Differential proteomics reveals main determinants for the improved pectinase activity in UV-mutagenized Aspergillus niger strain.

OBJECTIVES: To reveal the potential mechanism and key determinants that contributed to the improved pectinase activity in Aspergillus niger mutant EIMU2, which was previously obtained by UV-mutagenesis from the wild-type A. niger EIM-6. RESULTS: Proteomic analysis for Aspergillus niger EIMU2 by two-dimensional electrophoresis demonstrated that mutant EIMU2 harbored a multiple enzyme system for the degradation of pectin, mainly constituting by main-chain-cleaving enzymes polygalacturonase, pectate lyase, pectinesterase, and some accessory enzymes rhamnogalacturonan lyase and arabinofuranosidase. Further quantitatively differential proteomic analysis revealed that the quantities of four proteins, pectinesterase, rhamnogalacturonan lyase A, DNA-directed RNA polymerase A, and a hypothetical protein in strain EIMU2 were much higher than those in EIM-6. PCR amplification, sequencing and alignment analysis of genes for the two main members of pectin-degrading enzymes, pectate lyase and polygalacturonase showed that their sequences were completely consistent in A. niger EIM-6 and mutant EIMU2. CONCLUSIONS: The result demonstrated that the improved pectinase activity by UV-mutagenesis in A. niger EIMU2 was probably contributed to the up-regulated expression of rhamnogalacturonan lyase, or pectinesterase, which resulted in the optimization of synergy amongst different components of pectin-degrading enzymes.

Physicochemical treatments for the reduction of aflatoxins and Aspergillus niger in corn grains (Zea mays).

BACKGROUND: Corn grains are commonly contaminated with mycotoxins and fungi. The purpose of this study was to evaluate the reduction of aflatoxins B1 , B2 , G1 , and G2 and the inhibition of Aspergillus niger in corn grains using ultrasound, ultraviolet (UV) radiation, electrolyzed water, and sodium bicarbonate. The determination of aflatoxins was performed by high-performance liquid chromatography with fluorescence detection and postcolumn derivatization, and analysis of A. niger was performed by evaluating mycelial growth in potato dextrose agar. The best treatment for reducing aflatoxins and inhibiting mycelial growth was evaluated in corn contaminated with A. niger. RESULTS: The results show a significant reduction in aflatoxins in the following order: sodium bicarbonate > ultrasound > UV > electrolyzed water for aflatoxins B1 , B2 , and G2 . For aflatoxin G1 , the order of reduction was sodium bicarbonate > ultrasound > electrolyzed water > UV, with maximum values between 70.50% and 87.03% reached with sodium bicarbonate; for the other treatments, the reduction was between 51.51% and 65.44%. Regarding the fungus, the order of inhibition in the control of mycelial growth was sodium bicarbonate > ultrasound > electrolyzed water > UV in corn grains, and inhibition of mycelial growth was obtained at a sodium bicarbonate concentration of 3.0 g L-1 . CONCLUSION: Sodium bicarbonate, electrolyzed water, ultrasound, and UV radiation inhibited the growth of A. niger on potato dextrose agar and reduced the contents of aflatoxins B1 , B2 , G1 , and G2 in vitro. Sodium bicarbonate showed an ability to inhibit mycelial growth in corn grains. © 2020 Society of Chemical Industry.

Microbial radiosensitization using combined treatments of essential oils and irradiation- part B: Comparison between gamma-ray and X-ray at different dose rates.

