Development of a multiple-antigen protein fusion vaccine candidate that confers protection against Bacillus anthracis and Yersinia pestis.

Bacillus anthracis and Yersinia pestis are zoonotic bacteria capable of causing severe and sometimes fatal infections in animals and humans. Although considered as diseases of antiquity in industrialized countries due to animal and public health improvements, they remain endemic in vast regions of the world disproportionally affecting the poor. These pathogens also remain a serious threat if deployed in biological warfare. A single vaccine capable of stimulating rapid protection against both pathogens would be an extremely advantageous public health tool. We produced multiple-antigen fusion proteins (MaF1 and MaF2) containing protective regions from B. anthracis protective antigen (PA) and lethal factor (LF), and from Y. pestis V antigen (LcrV) and fraction 1 (F1) capsule. The MaF2 sequence was also expressed from a plasmid construct (pDNA-MaF2). Immunogenicity and protective efficacy were investigated in mice following homologous and heterologous prime-boost immunization. Antibody responses were determined by ELISA and anthrax toxin neutralization assay. Vaccine efficacy was determined against lethal challenge with either anthrax toxin or Y. pestis. Both constructs elicited LcrV and LF-specific serum IgG, and MaF2 elicited toxin-neutralizing antibodies. Immunizations with MaF2 conferred 100% and 88% protection against Y. pestis and anthrax toxin, respectively. In contrast, pDNA-MaF2 conferred only 63% protection against Y. pestis and no protection against anthrax toxin challenge. pDNA-MaF2-prime MaF2-boost induced 75% protection against Y. pestis and 25% protection against anthrax toxin. Protection was increased by the molecular adjuvant CARDif. In conclusion, MaF2 is a promising multi-antigen vaccine candidate against anthrax and plague that warrants further investigation.

BclA and toxin antigens augment each other to protect NMRI mice from lethal Bacillus anthracis challenge.

While proving highly effective in controlling Anthrax in farm animals all over the world currently attenuated live anthrax vaccines employed in a veterinary context suffer from drawbacks such as residual virulence, short term protection, variation in quality and, most importantly, lack of efficacy if administered simultaneously with antibiotics. These limitations have stimulated the development of non-living component vaccines which induce a broad spectrum immune response capable of targeting both toxaemia (as in the case of PA based vaccines) and bacteraemia. To contribute to this several new approaches were tested in outbred NMRI mice for antibody titres and protectiveness. Plasmids encoding a recombinant toxin derived fusion peptide and a spore surface derived peptide were tested as DNA-vaccines in comparison to their protein counterparts utilising two adjuvant approaches and two DNA-vector backbones. The combination of two plasmids encoding LFD1PAD4-mIPS1 and TPA-BclAD1D3-LAMP1, when delivered by GeneGun, protected 90% of the animals against a lethal challenge with 25LD50 spores of the Ames strain of Bacillus anthracis. Single applications of either antigen component showed significantly lower protection rates, indicating the beneficial interaction between anti-spore and anti-toxin components for an acellular vaccine formulation.

Affinity binding of antibodies to supermacroporous cryogel adsorbents with immobilized protein A for removal of anthrax toxin protective antigen.

Polymeric cryogels are efficient carriers for the immobilization of biomolecules because of their unique macroporous structure, permeability, mechanical stability and different surface chemical functionalities. The aim of the study was to demonstrate the potential use of macroporous monolithic cryogels for biotoxin removal using anthrax toxin protective antigen (PA), the central cell-binding component of the anthrax exotoxins, and covalent immobilization of monoclonal antibodies. The affinity ligand (protein A) was chemically coupled to the reactive hydroxyl and epoxy-derivatized monolithic cryogels and the binding efficiencies of protein A, monoclonal antibodies to the cryogel column were determined. Our results show differences in the binding capacity of protein A as well as monoclonal antibodies to the cryogel adsorbents caused by ligand concentrations, physical properties and morphology of surface matrices. The cytotoxicity potential of the cryogels was determined by an in vitro viability assay using V79 lung fibroblast as a model cell and the results reveal that the cryogels are non-cytotoxic. Finally, the adsorptive capacities of PA from phosphate buffered saline (PBS) were evaluated towards a non-glycosylated, plant-derived human monoclonal antibody (PANG) and a glycosylated human monoclonal antibody (Valortim(®)), both of which were covalently attached via protein A immobilization. Optimal binding capacities of 108 and 117 mg/g of antibody to the adsorbent were observed for PANG attached poly(acrylamide-allyl glycidyl ether) [poly(AAm-AGE)] and Valortim(®) attached poly(AAm-AGE) cryogels, respectively, This indicated that glycosylation status of Valortim(®) antibody could significantly increase (8%) its binding capacity relative to the PANG antibody on poly(AAm-AGE)-protien-A column (p < 0.05). The amounts of PA which remained in the solution after passing PA spiked PBS through PANG or Valortim bound poly(AAm-AGE) cryogel were significantly (p < 0.05) decreased relative to the amount of PA remained in the solution after passing through unmodified as well as protein A modified poly(AAm-AGE) cryogel columns, indicates efficient PA removal from spiked PBS over 60 min of circulation. The high adsorption capacity towards anthrax toxin PA of the cryogel adsorbents indicated potential application of these materials for treatment of Bacillus anthracis infection.

