also had patent coronal sutures and significantly (P < 0.01) greater sutural widths and areas than the other groups. The results suggest that there is a dose-dependent effect of TGF-beta 3 on suture morphology and area in these rabbits, and that the manipulation of such growth factors may have clinical applications in the treatment of craniosynostosis.

Delivery of transforming growth factor-beta2-perturbing antibody in a collagen vehicle inhibits cranial suture fusion in calvarial organ culture.

OBJECTIVE: To determine whether antibody perturbation of Tgf-beta, delivered in a collagen gel, could inhibit cranial suture fusion. DESIGN: Attachment and proliferation of osteoblasts cultured on a collagen gel with or without anti-Tgf-beta2 antibody were determined by AlamarBlue dye assay and cell morphology by toluidine-blue staining. In rat calvarial organ culture, collagen gel with and without anti-Tgf-beta2 antibody was injected subperiosteally over the posterior frontal suture of postnatal day 15 rat calvariae. A quantitative analysis of suture fusion was used to measure suture bridging in histological serial sections at various time points. RESULTS: Attachment and proliferation for cells cultured on collagen gel with anti-Tgf-beta2 antibody were similar to collagen gel controls. Although proliferation was lower than on tissue culture plastic, cells treated with anti-Tgf-beta2 antibody maintained an osteoblastic morphology. After 7, 10, and 15 days in organ culture, anti-Tgf-beta2 antibody treatment caused a reduction in the percent bridging of posterior frontal sutures, compared with controls. Sutures exposed to anti-Tgf-beta2 antibody and fibroblast growth factor-2 concurrently did not show an inhibition of bony bridging. CONCLUSIONS: These results support previous reports suggesting a role for Tgf-beta2 in cranial suture fusion. In cell culture the collagen gel, both with and without anti-Tgf-beta2 antibody, promoted similar osteoblast attachment, proliferation, and osteoblastic morphology. In organ culture anti-Tgf-beta2 antibody was delivered in a bioactive state via a collagen gel to inhibit cranial suture fusion. Also, the results suggest that the inductive effect of fibroblast growth factor-2 is not dependent on Tgf-beta2 activity. Together, these results provide further support for the role of Tgf-beta2 in cranial suture fusion.

Fibroblast growth factor 2 induces increased calvarial osteoblast proliferation and cranial suture fusion.

OBJECTIVE: Craniosynostosis has been associated with fibroblast growth factors (FGFs) and their receptors. The purpose of this study was to quantitatively determine the effect of FGF2 on rat calvarial osteoblasts and a rat cranial suture formation model. DESIGN: Fetal rat calvarial osteoblasts were cultured with and without FGF2. Cell attachment and proliferation was determined by alamar Blue dye assay and cell morphology by toluidine-blue staining. In rat calvarial organ culture, postnatal day 15 rat calvariae with dura mater were placed in serum-free media with and without FGF2. A unique quantitative analysis of suture fusion was developed by obtaining measurements of suture bridging in histological serial sections at progressive stages of fusion. RESULTS: Attachment for cells treated with FGF2 was similar to control. In contrast, proliferation was higher for cells treated with FGF2 while maintaining an osteoblastic morphology. After 5 days in organ culture, FGF2-treated posterior frontal sutures showed a dramatic increase in fusion, compared with untreated controls. This increased fusion was maintained throughout days 7 and 10 in culture. Also, fusion was enhanced on the dural side of the suture, as is normally observed in vivo, and the normal tissue architecture was maintained. CONCLUSIONS: These results indicate that FGF2 can promote rat osteoblast attachment and normal cell morphology as well as induce cell proliferation. In calvarial organ culture, FGF2 treatment produced an enhanced suture fusion. These results provide further support for a critical role for FGF2 in cranial suture development. These studies also present a new quantitative approach to evaluating the effect of suture-perturbing growth factors on cranial suture fusion.

Enhanced osteoblast response to a polymethylmethacrylate-hydroxyapatite composite.

Hydroxyapatite (HA)-reinforced polymers have been proposed as a method of improving the biological properties of bone cements and implant materials. For example, bone cements based on polymethylmethacrylate (PMMA) have long been used to secure orthopedic implants to the skeleton. This composite could also be used as a polished coating on other materials or in bulk form, shaped or molded, to custom fit a specific clinical need. However, complications may occur as a result of the limited mechanical and biological properties of PMMA. The purpose of this investigation was to determine whether the incorporation of HA in a PMMA matrix would enhance the biological properties of osteoblast response as compared to PMMA alone. Fetal rat calvarial osteoblasts were plated on discs of PMMA, PMMA/HA, commercially pure titanium (CpTi) and tissue culture polystyrene (control). Osteoblast attachment and day 2 proliferation were similar on all implant materials, whereas, day 8 proliferation on PMMA/HA was significantly higher than on PMMA and similar to CpTi and control. Extracellular matrix production was examined by immunohistochemistry which indicated that osteoblasts cultured on PMMA/HA showed a more distinct networked pattern of organized fibronectin. Histochemical staining of mineralization was examined by confocal microscopy which demonstrated a higher degree of mineralization in nodules formed on PMMA/HA as compared to PMMA. Together, these results indicate that the addition of HA in a PMMA matrix improves osteoblast response as compared to PMMA alone. Therefore, the incorporation of HA into a PMMA matrix may be a useful method to provide PMMA materials with enhanced osteogenic properties.