Effects of Orange Pulp Conservation Methods (Dehydrated or Ensiled Sun-Dried) on the Nutritional Value for Finishing Pigs and Implications on Potential Gaseous Emissions from Slurry.

The inclusion of orange pulp (OP) in pig diets may promote the circular economy, but drying procedures might influence its nutritional value and environmental impact. The purpose of this study was to determine the energy value and nutrient digestibility of dehydrated (DOP) and ensiled sun dried (ESDOP) orange pulp. The potential ammonia (NH3) and methane (CH4) emissions derived from slurry were also measured. Digestible energies of 14.2 and 13.2 MJ/kg DM for DOP and ESDOP, respectively, were estimated by difference after a 500 g/kg substitution of a basal diet with OPs. A high fiber digestion efficiency was observed for both OPs. Pigs fed the basal diet showed a higher intake and a greater excretion of urine N than pigs fed with OP, but fecal N excretion did not differ among diets. A higher benzoic and hippuric acid content in urine was observed in OP than in basal diet. Altogether, these findings explained a lower pH in slurry of OP diets and a reduction of potential NH3 emissions. The biochemical CH4 potential also decreased, especially with ESDOP. Overall, both OP are relevant sources of energy for pig diets. Their inclusion in feeds generate favorable changes of slurry characteristics that reduce potential NH3 and CH4 emissions.

Influence of storage time and processing on chemical composition and in vitro ruminal fermentation of olive cake.

Olive oil extraction generates olive cake (OC) that could be used in ruminant feeding. However, the chemical composition of OC is affected by multiple factors, being therefore highly variable. The objective of this study was to analyse the influence of storage time and further processing: crude, exhausted (subjected to a second oil extraction) and cyclone (obtained from a cyclone separator) on nutritive value of OC samples. Twelve samples (six crude and six exhausted) were obtained monthly from the same pond from 1 to 6 storage months, and nine samples (three crude, three exhausted and three cyclone) were obtained monthly from a different pond from 6 to 9 months storage. Chemical composition was analysed, and OC samples were fermented in vitro with sheep rumen fluid. Increasing storage time up to 6 months decreased sugars and total soluble polyphenols content but increased fibre content in OC. Dry matter effective degradability (DMED) decreased linearly (p < 0.001) by 35.9 and 45.5% as storage time augmented from 1 to 6 months for crude and exhausted OC, respectively. Crude OC had lower DMED values than exhausted OC (averaged values 0.255 and 0.294 g/g, respectively). Both potential production and rate of gas production were lower (p ≤ 0.018) in crude compared with exhausted OC, which was attributed to the high fat content of crude OC (≥86 g/kg dry matter). For samples stored longer than 6 months, cyclone had greater (p < 0.05) DMED than crude and exhausted OC (averaged values 0.207, 0.164 and 0.164 g/g, respectively). The results indicate that ruminal degradability of OC is reduced with advancing storage time, but only subtle changes were observed during the first two months. Cyclone showed greater degradability than crude and exhausted OC, but differences between crude and exhausted OC became negligible after five storage months.

Variability in the Chemical Composition and In Vitro Ruminal Fermentation of Olive Cake By-Products.

The objective of this study was to determine the variability in the chemical composition and in vitro ruminal fermentation of olive cake (OC) by-products. Forty-two OC samples with different storage times (1⁻14 months) and processing (25 crude (COC), 9 exhausted (EOC) and 9 cyclone (CYOC)) were fermented in vitro with sheep ruminal fluid. Exhausted OC samples had a lower ether extract content than COC and CYOC (15.9, 110 and 157 g/kg dry matter (DM), respectively), but greater neutral detergent fiber (NDF; 645, 570 and 441 g/kg DM) and acid insoluble nitrogen (9.76, 8.10 and 8.05 g/kg DM) content. Exhausted OC had the greatest (p < 0.05) average gas production rate (AGPR), whereas the greatest fermented organic matter (FOM) was obtained for EOC and CYOC. The best single predictor of the AGPR was total sugars content (R² = 0.898), whereas NDF was the best one for FOM (R² = 0.767; p < 0.001). Statistical models using storage time as a predictor variable had lower accuracy and R² values than those from the chemical composition. In summary, the nutritive value of OC was highly dependent on its processing, but its ether extract content did not negatively affect ruminal fermentation parameters, which could be estimated from either carbohydrate composition or storage time.

Regrouping of pigs by body weight at weaning does not affect growth performance, carcass quality or uniformity at slaughter of heavy weight pigs.

We studied the influence of pen uniformity at weaning (7.5 ± 0.6 kg vs. 7.5 ± 1.2 kg body weight (BW ± SD)) and sex on growth performance during the nursery (7.5 to 27.3 kg BW) and the fattening (27.1 to 130.5 kg BW) phases and carcass quality of barrows and castrated females (CF). During the nursery phase, pigs from the more uniform pens had lower feed efficiency (P = 0.05) than pigs from the less uniform pens. Also, barrows had higher average daily feed intake (ADFI) (P < 0.05) and average daily gain (P < 0.001) and better feed efficiency (P < 0.001) than CF. During the fattening phase, initial pen uniformity did not affect growth performance of the pigs but barrows tended (P = 0.08) to have higher ADFI and worse feed efficiency than CF. Trimmed primal cut yield tended to be higher for the more uniform pigs and better for barrows than for CF (P = 0.09). It is concluded that regrouping of the pigs at weaning according to uniformity of BW did not affect growth performance or carcass quality of the pigs at slaughter. Castrated females might be used as an alternative to barrows for the production of carcasses destined to the dry-cured industry.

Managing variability in decision making in swine growing-finishing units.

BACKGROUND: Analysis of data collected from pig farms may be useful to understand factors affecting pig health and productive performance. However, obtaining these data and drawing conclusions from them can be done at different levels and presents several challenges. In the present study, information from 688 batches of growing-finishing (GF) pigs (average initial and final body weight of 19.1 and 108.5 kg respectively) from 404 GF farms integrated in 7 companies was obtained between July 2008 and July 2010 in Spain by survey. Management and facility factors associated with feed conversion ratio (FCR) and mortality were studied by multiple linear regression analysis in each single company (A to G) and in an overall database (OD). Factors studied were geographic location of the farm, trimester the pigs entered the farm, breed of sire and sex segregation in pens (BREGENSEG), use of circovirus vaccine, number of origins the pigs were obtained from, age of the farm, percentage of slatted floor, type of feeder, drinker and ventilation, number of phases and form of feed, antibiotic administration system, water source, and number and initial weight of pigs. RESULTS: In two or more companies studied and/or in OD, the trimester when pigs were placed in the farm, BREGENSEG, number of origins of the pigs, age of the farm and initial body weight were factors associated with FCR. Regarding mortality, trimester of placement, number of origins of the pigs, water source in the farm, number of pigs placed and the initial body weight were relevant factors. Age of the farm, antibiotic administration system, and water source were only provided by some of the studied companies and were not included in the OD model, however, when analyzed in particular companies these three variables had an important effect and may be variables of interest in companies that do not record them. CONCLUSIONS: Analysing data collected from farms at different levels helps better understand factors associated with productive performance of pig herds. Out of the studied factors trimester of placement and number of origins of the pigs were the most relevant factors associated with FCR and mortality.