Stored rice and rice products are prone to contamination by pathogenic fungi and bacteria such as Aspergillus niger, Bacillus cereus, and Paenibacillus amylolyticus. Treatment with antimicrobial essential oils (EOs) and irradiation are options to control spoilage organisms. Microbial samples with or without fumigation with an oregano/thyme EO mixture were irradiated at 0.5, 0.75, 1.0, 1.5, 2.0, 2.5, 3.0 and 3.5 kGy for calculation of a D10 value. The relative sensitivity was calculated as the ratio of D10 values for the irradiation plus oregano and thyme EO combination and irradiation alone treatments. In all cases, irradiation plus fumigation with the oregano and thyme EO mixture showed increased efficacy compared with irradiation alone. The relative sensitivity of γ-ray irradiation against A. niger was 1.22, 1.33, and 1.24 for radiation dose rates of 10.445, 4.558, and 0.085 kGy/h, respectively, however against B. cereus it was 1.28, 1.45, and 1.49, and against P. amylolyticus it was 1.35, 1.33, and 1.38, for respective γ-ray irradiation dose rates. The relative sensitivity of X-ray irradiation against A. niger, B. cereus, and P. amylolyticus was 1.63, 1.21, and 1.31, respectively, at the X-ray dose rate of 0.76 kGy/h. The results showed that the relative sensitivity of γ-ray irradiation was higher against the two bacteria than the fungus, whereas X-ray showed higher sensitivity against the fungus than the two bacteria. There was no consistent positive or negative relationship between dose rate and relative sensitivity. The results demonstrated the potential of an oregano and thyme EOs mixture as an antimicrobial agent and its efficacy to increase the radiosensitization of A. niger, B. cereus, and P. amylolyticus during γ-ray or X-ray irradiation treatments.

Mutations in AraR leading to constitutive expression of arabinolytic genes in Aspergillus niger under derepressing conditions [corrected].

The AraR transcription factor of Aspergillus niger encodes a Zn(II)2Cys6 transcription factor required for the induction of genes encoding arabinolytic enzymes. One of the target genes of AraR is abfA, encoding an arabinofuranosidase. The expression of abfA as well as other L-arabinose-induced genes in A. niger requires the presence of L-arabinose or its derivative L-arabitol as an inducer to activate AraR-dependant gene expression. In this study, mutants were isolated that express L-arabinose-induced genes independently of the presence of an inducer under derepressing conditions. To obtain these mutants, a reporter strain was constructed in a ΔcreA background containing the L-arabinose-responsive promoter (PabfA) fused to the acetamidase (amdS) gene. Spores of the ΔcreA PabfA-amdS reporter strain were UV-mutagenized and mutants were obtained by their ability to grow on acetamide without the presence of inducer. From a total of 164 mutants, 15 mutants were identified to contain transacting mutations resulting in high arabinofuranosidase activity in the medium after growth under non-inducing conditions. Sequencing of the araR gene of the 15 constitutive mutants revealed that 14 mutants carried a mutation in AraR. Some mutations were found more than once and in total nine different point mutations were identified in AraR. The AraRN806I point mutation was reintroduced into a parental strain and confirmed that this point mutation leads to inducer-independent expression of AraR target genes. The inducer independent of L-arabinose-induced genes in the AraRN806I mutant was found to be sensitive to carbon catabolite repression, indicating that the CreA-mediated carbon catabolite repression is dominant over the AraRN806I mutant allele. These mutations in AraR provide new opportunities to improve arabinase production in industrial fungal strains.

Assessment of lead tolerance in gamma exposed Aspergillus niger van Tieghem & Penicillium cyclopium Westling.

Purpose: Present study deals with the role of gamma irradiation in modulating lead (Pb) tolerance of Aspergillus niger van Tieghem. and Penicillium cyclopium Westling. Materials and methods: After being exposed to gamma absorbed doses those fungal strains were subjected to heavy metal uptake efficacies and anti-oxidative study. Fourier Transform Infrared (FTIR) spectra and Scanning Electron Microscopic (SEM) studies were also evaluated. Result: Gamma exposed A. niger & P. cyclopium showed enhanced growth in terms of colony forming unit (CFU) and more Pb uptake efficacies compared to their un-irradiated counterparts. FTIR spectra illustrated the involvement of functional groups in Pb biosorption. SEM photographs revealed the structural deformities in both the fungal strains after being exposed to Pb and gamma. Upregulated anti-oxidative defense system (super oxide dismutase, catalase, total glutathione) in gamma exposed fungal groups are accountable for enhanced Pb tolerance and removal than that of their un-irradiated counterparts. Conclusion: The outcomes of this study exhibit a light towards a new step of heavy metal bioremediation.

Fabrication of pure and moxifloxacin functionalized silver oxide nanoparticles for photocatalytic and antimicrobial activity.

