Effect of residence time in continuous photobioreactor on mass and energy balance of microalgal protein production.

There is increasing interest in new protein sources for the food and feed industry and for the agricultural sector, and microalgae are considered a good alternative, having a high protein content and a well-balanced amino acid profile. However, protein production from microalgae presents several unsolved issues, as the biomass composition changes markedly as a function of cultivation operating conditions. Continuous systems, however, may be properly set to boost the accumulation of protein in the biomass, ensuring stable production. Here, two microalgae and two cyanobacterial species were cultivated in continuous operating photobioreactors (PBR) under nonlimiting nutrient conditions, to study the effects of light intensity and residence time on both biomass and protein productivity at steady state. Although light strongly affected biomass growth inside the PBR, the overall protein pool did not vary in response to irradiance. On the other hand, shorter residence times resulted in protein accumulation of up to 68 % in cyanobacteria, in contrast with green algae, where a minor influence of residence time on biomass composition was observed. Energy balance showed that light conversion to protein decreased with light intensity. Protein content was also related to energy costs for cell maintenance. In conclusion, it is shown that residence time is the key variable to increase protein content and yield of protein production, but its effect depends on the specific species.

[High efficient assimilation of NO3⁻-N with coproduction of microalgal proteins by Chlorella pyrenoidosa].

The aim of this study was to establish a novel technology using microalgae for NO3⁻ removal from high concentration wastewater and conversion to algal proteins. The effects of cultivation modes and illumination modes on the biomass yield, NO3⁻ assimilation rate and algal protein yield were first investigated in shaking flasks for mixotrophic cultivation of Chlorella pyrenoidosa, and subsequently the scale-up verification in 5-L photo fermenter was successfully conducted. Fed-batch cultivation without medium recycling was the best cultivation mode in shaking flask system, in which the highest biomass yield (35.95 g/L), the average NO3⁻ assimilation rate (2.06 g/(L·d)) and algal protein content (up to 42.44% of dry weight) were achieved. By using a staged increase of light intensity as illumination modes, the specific growth rate of cells could be significantly promoted to the highest (0.65 d⁻¹). After a 128-hour continuous cultivation in a 5-L photo fermenter, the highest biomass yield and the average NO3⁻ assimilation rate were reached to 66.22 g/L and 4.38 g/(L·d) respectively, with the highest algal protein content at 47.13% of dry weight. Our study could provide a photo fermentation technology of microalgae for highly efficient treatment of waste industrial nitric acid and/or high concentration nitrate wastewater. This microalgae-based bioconversion process could coproduce protein-rich microalgal biomass, which facilitates the resource utilization of these type wastewater by trash-to-treasure conversion.

Ecotoxicological and biochemical effects of environmental concentrations of the plastic-bond pollutant dibutyl phthalate on Scenedesmus sp.

Phthalate esters are highly present in aquatic plastic litter, which can interfere with the biological processes in the wildlife. In this work, the commonly found freshwater microalga Scenedesmus sp. was exposed to environmental concentrations (0.02, 1 and 100 µg L-1) and to a higher concentration (500 µg L-1) of dibutyl phthalate (DBP), which is an environmental pollutant. The growth, pH variation, production of photosynthetic pigments, proteins and carbohydrates were evaluated. The main inhibition effect of DBP on the microalgal growth was observed in the first 48 h of the exposure (EC50: 41.88 µg L-1). A reduction in the photosynthetic pigment concentration was observed for the 0.02, 1 and 100 µg L-1 conditions indicating that the DBP downregulated the growth rate and affected the photosynthetic process. A significant increase in protein production was only observed under 500 µg L-1 DBP exposure. The extracellular carbohydrates production slightly decreased with the presence of DBP, with a stronger decrease occurring in the 500 µg L-1 condition. These results highlight the environmental risk evaluation and ecotoxicological effects of DBP on the production of biovaluable compounds by microalgae. The results also emphasize the importance of assessing the consequences of the environmental concentrations exposure as a result of the DBP dose-dependent correlation effects.

Production of Fatty Acids and Protein by Nannochloropsis in Flat-Plate Photobioreactors.

