Ultra-diluted complex additive in the diet reveals benefits in the intestinal tract of nursery-phase piglets.

This study aimed to assess an ultra-diluted (UD) complex, as a replacement for an antimicrobial growth promoter in diets, on growth performance, intestinal health, and inflammatory response of nursery piglets. The experiment lasted 37 days and involved 126 animals weaned at 21 ± 1.3 d, with an initial body weight of 5.62 ± 1.16 kg. Piglets were assigned to six dietary treatments in a randomized block design with seven replicates and three piglets per pen as experimental unit. The treatments were: positive control (PC)- basal diet + 120 mg/kg of chlorohydroxyquinoline; negative control (NC)- basal diet without additives; and NC containing 4.5; 6.0; 7.5 or 9.0 kg of UD additive/ton diet. Performance data were calculated, and daily diarrhea was observed. Blood samples were collected for hematological analysis. At the end of the experiment, one animal per pen was slaughtered for organ weighing, pH, and the collection of intestinal samples for histopathology. Feces and cecal contents were collected for microbiological and antibiogram analyses. There was no difference in the performance between the treatments. Throughout the study, UD levels were equal to those of PC for diarrhea occurrence. Higher levels of UD complex led to higher total leukocyte counts. The 4.5 treatment showed a reduction in total and thermotolerant Enterobacteriaceae populations in piglet feces and an increase in lactic acid bacteria compared to PC. All treatments resulted in fewer duodenal histopathological alterations than those in the NC group. The use of UD additives, especially at 4.5 kg/ton, is a good alternative to chlorohydroxyquinoline in piglet diets.

Use of homeopathic products in pigs feed improves the percentage, quality and marbling of meat.

Studies and innovations on alternative feed additives, especially on homeopathic remedies have been highlighted in order to replace or reduce the use of antibiotics in pig production. This paper aimed to assess the addition of homeopathic products in pig diet and their effects on the growth performance, serum metabolites, nutrient and energy digestibility, carcass traits and meat quality. A total of 60 immunocastrated male pigs, weighing on average 30.91 ± 0.95 kg, were distributed in two treatments, 10 replicates and three animals/experimental unit. There was no effect (P≥0.05) of treatment on the growth performance and serum metabolites. The percentage of acid-insoluble ash recovered in the diet was greater (P≤0.01) in diets containing homeopathic products. The apparent digestible energy of diets containing homeopathic products was reduced (P≤0.01) in the growing phase and reduced (P≤0.01) the apparent digestibility coefficients of dry matter, crude protein, soluble neutral and acid detergent fibers, and gross energy in the growing and finishing phases. Pig that received diets with homeopathic products had higher (P≤0.05) amount of meat, percentage of meat and marbling. The use of homeopathic products in diets improves the percentage and quality of meat, as well as the marbling of the pig carcass, maintaining the performance.

ß-mannanase supplementation in diets reduced in 85 kcal metabolizable energy/kg containing xylanase-phytase improves gain to feed ratio, nutrient usage, and backfat thickness in finisher pigs.

This study aimed to assess the effects of ß-mannanase supplementation in metabolizable energy (ME)-reduced diets containing xylanase-phytase on performance, fecal score, blood biochemical and immunological profile, apparent total tract digestibility (ATTD), digesta passage rate, fecal microbiome, carcass traits and meat quality in finisher pigs (n = 40 entire male hybrid, 26.0 ± 0.9 kg) randomly assigned to 1 of 4 dietary treatments: a control diet containing isolated phytase and xylanase valued at 40 kcal of ME/kg (CD0), CD0 + ß-mannanase (0.3 g/kg valued at 30 kcal of ME/kg) (CD70), CD0 + ß-mannanase (0.3 g/kg valued at 45 kcal of ME/kg) (CD85), and CD0 + ß-mannanase (0.3 g/kg valued at 60 kcal of ME/kg) (CD100), with 10 pen replicates. Pigs fed CD0 diet showed (P = 0.002) greater ADFI. However, pigs fed CD0 diet showed (P = 0.009) lower G:F than those provided CD70 or CD85 diets. A greater (P < 0.001) superoxide dismutase concentration was observed in pigs fed CD70 diet. Pigs fed CD85 diet showed (P = 0.002) greater digestible protein than pigs fed CD0 or CD100 diets. Pigs fed CD70 diet showed an increase of 11.3% in digestible protein than those fed CD0 diet. In addition, greater (P < 0.001) digestible energy was observed in pigs fed CD85 diet. Pigs fed CD0 or CD100 diets showed greater (P < 0.05) Firmicutes:Bacteroidota ratio than those fed CD85 diet. The Muribaculaceae was more abundant (P = 0.030) in pigs fed CD70 diet than in those fed CD0 diet. The Prevotella was more abundant (P = 0.045) in pigs fed CD85 diet than in those fed CD100 diet. In conclusion, ß-mannanase supplementation in diets containing xylanase-phytase allows reducing 85 kcal of ME/kg because it improves gain to feed ratio, energy and protein usage, and backfat thickness without metabolic and intestinal ecosystem disorders in finisher pigs.

