The impact of putative methyltransferase overexpression on the Trichoderma harzianum cellulolytic system for biomass conversion.

Trichoderma harzianum has attracting attention for its potential alternative use in biofuel production, due to a recognized competence for high diversity glycoside hydrolases (GH) enzyme complex, including higher ß-glucosidases and auxiliary proteins, using low-cost carbon sources. This strain constitutively overexpressed the global regulator putative methyltransferase - LAE1, in order to improve the GHs production. The recombinant strain achieved 79-fold increase in lae1 expression and high GHs productivity. The evaluation of the LAE1 impact to induce the GHs used soluble and lignocellulose inexpensive carbon sources in a stirred-tank bioreactor. Using sugarcane bagasse with sucrose, the overexpression of lae1 resulted in significantly increment of gh61b (31x), cel7a (25x), bgl1(20x) and xyn3 (20x) genes expression. Reducing sugar released from pretreated sugarcane bagasse, which hydrolyzed by recombinant crude enzyme cocktail, achieved 41% improvement. Therefore, lae1 overexpression effectively is a promising improving GHs target for biomass degradation by T. harzianum.

Enhancement of Penicillium echinulatum glycoside hydrolase enzyme complex.

The enhancement of enzyme complex produced by Penicillium echinulatum grown in several culture media components (bagasse sugarcane pretreated by various methods, soybean meal, wheat bran, sucrose, and yeast extract) was studied to increment FPase, xylanase, pectinase, and ß-glucosidase enzyme activities. The present results indicated that culture media composed with 10 g/L of the various bagasse pretreatment methods did not have any substantial influence with respect to the FPase, xylanase, and ß-glucosidase attained maximum values of, respectively, 2.68 FPU/mL, 2.04, and 115.4 IU/mL. On the other hand, proposed culture media to enhance ß-glucosidase production composed of 10 g/L steam-exploded bagasse supplemented with soybean flour 5.0 g/L, yeast extract 1.0 g/L, and sucrose 10.0 g/L attained, respectively, 3.19 FPU/mL and 3.06 IU/mL while xylanase was maintained at the same level. The proteomes obtained from the optimized culture media for enhanced FPase, xylanase, pectinase, and ß-glucosidase production were analyzed using mass spectrometry and a panel of GH enzyme activities against 16 different substrates. Culture medium designed to enhance ß-glucosidase activity achieved higher enzymatic activities values (13 measured activities), compared to the culture media for FPase/pectinase (9 measured activities) and xylanase (7 measured activities), when tested against the 16 substrates. Mass spectrometry analyses of secretome showed a consistent result and the greatest number of spectral counts of Cazy family enzymes was found in designed ß-glucosidase culture medium, followed by FPase/pectinase and xylanase. Most of the Cazy identified protein was cellobiohydrolase (GH6 and GH7), endoglucanase (GH5), and endo-1,4-ß-xylanase (GH10). Enzymatic hydrolysis of hydrothermally pretreated sugarcane bagasse performed with ß-glucosidase enhanced cocktail achieved 51.4 % glucose yield with 10 % w/v insoluble solids at enzyme load of 15 FPU/g material. Collectively the results demonstrated that it was possible to rationally modulate the GH activity of the enzymatic complex secreted by P. echinulatum using adjustment of the culture medium composition. The proposed strategy may contribute to increase enzymatic hydrolysis of lignocellulosic materials.

Enhanced cellulase production by Trichoderma harzianum by cultivation on glycerol followed by induction on cellulosic substrates.

The use of glycerol obtained as an intermediate of the biodiesel manufacturing process as carbon source for microbial growth is a potential alternative strategy for the production of enzymes and other high-value bioproducts. This work evaluates the production of cellulase enzymes using glycerol for high cell density growth of Trichoderma harzianum followed by induction with a cellulosic material. Firstly, the influence of the carbon source used in the pre-culture step was investigated in terms of total protein secretion and fungal morphology. Enzymatic productivity was then determined for cultivation strategies using different types and concentrations of carbon source, as well as different feeding procedures (batch and fed-batch). The best strategy for cellulase production was then further studied on a larger scale using a stirred tank bioreactor. The proposed strategy for cellulase production, using glycerol to achieve high cell density growth followed by induction with pretreated sugarcane bagasse, achieved enzymatic activities up to 2.27 ± 0.37 FPU/mL, 106.40 ± 8.87 IU/mL, and 9.04 ± 0.39 IU/mL of cellulase, xylanase, and ß-glucosidase, respectively. These values were 2 times higher when compared to the control experiments using glucose instead of glycerol. This novel strategy proved to be a promising approach for improving cellulolytic enzymes production, and could potentially contribute to adding value to biomass within the biofuels sector.

