An in vitro biological and anti-bacterial study on a sol-gel derived silver-incorporated bioglass system.

OBJECTIVES: The purpose of this study was to evaluate the in vitro antibacterial and biological activity of silver-incorporated bioactive glass system SiO2-CaO-P2O5-Ag2O (AgBG). The bacteriostatic and bactericidal properties of this new quaternary glass system along with the ternary sol-gel glass system SiO2-CaO-P2O5 (BG) have been studied using Escherichia coli as a test micro-organism. The AGBG system thus appears to be a promising material for dental applications, since similar effects might be produced on a film of bacteria and mucous that grows on the teeth. METHODS: The SiO2-CaO-P2O5-Ag2O and SiO2-CaO-P2O5 glass systems were synthesized by the sol-gel technique and characterized for their physicho-chemical properties. The antibacterial activity and biological properties were evaluated by determining the minimum inhibitory concentrations (MICs). Release of Ag+ into the culture medium was measured by inductively coupled plasma (ICP) analysis. RESULTS: The in vitro antibacterial action of the SiO2-CaO-P2O5-Ag2O was compared with that of its ternary counterpart glass system. The concentrations of Ag-bioglass, in the range of 0.02-0.20 mg of Ag-bioglass per millilitre of culture medium, were found to inhibit the growth of these bacteria. The Ag-bioglass not only acts bacteriostatically but it also elicited a rapid bactericidal action. A complete bactericidal effect was elicited in the early stages of the incubation at Ag-bioglass concentration of 20 mg/ml and the ternary glass system had no effect on bacterial growth or viability. The antibacterial action of Ag-bioglass was exclusively attributed to the leaching of Ag+ ions from the glass matrix. SIGNIFICANCE: One of the major advantages of incorporating silver ions into a gel glass system is that the porous glass matrix can allow for controlled sustained delivery of the antibacterial agent to dental material, used even under anaerobic conditions such as deep in the periodontal pocket. This glass system also provides long-term action required for systems which are constantly at risk of microbial contamination.

Sol gel derived SiO(2)-CaO-MgO-P(2)O(5) bioglass system--preparation and in vitro characterization.

The synthesis of SiO(2)-CaO-MgO-P(2)O(5) bioactive glass was carried out by the sol-gel method. Sol-gel derived bioglass material was crushed into powder to produce pellet disks by uniaxial pressing, followed by sintering at 900 degrees C. The biocompatibility evaluation of the formed glass was assessed through in vitro cell culture experiments and immersion studies in simulated body fluid (SBF) for different time intervals while monitoring the pH changes and the concentration of calcium and magnesium in the SBF medium. Scanning electron microscopy, X-ray energy dispersive spectroscopy, X-ray diffraction analysis, and FT-IR spectroscopy studies were conducted before and after contact of the material with SBF. At first, an amorphous calcium phosphate was formed; after 21 days this surface consisted of deposited crystalline spheres of apatite. The present investigation also revealed that the sol-gel derived quaternary bioglass system has the ability to support the growth of osteoblast-like cells in vitro and to promote osteoblast differentiation by stimulating the expression of major phenotypic markers.

Characterization and in vivo evaluation of sol-gel derived hydroxyapatite coatings on Ti6Al4V substrates.

Hydroxyapatite (HAP) based coatings on titanium alloy Ti6Al4V were attempted by sol-gel process. Precursor sol was dip-coated onto the substrates and the formation of HAP as the main phase was ensured after the sintering of coatings at 900 degrees C, as confirmed by the characterization studies involving XRD, FT-IR, Raman, and SEM-EDXS analysis. The biocompatibility of HAP-based coated titanium implants was tested by implantation studies in rabbit's tibia for a period of 8 weeks. Bone remodelling and inflammatory responses of the implants were studied during the implantation period. The better tissue-implant interaction of the coated implants with respect to the uncoated implants was observed after a defect healing period of 8 weeks. A coated implant with no evidence of rejection is a further advantage of the sol-gel derived HAP coating.

