A prokaryote system optimization for rMEPLox expression: A promising non-toxic antigen for Loxosceles antivenom production.

Loxoscelism is the most dangerous araneism form in Brazil and antivenom therapy is the recommended treatment. Antivenom is produced by horse immunization with Loxosceles spider venom, which is toxic for the producer animal. Moreover, due to the high amount of venom required for horse hyperimmunization, new strategies for antigens obtention have been proposed. In this sense, our research group has previously produced a non-toxic recombinant multiepitopic protein derived from Loxosceles toxins (rMEPLox). rMEPLox was a successful immunogen, being able to induce the production of neutralizing antibodies, which could be used in the Loxoscelism treatment. However, rMEPLox obtention procedure requires optimization, as its production needs to be scaled up to suit antivenom manufacture. Therefore, an effective protocol development for rMEPlox production would be advantageous. To achieve this objective, we evaluated the influence of different cultivation conditions for rMEPLox optimum expression. The optimum conditions to obtain large amounts of rMEPlox were defined as the use of C43(DE3)pLysS as a host strain, 2xTY medium, 0.6 mM IPTG, biomass pre induction of OD600nm = 0.4 and incubation at 30 °C for 16 h. Following the optimized protocol, 39.84 mg/L of soluble rMEPLox was obtained and tested as immunogen. The results show that the obtained rMEPLox preserved the previously described immunogenicity, and it was able to generate antibodies that recognize different epitopes of the main Loxosceles venom toxins, which makes it a promising candidate for the antivenom production for loxoscelism treatment.

High-yield production of spider short-chain insecticidal neurotoxin Tx4(6-1) in Pichia pastoris and bioactivity assays in vivo.

Short-chain insecticidal neurotoxin Tx4(6-1) from the spider Phoneutria nigriventer can be prepared by reversed-phase high-performance liquid-chromatography (HPLC) fractionation of PhTx4, but this is difficult and represents an obstacle preventing analyses of its insecticidal activity against agricultural insect pests. Herein, we performed secretory expression of recombinant Tx4(6-1) using Pichia pastoris strain X33 as the host, and screened transformants using enzyme-linked immunosorbent assay (ELISA). In flasks, ∼5 mg/l rTx4(6-1) was expressed as a secreted protein following induction with methanol, and this was increased to 45 mg/l rTx4(6-1) in a fed-batch reactor. Approximately 4 mg of high-purity rTx4(6-1) was purified from a 400 ml fed-batch culture supernatant by Ni+-nitriloacetic acid affinity chromatography, followed by carboxymethyl (CM) sepharose ion-exchange chromatography. Purified rTx4(6-1) was determined by mass spectrometry (MS) analysis, revealing a molecular weight (MW) of 7660.5 Da, larger than the expected size due to O-linked glycosylation. Insect bioactivity tests of rTx4(6-1)-treated fifth-instar silkworm larvae (Bombyx mori Linnaeus) showed neurotoxin symptoms such as contraction paralysis, abdominal contraction, and mouth movement syndrome, with a half lethal dose at 12 h post-injection of ∼4.5-8.5 µg/g body weight. Dietary toxicity was not observed in silkworm larvae.

ω-Tbo-IT1-New Inhibitor of Insect Calcium Channels Isolated from Spider Venom.

Novel disulfide-containing polypeptide toxin was discovered in the venom of the Tibellus oblongus spider. We report on isolation, spatial structure determination and electrophysiological characterization of this 41-residue toxin, called ω-Tbo-IT1. It has an insect-toxic effect with LD50 19 µg/g in experiments on house fly Musca domestica larvae and with LD50 20 µg/g on juvenile Gromphadorhina portentosa cockroaches. Electrophysiological experiments revealed a reversible inhibition of evoked excitatory postsynaptic currents in blow fly Calliphora vicina neuromuscular junctions, while parameters of spontaneous ones were not affected. The inhibition was concentration dependent, with IC50 value 40 ± 10 nM and Hill coefficient 3.4 ± 0.3. The toxin did not affect frog neuromuscular junctions or glutamatergic and GABAergic transmission in rat brains. Ca(2+) currents in Calliphora vicina muscle were not inhibited, whereas in Periplaneta americana cockroach neurons at least one type of voltage gated Ca(2+) current was inhibited by ω-Tbo-IT1. Thus, the toxin apparently acts as an inhibitor of presynaptic insect Ca(2+) channels. Spatial structure analysis of the recombinant ω-Tbo-IT1 by NMR spectroscopy in aqueous solution revealed that the toxin comprises the conventional ICK fold containing an extended ß-hairpin loop and short ß-hairpin loop which are capable of making "scissors-like mutual motions".

