Properties of an NAD(H)-containing methanol dehydrogenase and its activator protein from Bacillus methanolicus.

Oxidation of C1-C4 primary alcohols in thermotolerant Bacillus methanolicus strains is catalyzed by an NAD-dependent methanol dehydrogenase (MDH), composed of ten identical 43,000-Mr subunits. Each MDH subunit contains a tightly, but non-covalently, bound NAD(H) molecule, in addition to 1 Zn2+ and 1-2 Mg2+ ions. The NAD(H) cofactor is oxidized and reduced by formaldehyde and methanol, respectively, while it remains bound to the enzyme. Incubation of MDH with methanol and exogenous NAD (coenzyme) results in reduction of this NAD coenzyme. Both NAD species are not exchanged during catalysis. NAD thus plays two different and important roles in the MDH-catalyzed reaction, with the bound NAD cofactor acting as primary electron acceptor and the NAD coenzyme being responsible for reoxidation of the reduced cofactor. MDH obeys a ping-pong type reaction mechanism, which is consistent with such a temporary parking of reducing equivalents at the MDH-bound cofactor. Spectral studies show that, in the presence of exogenous NAD and Mg2+ ions, MDH interacts with a previously identified 50,000-Mr activator protein. The activator protein appears to facilitate the oxidation of the reduced NADH cofactor of MDH, which results in a strongly increased turnover rate of MDH.

Control of glycolytic flux in Zymomonas mobilis by glucose 6-phosphate dehydrogenase activity.

Glycolytic genes in Zymomonas mobilis are highly expressed and constitute half of the cytoplasmic protein. The first four genes (glf, zwf, edd, glk) in this pathway form an operon encoding a glucose permease, glucose 6-phosphate dehydrogenase (G6-P dehydrogenase), 6-phosphogluconate dehydratase, and glucokinase, respectively. Each gene was overexpressed from a tac promoter to investigate the control of glycolysis during the early stages of batch fermentation when flux (qCO(2)) is highest. Almost half of flux control appears to reside with G6-P dehydrogenase (C(J) (G6-P dehydrogenase) = 0.4). Although Z. mobilis exhibits one of the highest rates of glycolysis known, recombinants with elevated G6-P dehydrogenase had a 10% to 13% higher glycolytic flux than the native organism. A small increase in flux was also observed for recombinants expressing glf. Results obtained did not allow a critical evaluation of glucokinase and this enzyme may also represent an important control point. 6-Phosphogluconate dehydratase appears to be saturating at native levels. With constructs containing the full operon, growth rate and flux were both reduced, complicating interpretations. However, results obtained were also consistent with G6-P dehydrogenase as a primary site of control. Flux was 17% higher in operon constructs which exhibited a 17% increase in G6-P dehydrogenase specific activity, relative to the average of other operon constructs which contain a frameshift mutation in zwf. It is unlikely that all flux control residues solely in G6-P dehydrogenase (calculated C(J) (G6-P dehydrogenase) = 1.0) although these results further support the importance of this enzyme. As reported in previous studies, changes in flux were not accompanied by changes in growth rate providing further evidence that ATP production does not limit biosynthesis in rich complex medium.

Reconstruction of glucose uptake and phosphorylation in a glucose-negative mutant of Escherichia coli by using Zymomonas mobilis genes encoding the glucose facilitator protein and glucokinase.

Expression of the Zymomonas mobilis glf (glucose facilitator protein) and glk (glucokinase) genes in Escherichia coli ZSC113 (glucose negative) provided a new functional pathway for glucose uptake and phosphorylation. Both genes were essential for the restoration of growth in glucose minimal medium and for acid production on glucose-MacConkey agar plates.

Electron microscopic analysis and structural characterization of novel NADP(H)-containing methanol: N,N'-dimethyl-4-nitrosoaniline oxidoreductases from the gram-positive methylotrophic bacteria Amycolatopsis methanolica and Mycobacterium gastri MB19.