Nannochloropsis is an industrially-promising microalga that may be cultivated for alternative sources of nutrition due to its high productivity, protein content and lipid composition. We studied the growth and biochemical profile of Nannochloropsis 211/78 (CCAP) in optimized flat-plate photobioreactors. Eighteen cultivations were performed at two nutrient concentrations. The fatty acid, protein content and calorific values were analyzed after 8, 12 and 16 days. Neutral lipids were separated and the changes in fatty acids in triglycerides (TAGs) during nutrient depletion were recorded. The maximum cell density reached 4.7 g∙L-1 and the maximum productivity was 0.51 g∙L-1∙d-1. During nutrient-replete conditions, eicosapentaneoic acid (EPA) and total protein concentrations measured 4.2-4.9% and 50-55% of the dry mass, respectively. Nutrient starvation induced the accumulation of fatty acids up to 28.3% of the cell dry weight, largely due to the incorporation of C16:0 and C16:1n-7 fatty acyl chains into neutral lipids. During nutrient starvation the total EPA content did not detectibly change, but up to 37% was transferred from polar membrane lipids to the neutral lipid fraction.

Microbial Proteins as Novel Industrial Biotechnology Hosts to Treat Epilepsy.

Epilepsy is characterized by the hyperexcitability of various neuronal circuits that results due to the imbalance between glutamate-mediated excitation of voltage-gated cation channels and γ-amino butyric acid (GABA)-mediated inhibition of anion channels leading to aberrant, sporadic oscillations or fluctuations in neuronal electrical activity. Epilepsy with a risk of mortality and around 65 million sufferers of all ages all over the world is limited therapeutically with high rates of adverse reactions, lack of complete seizure control, and over 30% patients with refractory epilepsy. The only alternative to medicines is to identify and surgically remove the seizure foci in the brain or to abort the seizures just as they begin using an implanted cerebral electrode. However, these alternatives are unable to precisely aim aberrant neuronal circuits while leaving others unaltered. Epilepsy animal models also constitute the identical constraint. Thus, a better target-specific approach is needed to study and treat epilepsy. Unicellular green algae Chlamydomonas reinhardtii expresses a channelrhodopsin-2 (ChR2) sodium ion channel protein that controls the phototaxis movement of algae in response to blue light. Similarly, archaeon Natronomonas pharaonis (NpHR) expresses a monovalent Cl- channel protein halorhodopsin that responds to yellow light. These features of ChR2 and NpHR proteins can be used in optogenetic techniques to manipulate the bi-directional firing pattern of neuronal circuits in an attempt to better understand the pathophysiology of epileptic seizures as well as to discover novel potential drugs to treat epilepsy.

Effect of CO2 Concentration on Growth and Biochemical Composition of Newly Isolated Indigenous Microalga Scenedesmus bajacalifornicus BBKLP-07.

Photosynthetic mitigation of CO2 through microalgae is gaining great importance due to its higher photosynthetic ability compared to plants, and the biomass can be commercially exploited for various applications. CO2 fixation capability of the newly isolated freshwater microalgae Scenedesmus bajacalifornicus BBKLP-07 was investigated using a 1-l photobioreactor. The cultivation was carried at varying concentration of CO2 ranging from 5 to 25%, and the temperature and light intensities were kept constant. A maximum CO2 fixation rate was observed at 15% CO2 concentration. Characteristic growth parameters such as biomass productivity, specific growth rate, and maximum biomass yield, and biochemical parameters such as carbohydrate, protein, lipid, chlorophyll, and carotenoid were determined and discussed. It was observed that the effect of CO2 concentration on growth and biochemical composition was quite significant. The maximum biomass productivity was 0.061 ± 0.0007 g/l/day, and the rate of CO2 fixation was 0.12 ± 0.002 g/l/day at 15% CO2 concentration. The carbohydrate and lipid content were maximum at 25% CO2 with 26.19 and 25.81% dry cell weight whereas protein, chlorophyll, and carotenoid contents were 32.89% dry cell weight, 25.07 µg/ml and 6.15 µg/ml respectively at 15% CO2 concentration.

Proteomic analyses bring new insights into the effect of a dark stress on lipid biosynthesis in Phaeodactylum tricornutum.

