Coated Cast Saw Blades Decrease Blade Temperature During Cast Removal.

BACKGROUND: Thermal injuries can occur during cast removal with an oscillating saw. The purpose of this study is to describe the effect of blade material, blade wear, and cast material on blade temperature. METHODS: Short arm plaster and fiberglass casts were cured overnight and bivalved with either new or worn stainless-steel or tungsten-disulfide coated blades. Blade use was defined as removing 1 short arm cast. Blades used to remove more than 20 casts were defined as worn. Ten trials were performed with each combination of blade material, blade wear, and cast material, except for the combination of fiberglass and a worn stainless-steel blade due to complete erosion of cutting teeth. Thirty casts were removed with stainless-steel blades, and 40 casts were removed with coated blades. Blade temperature was measured continuously at 5 Hz using a T-type thermocouple and microcontroller board. A Mann-Whitney U test was used to compare the mean maximum temperature between groups. RESULTS: For plaster casts, new and worn stainless-steel blades produced mean maximum temperatures of 51.4°C and 63.7°C ( P =0.003), respectively. New stainless-steel blades produced significantly higher mean maximum temperatures on fiberglass casts than plaster casts (95.9°C vs. 51.4°C, P <.001). For plaster casts, new and worn coated blades produced mean maximum temperatures of 56.9°C and 53.8°C ( P =0.347). For fiberglass casts, new and worn coated blades produced mean maximum temperatures of 76.6°C and 77.7°C ( P =0.653). As with new stainless-steel blades, new coated blades produced significantly higher mean maximum temperatures on fiberglass than plaster (76.6°C vs. 56.9°C, P <0.001). Mean maximum temperatures between new stainless-steel and coated blades during removal of plaster casts were 51.4°C and 56.9°C ( P =0.131), respectively. However, new coated blades demonstrated significantly lower mean maximum temperatures during fiberglass cast removal compared to new stainless-steel blades (76.6°C vs. 95.9°C, P =0.016). CONCLUSIONS: Coated blades outperformed stainless-steel in nearly all combinations. We recommend limited use of stainless-steel blades to minimize blade temperatures during cast removal. CLINICAL RELEVANCE: Appropriate selection of blade material and monitoring blade wear minimizes blade temperature during cast removal.

More Elevated Fastballs Associated With Placement on the Injured List due to Shoulder Injury.

Purpose: To evaluate whether impending shoulder injury was associated with changes in pitch location or velocity immediately preceding injury. Methods: Pitchers placed on the injured list (IL) due to a shoulder injury between 2015 and 2020 were identified in the Major League Baseball transactions database. Four-seam fastball velocity and frequency of pitch location for each pitch type was collected for each player in the season before placement on the IL and within 1 month of placement on the IL with a minimum of 55 pitches thrown of 1 type. Pitch locations were collected as identified by Baseball Savant's Game-Day Zones. Game-Day Zones were consolidated into high (above the strike zone midpoint) versus low, arm side (closer to the pitcher's arm side of the plate) versus opposite side, and within the strike zone versus out of zone. Repeated measures analysis of variance determined differences in four-seam velocity and the location distribution of 4-seam fastballs, change-ups, and breaking balls among each group. Results: In total, 267 pitchers were placed on the IL for a shoulder injury with the majority diagnosed with inflammation (89/267) followed by strain or sprain (69/267). Four-seam fastball locations significantly increased above the mid-point of the zone (45.9% vs 42.4%, P = .008) and out of the strike zone (48.5% vs 46.5%, P = .011) within a month before IL placement. There was no significant change in 4-seam fastball velocity immediately before IL placement. Conclusions: Pitchers threw more elevated 4-seam fastballs and out-of-zone 4-seam fastballs in the month before IL placement for shoulder injury. These findings suggest that a loss of 4-seam fastball command decreases with impending shoulder injury. Level of Evidence: IV, prognostic case series.

Secondary Injuries After Pediatric Anterior Cruciate Ligament Reconstruction: A Systematic Review With Quantitative Analysis.

BACKGROUND: In the skeletally mature anterior cruciate ligament (ACL) reconstruction population, patients aged <25 years are at significantly increased risk of graft failure and injury to the contralateral ACL. Skeletal immaturity often affects graft selection and reconstruction technique. PURPOSE: To examine the incidence of ipsilateral graft failure and contralateral ACL injury in the skeletally immature patient population. STUDY DESIGN: Systematic review and meta-analysis. METHODS: Using the PRISMA (Preferred Reporting Items for Systematic Meta-Analyses) guidelines, we reviewed all literature that involved ACL reconstruction performed on skeletally immature patients between May 1976 and May 2019. Patient demographics, surgical technique, and the prevalence of ipsilateral graft failure or subsequent contralateral ACL injury were recorded. Ipsilateral, contralateral, and secondary ACL injuries were then compared between sexes via chi-square tests. RESULTS: A total of 24 articles (1254 children; 1258 knees) met inclusion criteria for analysis. Ipsilateral graft failures occurred in 105 of 1258 patients (8.3%), and there were no statistically significant sex differences in the prevalence of graft failures (female, 9.7%; male patients, 7.1%; P = .14). The prevalence of contralateral ACL injury was significantly greater in female (29/129; 22.5%) than male (18/206; 8.7%; P = .0004) patients in the 9 studies that reported contralateral injury. Skeletally immature female patients were at significantly increased risk of contralateral ACL injury (odds ratio = 3.0; P = .0006) when compared with their male counterparts. CONCLUSION: In the literature to date, 1 in 3 female skeletally immature patients experienced an ipsilateral graft failure or contralateral ACL injury. Regardless of sex, the 24% prevalence of secondary injury after pediatric ACL reconstruction is almost identical to previously published secondary injury rates in skeletally mature patients <25 years old. As such, skeletal maturity alone does not seem to be a determinant of secondary injury; however, there is a clear need to improve postoperative rehabilitation, activity progression, and return-to-play testing to allow a safe return to sports that protects the long-term health of the reconstructed and contralateral limbs, especially for female patients.