This paper reports the synthesis of silver oxide (Ag2O) and moxifloxacin functionalized silver oxide (M-Ag2O) nanoparticles for photocatalytic and antimicrobial activity. The Ag2O nanoparticles were synthesized by using 2 dimethyl amino ethanol as reducing agent. The BET surface area measured from N2 adsorption method was found to be 16.89 m2/g. The mix (cubic and hexagonal) phase of silver oxide (Ag2O) nanoparticles was confirmed by X-rays diffraction (XRD). The extra diffracted peaks were observed after moxifloxacin fictionalization. The scanning electron micrographs display spherical shaped particles of different sizes. The elemental composition and weight percent of both samples were studied by energy dispersive X-ray (EDX). The decrease in the weight percent of silver with the subsequent increase in the weight percent of carbon and oxygen revealed the successful loading of moxifloxacin onto Ag2O NPs. The two stages of weight loss due to the removal of physisorbed and chemisorbed water was examined during thermogravimetric analysis (TGA). The optical band gap derived from the diffuse reflectance spectrum (DRS) was 1.83 eV, which corresponds to the transmittance edge of 676 nm. The Fourier transform infrared (FTIR) band at 668.56 cm-1 confirms the successful synthesis of moxifloxacin functionalized silver oxide (Ag2O) nanoparticles. The pure Ag2O nanoparticles were used for the degradation of rhodamine 6G and 98.56% dye was degraded in 330 min. The bacterial species selected for the present study were Bacillus subtilis, Staphylococcus aureus, Escherichia coli, Pseudomonas aeruginosa, Candida albicans and Aspergillus Niger. Both pure and functionalized Ag2O NPs were screened against selected bacterial and fungal species and they showed improved activity with the volume of samples taken in wells. However, the activity of Ag2O NPs against fungi was found less effective than bacteria which may be due to the difference in the composition of the cell wall. Further gram-positive bacteria showed more resistance toward both samples as compared to the gram-negative bacteria. It was concluded that Ag2O NPs upon conjugation with moxifloxacin displayed promising antimicrobial activity.

Impact of infrared treatment on quality and fungal decontamination of mung bean (Vigna radiata L.) inoculated with Aspergillus spp.

BACKGROUND: Mung bean is a rich source of protein, carbohydrates and fiber content. It also exhibits a high level of antioxidant activity due to the presence of phenolic compounds. Aspergillus flavus and A. niger are the two major fungal strains associated with stored mung bean that lead to post-harvest losses of grains and also cause serious health risks to human beings. Thus there is a need to explore an economical decontamination method that can be used without affecting the biochemical parameters of grains. RESULTS: It was observed that infrared (IR) treatment of mung bean surface up to 70 °C for 5 min at an intensity of 0.299 kW m-2 led to complete visible inhibition of fungal growth. Scanning electron microscopy revealed that surface irregularities and physical disruption of spores coat are the major reasons behind the inactivation of IR-treated fungal spores. It was also reported that IR treatment up to 70 °C for 5 min does not cause any negative impact on the biochemical and physical properties of mung bean. CONCLUSION: From the results of the present study, it was concluded that IR treatment at 70 °C for 5 min using an IR source having an intensity of 0.299 kW m-2 can be successfully used as a method of fungal decontamination. The fungal spore population was reduced (approximately 5.3 log10 CFU g-1 reductions) without significantly altering the biochemical and physical properties of grains. © 2017 Society of Chemical Industry.

New insight into the disinfection mechanism of Fusarium monoliforme and Aspergillus niger by TiO2 photocatalyst under low intensity UVA light.

Titanium dioxide (TiO2) photocatalytic reaction has great potential for the disinfection of harmful pathogens. However, the disinfection mechanisms of TiO2 photocatalysis are not yet well-known for fungi and protozoa. In this work, the photocatalytic disinfection mechanism of Fusarium monoliforme and Aspergillus niger under low intensity UVA light (365nm, <10W/m2) was studied at the ultrastructural level. Photocatalytic treatments showed that the photocatalytic oxidation of 10% TiO2 based paint was efficacious in the complete disinfection of F. monoliforme under low intensity UVA light. No growth of F. monoliforme was observed on agar plate in the subsequent dark. Transmission electron microscopy (TEM) of F. monoliforme exposed to TiO2 photocatalysis treatment showed a distinct damage to electron-dense outer cell wall, but not to an underlying electron-transparent layer cell wall. The TEM image revealed that the UVA-light only did not damage cell wall, cell membrane and cellular organelles. Unlike, A. niger was more sensitive to UVA-light. Serious destructions of cell membrane and cellular organelles were shown in A. niger exposed to UVA-light only and photocatalytic treatments. However, morphological change in A. niger cell wall was only observed in photocatalytic treatment. Changes to the outermost melanin like layer and cell wall of A. niger spore due to photocatalytic treatment were greatly apparent while the intracellular organelles of A. niger spore were not affected. Therefore, regrowth of A. niger on agar plate was expected from the germination of A. niger spore in the subsequent dark. These observations give a better understanding of the photocatalytic disinfection mechanism toward fungi.