The quaternary protein structure of two methanol:N,N'-dimethyl-4-nitrosoaniline (NDMA) oxidoreductases purified from Amycolatopsis methanolica and Mycobacterium gastri MB19 was analyzed by electron microscopy and image processing. The enzymes are decameric proteins (displaying fivefold symmetry) with estimated molecular masses of 490 to 500 kDa based on their subunit molecular masses of 49 to 50 kDa. Both methanol:NDMA oxidoreductases possess a tightly but noncovalently bound NADP(H) cofactor at an NADPH-to-subunit molar ratio of 0.7. These cofactors are redox active toward alcohol and aldehyde substrates. Both enzymes contain significant amounts of Zn2+ and Mg2+ ions. The primary amino acid sequences of the A. methanolica and M. gastri MB19 methanol:NDMA oxidoreductases share a high degree of identity, as indicated by N-terminal sequence analysis (63% identity among the first 27 N-terminal amino acids), internal peptide sequence analysis, and overall amino acid composition. The amino acid sequence analysis also revealed significant similarity to a decameric methanol dehydrogenase of Bacillus methanolicus C1.

Use of the tac promoter and lacIq for the controlled expression of Zymomonas mobilis fermentative genes in Escherichia coli and Zymomonas mobilis.

The Zymomonas mobilis genes encoding alcohol dehydrogenase I (adhA), alcohol dehydrogenase II (adhB), and pyruvate decarboxylase (pdc) were overexpressed in Escherichia coli and Z. mobilis by using a broad-host-range vector containing the tac promoter and the lacIq repressor gene. Maximal IPTG (isopropyl-beta-D-thiogalactopyranoside) induction of these plasmid-borne genes in Z. mobilis resulted in a 35-fold increase in alcohol dehydrogenase I activity, a 16.7-fold increase in alcohol dehydrogenase II activity, and a 6.3-fold increase in pyruvate decarboxylase activity. Small changes in the activities of these enzymes did not affect glycolytic flux in cells which are at maximal metabolic activity, indicating that flux under these conditions is controlled at some other point in metabolism. Expression of adhA, adhB, or pdc at high specific activities (above 8 IU/mg of cell protein) resulted in a decrease in glycolytic flux (negative flux control coefficients), which was most pronounced for pyruvate decarboxylase. Growth rate and flux are imperfectly coupled in this organism. Neither a twofold increase in flux nor a 50% decline from maximal flux caused any immediate change in growth rate. Thus, the rates of biosynthesis and growth in this organism are not limited by energy generation in rich medium.

Purification and characterization of an NAD(+)-linked formaldehyde dehydrogenase from the facultative RuMP cycle methylotroph Arthrobacter P1.

When Arthrobacter P1 is grown on choline, betaine, dimethylglycine or sarcosine, an NAD(+)-dependent formaldehyde dehydrogenase is induced. This formaldehyde dehydrogenase has been purified using ammonium sulphate fractionation, anion exchange- and hydrophobic interaction chromatography. The molecular mass of the native enzyme was 115 kDa +/- 10 kDa. Gel electrophoresis in the presence of sodium dodecyl sulphate indicated that the molecular mass of the subunit was 56 kDa +/- 3 kDa, which is consistent with a dimeric enzyme structure. After ammonium sulphate fractionation the partially purified enzyme required the addition of a reducing reagent in the assay mixture for maximum activity. The enzyme was highly specific for its substrates and the Km values were 0.10 and 0.80 mM for formaldehyde and NAD+, respectively. The enzyme was heat-stable at 50 degrees C for at least 10 min and showed a broad pH optimum of 8.1 to 8.5. The addition of some metal-binding compounds and thiol reagents inhibited the enzyme activity.

Cloning, expression, and sequence analysis of the Bacillus methanolicus C1 methanol dehydrogenase gene.