Microalgae biosynthesize high amount of lipids and show high potential for renewable biodiesel production. However, the production cost of microalgae-derived biodiesel hampers large-scale biodiesel commercialization and new strategies for increasing lipid production efficiency from algae are urgently needed. Here we submitted the marine algae Phaeodactylum tricornutum to a 4-day dark stress, a condition increasing by 2.3-fold the total lipid cell quotas, and studied the cellular mechanisms leading to lipid accumulation using a combination of physiological, proteomic (iTRAQ) and genomic (qRT-PCR) approaches. Our results show that the expression of proteins in the biochemical pathways of glycolysis and the synthesis of fatty acids were induced in the dark, potentially using excess carbon and nitrogen produced from protein breakdown. Treatment of algae in the dark, which increased algal lipid cell quotas at low cost, combined with optimal growth treatment could help optimizing biodiesel production.

High-Mannose Specific Lectin and Its Recombinants from a Carrageenophyta Kappaphycus alvarezii Represent a Potent Anti-HIV Activity Through High-Affinity Binding to the Viral Envelope Glycoprotein gp120.

We previously reported that a high-mannose binding lectin KAA-2 from the red alga Kappaphycus alvarezii, which is an economically important species and widely cultivated as a source of carrageenans, had a potent anti-influenza virus activity. In this study, the full-length sequences of two KAA isoforms, KAA-1 and KAA-2, were elucidated by a combination of peptide mapping and cDNA cloning. They consisted of four internal tandem-repeated domains, which are conserved in high-mannose specific lectins from lower organisms, including a cyanobacterium Oscillatoria agardhii and a red alga Eucheuma serra. Using an Escherichia coli expression system, an active recombinant form of KAA-1 (His-tagged rKAA-1) was successfully generated in the yield of 115 mg per a litter of culture. In a detailed oligosaccharide binding analysis by a centrifugal ultrafiltration-HPLC method with 27 pyridylaminated oligosaccharides, His-tagged rKAA-1 and rKAA-1 specifically bound to high-mannose N-glycans with an exposed α1-3 mannose in the D2 arm as the native lectin did. Predicted from oligosaccharide-binding specificity, a surface plasmon resonance analysis revealed that the recombinants exhibit strong interaction with gp120, a heavily glycosylated envelope glycoprotein of HIV with high association constants (1.48-1.61 × 10(9) M(-1)). Native KAAs and the recombinants inhibited the HIV-1 entry at IC50s of low nanomolar levels (7.3-12.9 nM). Thus, the recombinant proteins would be useful as antiviral reagents targeting the viral surface glycoproteins with high-mannose N-glycans, and the cultivated alga K. alvarezii could also be a good source of not only carrageenans but also this functional lectin(s).

[Prokaryotic expression and purification of Chlamydomonas reinhardtii intraflagellar transport protein 46(IFT46) and preparation of polyclonal antibody].

IFT46 is one of the important components of intraflagellar transport complex B in Chlamydomonas reinhardtii, and plays important roles in the assembly, movement and perception of ciliary. To study its functional mechanism, a GST-tagged and an MBP-tagged prokaryotic expression plasmid, pGEX-2T-ift46 and pMAL-C2X-ift46 were constructed, respectively, by inserting ift46 into the pGEX-2T and pMAL-C2X vector, and then transformed into Escherichia coli BL21 (DE3) for protein expression. SDS-PAGE (15%) analysis results showed that the molecular weights of the fusion protein GST-IFT46 and MBP-IFT46 were 70 kDa and 86 kDa, respectively. We used the fusion protein GST-IFT46 purified by affinity adsorption purification (more than 95% purity) for immunity to New Zealand white rabbits. The 5th immune serum was collected and the antibody titer was determined to be 256 000 by ELISA. The antiserum was purified by Protein A affinity adsorption purification and immobilized MBP-IFT46 purification, and the specificity of polyclonal antibodies was evaluated by Western blotting and immunofluorescence. Results showed that the polyclonal antibody prepared could specifically and precisely bind IFT46 in C. reinhardtii, and IFT46 was mainly concentrated at basal body regions and few localized along the entire length of the flagellum as punctuated dots, which will make a foundation to further study the mechanism of IFT46 in cilia related diseases such as obesity, diabetes and polycystic kidney disease.

Simulation design for microalgal protein optimization.

