Analysis of the Effects of Microwave Combined Induction Heating on Steamed Pork with Rice Powder.

This study investigates the application of microwave combined induction heating (MCIH) to steam ready-to-eat pork with rice powder, emphasizing the advantages of rapid and uniform heating. The experimental setup included a mixture of 180 g pork strips, 30 g rice powder, and 10 g water in a CPET tray using MCIH with 1080 W microwave (MW) and 130 °C induction heating (IH) for 150 s. The results showed a quick temperature increase rate of 0.56 °C/s that achieved pasteurization against a variety of pathogenic bacteria, such as Listeria monocytogenes, but not Clostridium botulinum, by lethality calculation. Compared to typical electric cooker steaming, MCIH significantly shortened cooking time (8.6 times faster). To address rice starch gelatinization, two-stage heating techniques to steam pork with rice powder were MCIH: 150 s, and then IH: 60 s (MW1), and MCIH: 180 s, and then IH: 30 s (MW2), with no significant differences seen in color or the nine-point taste scale between treatment groups. MCIH groups had smaller shear forces than control. After MCIH cooking, no microbial counts were detected in the MW1 and MW2 groups initially, and the pork with rice powder had a shelf life of 14 days at 4 °C based on aerobic plate count assay.

Study of Inducing Factors on Resveratrol and Antioxidant Content in Germinated Peanuts.

When peanuts germinate, bioactive compounds such as resveratrol (RES), γ-aminobutyric acid (GABA), isoflavones, and polyphenol compounds are generated. Peanut kernels were germinated in the dark for two days, and stimuli including soaking liquid, rice koji, high-pressure processing (HPP), and ultrasonic treatment were tested for their ability to activate the defense mechanisms of peanut kernels, thus increasing their bioactive compound content. The results of this study indicate that no RES was detected in ungerminated peanuts, and only 5.58 µg/g of GABA was present, while unstimulated germinated peanuts contained 4.03 µg/g of RES and 258.83 µg/g of GABA. The RES content of the germinated peanuts increased to 13.64 µg/g after soaking in 0.2% phenylalanine solution, whereas a higher GABA content of 651.51 µg/g was observed after the peanuts were soaked in 0.2% glutamate. Soaking peanuts in 5% rice koji produced the highest RES and GABA contents (28.83 µg/g and 506.34 µg/g, respectively). Meanwhile, the RES and GABA contents of HPP-treated germinated peanuts (i.e., treated with HPP at 100 MPa for 10 min) increased to 7.66 µg/g and 497.09 µg/g, respectively, whereas those of ultrasonic-treated germinated peanuts (for 20 min) increased to 13.02 µg/g and 318.71 µg/g, respectively. After soaking peanuts in 0.5% rice koji, followed by HPP treatment at 100 MPa for 10 min, the RES and GABA contents of the germinated peanuts increased to 37.78 µg/g and 1196.98 µg/g, while the RES and GABA contents of the germinated peanuts treated with rice koji followed by ultrasonic treatment for 20 min increased to 46.53 µg/g and 974.52 µg/g, respectively. The flavonoid and polyphenol contents of the germinated peanuts also increased after exposure to various external stimuli, improving their DPPH free radical-scavenging ability and showing the good potential of germinated peanuts as functional products.

Developing Radio-Frequency Roasting Protocols for Almonds Based on Quality Evaluations.

Hot air roasting is a popular method for preparing almonds, but it takes a long time. We roasted almonds via dielectric heating using 5 kW, 40.68 MHz batch radio-frequency (RF) equipment and analyzed their quality and aroma using a gas chromatography/ion mobility spectrometer and sensory evaluation. Almonds with an initial moisture content of 8.47% (w.b.) were heated at an RF electrode gap of 10 cm; the target roasting temperature of 120 °C was achieved at weights of 0.5, 1, 1.5, and 2 kg for 4, 3.5, 7.5, and 11 min, respectively; and the moisture content was reduced to less than 2% (w.b.). For comparison, 1 kg of almonds was roasted in a 105 °C conventional oven for 120 min. The darker color and lower moisture content, water activity, and acid value of the RF-roasted almonds were favorable for preservation. The aroma analysis using gas chromatography/ion mobility spectroscopy (GC-IMS) revealed that the aroma signal after roasting was richer than that of raw almonds, and principal component analysis (PCA) demonstrated that the aromas of roasted and commercial almonds were similar. The RF-roasted almonds presented a better flavor, texture, and overall preferability compared to commercial almonds. RF heating could be used in the food industry to roast nuts.