Interfacial reactions of glasses for biomedical application by scanning transmission electron microscopy and microanalysis.

Short-term physico-chemical reactions at the interface between bioactive glass particles and biological fluids are studied for three glasses with different bioactive properties; these glasses are in the SiO(2)-Na(2)O-CaO-P(2)O(5)-K(2)O-Al(2)O(3)-MgO system. Our aim is to show the difference between the mechanisms of their surface reactions. The relation between the composition and the bioactive properties of these glasses is also discussed. The elemental analysis is performed at the submicrometer scale by scanning transmission electron microscopy associated with energy-dispersive X-ray spectroscopy and electron energy loss spectroscopy. After different immersion times (ranging from 0 to 96 h) of bioactive glass particles in a simulated biological solution, results show the formation of different surface layers at the glass periphery in the case of two bioactive glasses (A9 and BVA). For the third glass (BVH) we do not observe any surface layer formation or any modification of the glass composition. For the two other glasses (A9 and BVA), we observe the presence of different layers: an already observed (Si, O, Al) rich layer at the periphery, a previously demonstrated thin (Si, O) layer formed on top of the (Si, O, Al) layer and a (Ca, P) layer. We determine the different steps of the mechanisms of the surface reactions, which appear to be similar in these glasses, and compare the physico-chemical reactions and kinetics using the different immersion times. The A9 glass permits the observation of all important steps of the surface reactions which lead to bioactivity. This study shows the important relationship between composition and bioactivity which can determine the medical applicability of the glass.

Behavior of human osteoblast-like cells in contact with electrodeposited calcium phosphate coatings.

Calcium-deficient hydroxyapatite (Ca-def-HAP) thin films were elaborated on Ti6Al4V substrates by electrodeposition. The coatings exhibit two different morphologies and crystallinities. Human osteoblast-like cells (MG-63) were cultured on the surfaces of these materials; the cell content and viability were evaluated up to 28 days. The scanning electron microscopy and biological investigations showed cells with a normal morphology, good proliferation, and viability from 7 to 21 days. But after 28 days, the number of live cells decreases in both cases; however, this decrease is less important in the case of calcium phosphate (CaP) coating surface when compared with the control (cell culture plastic). The cells cultured on Ca-def-HAP coating exhibit more cellular extensions and extracellular matrix. RT-PCR for type I collagen, alkaline phosphatase, and osteocalcin studies were also carried out, and was found that the CaP enhances gene expression of ALP and OC and thus the differentiation of osteoblast-like cells. Moreover, this study shows that the difference in the morphology of CaP coatings has no effect on the biocompatibility.

Abnormal ion content, hydration and granule expansion of the secretory granules from cystic fibrosis airway glandular cells.

The absence or decreased expression of cystic fibrosis transmembrane conductance regulator (CFTR) induces increased Na(+) absorption and hyperabsorption of the airway surface liquid (ASL) resulting in a dehydrated and hyperviscous ASL. Although the implication of abnormal airway submucosal gland function has been suggested, the ion and water content in the Cystic Fibrosis (CF) glandular secretory granules, before exocytosis, is unknown. We analyzed, in non-CF and CF human airway glandular cell lines (MM-39 and KM4, respectively), the ion content in the secretory granules by electron probe X-ray microanalysis and the water content by quantitative dark field imaging on freeze-dried cryosections. We demonstrated that the ion content (Na(+), Mg(2+), P, S and Cl(-)) is significantly higher and the water content significantly lower in secretory granules from the CF cell line compared to the non-CF cell line. Using videomicroscopy, we observed that the secretory granule expansion was deficient in CF glandular cells. Transfection of CF cells with CFTR cDNA or inhibition of non-CF cells with CFTR(inh)-172, respectively restored or decreased the water content and granule expansion, in parallel with changes in ion content. We hypothesize that the decreased water and increased ion content in glandular secretory granules may contribute to the dehydration and increased viscosity of the ASL in CF.