A method for designing the operating parameters (surface light intensity, operating temperature and agitation rate) was proposed for microalgal protein production. Furthermore, quadratic model was established and validated (R(2) > 0.90) with experimental data. It was recorded that temperature and agitation rate were slightly interdependent. The microalgal protein performance could be estimated using the simulated experimental setup and procedure developed in this study. The results also showed a holistic approach for opening a new avenue on simulation design for microalgal protein optimization.

Algal lectin binding to core (α1-6) fucosylated N-glycans: structural basis for specificity and production of recombinant protein.

We determined the specificity of BTL, a lectin from the red marine alga Bryothamnion triquetrum, toward fucosylated oligosaccharides. BTL showed a strict specificity for the core α1,6-fucosylation, which is an important marker for cancerogenesis and quality control of therapeutical antibodies. The double fucosylation α1,6 and α1,3 was also recognized, but the binding was totally abolished in the sole presence of the α1,3-fucosylation. A more detailed analysis of the specificity of BTL showed a preference for bi- and tri-antennary nonbisected N-glycans. Sialylation or fucosylation at the nonreducing end of N-glycans did not affect the recognition by the lectin. BTL displayed a strong affinity for a core α1,6-fucosylated octasaccharide with a Kd of 12 µM by titration microcalorimetry. The structural characterization of the interaction between BTL and the octasaccharide was obtained by STD-NMR. It demonstrated an extended epitope for recognition that includes the fucose residue, the distal GlcNAc and one mannose residue. Recombinant rBTL was obtained in Escherichia coli and characterized. Its binding properties for carbohydrates were studied using hemagglutination tests and glycan array analysis. rBTL was able to agglutinate rabbit erythrocytes with strong hemagglutination activity only after treatment with papain and trypsin, indicating that its ligands were not directly accessible at the cell surface. The hemagglutinating properties of rBTL confirm the correct folding and functional state of the protein. The results show BTL as a potent candidate for cancer diagnosis and as a reagent for the preparation and quality control of antibodies lacking core α1,6-fucosylated N-glycans.

Genetic improvement of the microalga Phaeodactylum tricornutum for boosting neutral lipid accumulation.

To obtain fast growing oil-rich microalgal strains has been urgently demanded for microalgal biofuel. Malic enzyme (ME), which is involved in pyruvate metabolism and carbon fixation, was first characterized in microalgae here. Overexpression of Phaeodactylum tricornutum ME (PtME) significantly enhanced the expression of PtME and its enzymatic activity in transgenic P. tricornutum. The total lipid content in transgenic cells markedly increased by 2.5-fold and reached a record 57.8% of dry cell weight with a similar growth rate to wild type, thus keeping a high biomass. The neutral lipid content was further increased by 31% under nitrogen-deprivation treatment, still 66% higher than that of wild type. Transgenic microalgae cells exhibited obvious morphological changes, as the cells were shorter and thicker and contained larger oil bodies. Immuno-electron microscopy targeted PtME to the mitochondrion. This study markedly increased the oil content in microalgae, suggesting a new route for developing ideal microalgal strains for industrial biodiesel production.

Production of ketocarotenoids in tobacco alters the photosynthetic efficiency by reducing photosystem II supercomplex and LHCII trimer stability.

The consequences of ketocarotenoid production in transgenic tobacco (Nicotiana tabacum) plants expressing a Chlamydomonas reinhardtii gene encoding a ß-carotene ketolase were examined concerning the functionality of the photosynthetic apparatus. T1 plants produced less photosynthetic pigments per dry weight, but Chl a/Chl b ratios remained unchanged. Almost as much ketocarotenoids as accessory xanthophylls accumulated per Chl a molecule. These ketocarotenoids were found mainly in the thylakoid membranes, but were not functionally bound to light-harvesting complexes, although LHCII is known to be able to bind astaxanthin. On the contrary, high amounts of ketocarotenoids probably changed the properties of the lipid phase of the thylakoids, thereby reducing the stability of photosystem II supercomplexes and LHCII trimers and ultimately decreasing grana formation. In addition, photosystem II function in electron transport was impaired, and plants exhibited less non-photochemical quenching compared to wild-type plants. Thus, in order not to disturb vital functions of the plants, production of astaxanthin and other nutritionally valuable ketocarotenoids apparently requires ways to sequester the additional carotenoids to plastoglobuli.