Determinant production factors to the in vitro organic matter digestibility and protein oxidation of poultry by-product meal.

The quality of poultry by-product meal (PBM) is not standardized in the industry. Several factors are detrimental to PBM and compromise its nutritional value and shelf life. Therefore, this study was conducted to determine the main PBM production factors that directly affect its in vitro organic matter digestibility (IVDOM) and protein oxidation (POX). Data on the processing of PBM samples (n = 100) were recorded in a rendering plant. Two types of PBM were used: 1) Low ash (LA, n = 66) with mineral matter (MM) content of 11% and 2) High ash (HA, n = 34) with MM above 11%. Processing traits and chemical composition of PBM were considered independent variables. The IVDOM and POX were determined in each sample and considered dependent variables. Data on independent variables were submitted to factorial and principal components (PC) analyses. In vitro organic matter digestibility data were clustered (P = 0.001) in low (778.92 g/kg), average (822.85 g/kg), and high (890.06 g/kg). The best arrangement was composed of six independent variables distributed in two PC, which explained 82.10% of the total variation. The ash concentration, oil to raw material ratio, collagen, and crude protein comprised PC1 with greater relevance and explained 58.46% of the total variance. The PC2 was composed of the processing time and temperature and explained 23.64% of the total variance. Protein oxidation data were clustered (P < 0.001) in low (265.19 nmol/mg CP), average (393.07 nmol/mg CP), and high (524.40 nmol/mg CP). Based on our results, the composition of the raw material from the slaughterhouse holds most of the information on PBM composition and digestibility. Developing improvements in the slaughtering or in the screening of the raw material that will be used by the rendering process is important to obtain a more nutritionally standardized ingredient.

Blend of essential oils can reduce diarrheal disorders and improve liver antioxidant status in weaning piglets.

OBJECTIVE: This study was to assess the effects of different doses of an essential oil blend (EOB) on growth performance, diarrhea occurrence (DO), hematological and blood biochemical profile, intestinal morphometry, morphology and microbiology, relative weight and length of organs, digestive content pH, and liver antioxidant status in weaning piglets. METHODS: A total of 135 barrows (7.09±0.29 kg body weight) were allotted randomly in a randomized complete block design based on body weight with nine replications and three animals per pen. Dietary treatments were a negative control (NC): basal diet; positive control (PC): NC plus 125 mg performance-enhancing antibiotic (enramycin 8%)/kg diet; NC plus 100 mg EOB/kg diet (EO100); NC plus 200 mg EOB/kg diet (EO200); and NC plus 400 mg EOB/kg diet (EO400). Diarrhea occurrence was monitored daily, and performance at the end of each phase. RESULTS: Gain to feed ratio was greater (p<0.05) in starter II pigs fed EO400 and EO200 than in those fed EO100. Pigs fed EO400 had lower (p<0.05) DO than those fed NC and EO100 in the total period. Pre-starter II pigs fed NC had (p<0.05) lower serum total protein and plasma protein than pigs fed PC. Pigs fed EO100 showed smaller (p<0.05) mean corpuscular volume (MCV) than pigs fed EO400. Starter II pigs fed EO400 had (p<0.05) greater MCV and lower mean corpuscular hemoglobin and erythrocytes than those fed EO100. There was a greater concentration (p<0.05) of band cells for PC, similar to EO400 and EO200. Performance-enhancing antibiotic and EOB to diets increased (p<0.05) liver superoxide dismutase activity. CONCLUSION: Adding 200 and 400 mg EOB/kg diet decreased DO and was advantageous to hematological and blood biochemical profile and liver antioxidant status without being detrimental to growth performance and gastrointestinal health in nursery pigs.

Characterization of the variations in the industrial processing and nutritional variables of poultry by-product meal.