The gene (mdh) coding for methanol dehydrogenase (MDH) of thermotolerant, methylotroph Bacillus methanolicus C1 has been cloned and sequenced. The deduced amino acid sequence of the mdh gene exhibited similarity to those of five other alcohol dehydrogenase (type III) enzymes, which are distinct from the long-chain zinc-containing (type I) or short-chain zinc-lacking (type II) enzymes. Highly efficient expression of the mdh gene in Escherichia coli was probably driven from its own promoter sequence. After purification of MDH from E. coli, the kinetic and biochemical properties of the enzyme were investigated. The physiological effect of MDH synthesis in E. coli and the role of conserved sequence patterns in type III alcohol dehydrogenases have been analyzed and are discussed.

Bacillus methanolicus sp. nov., a new species of thermotolerant, methanol-utilizing, endospore-forming bacteria.

The generic position of 14 strains of gram-positive bacteria able to use methanol as a growth substrate was determined. All are obligately aerobic, thermotolerant organisms that are able to grow at temperatures of 35 to 60 degrees C. Nine of the strains produce oval spores at a subterminal-to-central position in slightly swollen rod-shaped cells. DNA-DNA hybridization studies, 5S rRNA sequence analysis, and physiological characteristics revealed that all 14 strains cluster as a well-defined group and form a distinct new genospecies. Analysis of the 16S and 5S rRNA sequences indicated that this new species is distinct from Bacillus brevis but closely related to B. firmus and B. azotoformans. The name proposed for this new species is B. methanolicus. The type strain, PB1, has been deposited in the National Collection of Industrial and Marine Bacteria as NCIMB 13113.

Environmental regulation of alcohol metabolism in thermotolerant methylotrophic Bacillus strains.

The thermotolerant methylotroph Bacillus sp. C1 possesses a novel NAD-dependent methanol dehydrogenase (MDH), with distinct structural and mechanistic properties. During growth on methanol and ethanol, MDH was responsible for the oxidation of both these substrates. MDH activity in cells grown on methanol or glucose was inversely related to the growth rate. Highest activity levels were observed in cells grown on the C1-substrates methanol and formaldehyde. The affinity of MDH for alcohol substrates and NAD, as well as Vmax, are strongly increased in the presence of a Mr 50,000 activator protein plus Mg(2+)-ions [Arfman et al. (1991) J Biol Chem 266: 3955-3960]. Under all growth conditions tested the cells contained an approximately 18-fold molar excess of (decameric) MDH over (dimeric) activator protein. Expression of hexulose-6-phosphate synthase (HPS), the key enzyme of the RuMP cycle, was probably induced by the substrate formaldehyde. Cells with high MDH and low HPS activity levels immediately accumulated (toxic) formaldehyde when exposed to a transient increase in methanol concentration. Similarly, cells with high MDH and low CoA-linked NAD-dependent acetaldehyde dehydrogenase activity levels produced acetaldehyde when subjected to a rise in ethanol concentration. Problems frequently observed in establishing cultures of methylotrophic bacilli on methanol- or ethanol-containing media are (in part) assigned to these phenomena.

Electron microscopic analysis and biochemical characterization of a novel methanol dehydrogenase from the thermotolerant Bacillus sp. C1.

Methanol dehydrogenase from the thermotolerant Bacillus sp. C1 was studied by electron microscopy and image processing. Two main projections can be distinguished: one exhibits 5-fold symmetry and has a diameter of 15 nm, the other is rectangular with sides of 15 and 9 nm. Subsequent image processing showed that the 5-fold view possesses mirror symmetry. The rectangular views can be divided into two separate classes, one of which has 2-fold rotational symmetry. It is concluded that methanol dehydrogenase is a decameric molecule, and a tentative model is presented. The estimated molecular weight is 430,000, based on a subunit molecular weight of 43,000. The enzyme contains one zinc and one to two magnesium ions per subunit. N-terminal amino acid sequence analysis revealed substantial similarity with alcohol dehydrogenases from Saccharomyces cerevisiae, Zymomonas mobilis, Clostridium acetobutylicum, and Escherichia coli, which contain iron or zinc but no magnesium. In view of the aberrant structural and kinetic properties, it is proposed to distinguish the enzyme from common alcohol dehydrogenases (EC 1.1.1.1) by using the name NAD-dependent methanol dehydrogenase.