Preparation and characterization of an electrodeposited calcium phosphate coating associated with a calcium alginate matrix.

A new way of optimizing osteoconduction of biomaterials is to bring to them biological properties. In this work, we associated a novel release system with an electrodeposited calcium phosphate (CaP) coated titanium alloy Ti6Al4V. The characterization of this material was performed by means of light microscopy, scanning electron microscopy (SEM), scanning transmission electron microscopy (STEM) and X-ray energy dispersive spectroscopy (EDXS). The electrodeposited CaP coating was a tricalcium phosphate, and the release system was composed of microcapsules entrapped in an alginate film. We observed that the alginate matrix had a close contact with the coating. An intermediate layer containing calcium and phosphorus appeared at the interface between the alginate matrix and the CaP coating. These results allowed us to conclude that the association of two techniques, i.e. electrodeposition followed by deposition of a calcium alginate matrix, led to the elaboration of a new biomaterial.

Implementation of subcellular water mapping by electron energy loss spectroscopy in a medium-voltage scanning transmission electron microscope.

The water concentration in biological cells plays a predominant role in cellular life. Using electron energy loss spectroscopy, the feasibility to measure the water content in cells has already been demonstrated. In this paper, we present an upgrade of water measurement in hydrated cryosections by spectrum imaging mode in a medium-voltage scanning transmission electron microscope. The electron energy loss spectra are recorded in spectrum imaging mode in a 2(n)x2(n) pixels array. Each spectrum is processed in order to determine the water mass content in the corresponding pixel. Then a parametric image is obtained in which grey levels are related to water concentration. In this image, it is possible to recognize the different subcellular compartments. By averaging the water concentration over the relevant pixels, we can determine the water mass content in the concerned subcellular compartment. As an example, we present water mass content measurement at subcellular level in rat hepatocytes.

Influence of physicochemical reactions of bioactive glass on the behavior and activity of human osteoblasts in vitro.

Bioactive glasses are characterized by a bond to bone with a hydroxyl carbonate apatite layer. They enhance bone tissue formation and for this purpose are used in orthopedic surgery and in dental implantology. In the current work, we studied the biological response of human osteoblasts with a bioactive glass. This bioactive glass is based on 50% Si0(2), 20% Na(2)O, 16% CaO, 6% P(2)O(5), 5% K(2)0, 2% Al(2)O(3) and 1% MgO and designated A9. Cracks and irregularities were observed on the material surface when it was immersed in the culture medium. In addition, energy dispersive X-ray analyses highlighted a selective release of the elements at the surface of the bioactive glass, such as Na(+) and K(+) ions, released from the first day, contrary to the Si, Al, Ca, P, and Mg elements, which were released more slowly. Cell proliferation kinetics, total protein synthesis, and DNA content of the osteoblasts in contact with bioactive glass were similar to control cells. The morphological studies by light and scanning electron microscopy revealed an increasing cellular density in culture with bioactive glass without contact inhibition. The immunohistochemical studies highlighted the expression of types I, III, and V collagens by osteoblasts cultured in the presence of bioactive glass. The pH measurement of the culture medium in the presence of bioactive glass demonstrated a slight alkalinization. We thus conclude that human osteoblasts preserve their properties in the presence of bioactive glass (A9).

Subcellular localization of boron in cultured melanoma cells by electron energy-loss spectroscopy of freeze-dried cryosections.

Boron neutron capture therapy (BNCT) is based on the ability of the non-radioactive isotope 10B to capture thermal neutrons and to disintegrate instantaneously. This reaction opens a way to selectively destroy tumour cells after specific uptake of 10B. In this paper, a method based on electron energy-loss spectroscopy is presented for detecting and quantifying boron in freeze-dried cryosections of human melanoma cells. A practical detection limit of around 6 mmol kg-1 in 0.1- micro m2 areas is estimated using specimens prepared from standard boron solutions. Preliminary results of boron mapping in the spectrum-imaging acquisition mode reveal boron penetration and probably spot-like accumulation within melanoma cells when exposed to culture medium containing sodium borocaptate.