Natural mutations change the affinity of µ-theraphotoxin-Hhn2a to voltage-gated sodium channels.

µ-Theraphotoxin-Hhn2a (HNTX-III) isolated from the venom of the spider Ornithoctonus hainana is a selective antagonist of neuronal tetrodotoxin-sensitive (TTX-S) voltage-gated sodium channels (VGSCs). Intriguingly, previous transcriptomic study revealed HNTX-III family consists of more than 15 precursors, in which the 20(th) and 24(th) residues of the mature sequences are variable. Try20 and Ser24 of HNTX-III are mutated to His20 and Asn24 of other members, respectively. In addition, the alkaline residue His26 of the potent VGSC inhibitor HNTX-III is substituted by acidic residue Asp of the weak VGSC inhibitor HNTX-I. Therefore, four mutants of HNTX-III, HNTX-III-Y20H, -S24N, -H26D and -Y20H/24N, were synthesized to examine the effects of these natural mutations on the inhibitory activity of HNTX-III. They were subjected to an electrophysiological screening on five VGSC subtypes (Nav1.3-1.5, Nav1.7 and Nav1.8) expressed on HEK293 cells by whole-cell patch clamp. Like HNTX-III, all mutants only displayed inhibitory activity on Nav1.3 and Nav1.7 among the five subtypes, but the inhibitory potency was much lower than that of HNTX-III. Regarding Nav1.7, the IC50 values of HNTX-III-Y20H, -S24N, -H26D and -Y20H/S24N were increased by approximately 62-, 8.4-, 49- and 19.5-folds compared with that of HNTX-III, respectively. Similar data were obtained for Nav1.3. Our results provide new insights into the activity-related residues of HNTX-III at genic level. Furthermore, the reduced potency of the four mutants probably reflects natural selection might favor and reserve the most potent bioactivity of HNTX-III which is one of the most abundant fractions of the venom.

Optimising expression of the recombinant fusion protein biopesticide ω-hexatoxin-Hv1a/GNA in Pichia pastoris: sequence modifications and a simple method for the generation of multi-copy strains.

Production of recombinant protein bio-insecticides on a commercial scale can only be cost effective if host strains with very high expression levels are available. A recombinant fusion protein containing an arthropod toxin, ω-hexatoxin-Hv1a, (from funnel web spider Hadronyche versuta) linked to snowdrop lectin (Galanthus nivalis agglutinin; GNA) is an effective oral insecticide and candidate biopesticide. However, the fusion protein was vulnerable to proteolysis during production in the yeast Pichia pastoris. To prevent proteolysis, the Hv1a/GNA fusion expression construct was modified by site-directed mutagenesis to remove a potential Kex2 cleavage site at the C-terminus of the Hv1a peptide. To obtain a high expressing clone of P. pastoris to produce recombinant Hv1a/GNA, a straightforward method was used to produce multi-copy expression plasmids, which does not require multiple integrations to give clones of P. pastoris containing high copy numbers of the introduced gene. Removal of the Kex2 site resulted in increased levels of intact fusion protein expressed in wild-type P. pastoris strains, improving levels of intact recombinant protein recoverable. Incorporation of a C-terminal (His)6 tag enabled single step purification of the fusion protein. These modifications did not affect the insecticidal activity of the recombinant toxin towards lepidopteran larvae. Introduction of multiple expression cassettes increased the amount of secreted recombinant fusion protein in a laboratory scale fermentation by almost tenfold on a per litre of culture basis. Simple modifications in the expression construct can be advantageous for the generation of high expressing P. pastoris strains for production of a recombinant protein, without altering its functional properties.

A new theraphosid spider toxin causes early insect cell death by necrosis when expressed in vitro during recombinant baculovirus infection.