Purification and characterization of an activator protein for methanol dehydrogenase from thermotolerant Bacillus spp.

All thermotolerant methanol-utilizing Bacillus spp. investigated by us possess a NAD-dependent methanol dehydrogenase (MDH) activity which is stimulated by a protein present in the soluble fraction of Bacillus sp. C1 cells. This activator protein was purified to homogeneity from Bacillus sp. C1 cells grown at a low dilution rate in a methanol-limited chemostat culture. The native activator protein (Mr = 50,000) is a dimer of Mr = 27,000 subunits. The N-terminal amino acid sequence revealed no significant similarity with any published sequences. Stimulation of MDH activity by the activator protein required the presence of Mg2+ ions. Plots of specific MDH activity versus activator protein concentration revealed Michaelis-Menten type kinetics. In the presence of activator protein, MDH displayed biphasic kinetics (v versus substrate concentration) toward C1-C4 primary alcohols and NAD. The data suggest that in the presence of activator protein plus Mg2+ ions, MDH possesses a high affinity active site for alcohols and NAD, in addition to an activator- and Mg2(+)-independent low affinity active site. The activation mechanism remains to be elucidated.

Methanol metabolism in thermotolerant methylotrophic Bacillus strains involving a novel catabolic NAD-dependent methanol dehydrogenase as a key enzyme.

The enzymology of methanol utilization in thermotolerant methylotrophic Bacillus strains was investigated. In all strains an immunologically related NAD-dependent methanol dehydrogenase was involved in the initial oxidation of methanol. In cells of Bacillus sp. C1 grown under methanol-limiting conditions this enzyme constituted a high percentage of total soluble protein. The methanol dehydrogenase from this organism was purified to homogeneity and characterized. In cell-free extracts the enzyme displayed biphasic kinetics towards methanol, with apparent Km values of 3.8 and 166 mM. Carbon assimilation was by way of the fructose-1,6-bisphosphate aldolase cleavage and transketolase/transaldolase rearrangement variant of the RuMP cycle of formaldehyde fixation. The key enzymes of the RuMP cycle, hexulose-6-phosphate synthase (HPS) and hexulose-6-phosphate isomerase (HPI), were present at very high levels of activity. Failure of whole cells to oxidize formate, and the absence of formaldehyde- and formate dehydrogenases indicated the operation of a non-linear oxidation sequence for formaldehyde via HPS. A comparison of the levels of methanol dehydrogenase and HPS in cells of Bacillus sp. C1 grown on methanol and glucose suggested that the synthesis of these enzymes is not under coordinate control.

Structure of the Pseudomonas putida alkBAC operon. Identification of transcription and translation products.

The structural genes of the Pseudomonas oleovorans alk (alkane utilization) system, which are localized on the alkBAC operon, were cloned as a 16.9-kilobase pair EcoRI fragment. We have measured the length and determined the position of the alkBAC operon on this fragment by electron microscopy of R-loops. Furthermore, the 7.3-kilobase pair long alkBAC operon was analyzed for translation products in Escherichia coli minicells. Using a spectrum of overlapping subclones, six different proteins were identified. Starting from the alkBAC promotor, these polypeptides had molecular masses of 41, 15, 49, 58, 59, and 20 kDa, respectively. The 41-kDa protein was identified as alkane hydroxylase by reaction with a specific antibody. The 15- and 49-kDa peptides are soluble components of the alkane hydroxylase complex. The 58-kDa protein is most likely involved in alkanol dehydrogenase activity.