Immunogenicity and efficacy of an anthrax/plague DNA fusion vaccine in a mouse model.

The efficacy of multi-agent DNA vaccines consisting of a truncated gene encoding Bacillus anthracis lethal factor (LFn) fused to either Yersinia pestis V antigen (V) or Y . pestis F1 was evaluated. A/J mice were immunized by gene gun and developed predominantly IgG1 responses that were fully protective against a lethal aerosolized B. anthracis spore challenge but required the presence of an additional DNA vaccine expressing anthrax protective antigen to boost survival against aerosolized Y. pestis.

A non-glycosylated, plant-produced human monoclonal antibody against anthrax protective antigen protects mice and non-human primates from B. anthracis spore challenge.

The health and economic burden of infectious diseases in general and bioterrorism in particular necessitate the development of medical countermeasures. One proven approach to reduce the disease burden and spread of pathogen is treatment with monoclonal antibodies (mAb). mAbs can prevent or reduce severity of the disease by variety of mechanisms, including neutralizing pathogen growth, limiting its spread from infected to adjacent cells, or by inhibiting biological activity of toxins, such as anthrax lethal toxin. Here, we report the production of glycosylated (pp-mAb (PA) ) and non-glycosylated (pp-mAb (PANG) ) versions of a plant-derived mAb directed against protective antigen (PA) of Bacillus anthracis in Nicotiana benthamiana plants using agroinfiltration. Both forms of the antibody were able to neutralize anthrax lethal toxin activity in vitro and protect mice against an intraperitoneal challenge with spores of B. anthracis Sterne strain. A single 180 µg intraperitoneal dose of pp-mAb (PA) or pp-mAb (PANG) provided 90% and 100% survival, respectively. When tested in non-human primates, pp-mAb (PANG) was demonstrated to be superior to pp-mAb (PA) in that it had a significantly longer terminal half-life and conferred 100% protection against a lethal dose of aerosolized anthrax spore challenge after a single 5 mg/kg intravenous dose compared to a 40% survival rate conferred by pp-mAb (PA) . This study demonstrates the potential of a plant-produced non-glycosylated antibody as a useful tool for the treatment of inhalation anthrax.

An anthrax subunit vaccine candidate based on protective regions of Bacillus anthracis protective antigen and lethal factor.

Studies have confirmed the key role of Bacillus anthracis protective antigen (PA) in the US and UK human anthrax vaccines. However, given the tripartite nature of the toxin, other components, including lethal factor (LF), are also likely to contribute to protection. We examined the antibody and T cell responses to PA and LF in human volunteers immunized with the UK anthrax vaccine (AVP). Individual LF domains were assessed for immunogenicity in mice when given alone or with PA. Based on the results obtained, a novel fusion protein comprising D1 of LF and the host cell-binding domain of PA (D4) was assessed for protective efficacy. Murine protection studies demonstrated that both full-length LF and D1 of LF conferred complete protection against a lethal intraperitoneal challenge with B. anthracis STI spores. Subsequent studies with the LFD1-PAD4 fusion protein showed a similar level of protection. LF is immunogenic in humans and is likely to contribute to the protection stimulated by AVP. A single vaccine comprising protective regions from LF and PA would simplify production and confer a broader spectrum of protection than that seen with PA alone.

Mucosal priming of newborn mice with S. Typhi Ty21a expressing anthrax protective antigen (PA) followed by parenteral PA-boost induces B and T cell-mediated immunity that protects against infection bypassing maternal antibodies.