Changes in transcript levels of starch hydrolysis genes and raising citric acid production via carbon ion irradiation mutagenesis of Aspergillus niger.

The filamentous ascomycete Aspergillus niger is well known for its ability to accumulate citric acid for the hydrolysis of starchy materials. To improve citric acid productivity, heavy ion beam mutagenesis was utilized to produce mutant A.niger strains with enhanced production of citric acid in this work. It was demonstrated that a mutant HW2 with high concentration of citric acid was isolated after carbon ion irradiation with the energy of 80Mev/µ, which was obvious increase higher than the original strain from liquefied corn starch as a feedstock. More importantly, with the evidence from the expression profiles of key genes and enzyme activity involved in the starch hydrolysis process between original strain and various phenotype mutants, our results confirmed that different transcript levels of key genes involving in starch hydrolysis process between original strain and mutants could be a significant contributor to different citric acid concentration in A.niger, such as, amyR and glaA, which therefore opened a new avenue for constructing genetically engineered A.niger mutants for high-yield citric acid accumulation in the future. As such, this work demonstrated that heavy ion beam mutagenesis presented an efficient alternative strategy to be developed to generate various phenotype microbe species mutants for functional genes research.

UV Tolerance of Spoilage Microorganisms and Acid-Shocked and Acid-Adapted Escherichia coli in Apple Juice Treated with a Commercial UV Juice-Processing Unit.

The enhanced thermal tolerance and survival responses of Escherichia coli O157:H7 in acid and acidified foods is a major safety concern for the production of low-pH products, including beverages. Little is known about this phenomenon when using UV light treatments. This study was conducted to evaluate the effects of strain (E. coli O157:H7 strains C7927, ATCC 35150, ATCC 43895, and ATCC 43889 and E. coli ATCC 25922) and physiological state (control-unadapted, acid adapted, and acid shocked) on the UV tolerance of E. coli in apple juice treated under conditions stipulated in current U.S. Food and Drug Administration regulations. A greater than 5-log reduction of E. coli was obtained under all tested conditions. A significant effect of strain (P < 0.05) was observed, but the physiological state did not influence pathogen inactivation (P ≥ 0.05). The UV sensitivity of three spoilage microorganisms (Aspergillus niger, Penicillium commune, and Alicyclobacillus acidoterrestris) was also determined at UV doses of 0 to 98 mJ/cm(2). Alicyclobacillus was the most UV sensitive, followed by Penicillium and Aspergillus. Because of the nonsignificant differences in UV sensitivity of E. coli in different physiological states, the use of an unadapted inoculum would be adequate to conduct challenge studies with the commercial UV unit used in this study at a UV dose of 14 mJ/cm(2). The high UV tolerance of spoilage microorganisms supports the need to use a hurdle approach (e.g., coupling of refrigeration, preservatives, and/or other technologies) to extend the shelf life of UV-treated beverages.

Comparative Sensitivity of Trichophyton and Aspergillus Conidia to Inactivation by Violet-Blue Light Exposure.