Baculoviruses are the most studied insect viruses in the world and are used for biological control of agricultural and forest insect pests. They are also used as versatile vectors for expression of heterologous proteins. One of the major problems of their use as biopesticides is their slow speed to kill insects. Thus, to address this shortcoming, insect-specific neurotoxins from arachnids have been introduced into the baculovirus genome solely aiming to improve its virulence. In this work, an insecticide-like toxin gene was obtained from a cDNA derived from the venom glands of the theraphosid spider Brachypelma albiceps. The mature form of the peptide toxin (called Ba3) has a high content of basic amino acid residues, potential for three possible disulfide bonds, and a predicted three-stranded ß-sheetDifferent constructions of the gene were engineered for recombinant baculovirus Autographa californica multiple nuclepolyhedrovirus (AcMNPV) expression. Five different forms of Ba3 were assessed; (1) the full-length sequence, (2) the pro-peptide and mature region, (3) only the mature region, and the mature region fused to an (4) insect or a (5) virus-derived signal peptide were inserted separately into the genome of the baculovirus. All the recombinant viruses induced cell death by necrosis earlier in infection relative to a control virus lacking the toxin gene. However, the recombinant virus containing the mature portion of the toxin gene induced a faster cell death than the other recombinants. We found that the toxin construct with the signal peptide and/or pro-peptide regions delayed the necrosis phenotype. When infected cells were subjected to ultrastructural analysis, the cells showed loss of plasma membrane integrity and structural changes in mitochondria before death. Our results suggest this use of baculovirus is a potential tool to help understand or to identify the effect of insect-specific toxic peptides when produced during infection of insect cells.

Molecular cloning, heterologous expression and functional characterization of a novel translationally-controlled tumor protein (TCTP) family member from Loxosceles intermedia (brown spider) venom.

Envenoming with brown spiders (Loxosceles genus) is common throughout the world. Cutaneous symptoms following spider bite accidents include dermonecrosis, erythema, itching and pain. In some cases, accidents can cause hypersensibility or even allergic reactions. These responses could be associated with histaminergic events, such as an increase in vascular permeability and vasodilatation. A protein that may be related to the effects of spider venom was identified from a previously obtained cDNA library of the L. intermedia venom gland. The amino acid sequence of this protein is homologous to proteins from the TCTP (translationally-controlled tumor protein) family, which are extracellular histamine-releasing factors (HRF) that are associated with the allergic reactions to parasites. Herein, we described the cloning, heterologous expression, purification and functional characterization of a novel member of the TCTP family from the Loxosceles intermedia venom gland. This recombinant protein, named LiRecTCTP, causes edema, enhances vascular permeability and is likely related to the inflammatory activity of the venom. Moreover, LiRecTCTP presents an immunological relationship with mammalian TCTPs.

[Expression and characterization of Huwentoxin-XI (HWTX-XI) and its mutants].

Huwentoxin-XI (HWTX-XI) is a protein isolated from the crude venom of spider Ornithoctonus huwena. It has 55 amino acid residues containing 6 cysteine residues forming 3 disulfide bonds. It shows potent inhibitory effect on trypsin and voltage-gated potassium channels in rat dorsal root ganglion cells. According to the structure-function relationship of HWTX-XI, we designed two mutants through mutation of potassium channel inhibition related amino acid residues (R5I, R10T,R25A and R5I,R25A) and then expressed them with high purity by using the vector pVT102U on Saccharamyces cerevisiae strain S78; The two mutants had the same trypsin inhibition activity as HWTX-XI, whereas their potassium channel inhibition activity and animal toxicity were much lower than those of HWTX-XI. This study is helpful for designing drugs of trypsin related diseases based on HWTX-XI.

Spider toxin (Hvt) gene cloned under phloem specific RSs1 and RolC promoters provides resistance against American bollworm (Heliothis armigera).

Spider venoms are neurotoxin proteins that can kill insects. Spider toxin Hvt gene was cloned under two phloem specific RSs1 and RolC promoters, transformed into tobacco plants through Agrobacterium-mediated transformation and tested against Heliothis armigera larvae. Transgenic plants were confirmed through PCR. First instar larvae of H. armigera were released on detached leaves of transformed and non-transformed plants. Insect bioassays showed 93-100% mortality of H. armigera larvae within 72 h on the leaves of transgenic plants while all larvae survived and continued feeding on detached leaves from non-transformed control plants. The Hvt gene expressing under phloem specific RSs1 and RolC promoters could therefore be used for developing H. armigera-resistant, genetically-modified crops.