Caracterização de fungos isolados da região Amazônica quanto ao potencial para produção das enzimas envolvidas na conversão da biomassa vegetal / Characterization of fungi isolated from the Amazon region for the potential of biomass-degrading enzymes production

A conversão da biomassa vegetal proveniente de resíduos agroindustriais e florestais em biocombustíveis e bioprodutos, dentro do conceito de biorrefinarias, é de grande interesse, principalmente para o Brasil, onde a agroenergia possui um enorme potencial de desenvolvimento. Entretanto, para garantir a viabilidade do processo de conversão, é fundamental reduzir o custo das enzimas utilizadas na etapa de hidrólise. Para isso, deve-se dispor da peça chave deste processo, que é o microrganismo. Nesse contexto, o objetivo deste trabalho foi avaliar fungos isolados da região Amazônica em relação ao potencial de produção das enzimas celulases e xilanases. De um total de 40 isolados cultivados por fermentação em estado sólido (FES), durante 10 dias, os fungos que se destacaram quanto à produção de endoglucanase (351,79Ug^-1 em 120h) e β-glicosidase (62,31Ug^-1em 72h) foi o P47C3 (A. niger), e na produção de xilanase (1076,94Ug^-1 em 72h) e FPase (2,46Ug^-1 em 120h) foram o P6B2 (A. oryzae) e o P40B3, respectivamente. Os resultados obtidos demonstram o enorme potencial de aplicação das enzimas produzidas pelos fungos isolados da Amazônia, contribuindo, assim, para gerar os avanços tecnológicos necessários para o aumento da eficiência do uso da biomassa vegetal como fonte de energia renovável

The conversion of biomass from forestry and agroindustrial residues into biofuels and bioproducts, within the biorefinery concept, is of great interest, especially to Brazil, where bioenergy has a huge potential for development. However, to ensure the viability of the conversion process it is essential to reduce the cost of the enzymes used in the hydrolysis step. For this, one must have the key element of this process, which is the microorganism. In this context, the objective of this study was to evaluate different fungi isolated from the Amazon region for their potential in terms of the production of cellulase and xylanase enzymes. Of a total of 40 strains cultivated under solid state fermentation (SSF) for 10 days, the strain that stood out for the production of endoglucanase (351.79Ug-1120h) and β-glucosidase (62.31Ug-1 at 72h) was P47C3 (A. niger) whereas for xylanase (1076.94Ug-1 in 72 hours) and FPase (2.46Ug-1 in120 hours) were P6B2 (A. oryzae) and P40B3, respectively. These results demonstrate the great potential application of the enzymes produced by the Amazon isolated fungi, thus contributing to generate the necessary technological advances in order to increase the efficiency of the use of biomass as a renewable energy source.

Enhancing of sugar cane bagasse hydrolysis by Annulohypoxylon stygium glycohydrolases.

The aim of this study was to develop a bioprocess for the production of ß-glucosidase and pectinase from the fungus Annulohypoxylon stygium DR47. Media optimization and bioreactor cultivation using citrus bagasse and soybean bran were explored and revealed a maximum production of 6.26 U/mL of pectinase at pH 4.0 and 10.13 U/mL of ß-glucosidase at pH 5.0. In addition, the enzymes extracts were able to replace partially Celluclast 1.5L in sugar cane bagasse hydrolysis. Proteomic analysis from A. stygium cultures revealed accessory enzymes, mainly belong to the families GH3 and GH54, that would support enhancement of commercial cocktail saccharification yields. This is the first report describing bioreactor optimization for enzyme production from A. stygium with a view for more efficient degradation of sugar cane bagasse.

Addition of feruloyl esterase and xylanase produced on-site improves sugarcane bagasse hydrolysis.

