RESUMEN
The safety of microwave and electron-beam treatments has been demonstrated, in regards to the formation of reaction products that could endanger human health. An integrated approach was used combining the potential toxicity of all the substances likely to migrate to their chemical characterizations. This approach was applied to polypropylene (PP) films prepared with a selection of additives. Components were identified by liquid and gas chromatography using a mass selective detector system. Their potential toxicity was assessed using three in vitro short-term bioassays and their migrations were carried out using a standards-based approach. After the electron-beam treatment some additives decomposed and there was a significant increase in the polyolefin oligomeric saturated hydrocarbons concentration. PP prepared with Irgafos 168 led to a significantly strong cytotoxic effect and PP prepared with Irganox 1076 induced a dose-dependant estrogenic effect in vitro. Migration values were low and below the detection limit of the analytical method applied.
Asunto(s)
Electrones/efectos adversos , Embalaje de Alimentos , Inocuidad de los Alimentos , Microondas/efectos adversos , Polipropilenos/química , HumanosRESUMEN
In vitro toxicological tests have been proposed as an approach to complement the chemical safety assessment of food contact materials, particularly those with a complex or unknown chemical composition such as paper and board. Among the concerns raised regarding the applicability of in vitro tests are the effects of interference of the extractables on the outcome of the cytotoxicity and genotoxicity tests applied and the role of known compounds present in chemically complex materials, such as paper and board, either as constituents or contaminants. To answer these questions, a series of experiments were performed to assess the role of natural substances (wood extracts, resin acids), some additives (diisopropylnaphthalene, phthalates, acrylamide, fluorescent whitening agents) and contaminants (2,4-diaminotoluene, benzo[a]pyrene) in the toxicological profile of paper and board. These substances were individually tested or used to spike actual paper and board extracts. The toxic concentrations of diisopropylnaphthalenes and phthalates were compared with those actually detected in paper and board extracts showing conspicuous toxicity. According to the results of the spiking experiments, the extracts did not affect the toxicity of tested chemicals nor was there any significant metabolic interference in the cases where two compounds were used in tests involving xenobiotic metabolism by the target cells. While the identified substances apparently have a role in the cytotoxicity of some of the project samples, their presence does not explain the total toxicological profile of the extracts. In conclusion, in vitro toxicological testing can have a role in the safety assessment of chemically complex materials in detecting potentially harmful activities not predictable by chemical analysis alone.
Asunto(s)
Contaminación de Alimentos/prevención & control , Embalaje de Alimentos , Papel , Animales , Bioensayo , Línea Celular Tumoral , Humanos , Mutágenos , Salmonella typhimurium/efectos de los fármacos , Salmonella typhimurium/genética , Madera/químicaRESUMEN
The rheology of milk powder suspensions is investigated up to very high concentrations, where structural arrest occurs. The main component of the milk powder investigated is casein, so that the suspensions can be regarded as casein suspensions. Four concentration regimes are identified. For effective casein volume fractions less than 0.54 the concentration dependence of the zero-shear viscosity is similar to that of hard-sphere suspensions. However, due to the elastic deformation of the caseins, the viscosity does not diverge at the hard sphere glass transition. In the volume-fraction range of 0.55-0.61 the viscosity exhibits a surprisingly weak dependence on concentration. The shape of the curve of the shear viscosity versus concentration deviates from hard sphere behavior in an unusual way, due to the observation of a region of almost constant viscosity. This concentration regime is followed by a regime where the viscosity steeply increases, eventually diverging at an effective volume fraction of 0.69. Frequency dependent rheology and diffusing wave spectroscopy measurements indicate that the suspensions are jammed for volume fractions above 0.69. Finally we found the concentration dependence of the relative zero-shear viscosity of casein suspensions to be very similar with the one of the micro-gels at volume fractions below 0.50 and above 0.55, which are know to shrink above a certain volume fraction, due to osmotic stress.
RESUMEN
An European Union (EU)-funded project QLK1-CT-2001-00930 (BIOSAFEPAPER) involves the development, validation and intercalibration of a short-term battery of toxicological tests for the safety assessment of food-contact paper and board. Dissemination of the results to industry, legislators (e.g. DG Consumer Protection, DG Enterprises, DG Research), standardization bodies such as CEN, and consumers will create an agreed risk evaluation procedure. The project involves pre-normative research in order to establish a set of in-vitro cytotoxicity and genotoxicity tests that will be easily adaptable to food-contact fibre-based materials and have endpoints relevant to consumer safety, including sub-lethal cellular events. These tests will be performed on samples representing actual migration conditions from food-contact paper and board with respect to different foodstuffs, and should form an experimental basis for scientifically sound recommendations for a harmonized system of risk evaluation and product testing.