Expression and characterization of jingzhaotoxin-34, a novel neurotoxin from the venom of the tarantula Chilobrachys jingzhao.

Jingzhaotoxin-34 (JZTX-34) is a 35-residue polypeptide from the venom of Chinese tarantula Chilobrachys jingzhao. Our previous work reported its full-length cDNA sequence encoding a precursor with 87 residues. In this study we report the protein expression and biological function characterization. The toxin was efficiently expressed by the secretary pathway in yeast. Under whole-cell patch-clamp mode, the expressed JZTX-34 was able to inhibit tetrodotoxin-sensitive (TTX-S) sodium currents (IC(50) approximately 85 nM) while having no significant effects on tetrodotoxin-resistant (TTX-R) sodium currents on rat dorsal root ganglion neurons. The inhibition of TTX-S sodium channels was completely reversed by strong depolarization (+120 mV). Toxin treatment altered neither channel activation and inactivation kinetics nor recovery rate from inactivation. However, it is interesting to note that in contrast to huwentoxin-IV, a recently identified receptor site-4 toxin from Ornithoctonus huwena venom, 100 nM JZTX-34 caused a negative shift of steady-state inactivation curve of TTX-S sodium channels by approximately 10 mV. The results indicated that JZTX-34 might inhibit mammalian sensory neuronal sodium channels through a mechanism similar to HWTX-IV by trapping the IIS4 voltage sensor in the resting conformation, but their binding sites should not overlay completely.

Soluble expression and one-step purification of a neurotoxin Huwentoxin-I in Escherichia coli.

Huwentoxin-I (HWTX-I) is a small 33-amino acid neurotoxin from the venom of the Chinese bird spider Ornithoctonus huwena. HWTX-I selectively blocks N-type voltage-sensitive calcium channels (N-VSCCs) and has great potential for clinical application as a novel analgesic without inducing drug tolerance. However, there are still many unsolved issues for this peptide, such as its clinical efficacy in analgesia, anesthesia, and even its potential role in drug rehabilitation. Therefore, large amounts of active recombinant HWTX-I are urgently needed. In this report, we describe a novel and efficient way to produce large amounts of the valuable form in Escherichia coli. HWTX-I was expressed in soluble form as an N-terminal intein fusion product. After affinity purification, a pH shift-induced self-cleavage of the intein released HWTX-I, resulting in a single-column purification of the target protein. The whole-cell patch clamp assay showed that purified HWTX-I has activity similar to another commercialized N-VSCC blocker omega-conotoxin MVIIA. Production of HWTX-I by this method has the major advantages of high efficiency and low cost.

Expression and characterization of LTx2, a neurotoxin from Lasiodora sp. effecting on calcium channels.

Here, we described the expression and characterization of the recombinant toxin LTx2, which was previously isolated from the venomous cDNA library of a Brazilian spider, Lasiodora sp. (Mygalomorphae, Theraphosidae). The recombinant toxin found in the soluble and insoluble fractions was purified by reverse phase high-performance liquid chromatography (HPLC). Ca2+ imaging analysis revealed that the recombinant LTx2 acts on calcium channels of BC3H1 cells, blocking L-type calcium channels.

Bacterial production of latarcin 2a, a potent antimicrobial peptide from spider venom.

Natural venoms are promising sources of candidate therapeutics including antibiotics. A recently described potent antimicrobial peptide latarcin 2a (Ltc 2a) from Lachesana tarabaevi spider venom shows a broad-spectrum antibacterial activity. This peptide consists of 26 amino acid residues and therefore its production using chemical synthesis, although trivial, is costly. We describe an easy approach to Ltc 2a production in Escherichia coli using the conventional fusion partner thioredoxin. Latarcin 2a synthetic gene was cloned into the expression vector pET-32b, which was then used to transform E. coli BL21(DE3) strain. His-tagged fusion purification was achieved using metal-chelate affinity chromatography. Since no methionine residues are present in the latarcin 2a sequence, cyanogen bromide could be effectively utilized to separate the target product from the carrier protein. Reverse-phase HPLC was used as the final step of purification; the final yield was approximately 3 mg/L of bacterial culture. To increase the yields, we attempted incorporation of Ltc 2a tandem repeats into the fusion protein; however, production rates greatly decreased due to enhanced fusion toxicity. Moreover, we probed constructs to produce an Ltc 2a dimer and the Ltc 2a propeptide to study their functional properties. Recombinant peptides were produced at appreciable yields and biological tests to determine their activities were performed. Latarcin 2a is the first linear peptide from spider venom and one of the first membrane-active peptides from venomous animals to be biosynthetically produced.