Micrometer level structural and chemical evaluation of electrodeposited calcium phosphate coatings on TA6V substrate by STEM-EDXS.

Hydroxyapatite (HA) coatings on titanium alloy substrates Ti6Al4V have been prepared in our laboratory by electrodeposition and hydrothermal synthesis. In this paper, the morphology, crystal size, porosity and Ca/P atomic ratio are investigated using scanning electron microscopy (SEM), scanning transmission electron microscopy (STEM), Raman microspectroscopy and X-ray energy dispersive spectroscopy (EDXS). The results obtained show that after being hydrothermally treated and calcined at high temperature, the electrodeposited brushite coating is converted into a stoichiometric hydroxyapatite having a crystal size which changes considerably from the surface to the substrate alloy. In addition, variation of the surface coating porosity as a function of the electrolyte temperature has also been carried out.

X-ray microanalysis of airway surface liquid collected in cystic fibrosis mice.

The airway surface liquid (ASL) that lines the airway surface epithelium plays a major role in airway antibacterial defense and mucociliary transport efficiency, two key factors in cystic fibrosis (CF) disease. A major difficulty is to collect ASL in native conditions without stimulation or alteration of the underlying airway epithelium. Using a cryoprobe specifically adapted to collect native ASL from the tracheal mouse surface, we analyzed by X-ray microanalysis the complete ASL and plasma ion content in Cftr(tm1Hgu)/Cftr(tm1Hgu) mice compared with that in control littermates. ASL ion content from eight Cftr(tm1Hgu)/Cftr(tm1Hgu) mice and eight control littermates did not appear significantly different. The mean (+/-SE) concentrations were 2,352 +/- 367 and 2,058 +/- 401 mmol/kg dry weight for Na, 1,659 +/- 272 and 1,448 +/- 281 mmol/kg dry weight for Cl, 357 +/- 57 and 337 +/- 38 mmol/kg dry weight for S, 1,066 +/- 220 and 787 +/- 182 mmol/kg dry weight for K, 400 +/- 82 and 301 +/- 58 mmol/kg dry weight for Ca, 105 +/- 31 and 105 +/- 20 mmol/kg dry weight for Mg, 33 +/- 15 and 29 +/- 9 mmol/kg dry weight for P in non-CF and CF mice, respectively. This cryotechnique appears to be a promising technique for analyzing the complete elemental composition of native ASL in CF and non-CF tissues.

Effect of hydroxyapatite sintering temperature on intracellular ionic concentrations of monocytes: a TEM-cryo-X-ray microanalysis study.

Hydroxyapatite used as bone replacement can lead to particle release in the implantation site. These particles interact with monocytes, which are the first immune cells to colonize the implant and an inflammatory site. Thanks to cryo-X-ray microanalysis, we can observe cells in a state close to the physiological one and we have access to diffusible ions. We paid particular attention to the potassium-to-sodium ratio, which is one of the best viability criteria. We used this method to study the interaction between three hydroxyapatite particles treated at three different temperatures (not treated, treated at 600 degrees C and 1180 degrees C), and monocytes. In the culture condition, the hydroxyapatite treated at 1180 degrees C underwent the least dissolution. We demonstrate that monocytes were altered by the three hydroxyapatite particles. The hydroxyapatite particules treated at 600 degrees C were found to be more toxic.

X-ray microanalysis of organic thin sections in TEM using an UTW Si(Li) detector: comparison of quantification methods.