Cultivation of Scenedesmus obliquus in photobioreactors: effects of light intensities and light-dark cycles on growth, productivity, and biochemical composition.

One of the main parameters influencing microalgae production is light, which provides energy to support metabolism but, if present in excess, can lead to oxidative stress and growth inhibition. In this work, the influence of illumination on Scenedesmus obliquus growth was assessed by cultivating cells at different light intensities in a flat plate photobioreactor. S. obliquus showed a maximum growth rate at 150 µmol photons m(-2) s(-1). Below this value, light was limiting for growth, while with more intense illumination photosaturation effects were observed, although cells still showed the ability to duplicate. Looking at the biochemical composition, light affected the pigment contents only while carbohydrate, lipid, and protein contents remained stable. By considering that in industrial photobioreactors microalgae cells are subjected to light-dark cycles due to mixing, algae were also grown under pulsed illumination (5, 10, and 15 Hz). Interestingly, the ability to exploit pulsed light with good efficiency required a pre-acclimation to the same conditions, suggesting the presence of a biological response to these conditions.

[Stress proteins in the cells of Porphyra purpurea (Rhodophyta) thallus].

Heat shock proteins have been revealed for the first time by the methods of Western blotting using alkaline phosphatase and ECL in the cells of Porphyra purpurea from Kattegat area of the Baltic Sea in normal and experimental stress conditions. It was demonstrated with application of monoclonal anti-Hsp70 antibodies that a slight band about 70 kDa is present constitutively at the film; additionally the polypeptide of about 40 kDa ("Hsp40") has been detected. After heat shock at 28 degrees C during 1 hr significant "expenditure" of Hsp70 was observed, as well as the pronounced induction of "Hsp40"; the induction was expressed especially strongly in 24 hr after the stress application.

Characterization of gamma radiation inducible thioredoxin h from Spirogyra varians.

In this study, thioredoxin h (Trxh) was isolated and characterized from the fresh water green alga Spirogyra varians, which was one amongst the pool of proteins induced upon gamma radiation treatment. cDNA clones encoding S. varians thioredoxin h were isolated from a pre-constructed S. varians cDNA library. Trxh had a molecular mass of 13.5kDa and contained the canonical WCGPC active site. Recombinant Trxh showed the disulfide reduction activity, and exhibited insulin reduction activity. Also, Trxh had higher 5,5'-dithiobis(2-nitrobenzoic acid) reduction activity with Arabidopsis thioredoxin reductase (TR) than with Escherichia coli TR. Specific expression of the Trxh gene was further analyzed at mRNA and protein levels and was found to increase by gamma irradiation upto the absorbed dose of 3kGy, suggesting that Trxh may have potential functions in protection of biomolecules from gamma irradiation.

Proteomic analysis of Chlorella vulgaris: potential targets for enhanced lipid accumulation.

Oleaginous microalgae are capable of producing large quantities of fatty acids and triacylglycerides. As such, they are promising feedstocks for the production of biofuels and bioproducts. Genetic strain-engineering strategies offer a means to accelerate the commercialization of algal biofuels by improving the rate and total accumulation of microalgal lipids. However, the industrial potential of these organisms remains to be met, largely due to the incomplete knowledgebase surrounding the mechanisms governing the induction of algal lipid biosynthesis. Such strategies require further elucidation of genes and gene products controlling algal lipid accumulation. In this study, we have set out to examine these mechanisms and identify novel strain-engineering targets in the oleaginous microalga, Chlorella vulgaris. Comparative shotgun proteomic analyses have identified a number of novel targets, including previously unidentified transcription factors and proteins involved in cell signaling and cell cycle regulation. These results lay the foundation for strain-improvement strategies and demonstrate the power of translational proteomic analysis. BIOLOGICAL SIGNIFICANCE: We have applied label-free, comparative shotgun proteomic analyses, via a transcriptome-to-proteome pipeline, in order to examine the nitrogen deprivation response in the oleaginous microalga, C. vulgaris. Herein, we identify potential targets for strain-engineering strategies targeting enhanced lipid accumulation for algal biofuels applications. Among the identified targets are proteins involved in transcriptional regulation, lipid biosynthesis, cell signaling and cell cycle progression. This article is part of a Special Issue entitled: Translational Plant Proteomics.