[The analysis of heterogeneity of HWTX-I expressed in Pichia pastoris].

To seek the reason of heterogeneity of recombinant HWTX-I (rHWTX-I) expressed in Pichia pastoris. We expressed HWTX-I gene of interest in Pichia pastoris GS115/HWTX-I. The heterogenous product expressed was separated, purified and identified by using Ion exchange HPLC, reverse HPLC, Tricine SDS-PAGE and MALDI-TOF Mass Spectrometry and then sequenced in both N-terminus and C-terminus. These results show that the heterogeneity of rHWTX-I results from the incomplete processing of signal peptide of N-terminus and the internal degradation of C-terminus. Biological activity assay shows that the activity of the heterogenous rHWTX-I only showed 30% activity compared with the native HWTX-I. The Solutions to how to avoid the heterogeneity are also discussed.

Localization of the voltage-sensor toxin receptor on KvAP.

A variety of venomous animals produce small protein toxins that impair the function of voltage-dependent cation channels by affecting the motions of the voltage-sensor domains and altering the energetics of the opening of the channel. In this study, we investigate the location of the receptor for tarantula venom voltage-sensor toxins on the voltage-dependent K+ channel from Aeropyrum pernix (KvAP), an archeabacterial channel that is functionally inhibited by members of this toxin family. We show that it is possible to purify the same set of toxins from venom of the tarantula Grammostola spatulata using either the purified KvAP voltage-sensor domain or the full-length KvAP channel. The equivalence of toxin retention profiles for the two channel proteins implies that the tarantula voltage-sensor toxin receptor resides exclusively on the voltage-sensor domain and that the pore is not required for the toxin-channel interaction. We have identified and characterized the functional properties of a subset of the tarantula toxins that bind to the KvAP voltage-sensor domain. Some of these toxins, VSTX1 and GSMTX4, have been previously isolated, while others, VSTX2 and VSTX3, are new members of the tarantula voltage-sensor toxin family. Some but not all toxins that bind to the voltage-sensor domain affect voltage-dependent gating of KvAP channels in lipid membranes.

Recombinant production and solution structure of PcTx1, the specific peptide inhibitor of ASIC1a proton-gated cation channels.

Acid-sensing ion channels (ASICs) are thought to be important ion channels, particularly for the perception of pain. Some of them may also contribute to synaptic plasticity, learning, and memory. Psalmotoxin 1 (PcTx1), the first potent and specific blocker of the ASIC1a proton-sensing channel, has been successfully expressed in the Drosophila melanogaster S2 cell recombinant expression system used here for the first time to produce a spider toxin. The recombinant toxin was identical in all respects to the native peptide, and its three-dimensional structure in solution was determined by means of (1)H 2D NMR spectroscopy. Surface characteristics of PcTx1 provide insights on key structural elements involved in the binding of PcTx1 to ASIC1a channels. They appear to be localized in the beta-sheet and the beta-turn linking the strands, as indicated by electrostatic anisotropy calculations, surface charge distribution, and the presence of residues known to be implicated in channel recognition by other inhibitor cystine knot (ICK) toxins.

The influence of hunger and breeding temperature on the venom production of the spider Cupiennius salei (Araneae, Ctenidae).

The venom production of the free hunting neotropic spider Cupiennius salei was tested under different breeding conditions. Three groups kept at different temperatures (17, 21 and 25 degrees C) showed that venom production remained stable within this temperature range, only at a temperature of 15 degrees C the spiders stopped feeding and venom synthesis. Hunger periods do not have a direct effect on the released venom quantity. Two groups of spiders--the first group after a four and the second after an eight weeks hunger period--were compared and no difference in venom production was found. Such long fasting periods are a natural situation for spiders. In this case Cupiennius salei reduces its body weight but not venom supply. This means that body weight is a parameter only of short-term fitness which changes with the actual living conditions (temperature, feeding intervals) of each individual. Long-term fitness is best described by the prosoma length, which was formed during the juvenile growth of each spider and is rather invariable in adulthood. It was shown that the quantity of released venom is better correlated with the length of the prosoma than with the weight of the animal. This means that venom production is mostly an indicator of long-term fitness.