We compared Hall's peak to continuum ratio method with a peak ratio method in order to quantify light elements (C, N, and O) in organic specimens as a model for biological thin sections. X-ray spectra were recorded by an energy dispersive X-ray spectrometer equipped with an ultra thin window detector. Spectra were processed by means of a top-hat filter adapted to peak full-width half maximum. The peak intensities were measured by multiple least square fitting to reference spectra. For most elements of biological interest, theoretical and experimental k-factors were determined. Absorption correction was found to be important for quantitation of carbon, nitrogen, and oxygen. Boron was efficiently detected; however, quantitative analysis was not possible. We conclude from our experiments that the peak ratio method is more suitable for quantitation of elemental concentrations in biological thin sections than the peak to continuum method.

Dissolution Kinetics, Selective Leaching, and Interfacial Reactions of a Bioglass Coating Enriched in Alumina.

Bioglass coatings are interesting for developing a direct bond between prostheses and bone. But the high solubility of these materials limits their application. The addition of alumina can be used to control their solubility, but may inhibit the bonding mechanisms. In this paper, we study a bioglass in the SiO(2)-Na(2)O-CaO-P(2)O(5)-K(2)O-Al(2)O(3)-MgO system. After delays of implantation from 2 to 12 months, the bioglass/bone interface is characterized by energy-dispersive X-ray spectroscopy coupled with scanning transmission electron microscopy. Bioglass dissolution can be decomposed into three steps with selective leaching. Results show that, at 2 months after implantation, the bioglass is composed of Al, Si, Ca, and P. Alumina addition increases the coating stability without inhibiting the bonding process. Complex physicochemical reactions take place at the bioglass periphery. The coating bonds to bone through a Ca-P layer on top of a pure Si-rich layer. These phenomena are associated with bioactivity properties, which occur for up to 6 months. After 12 months, the bioglass is composed of silicon. Copyright 2001 Academic Press.

Integration of dense HA rods into cortical bone.

HA ceramics are daily used in human surgery for bone healing partly due to their ability to integrate into bone. They are generally used under a macroporous form. The behaviour of dense HA after implantation is not so well known. We implanted within cortical sheep femurs dense pure HA-ceramics cylinders for periods from 2 weeks to 18 months. The samples were then sectioned and examined using back-scattered and secondary SEM and the interface was analysed using EDS. Histomorphometry measurement was also performed using an image analysis device coupled to a light microscope. It appeared that the cylinders were in direct contact with immature bone after three weeks. The bone maturated within three months. The implant surface showed moderate signs of resorption and some grains were released from the surface. The resorption zone was only a few microm thick after 18 months. The bulk ceramic contained default zones of increased porosity. They can constitute fragile zone when located close to the surface in which the resorption rate is increased. We conclude that dense pure HA is poorly degraded when implanted in cortical bone. Degradation depends on the defaults found on the ceramic structure and the remodelling of bone surrounding the material.

Tachyzoite calcium changes during cell invasion by Toxoplasma gondii.

The invasion of host cells by the obligate intracellular protozoan parasite Toxoplasma gondii is calcium dependent. We have identified two calcium storage areas in tachyzoites, the endoplasmic reticulum and vesicles that contain high concentrations of calcium as amorphous calcium phosphate precipitates. Our data indicate that these vesicles slowly lose their calcium during the intracellular development of the tachyzoite as their nucleus phosphorus content increases. We found fluctuations in the sulfur content of the tachyzoite during invasion following the exocytosis of protein from the secretory organelles, with a loss of sodium and chlorine, and the uptake of potassium from the host cell cytoplasm. We demonstrated that penetration of the tachyzoite into the host cell was accompanied by increases in the concentrations of phosphorus and sulfur in the host cell nucleus, probably due to increased transcription. The cytosol sodium concentrations decreased, while the potassium content increased. Thus, the subcellular element distribution of tachyzoites and host cells changes during invasion and intracellular growth of the parasites. In addition, our results indicate that tachyzoite calcium might be involved in the egress of the parasite from the host cell.

Ion composition and rheology of airway liquid from cystic fibrosis fetal tracheal xenografts.