Accessory enzymes that assist biomass degradation could be used to improve the recovery of fermentable sugar for use in biorefineries. In this study, different fungal strains isolated from the Amazon rainforest were evaluated in terms of their ability to produce feruloyl esterase (FAE) and xylanase enzymes, and an assessment was made of the contributions of the enzymes in the hydrolysis of pretreated sugarcane bagasse. In the selection step, screening using plate assays was followed by shake flask submerged cultivations. After carbon source selection and cultivation in a stirred-tank bioreactor, Aspergillusoryzae P21C3 proved to be a promising strain for production of the enzymes. Supplementation of a commercial enzyme preparation with 30% (v/v) crude enzymatic complex from A. oryzae P21C3 increased the conversion of cellulose derived from pretreated sugarcane bagasse by 36%. Supplementation with FAE and xylanase enzymes produced on-site can therefore be used to improve the hydrolysis of sugarcane bagasse.

Transcriptome profile of Trichoderma harzianum IOC-3844 induced by sugarcane bagasse.

Profiling the transcriptome that underlies biomass degradation by the fungus Trichoderma harzianum allows the identification of gene sequences with potential application in enzymatic hydrolysis processing. In the present study, the transcriptome of T. harzianum IOC-3844 was analyzed using RNA-seq technology. The sequencing generated 14.7 Gbp for downstream analyses. De novo assembly resulted in 32,396 contigs, which were submitted for identification and classified according to their identities. This analysis allowed us to define a principal set of T. harzianum genes that are involved in the degradation of cellulose and hemicellulose and the accessory genes that are involved in the depolymerization of biomass. An additional analysis of expression levels identified a set of carbohydrate-active enzymes that are upregulated under different conditions. The present study provides valuable information for future studies on biomass degradation and contributes to a better understanding of the role of the genes that are involved in this process.

The capability of endophytic fungi for production of hemicellulases and related enzymes.

BACKGROUND: There is an imperative necessity for alternative sources of energy able to reduce the world dependence of fossil oil. One of the most successful options is ethanol obtained mainly from sugarcane and corn fermentation. The foremost residue from sugarcane industry is the bagasse, a rich lignocellulosic raw material uses for the production of ethanol second generation (2G). New cellulolytic and hemicellulytic enzymes are needed, in order to optimize the degradation of bagasse and production of ethanol 2G. RESULTS: The ability to produce hemicellulases and related enzymes, suitable for lignocellulosic biomass deconstruction, was explored using 110 endophytic fungi and 9 fungi isolated from spoiled books in Brazil. Two initial selections were performed, one employing the esculin gel diffusion assay, and the other by culturing on agar plate media with beechwood xylan and liquor from the hydrothermal pretreatment of sugar cane bagasse. A total of 56 isolates were then grown at 29°C on steam-exploded delignified sugar cane bagasse (DEB) plus soybean bran (SB) (3:1), with measurement of the xylanase, pectinase, ß-glucosidase, CMCase, and FPase activities. Twelve strains were selected, and their enzyme extracts were assessed using different substrates. Finally, the best six strains were grown under xylan and pectin, and several glycohydrolases activities were also assessed. These strains were identified morphologically and by sequencing the internal transcribed spacer (ITS) regions and the partial ß-tubulin gene (BT2). The best six strains were identified as Aspergillus niger DR02, Trichoderma atroviride DR17 and DR19, Alternaria sp. DR45, Annulohypoxylon stigyum DR47 and Talaromyces wortmannii DR49. These strains produced glycohydrolases with different profiles, and production was highly influenced by the carbon sources in the media. CONCLUSIONS: The selected endophytic fungi Aspergillus niger DR02, Trichoderma atroviride DR17 and DR19, Alternaria sp. DR45, Annulohypoxylon stigyum DR47 and Talaromyces wortmannii DR49 are excellent producers of hydrolytic enzymes to be used as part of blends to decompose sugarcane biomass at industrial level.

Understanding the cellulolytic system of Trichoderma harzianum P49P11 and enhancing saccharification of pretreated sugarcane bagasse by supplementation with pectinase and α-L-arabinofuranosidase.