OBJECTIVE: To investigate the use of 405 nm light for inhibiting the growth of selected species of dermatophytic and saprophytic fungi. BACKGROUND DATA: The increasing incidence and resilience of dermatophytic fungal infections is a major issue, and alternative treatment methods are being sought. METHODS: The sensitivity of the dermatophytic fungi Trichophyton rubrum and Trichophyton mentagrophytes to 405 nm violet-blue light exposure was investigated, and the results compared with those obtained with the saprophytic fungus Aspergillus niger. Microconidia of T. rubrum and T. mentagrophytes and conidia of A. niger were seeded onto Sabauroud dextrose agar plates and irradiated with 405 nm light from an indium-gallium-nitride 99-DIE light-emitting diode (LED) array and the extent of inhibition was measured. RESULTS: Germination of the microconidia of the Trichophyton species was completely inhibited using an irradiance of 35 mW/cm(2) for 4 h (dose of 504 J/cm(2)). A. niger conidia showed greater resistance, and colonial growth developed after light exposure. In liquid suspension tests, 405 nm light dose levels of 360, 720, and 1440 J/cm(2) resulted in complete inactivation of T. rubrum microconidia, whereas A. niger showed greater resistance, and at the highest dose level applied (1440 J/cm(2)) although A niger hyphae were completely inactivated, only a 3-log10 reduction of a 5-log10 conidial suspension was achieved. CONCLUSIONS: The study results demonstrate the relatively high sensitivity of Trichophyton microconidia to 405 nm violet-blue light, and this is may be of potential interest regarding the control and treatment of dermatophyte infections.

Study of a High-Yield Cellulase System Created by Heavy-Ion Irradiation-Induced Mutagenesis of Aspergillus niger and Mixed Fermentation with Trichoderma reesei.

The aim of this study was to evaluate and validate the efficiency of 12C6+ irradiation of Aspergillus niger (A. niger) or mutagenesis via mixed Trichoderma viride (T. viride) culturing as well as a liquid cultivation method for cellulase production via mixed Trichoderma reesei (T. reesei) and A. niger culture fermentation. The first mutagenesis approach was employed to optimize yield from a cellulase-producing strain via heavy-ion mutagenesis and high-throughput screening, and the second was to effectively achieve enzymatic hydrolysis of cellulase from a mixed culture of mutant T. viride and A. niger. We found that 12C6+-ion irradiation induced changes in cellulase biosynthesis in A. niger but had no effect on the time course of the synthesis. It is notable that the exoglucanases (CBH) activities of A. niger strains H11-1 and H differed (6.71 U/mL vs. 6.01 U/mL) and were significantly higher than that of A. niger mutant H3-1. Compared with strain H, the filter paper assay (FPA), endoglucanase (EG) and ß-glucosidase (BGL) activities of mutant strain H11-1 were increased by 250.26%, 30.26% and 34.91%, respectively. A mixed culture system was successfully optimized, and the best ratio of T. reesei to A. niger was 5:1 for 96 h with simultaneous inoculation. The BGL activity of the mixed culture increased after 72 h. At 96 h, the FPA and BGL activities of the mixed culture were 689.00 and 797.15 U/mL, respectively, significantly higher than those of monocultures, which were 408.70 and 646.98 U/mL for T. reesei and 447.29 and 658.89 U/mL for A. niger, respectively. The EG activity of the mixed culture was 2342.81 U/mL, a value that was significantly higher than that of monocultures at 2206.57 U/mL for T. reesei and 1727.62 U/mL for A. niger. In summary, cellulose production and hydrolysis yields were significantly enhanced by the proposed combination scheme.

[Research of UV-Induced Changes in the Structural and Functional Properties of Inulinases].

UV-induced changes in the catalytic activity and radiuses of inulinases molecules from various producers (plants, fungy, yeast) are studied. It is established that specific enzymes activity and the sizes of inulinases molecules from Helianthus tuberosus and Kluyveromyces marxianus under the influence of UV-light in the ranges of doses 4530-6040 and 755-6040 J/m2, respectively, are subjected to changes more than structural and functional characteristics of inulinase fromAspergillus niger. It is probably connected with lower contents in it of aromatic amino acids such as tyrosine and phenylalanine. The most expressed loss of functional properties of inulinase from Helianthus tuberosus can be caused by the'existence of significantly more numbers of cysteine in plant fructan-exohydrolases in relation to microbic enzymes. A scheme for the stages of response of inulinases of various origins on the influence of UV-light in a certain range of radiation doses is offered.

The impact of dose, irradiance and growth conditions on Aspergillus niger (renamed A. brasiliensis) spores low-pressure (LP) UV inactivation.