Influence of Radio Frequency Heating on the Pasteurization and Drying of Solid-State Fermented Wolfiporia cocos Products.

Rice bran and soybean residue are high in nutrients and active ingredients. They are used as media in the solid-state fermentation of Wolfiporia cocos. They not only reduce raw material costs, but also raise the economic value and applications of soybean residues and rice bran. After 30 days of fermentation, the moisture content (w.b.) of the W. cocos product was approximately 40%, requiring it to be pasteurized and dried later. The objective of this research is to use radio frequency (RF) rapid heating technology to pasteurize and dry the solid-state fermented product. A 500 g bag of solid-state fermented W. cocos product took only 30 and 200 s at the RF electrode gap of 15 cm to pasteurize and reduce the moisture content (w.b.) below 15%, respectively; therefore, the methods can be used instead of the traditional 60 min autoclave sterilization and 100 min hot air drying at 45 °C. After RF treatment, the fermented W. cocos product was white, indicating that browning was prevented; the product contained 5.03% mycelium, 9.83% crude polysaccharide, 4.43% crude triterpene, 3.54 mg gallic acid equivalent/g dry weight (DW) of total polyphenols, and 0.38 mg quercetin equivalent/g DW of flavonoid contents and showed a good antioxidant capacity.

Hot Air-Assisted Radio Frequency (HARF) Drying on Wild Bitter Gourd Extract.

Wild bitter gourd (Momordica charantia L. var. abbreviata S.) is a kind of Chinese herbal medicine and is also a vegetable and fruit that people eat daily. Wild bitter gourd has many bioactive components, such as saponin, polysaccharide, and protein, and the extract is used to adjust blood sugar in patients with diabetes. The objective of this study was to investigate simultaneous hot air-assisted radio frequency (HARF) drying and pasteurization for bitter gourd extract, and then to evaluate its effects on blood sugar of type II diabetic mice. The results showed that the solid-liquid ratio of the wild bitter gourd powder to water was 1:10 and it was extracted using focused ultrasonic extraction (FUE) for only 10 min with 70 °C water. Then, 1 kg of concentrated bitter gourd extract was mixed with soybean fiber powder at a ratio of 2:1.1. It was dried by HARF, and the temperature of the sample could reach above 80 °C in only 12 min to simultaneously reduce moisture content (wet basis) from 58% to 15% and achieve a pasteurization effect to significantly reduce the total bacterial and mold counts. Type II diabetic mice induced by nicotinamide and streptozocin (STZ) for two weeks and then were fed four-week feeds containing 5% RF-dried wild gourd extract did not raise fasting blood glucose. Therefore, the dried powder of wild bitter gourd extracts by HARF drying had a hypoglycemic effect.

Effect of Water and Ethanol Extracts from Hericium erinaceus Solid-State Fermented Wheat Product on the Protection and Repair of Brain Cells in Zebrafish Embryos.

Extracts from Hericium erinaceus can cause neural cells to produce nerve growth factor (NGF) and protect against neuron death. The objective of this study was to evaluate the effects of ethanol and hot water extracts from H. erinaceus solid-state fermented wheat product on the brain cells of zebrafish embryos in both pre-dosing protection mode and post-dosing repair mode. The results showed that 1% ethanol could effectively promote zebrafish embryo brain cell death. Both 200 ppm of ethanol and water extracts from H. erinaceus solid-state fermented wheat product protected brain cells and significantly reduced the death of brain cells caused by 1% ethanol treatment in zebrafish. Moreover, the zebrafish embryos were immersed in 1% ethanol for 4 h to cause brain cell damage and were then transferred and soaked in the 200 ppm of ethanol and water extracts from H. erinaceus solid-state fermented wheat product to restore the brain cells damaged by the 1% ethanol. However, the 200 ppm extracts from the unfermented wheat medium had no protective and repairing effects. Moreover, 200 ppm of ethanol and water extracts from H. erinaceus fruiting body had less significant protective and restorative effects on the brain cells of zebrafish embryos. Both the ethanol and hot water extracts from H. erinaceus solid-state fermented wheat product could protect and repair the brain cells of zebrafish embryos damaged by 1% ethanol. Therefore, it has great potential as a raw material for neuroprotective health product.

Effects of Radio Frequency Heating on the Stability and Antioxidant Properties of Rice Bran.