The study aimed to measure variations in industrial process and nutritional variables of poultry by-product meal (PBM) in rendering plants from batch cookers. A total of 200 samples of low ash PBM with mineral matter (MM) content of 11% (LA, n = 104) or high ash with MM above 11% (HA, n = 96) were collected from 5 industrial processing plants. The highest coefficients of variation in chemical composition were for MM (LA - 19.70%; HA - 19.59%), ether extract (LA - 20.72%; HA - 14.86%), collagen (LA - 21.16%; HA - 30.00%) and water activity (LA - 24.54%; HA - 25.89%). However, the crude protein (LA - 5.07%; HA - 7.39%), dry matter (LA - 1.75%; HA - 2.90%) and organic matter digestibility (LA - 4.81%; HA - 6.78%) were lower. The variability of the data related to the process of PBM was: maximum process temperature (LA - 3.91%; HA - 3.56%), average process temperature (LA - 3.73%; HA - 4.71%), and processing time (LA - 27.37%; HA - 37.59%). This study evidenced that the corrective measures by limiting the amount of bones in the raw material, optimizing the pressing step for the poultry fat extraction, and also controlling the processing time of PBM may favor the production of more standardized PBM in terms of chemical composition and quality.

Effect of endoparasites occurrence in sows from intensive production system.

The goal of this study was to assess the effect of farm size (FS) and farrowing order (FO) on the occurrence of endoparasites eggs in commercial sows housed in maternity and gestation areas during the period from May to July 2014. Forty-three piglet production units were classified by FS: small (100 to 250 sows), medium (251 to 510 sows), large (511 to 1,000 sows) and very large (more than 1,000 sows). Sows were classified by FO: up to two, three to five or more than five parturitions. Faecal samples were processed using the simple flotation technique in a hypersaturated salt solution (30-35% NaCl). The results revealed that the overall prevalence of gastrointestinal endoparasites obtained in this study was 12.47%, in that 4.64% were positive for Ascaris suum, 0.56% for Trichuris suis and 8.27% for coccidia oocysts. The prevalence of endoparasites obtained for small and medium size farm, and for large and very large farm was 34.58% and 15.52%, respectively. In conclusion, the study shows that more than half of the farms were positive for A. suum and coccidia oocysts, but mainly for younger females. In general, sows with up to two parturitions and small farms showed a higher endoparasites percentage.

Effect of endoparasites occurrence in sows from intensive production system / Efeito da ocorrência de endoparasitas em matrizes suínas de sistema de produção intensivo

Abstract The goal of this study was to assess the effect of farm size (FS) and farrowing order (FO) on the occurrence of endoparasites eggs in commercial sows housed in maternity and gestation areas during the period from May to July 2014. Forty-three piglet production units were classified by FS: small (100 to 250 sows), medium (251 to 510 sows), large (511 to 1,000 sows) and very large (more than 1,000 sows). Sows were classified by FO: up to two, three to five or more than five parturitions. Faecal samples were processed using the simple flotation technique in a hypersaturated salt solution (30-35% NaCl). The results revealed that the overall prevalence of gastrointestinal endoparasites obtained in this study was 12.47%, in that 4.64% were positive for Ascaris suum, 0.56% for Trichuris suis and 8.27% for coccidia oocysts. The prevalence of endoparasites obtained for small and medium size farm, and for large and very large farm was 34.58% and 15.52%, respectively. In conclusion, the study shows that more than half of the farms were positive for A. suum and coccidia oocysts, but mainly for younger females. In general, sows with up to two parturitions and small farms showed a higher endoparasites percentage.

Resumo O objetivo deste estudo foi o de avaliar o efeito de tamanho de granja (TG) e a ordem de parição (OP) sobre a ocorrência de ovos de endoparasitas em matrizes suínas comerciais alojadas na maternidade e gestação durante o período de maio a julho de 2014. Quarenta e três unidades produtoras de leitões foram classificadas por TG: pequena (100 a 250 porcas), média (251 a 510 porcas), grande (511 a 1.000 porcas) e muito grande (mais de 1.000 porcas). As porcas foram classificadas por OP: até dois, três a cinco e mais que cinco partos. As amostras fecais foram processadas usando a técnica de flotação em solução salina hipersaturada a 30-35%. Os resultados revelaram que a prevalência global de endoparasitas gastrointestinais obtidos neste estudo foi de 13,59%, em que 4,64% foram positivas para Ascaris suum, 0,56% para Trichuris suis e 8,27% para oocistos de coccídeos. A prevalência de endoparasitas obtidos para fazendas de pequeno e médio porte, e para fazendas grandes e muito grandes foi de 34,58% e 15,52%, respectivamente. Em conclusão, o estudo mostra que mais da metade das fazendas foram positivas para A. suum e oocistos de coccídeos, mas principalmente para as fêmeas mais jovens. Em geral, as porcas com até dois partos e pequenas propriedades mostraram uma porcentagem maior de endoparasitas.