Functional expression of alpha-latrotoxin in baculovirus system.

To facilitate the study of the mechanism of alpha-latrotoxin action, it is necessary to create a biologically active recombinant toxin. Mature alpha-latrotoxin is naturally produced by post-translational cleavage, probably at two furin sites located at the N- and C-termini of the precursor. A recombinant baculovirus has now been constructed, which encodes the melittin signal peptide fused to the 130-kDa mature toxin between the furin sites. Insect cells, infected with this baculovirus, secreted recombinant alpha-latrotoxin. This was partially purified and proved indistinguishable from the natural toxin with respect to its molecular mass, immunostaining, toxicity to mice, binding to alpha-latrotoxin receptors (latrophilin or neurexin Ialpha) and electrophysiological recording in the mouse diaphragm. The successful expression of recombinant alpha-latrotoxin permits mutational analysis of the toxin.

Cloning and structure of delta-latroinsectotoxin, a novel insect-specific member of the latrotoxin family: functional expression requires C-terminal truncation.

The venom of the black widow spider (BWSV) (Latrodectus mactans tredecimguttatus) contains several potent, high molecular mass (>110 kDa) neurotoxins that cause neurotransmitter release in a phylum-specific manner. The molecular mechanism of action of these proteins is poorly understood because their structures are largely unknown, and they have not been functionally expressed. This study reports on the primary structure of delta-latroinsectotoxin (delta-LIT), a novel insect-specific toxin from BWSV, that contains 1214 amino acids. delta-LIT comprises four structural domains: a signal peptide followed by an N-terminal domain that exhibits the highest degree of identity with other latrotoxins, a central region composed of 15 ankyrin-like repeats, and a C-terminal domain. The domain organization of delta-LIT is similar to that of other latrotoxins, suggesting that these toxins are a family of related proteins. The predicted molecular mass and apparent mobility of the protein (approximately 130 kDa) encoded in the delta-LIT gene differs from that of native delta-LIT purified from BWSV (approximately 100 kDa), suggesting that the toxin is produced by proteolytic processing of a precursor. MALDI-MS of purified native delta-LIT revealed a molecular ion with m/z+ of 110916 +/- 100, indicating that the native delta-LIT is 991 amino acids in length. When the full-length delta-LIT cDNA was expressed in bacteria the protein product was inactive, but expression of a C-terminally truncated protein containing 991 residues produced a protein that caused massive neurotransmitter release at the locust neuromuscular junction at nanomolar concentrations. Channels formed in locust muscle membrane and artificial lipid bilayers by the native delta-LIT have a high Ca2+ permeability, whereas those formed by truncated, recombinant protein do not.

Functional characterization of black widow spider neurotoxins synthesised in insect cells.

alpha-latrotoxin, alpha-latroinsectotoxin and the low-molecular-mass protein from black widow spider venom were synthesised in insect cells using the baculovirus expression system. SDS/PAGE analysis of recombinant-virus-infected cells revealed novel proteins that migrated with sizes similar to those of the neurotoxins from spider venom. The identities of these proteins as alpha-latrotoxin, alpha-latroinsectotoxin or the low-molecular-mass protein were confirmed by immunoblot analysis of infected cells with anti-(alpha-latrotoxin), anti-(alpha-latroinsectotoxin) or anti-(low-molecular-mass protein) IgG. Neither the low-molecular-mass protein nor alpha-latrotoxin were toxic upon injection into Trichoplusia ni larvae or upon virus-derived synthesis directly in the cytoplasm of the target tissue. Analysis of the biological activity of the recombinant virus encoding alpha-latroinsectotoxin, however, revealed a strong toxic effect on the T. ni larvae. These data indicate that the toxic effect of the native insectotoxin may be promoted by the alpha-latroinsectotoxin subunit alone and provides evidence that the mechanism of action of alpha-latroinsectotoxin may be mediated by internalisation of part of the neurotoxin alpha-subunit molecule.