The use of Aspergillus niger (A. niger) fungal spores as challenge organism for UV reactor validation studies is attractive due to their high UV-resistance and non-pathogenic nature. However A. niger spores UV dose-response was dependent upon sporulation conditions and did not follow the Bunsen-Roscoe Principle of time-dose reciprocity. Exposure to 8 h of natural sunlight for 10 consecutive days increased UV resistance when compared to spores grown solely in dark conditions. Application of 250 mJ cm(-2) at high irradiance (0.11 mW cm(-2)) resulted in a 2-log inactivation; however, at low irradiance (0.022 mW cm(-2)) a 1-log inactivation was achieved. In addition, surface electron microscopy (SEM) images revealed morphological changes between the control and UV exposed spores in contrast to other well accepted UV calibrated test organisms, which show no morphological difference with UV exposure.

Screening of thermotolerant and thermophilic fungi aiming β-xylosidase and arabinanase production

Plant cell wall is mainly composed by cellulose, hemicellulose and lignin. The heterogeneous structure and composition of the hemicellulose are key impediments to its depolymerization and subsequent use in fermentation processes. Thus, this study aimed to perform a screening of thermophilic and thermotolerant filamentous fungi collected from different regions of the São Paulo state, and analyze the production of β-xylosidase and arabinanase at different temperatures. These enzymes are important to cell wall degradation and synthesis of end products as xylose and arabinose, respectively, which are significant sugars to fermentation and ethanol production. A total of 12 fungal species were analyzed and 9 of them grew at 45 ºC, suggesting a thermophilic or thermotolerant character. Additionally Aspergillus thermomutatus anamorph of Neosartorya and A. parasiticus grew at 50 ºC. Aspergillus niger and Aspergillus thermomutatus were the filamentous fungi with the most expressive production of β-xylosidase and arabinanase, respectively. In general for most of the tested microorganisms, β-xylosidase and arabinanase activities from mycelial extract (intracellular form) were higher in cultures grown at high temperatures (35-40 ºC), while the correspondent extracellular activities were favorably secreted from cultures at 30 ºC. This study contributes to catalogue isolated fungi of the state of São Paulo, and these findings could be promising sources for thermophilic and thermotolerant microorganisms, which are industrially important due to their enzymes.

A mutation of Aspergillus niger for hyper-production of citric acid from corn meal hydrolysate in a bioreactor.

The properties of the screened mutants for hyper-production of citric acid induced by carbon ((12)C(6+)) ion beams and X-ray irradiation were investigated in our current study. Among these mutants, mutant H4002 screened from (12)C(6+) ion irradiation had a higher yield of citric acid production than the parental strain in a 250-ml shaking flash. These expanded submerged experiments in a bioreactor were also carried out for mutant H4002. The results showed that (177.7-196.0) g/L citric acid was accumulated by H4002 through exploiting corn meal hydrolysate (containing initial 200.0-235.7 g/L sugar) with the productivity of (2.96-3.27) g/(L∙h). This was especially true when the initial sugar concentration was 210 g/L, and the best economical citric acid production reached (187.5±0.7) g/L with a productivity of 3.13 g/(L∙h). It was observed that mutant H4002 can utilize low-cost corn meal as a feedstock to efficiently produce citric acid. These results imply that the H4002 strain has the industrial production potentiality for citric acid and offers strong competition for the citric acid industry.

Screening of thermotolerant and thermophilic fungi aiming ß-xylosidase and arabinanase production.

Plant cell wall is mainly composed by cellulose, hemicellulose and lignin. The heterogeneous structure and composition of the hemicellulose are key impediments to its depolymerization and subsequent use in fermentation processes. Thus, this study aimed to perform a screening of thermophilic and thermotolerant filamentous fungi collected from different regions of the São Paulo state, and analyze the production of ß-xylosidase and arabinanase at different temperatures. These enzymes are important to cell wall degradation and synthesis of end products as xylose and arabinose, respectively, which are significant sugars to fermentation and ethanol production. A total of 12 fungal species were analyzed and 9 of them grew at 45 °C, suggesting a thermophilic or thermotolerant character. Additionally Aspergillus thermomutatus anamorph of Neosartorya and A. parasiticus grew at 50 °C. Aspergillus niger and Aspergillus thermomutatus were the filamentous fungi with the most expressive production of ß-xylosidase and arabinanase, respectively. In general for most of the tested microorganisms, ß-xylosidase and arabinanase activities from mycelial extract (intracellular form) were higher in cultures grown at high temperatures (35-40 °C), while the correspondent extracellular activities were favorably secreted from cultures at 30 °C. This study contributes to catalogue isolated fungi of the state of São Paulo, and these findings could be promising sources for thermophilic and thermotolerant microorganisms, which are industrially important due to their enzymes.