Radio frequency (RF) technology is considered as a rapid heating method. Lipase in rice bran could highly accelerate lipid oxidation. The objectives of this study were to establish the radio frequency heating conditions for lipase inactivation and to evaluate the stability and antioxidant capacity. The results showed that the suitable electrode gap for a 1 kg sample load was 6 cm, and it only took 2 min to heat rice bran from 25 °C to 100 °C. Besides, there were no significant differences in the total phenolic content, flavonoid content and color between the untreated and RF-treated group, and the DPPH free radical scavenging activity of the RF treatment reached 84.8%. The acid value, free fatty acid content and peroxide value of the RF-treated rice bran met the quality standard after 8 weeks of storage at 4, 25 and 37 °C. In summary, this study provides valuable information about the RF heating procedure, and shows the great potential of RF technology for stabilizing rice bran efficiently.

Antioxidant Profile and Biosafety of White Truffle Mycelial Products Obtained by Solid-State Fermentation.

Solid-state fermentation may produce therapeutic compounds with higher biomass or better product characteristics than those generated by submerged fermentation. The objectives of this study were to analyze the antioxidant activities and biosafety of products obtained by white truffle (Tuber magnatum) solid-state fermentation in media with different ratios of soybean and red adlay. High levels of antioxidant components and high antioxidant activities such as DPPH radical scavenging, ferrous ion chelation, and reducing power were measured in 20 mg/mL water and ethanol extracts of the white truffle fermentation products. When the solid-state fermentation medium contained soybean and red adlay in a 1:3 ratio (S1A3), the fermentation product had more uniform antioxidant compositions and activities by principal component analysis (PCA). In addition, a 200 ppm water extract of the mycelial fermentation product was able to protect zebrafish embryos from oxidative stress induced by 5 mM hydrogen peroxide. Sprague-Dawley rats were fed the mycelial fermentation product for 90 consecutive days, revealing a no-observed-adverse-effect level (NOAEL) of 3000 mg/kg BW/day. Therefore, mycelial products obtained by white truffle solid-state fermentation can be used instead of expensive fruiting bodies as a good source of antioxidant ingredients.

Assessment of the tumorigenesis and drug susceptibility of three new canine mammary tumor cell lines.

Three canine mammary tumor (CMT) cell lines, namely DE-E, DE-F and DE-SF, have been established from a surgically excised specimen of a malignant mammary tumor. These CMT cell lines have been cultured for over 200 passages. The cell doubling time was estimated to be approximately 30 h for all three cell lines. DE-E, DE-F and DE-SF were epithelial, fibroblast and spindle fibroblast in morphology, respectively. Under electron microscope, DE-F and DE-SF cells displayed a higher nucleus/cytoplasm ratio as compared with DE-E. Variation in chromosome number was also observed in the three cell lines. In addition to the morphological characteristics, these cell lines displayed differential patterns of several known mammary tumor cell markers. Following xenotransplantation of the CMT cells into nude mice, DE-F and DE-SF developed tumors within 2 weeks, whereas DE-E failed to develop any visible tumor up to 8 weeks after injection. Lastly, the CMT cell lines exhibited differential chemoresistance to several anti-tumor drugs, including melatonin, cyclosporine A, tamoxifen and indole, suggesting that these cell lines can be used as a comparative experimental model for the tumorigenesis of mammary carcinomas and a valuable tool for anti-cancer drug screening.

Effects of fermentation products of Ganoderma lucidum on growth performance and immunocompetence in weanling pigs.

The purpose of this study was to test fermentation, for its products of a Chinese medicinal mushroom, Ganoderma lucidum, cultured by submerged fermentation for its effect on growth performance and immunocompetence in weanling piglets. In Experiment 1, 72 weanling piglets were allotted to one of four treatments receiving these fermentation products (GLF, expressed as amount of beta-glucans) at 0 (control), 50, 100, and 150 mg/kg feed for 4 weeks. The results showed that at a supplementation level of 50 mg/kg feed, GLF caused the best growth performance, the highest pseudorabies antibody titre, and a decrease of blood glucose level. It was also demonstrated that GLF up-regulated the cell-mediated immune response related cytokines (IL-2, IFN-gamma, and TNF-alpha) expression in different lymphoid tissues. After challenging with porcine circovirus (PCV) type 2 (Experiment 2), a supplementation with 50 mg GLF per kg feed also inhibited PCV-2 virus amplification, and ameliorated lymphocyte depletion in different lymphoid tissues. Conclusively, feed supplemented with GLF at 50 mg/kg could be beneficial to counteract the physiological stress in weanling piglets.