The currently licensed anthrax vaccine has several limitations and its efficacy has been proven only in adults. Effective immunization of newborns and infants requires adequate stimulation of their immune system, which is competent but not fully activated. We explored the use of the licensed live attenuated S. Typhi vaccine strain Ty21a expressing Bacillus anthracis protective antigen [Ty21a(PA)] followed PA-alum as a strategy for immunizing the pediatric population. Newborn mice primed with a single dose of Ty21a(PA) exhibited high frequencies of mucosal IgA-secreting B cells and IFN-gamma-secreting T cells during the neonatal period, none of which was detected in newborns immunized with a single dose of PA-alum. Priming with Ty21a(PA) followed by PA-boost resulted in high levels of PA-specific IgG, toxin neutralizing and opsonophagocytic antibodies and increased frequency of bone marrow IgG plasma cells and memory B cells compared with repeated immunization with PA-alum alone. Robust B and T cell responses developed even in the presence of maternal antibodies. The prime-boost protected against systemic and respiratory infection. Mucosal priming with a safe and effective S. Typhi-based anthrax vaccine followed by PA-boost could serve as a practical and effective prophylactic approach to prevent anthrax early in life.

Human monoclonal antibodies against anthrax lethal factor and protective antigen act independently to protect against Bacillus anthracis infection and enhance endogenous immunity to anthrax.

The unpredictable nature of bioterrorism and the absence of real-time detection systems have highlighted the need for an efficient postexposure therapy for Bacillus anthracis infection. One approach is passive immunization through the administration of antibodies that mitigate the biological action of anthrax toxin. We isolated and characterized two protective fully human monoclonal antibodies with specificity for protective antigen (PA) and lethal factor (LF). These antibodies, designated IQNPA (anti-PA) and IQNLF (anti-LF), were developed as hybridomas from individuals immunized with licensed anthrax vaccine. The effective concentration of IQNPA that neutralized 50% of the toxin in anthrax toxin neutralization assays was 0.3 nM, while 0.1 nM IQNLF neutralized the same amount of toxin. When combined, the antibodies had additive neutralization efficacy. IQNPA binds to domain IV of PA containing the host cell receptor binding site, while IQNLF recognizes domain I containing the PA binding region in LF. A single 180-mug dose of either antibody given to A/J mice 2.5 h before challenge conferred 100% protection against a lethal intraperitoneal spore challenge with 24 50% lethal doses [LD50s] of B. anthracis Sterne and against rechallenge on day 20 with a more aggressive challenge dose of 41 LD50s. Mice treated with either antibody and infected with B. anthracis Sterne developed detectable murine anti-PA and anti-LF immunoglobulin G antibody responses by day 17 that were dependent on which antibody the mice had received. Based on these results, IQNPA and IQNLF act independently during prophylactic anthrax treatment and do not interfere with the establishment of endogenous immunity.

Population structure and evolution of the Bacillus cereus group.

Representative strains of the Bacillus cereus group of bacteria, including Bacillus anthracis (11 isolates), B. cereus (38 isolates), Bacillus mycoides (1 isolate), Bacillus thuringiensis (53 isolates from 17 serovars), and Bacillus weihenstephanensis (2 isolates) were assigned to 59 sequence types (STs) derived from the nucleotide sequences of seven alleles, glpF, gmk, ilvD, pta, pur, pycA, and tpi. Comparisons of the maximum likelihood (ML) tree of the concatenated sequences with individual gene trees showed more congruence than expected by chance, indicating a generally clonal structure to the population. The STs followed two major lines of descent. Clade 1 comprised B. anthracis strains, numerous B. cereus strains, and rare B. thuringiensis strains, while clade 2 included the majority of the B. thuringiensis strains together with some B. cereus strains. Other species were allocated to a third, heterogeneous clade. The ML trees and split decomposition analysis were used to assign STs to eight lineages within clades 1 and 2. These lineages were defined by bootstrap analysis and by a preponderance of fixed differences over shared polymorphisms among the STs. Lineages were named with reference to existing designations: Anthracis, Cereus I, Cereus II, Cereus III, Kurstaki, Sotto, Thuringiensis, and Tolworthi. Strains from some B. thuringiensis serovars were wholly or largely assigned to a single ST, for example, serovar aizawai isolates were assigned to ST-15, serovar kenyae isolates were assigned to ST-13, and serovar tolworthi isolates were assigned to ST-23, while other serovars, such as serovar canadensis, were genetically heterogeneous. We suggest a revision of the nomenclature in which the lineage and clone are recognized through name and ST designations in accordance with the clonal structure of the population.