Role of ozone in UV-C disinfection, demonstrated by comparison between wild-type and mutant conidia of Aspergillus niger.

This study aimed to investigate the tolerance of a melanized wild-type strain of Aspergillus niger (CON1) and its light-colored mutant (MUT1) to UV-C light and the concomitantly generated ozone. Treatments were segregated into four groups based on whether UV irradiation was used and the presence or absence of ozone: (-UV, -O3), (-UV, +O3), (+UV, -O3) and (+UV, +O3). The survival of CON1 and MUT1 conidia under +UV decreased as the exposure time increased, with CON1 showing greater resistance to UV irradiation than MUT1. Ozone induced CON1 conidium inactivation only under conditions of UV radiation exposure. While, the inactivation effect of ozone on MUT1 was always detectable regardless of the presence of UV irradiation. Furthermore, the CON1 conidial suspension showed lower UV light transmission than MUT1 when examined at the same concentration. Compared with the pigment in MUT1, the melanin in CON1 exhibited more potent radical-scavenging activity and stronger UV absorbance. These results suggested that melanin protected A. niger against UV disinfection via UV screening and free radical scavenging. The process by which UV-C disinfection induces a continual decrease in conidial survival suggests that UV irradiation and ozone exert a synergistic fungicidal effect on A. niger prior to reaching a plateau.

Lethal effects of high-intensity violet 405-nm light on Saccharomyces cerevisiae, Candida albicans, and on dormant and germinating spores of Aspergillus niger.

This study assessed the effects of high-intensity violet light on selected yeast and mould fungi. Cell suspensions of Saccharomyces cerevisiae, Candida albicans, and dormant and germinating spores (conidia) of the mould Aspergillus niger were exposed to high-intensity narrow band violet light with peak output at 405 nm generated from a light-emitting diode (LED) array. All three fungal species were inactivated by the 405-nm light without a requirement for addition of exogenous photosensitiser chemicals. Of the fungal species tested, S. cerevisiae was most sensitive and dormant conidia of A. niger were most resistant to 405-nm light exposure. Five-log10 colony forming units per millilitre (CFU ml(-1)) reductions of the tested species required exposure doses of 288 J cm(-2) for S. cerevisiae, 576 J cm(-2) for C. albicans, and a much higher value of 2.3 kJ cm(-2) for dormant conidia of A. niger. During germination, A. niger conidia became more sensitive to 405-nm light exposure and sensitivity increased as germination progressed over an 8 h test period. Light exposure under aerobic and anaerobic conditions, together with results obtained using ascorbic acid as a scavenger of reactive oxygen species, revealed that 405-nm light inactivation in fungi involved an oxygen-dependent mechanism, as previously described in bacteria. The inactivation results achieved with yeast cells and fungal spores together with operational advantages associated with the use of a visible (nonultraviolet (UV)) light source highlight the potential of 405-nm light for fungal decontamination applications.

Effect of forced aeration on citric acid production by Aspergillus sp. mutants in SSF.

Citric acid (CA) is one of the most important products of fermentation in the world. A great variety of agro-industrial residues can be used in solid state fermentation. Aspergillus niger parental strain (CCT 7716) and two strains obtained by mutagenesis (CCT 7717 and CCT 7718) were evaluated in Erlenmeyer flasks and glass columns using citric pulp (CP) as substrate/support, sugarcane molasses and methanol. Best results using glass columns (forced aeration) were found in the fourth day of fermentation: 278.4, 294.9 and 261.1 g CA/kg of dry CP with CCT 7716, CCT 7718 and CCT 7717, respectively. In Erlenmeyer flasks (aeration by diffusion) CA reached 410.7, 446.8 and 492.7 g CA/kg of dry CP with CCT 7716, CCT 7718 and CCT 7717, respectively. The aeration by diffusion improved CA production by the three strains. A data acquisition system specially developed for biotechnological processes analysis was used to perform the respirometric parameters measurement.