Partial replacement of soybean meal with different protein sources in piglet feed during the nursery phase.

OBJECTIVE: Evaluate the partial replacement of soybean meal with different protein sources in piglet feed during the nursery phase in terms of digestibility of feed, nitrogen balance, growth performance and blood parameters. METHODS: Experiment I involved 24 crossbred entire male pigs with an initial body weight of 18.28 ± 0.7 kg, and used a randomized complete block design consisting of three treatments (Fish Meal - FM, Soybean Protein Concentrate - SPC, and Soybean Meal - SM) and eight replicates, with one pig per experimental unit. Experiment II involved 1843 crossbred male and female pigs with an initial body weight of 6.79 ± 0.90 kg, and was based on a completely randomized design with a 2 × 3 factorial arrangement (two sexes and three protein sources) and 13 replicates. RESULTS: The results of Experiment I indicate a significant effect (p &lt;0.05) of the treatment on digestible protein (FM: 17.84%; SPC: 16.72% and SM: 18.13%) and on total nitrogen excretion (TNE, g/kg BW0.75/day) in which pigs fed with SM-based feed had TNE values that were 5.36% and 3.72% higher than SPC and FM, respectively. In the Experiment II, there was difference (p &lt;0.01) between sexes in the starter phase and total period in daily feed intake (DFI) values, which were higher in females, and between the protein sources in DFI, final weight and daily weight gain, which were higher in piglets fed with SPC. For urea in both phases and glucose in the pre-starter II phase, there was a difference (p &lt;0.05) between protein sources and between sexes, in starter phase in urea levels (females: 57.11 mg/dL and males: 50.60 mg/dL). CONCLUSION: The use of feed only at basis of SM influences larger TNE (g/kg BW0.75/day), promotes a reduction in the growth performance of piglets and increases plasma urea levels in pre-starter II.

Casca de café melosa ensilada na alimentação de suínos na fase inicial / Sticky coffee hull silage on pig starter feeding

Dois experimentos foram conduzidos, objetivando determinar o valor nutricional e verificar o desempenho de leitões na fase de inicial, alimentados com rações contendo casca de café melosa ensilada (CCEn). Os alimentos estudados foram casca de café melosa (CCM) e CCEn. No Experimento I, foi conduzido um ensaio de digestibilidade utilizando 15 suínos mestiços, machos castrados, distribuídos em delineamento inteiramente casualizado. A CCM foi moída em peneira de diâmetro de 4 mm e ensilada com a adição de 30 por cento de água e inoculante enzimo-bacteriano. De forma geral, o processo de ensilagem não melhorou a digestibilidade da casca de café melosa. No Experimento II, foram utilizados 60 leitões (15,52 ± 2,19 a 32,52 ± 3,51 kg), distribuídos em delineamento inteiramente casualizado, com cinco tratamentos (0, 4, 8, 12 e 16 por cento de CCEn), seis repetições e dois animais por unidade experimental. Não foi verificado efeito da inclusão de CCEn sobre o consumo diário de ração, ganho diário de peso, conversão alimentar e nitrogênio da uréia plasmática. Conclui-se que a casca de café melosa ensilada apresenta bom valor nutricional e pode ser utilizada em até 16 por cento na alimentação de leitões na fase inicial (15-30 kg), sem prejuízo no desempenho, entretanto deve-se avaliar a viabilidade econômica em função da relação de preços dos ingredientes utilizados.

Two experiments were carried out aiming to determine the nutritional value and to verify performance of starting piglets, fed on sticky coffee hull silage (SCHS) diets. The evaluated feeds were sticky coffee hull (SCH) and SCHS. In the Experiment I, a digestibility trial was carried out using fifteen crossbreed barrows, allotted in a completely randomized design. The SCH was ground on a 4 mm screen-opening diameter and was ensilaged with 30 percent water and enzymatic-bacterial inoculants. In general, the process of ensilage did not improve the SCHS digestibility. In the Experiment II, 60 piglets (15.52 ± 2.19 to 32.52 ± 3.51 kg) were used, allotted in a completely randomized design with five treatments (0, 4, 8, 12, and 16 percent SCHS), six replicates and two pigs per pen (experimental unit). There were no effects of SCHS inclusion on daily feed intake, daily weight gain, feed to gain ratio and plasma urea nitrogen. It is concluded that SCHS has good nutritional value and can be included up to 16 percent in starting piglets (15-30 kg) diets without impairing performance, however the economical feasibility of using SCHS will depend on the price of the feedstuffs.