The genome sequence of Bacillus anthracis Ames and comparison to closely related bacteria.

Bacillus anthracis is an endospore-forming bacterium that causes inhalational anthrax. Key virulence genes are found on plasmids (extra-chromosomal, circular, double-stranded DNA molecules) pXO1 (ref. 2) and pXO2 (ref. 3). To identify additional genes that might contribute to virulence, we analysed the complete sequence of the chromosome of B. anthracis Ames (about 5.23 megabases). We found several chromosomally encoded proteins that may contribute to pathogenicity--including haemolysins, phospholipases and iron acquisition functions--and identified numerous surface proteins that might be important targets for vaccines and drugs. Almost all these putative chromosomal virulence and surface proteins have homologues in Bacillus cereus, highlighting the similarity of B. anthracis to near-neighbours that are not associated with anthrax. By performing a comparative genome hybridization of 19 B. cereus and Bacillus thuringiensis strains against a B. anthracis DNA microarray, we confirmed the general similarity of chromosomal genes among this group of close relatives. However, we found that the gene sequences of pXO1 and pXO2 were more variable between strains, suggesting plasmid mobility in the group. The complete sequence of B. anthracis is a step towards a better understanding of anthrax pathogenesis.

Mucosal or parenteral administration of microsphere-associated Bacillus anthracis protective antigen protects against anthrax infection in mice.

Existing licensed anthrax vaccines are administered parenterally and require multiple doses to induce protective immunity. This requires trained personnel and is not the optimum route for stimulating a mucosal immune response. Microencapsulation of vaccine antigens offers a number of advantages over traditional vaccine formulations, including stability without refrigeration and the potential for utilizing less invasive routes of administration. Recombinant protective antigen (rPA), the dominant antigen for protection against anthrax infection, was encapsulated in poly-L-lactide 100-kDa microspheres. Alternatively, rPA was loosely attached to the surfaces of microspheres by lyophilization. All of the microspheric formulations were administered to A/J mice with a two-dose schedule by either the intramuscular route, the intranasal route, or a combination of these two routes, and immunogenicity and protective efficacy were assessed. An intramuscular priming immunization followed by either an intramuscular or intranasal boost gave optimum anti-rPA immunoglobulin G titers. Despite differences in rPA-specific antibody titers, all immunized mice survived an injected challenge consisting of 10(3) median lethal doses of Bacillus anthracis STI spores. Immunization with microencapsulated and microsphere-associated formulations of rPA also protected against aerosol challenge with 30 median lethal doses of STI spores. These results show that rPA can be encapsulated and surface bound to polymeric microspheres without impairing its immunogenicity and also that mucosal or parenteral administration of microspheric formulations of rPA efficiently protects mice against both injected and aerosol challenges with B. anthracis spores. Microspheric formulations of rPA could represent the next generation of anthrax vaccines, which could require fewer doses because they are more potent, are less reactogenic than currently available human anthrax vaccines, and could be self-administered without injection.

Optimization of the cell wall microenvironment allows increased production of recombinant Bacillus anthracis protective antigen from B. subtilis.

The stability of heterologous proteins secreted by gram-positive bacteria is greatly influenced by the microenvironment on the trans side of the cytoplasmic membrane, and secreted heterologous proteins are susceptible to rapid degradation by host cell proteases. In Bacillus subtilis, degradation occurs either as the proteins emerge from the presecretory translocase and prior to folding into their native conformation or after the native conformation has been reached. The former process generally involves membrane- and/or cell wall-bound proteases, while the latter involves proteases that are released into the culture medium. The identification and manipulation of factors that influence the folding of heterologous proteins has the potential to improve the yield of secreted heterologous proteins. Recombinant anthrax protective antigen (rPA) has been used as a model secreted heterologous protein because it is sensitive to proteolytic degradation both before and after folding into its native conformation. This paper describes the influence of the microenvironment on the trans side of the cytoplasmic membrane on the stability of rPA. Specifically, we have determined the influence of net cell wall charge and its modulation by the extent to which the anionic polymer teichoic acid is D-alanylated on the secretion and stability of rPA. The potential role of the dlt operon, responsible for D-alanylation, was investigated using a Bacillus subtilis strain encoding an inducible dlt operon. We show that, in the absence of D-alanylation, the yield of secreted rPA is increased 2.5-fold. The function of D-alanylation and the use of rPA as a model protein are evaluated with respect to the optimization of B. subtilis for the secretion of heterologous proteins.