RESUMEN
Catalysts prepared from industrial wastes rich in Fe, Ca, Si, and Al were used in catalytic upgrading of pyrolysis vapour derived from durian shell and their effect on product yield and properties were compared. With same silica-to-alumina ratio, catalyst prepared from oil palm ash (AS-OPA) with lower Fe and Ca contents gave higher liquid yield (8.32â¯wt%) with alcohols (28.90%), hydrocarbons (46.00%), and nitrogen-containing compounds (21.46%) while catalyst prepared from electric arc furnace slag (AS-EAF) with higher Fe and Ca contents produced lower liquid yield (50.21â¯wt%) with high amount of esters (25.80%) and hydrocarbons (72.82%). The presence of AS-OPA and AS-EAF catalysts enhanced deoxygenation degree of bio-oil to 81.13% and 85.49%, respectively. The catalytic performance of AS-EAF at different temperatures (400-600⯰C) and AS-EAF/durian shell ratios (1:30, 2:30, 3:30) was investigated. Increasing catalytic temperature enhanced production of bio-oil, reduced oxygenates and enhanced formation of esters. The liquid yield and yield of esters decreased with increasing catalyst loading. Hydrocarbons (mainly neopentane) were the major chemical compounds found in bio-oil produced over AS-EAF. Besides that, AS-EAF showed good deoxygenation performance with highest selectivity of hydrocarbons at 500⯰C and AS-EAF/durian shell ratio of 2:30. Catalytic fast pyrolysis of durian shell using waste-derived catalysts is an effective waste management strategy as the bio-oil produced can be a potential alternative source of energy or chemical feedstocks.
RESUMEN
Silica-alumina catalyst was prepared and used in the catalytic fast pyrolysis of durian rind in a drop-type two-stage reactor. The effects of catalytic temperature (400⯰C-600⯰C) and catalyst-to-durian rind ratio (1:30-3:30) were evaluated. Bio-oil yield was increased with increased catalytic temperature due to considerable dehydration process, but it was reduced with high catalyst loading due to the overcracking of organics into light gases. Silica-alumina catalyst possessed good selectivity and the products changed according to the temperature. The major components in bio-oil were hydrocarbons, furan derivatives, and aromatic compounds at 400⯰C, 500⯰C, and 600⯰C, respectively. The hydrogen and carbon contents of bio-oil were reduced with high catalyst loading due to the overcracking of organics, and the deoxygenation process became unfavorable. The silica-alumina catalyst worked well in catalytic fast pyrolysis of durian rind, and the condition may be adjusted based on the desired products.
Asunto(s)
Óxido de Aluminio , Biocombustibles , Dióxido de Silicio , Biomasa , Bombacaceae , Catálisis , CalorRESUMEN
Durian shell (DS) was pyrolyzed in a drop-type fixed-bed reactor to study the physicochemical properties of the products. The experiment was carried out with different particle sizes (up to 5mm) and reaction temperatures (250-650°C). The highest bio-oil yield was obtained at 650°C (57.45wt%) with DS size of 1-2mm. The elemental composition and higher heating value of the feedstock, bio-oil (650°C), and bio-char (650°C) were determined and compared. The compositions of product gases were determined via gas chromatography with thermal conductivity detector. The chemical composition of bio-oil was analyzed by gas chromatography-mass spectrometry. The bio-oil produced at lower temperature yields more alcohols, whereas the bio-oil produced at higher temperature contains more aromatics and carbonyls. Bio-oil has potential to be used as liquid fuel or fine chemical precursor after further upgrading. The results further showed the potential of bio-char as a solid fuel.
Asunto(s)
Biocombustibles , Bombacaceae , Cromatografía de Gases y Espectrometría de Masas , Calor , TemperaturaRESUMEN
In the present study, characteristics of the granular sludge (including physical characteristics under stable conditions and process shocks arising from suspended solid overload, soluble organic overload, and high temperature; biological activity; and sludge kinetic evaluation in a batch experiment) developed in an upflow anaerobic sludge blanket fixed-film reactor for palm oil mill effluent (POME) treatment was investigated. The main aim of this work was to provide suitable understanding of POME anaerobic digestion using such a granular sludge reactor, particularly with respect to granule structure at various operating conditions. The morphological changes in granular sludge resulting from various operational conditions was studied using scanning electron microscopy and transmission electron microscopy images. It was shown that the developed granules consisted of densely packed rod- (Methanosaeta-like microorganism; predominant) and cocci- (Methanosarsina) shaped microorganisms. Methanosaeta aggregates functioned as nucleation centers that initiated granule development of POME-degrading granules. Under the suspended solid overload condition, most of the granules were covered with a thin layer of fiberlike suspended solids, so that the granule color changed to brown and the sludge volume index also increased to 24.5 from 12 to 15 mL/g, which caused a large amount of sludge washout. Some of the granules were disintegrated because of an acidified environment, which originated from acidogenesis of high influent organic load (29 g chemical oxygen demand [COD]/L d). At 60 degrees C, the rate of biomass washout increased, as a result of disintegration of the outer layer of the granules. In the biological activity test, approximately 95% COD removal was achieved within 72 hours, with an initial COD removal rate of 3.5 g COD/L d. During POME digestion, 275 mg calcium carbonate/L bicarbonate alkalinity was produced per 1000 mg COD(removed)/ L. A consecutive reaction kinetic model was used to simulate the data obtained from the sludge activity in the batch experiment. The mathematical model gave a good fit with the experimental results (R2 > 0.93). The slowest step was modeled to be the acidification step, with a rate constant between 0.015 and 0.083 hours(-1), while the rate constant for the methanogenic step was obtained to be between 0.218 and 0.361 hours(-1).