The composition of airway surface liquid (ASL) is partly determined by active ion and water transport through the respiratory epithelium. It is usually stated that in cystic fibrosis (CF), CF transmembrane conductance regulator protein abnormality results in imbalanced ion composition and dehydration of ASL, leading to abnormal rheologic and transport properties. To explore the relationship between ion composition, water content, and viscosity of airway liquid (AL), we used a human xenograft model of fetal airways developed in severe combined immunodeficiency (SCID) mice. Six non-CF and six CF portions of fetal tracheas were engrafted subcutaneously in the flanks of SCID mice raised in pathogen-free conditions. AL accumulated in the closed cylindric grafts was harvested 9 to 17 wk after implantation. At the time of AL sampling, all tracheal grafts displayed well-differentiated pseudostratified surface epithelium and submucosal glands. The viscosity of AL was measured using a controlled-stress rheometer. The ion composition of AL was quantified by X-ray microanalysis. No significant difference was observed for AL viscosity between non-CF (0.6 +/- 0.5 Pa. s) and CF (0.2 +/- 0.1 Pa. s) samples. In AL from non-CF and CF samples, the ion concentrations were Na: 63.9 +/- 7.6, 79.7 +/- 11.6; Cl: 64.9 +/- 13.2, 82.6 +/- 15.7; Mg: 1.9 +/- 0.3, 2.2 +/- 0.4; S: 4.9 +/- 1. 3, 4.8 +/- 0.5; K: 2.4 +/- 0.5, 3.2 +/- 1.6; and Ca: 1.2 +/- 0.3, 2.6 +/- 0.8 mmol/liter, respectively. The ion composition of AL from CF versus non-CF xenografts was not significantly different. These results suggest that prior to inflammation and infection, the viscosity and ion composition of the fetal AL do not differ in CF and non-CF.

X-ray microanalysis of native airway surface liquid collected by cryotechnique.

The airway surface liquid (ASL) that lines the surface epithelium of the tracheobronchial tree is of vital importance to the airway defence against microbial invasion and damage due to environmental factors. Little is known about the ASL collected in situ in native conditions, owing to difficulties in collecting ASL without causing damage to the airway mucosa. We have developed a method to collect and analyse the elemental composition of tracheal ASL in pathogen-free mice. A specially designed cryoprobe, adapted to the internal curvature of the mouse trachea, was used to collect the native ASL from the tracheal surface. The complete ASL elemental composition including [Na] = 5.5 +/- 0.3, [Cl] = 1.3 +/- 0.3, [K] = 1.1 +/- 0.2, [Ca] = 1.2 +/- 0.3, [P] = 1.5 +/- 0.8, [S] = 1.7 +/- 0.4 and [Mg] = 1.3 +/- 0.4 mmol L-1 was determined by X-ray micro-analysis. We demonstrate here that the technique that we used for ASL collection maintained perfectly the airway epithelial integrity and functionality.

X-ray microanalysis of native airway surface liquid collected by cryotechnique.

The airway surface liquid (ASL) that lines the surface epithelium of the tracheobronchial tree is of vital importance to the airway defence against microbial invasion and damage due to environmental factors. Little is known about the ASL collected in situ in native conditions, owing to difficulties in collecting ASL without causing damage to the airway mucosa. We have developed a method to collect and analyse the elemental composition of tracheal ASL in pathogen-free mice. A specially designed cryoprobe, adapted to the internal curvature of the mouse trachea, was used to collect the native ASL from the tracheal surface. The complete ASL elemental composition including [Na] = 5.5 +/- 0.3, [Cl] = 1.3 +/- 0.3, [K] = 1.1 +/- 0.2, [Ca] = 1.2 +/- 0.3, [P] = 1.5 +/- 0.8, [S] = 1.7 +/- 0.4 and [Mg] = 1.3 +/- 0.4 mmol L-1 was determined by X-ray micro analysis. We demonstrate here that the technique that we used for ASL collection maintained perfectly the airway epithelial integrity and functionality.