Sex-biased gene expression in the brown alga Fucus vesiculosus.

BACKGROUND: The fucoid brown algae (Heterokontophyta, Phaeophyceae) are increasingly the focus of ecological genetics, biodiversity, biogeography and speciation research. The molecular genetics underlying mating system variation, where repeated dioecious - hermaphrodite switches during evolution are recognized, and the molecular evolution of sex-related genes are key questions currently hampered by a lack of genomic information. We therefore undertook a comparative analysis of male and female reproductive tissue transcriptomes against a vegetative background during natural reproductive cycles in Fucus vesiculosus. RESULTS: Over 300 k reads were assembled and annotated against public protein databases including a brown alga. Compared with the vegetative tissue, photosynthetic and carbohydrate metabolism pathways were under-expressed, particularly in male tissue, while several pathways involved in genetic information processing and replication were over-expressed. Estimates of sex-biased gene (SBG) expression were higher for male (14% of annotated orthologues) than female tissue (9%) relative to the vegetative background. Mean expression levels and variance were also greater in male- than female-biased genes. Major female-biased genes were carbohydrate-modifying enzymes with likely roles in zygote cell wall biogenesis and/or modification. Male-biased genes reflected distinct sperm development and function, and orthologues for signal perception (a phototropin), transduction (several kinases), and putatively flagella-localized proteins (including candidate gamete-recognition proteins) were uniquely expressed in males. Overall, the results suggest constraint on female-biased genes (possible pleiotropy), and less constrained male-biased genes, mostly associated with sperm-specific functions. CONCLUSIONS: Our results support the growing contention that males possess a large array of genes regulating male fitness, broadly supporting findings in evolutionarily distant heterogametic animal models. This work identifies an annotated set of F. vesiculosus gene products that potentially regulate sexual reproduction and may contribute to prezygotic isolation, one essential step towards developing tools for a functional understanding of species isolation and differentiation.

Purification of the photosynthetic pigment C-phycocyanin from heterotrophic Galdieria sulphuraria.

BACKGROUND: The phycobiliprotein C-phycocyanin (C-PC) is used in cosmetics, diagnostics and foods and also as a nutraceutical or biopharmaceutical. It is produced in the cyanobacterium Arthrospira platensis grown phototrophically in open cultures. C-PC may alternatively be produced heterotrophically in the unicellular rhodophyte Galdieria sulphuraria at higher productivities and under improved hygienic standards if it can be purified as efficiently as C-PC from A. platensis. RESULTS: Ammonium sulfate fractionation, aqueous two-phase extraction, tangential flow ultrafiltration and anion exchange chromatography were evaluated with respect to the purification of C-PC from G. sulphuraria extracts. Galdieria sulphuraria C-PC showed similar properties to those described for cyanobacterial C-PC with respect to separation by all methodologies. The presence of micelles in G. sulphuraria extracts influenced the different procedures. Only chromatography was able to separate C-PC from a second phycobiliprotein, allophycocyanin. CONCLUSION: C-PC from heterotrophic G. sulphuraria shows similar properties to cyanobacterial C-PC and can be purified to the same standards, despite initial C-PC concentrations being low and impurity concentrations high in G. sulphuraria extracts.

Characterization of major lipid droplet proteins from Dunaliella.

Many green algal species can accumulate large amounts of triacylglycerides (TAG) under nutrient deprivation, making them a potential source for production of biodiesel. TAG are organized in cytoplasmic lipid bodies, which contain a major lipid droplet protein termed MLDP. Green algae MLDP differ in sequence from plant oleosins and from animal perilipins, and their structure and function are not clear. In this study, we describe the isolation of MLDP from three species of the extreme halotolerant green algae Dunaliella. Sequence alignment with other green algae MLDP proteins identified a conserved 4-proline domain that may be considered as a signature domain of Volvocales green algae MLDP. Gold immunolabeling localized MLDP at the surface of lipid droplets in D. salina. The induction of MLDP by nitrogen deprivation is kinetically correlated with TAG accumulation, and inhibition of TAG biosynthesis impairs MLDP accumulation suggesting that MLDP induction is co-regulated with TAG accumulation. These results can lead to a better understanding of the structure and function of Volvocales green algae MLDP proteins.