Asunto(s)
Biopelículas/crecimiento & desarrollo , Reactores Biológicos , Methanosarcina/metabolismo , Eliminación de Residuos Líquidos/métodos , Anaerobiosis , Biodegradación Ambiental , Cinética , Metano/metabolismo , Microscopía Electrónica de Transmisión , Aceite de Palma , Aceites de Plantas/metabolismoRESUMEN
Previous studies have concluded that copper might inhibit enamel demineralization in vitro. Our aim was to assess the effect of copper (Cu2+), with and without amine fluoride, on human dental enamel under cariogenic challenge in situ. In a double-blind randomized four-leg crossover trial, 14 individuals wore a removable appliance containing 2 enamel slabs, 1 containing an artificial caries lesion. During each leg, the appliance was exposed twice daily to one of the test solutions: 1.25 mM CuSO4, amine fluoride (250 ppm F), copper and amine fluoride combined, or a placebo (water). A cariogenic challenge was provided in all cases by 5 daily exposures to 10% sucrose. Slabs were assessed before and after 21 days' exposure by Knoop microhardness and transverse microradiography. Significantly less demineralization was observed with Cu2+ and fluoride in combination than with fluoride treatment alone (p < 0.05), whereas copper alone had no significant protective effect.
Asunto(s)
Cariostáticos/uso terapéutico , Cobre/uso terapéutico , Fluoruros Tópicos/uso terapéutico , Desmineralización Dental/prevención & control , Adulto , Esmalte Dental , Solubilidad del Esmalte Dental , Método Doble Ciego , Combinación de Medicamentos , Femenino , Pruebas de Dureza , Humanos , Masculino , Microrradiografía , Estadísticas no ParamétricasRESUMEN
In this study, the interactive effects of feed flow rate (QF) and up-flow velocity (V up) on the performance of an up-flow anaerobic sludge fixed film (UASFF) reactor treating palm oil mill effluent (POME) were investigated. Long-term performance of the UASFF reactor was first examined with raw POME at a hydraulic loading rate (HRT) of 3 d and an influent COD concentration of 44300 mg/l. Extreme reactor instability was observed after 25 d. Raw POME was then chemically pretreated and used as feed. Anaerobic digestion of pretreated POME was modeled and analyzed with two operating variables, i.e. feed flow rate and up-flow velocity. Experiments were conducted based on a central composite face-centered design (CCFD) and analyzed using response surface methodology (RSM). The region of exploration for digestion of the pretreated POME was taken as the area enclosed by the feed flow rate (1.01, 7.63 l/d) and up-flow velocity (0.2, 3 m/h) boundaries. Twelve dependent parameters were either directly measured or calculated as response. These parameters were total COD (TCOD) removal, soluble COD (SCOD) removal, effluent pH, effluent total volatile fatty acid (TVFA), effluent bicarbonate alkalinity (BA), effluent total suspended solids (TSS), CH4 percentage in biogas, methane yield (Y M), specific methanogenic activity (SMA), food-to-sludge ratio (F/M), sludge height in the UASB portion and solid retention time (SRT). The optimum conditions for POME treatment were found to be 2.45 l/d and 0.75 m/h for QF and V up, respectively (corresponding to HRT of 1.5 d and recycle ratio of 23.4:1). The present study provides valuable information about interrelations of quality and process parameters at different values of the operating variables.
Asunto(s)
Anaerobiosis , Reactores Biológicos , Restauración y Remediación Ambiental , Residuos Industriales , Modelos Teóricos , Aceites de Plantas/análisis , Aguas del Alcantarillado , Aceite de PalmaRESUMEN
Three sisters in a same family (MIAH FAMILY) are of 'Bombay' phenotype. These being the first known female examples of 'Bombay' blood group have been detected in Bangladesh. As predicted by current theory their red cells are Le(a+b-) and their saliva do not contain any of the antigens A, B and H except Lea substance. Family studies showed that individuals with 'Bombay' or Oh phenotype may have A or B gene which are not expressed. This very particular type of blood is one of the rarest in any other parts of world except in India. Due to the presence of anti-H antibody in the plasma of Oh phenotype, when considering such patients for transfusion only blood of identical Bombay type can be safely transfused.