Supplementation of cellulase cocktails with accessory enzymes can contribute to a higher hydrolytic capacity in releasing fermentable sugars from plant biomass. This study investigated which enzymes were complementary to the enzyme set of Trichoderma harzianum in the degradation of sugarcane bagasse. Specific activities of T. harzianum extract on different substrates were compared with the extracts of Penicillium echinulatum and Trichoderma reesei, and two commercial cellulase preparations. Complementary analysis of the secretome of T. harzianum was also used to identify which enzymes were produced during growth on pretreated sugarcane bagasse. These analyses enabled the selection of the enzymes pectinase and α-L-arabinofuranosidase (AF) to be further investigated as supplements to the T. harzianum extract. The effect of enzyme supplementation on the efficiency of sugarcane bagasse saccharification was evaluated using response surface methodology. The supplementation of T. harzianum enzymatic extract with pectinase and AF increased the efficiency of hydrolysis by up to 116%.

Experimental mixture design as a tool to enhance glycosyl hydrolases production by a new Trichoderma harzianum P49P11 strain cultivated under controlled bioreactor submerged fermentation.

This work investigates the glycosyl hydrolase (GH) profile of a new Trichoderma harzianum strain cultivated under controlled bioreactor submerged fermentation. The influence of different medium components (delignified steam-exploded sugarcane bagasse, sucrose, and soybean flour) on GH biosynthesis was assessed using experimental mixture design (EMD). Additionally, the effect of increased component concentrations in culture media selected from the EMD was studied. It was found that that a mixed culture medium could significantly maximize GH biosynthesis rate, especially for xylanase enzymes which achieved a 2-fold increment. Overall, it was demonstrated that T. harzianumP49P11 enzymes have a great potential to be used in the deconstruction of biomass.

Use of a new Trichoderma harzianum strain isolated from the Amazon rainforest with pretreated sugar cane bagasse for on-site cellulase production.

The on-site production of cellulases is an important strategy for the development of sustainable second-generation ethanol production processes. This study concerns the use of a specific cellulolytic enzyme complex for hydrolysis of pretreated sugar cane bagasse. Glycosyl hydrolases (FPase, xylanase, and ß-glucosidase) were produced using a new strain of Trichoderma harzianum, isolated from the Amazon rainforest and cultivated under different conditions. The influence of the carbon source was first investigated using shake-flask cultures. Selected carbon sources were then further studied under different pH conditions using a stirred tank bioreactor. Enzymatic activities up to 121 FPU/g, 8000 IU/g, and 1730 IU/g of delignified steam-exploded bagasse+sucrose were achieved for cellulase, xylanase and ß-glucosidase, respectively. This enzymatic complex was used to hydrolyze pretreated sugar cane bagasse. A comparative evaluation, using an enzymatic extract from Trichoderma reesei RUTC30, indicated similar performance of the T. harzianum enzyme complex, being a potential candidate for on-site production of enzymes.

Purification, and biochemical and biophysical characterization of cellobiohydrolase I from Trichoderma harzianum IOC 3844.

Because of its elevated cellulolytic activity, the filamentous fungus Trichoderma harzianum has a considerable potential in biomass hydrolysis applications. Trichoderma harzianum cellobiohydrolase I (ThCBHI), an exoglucanase, is an important enzyme in the process of cellulose degradation. Here, we report an easy single-step ion-exchange chromatographic method for purification of ThCBHI and its initial biophysical and biochemical characterization. The ThCBHI produced by induction with microcrystalline cellulose under submerged fermentation was purified on DEAE-Sephadex A-50 media and its identity was confirmed by mass spectrometry. The ThCBHI biochemical characterization showed that the protein has a molecular mass of 66 kDa and pI of 5.23. As confirmed by smallangle X-ray scattering (SAXS), both full-length ThCBHI and its catalytic core domain (CCD) obtained by digestion with papain are monomeric in solution. Secondary structure analysis of ThCBHI by circular dichroism revealed alpha- helices and beta-strands contents in the 28% and 38% range, respectively. The intrinsic fluorescence emission maximum of 337 nm was accounted for as different degrees of exposure of ThCBHI tryptophan residues to water. Moreover, ThCBHI displayed maximum activity at pH 5.0 and temperature of 50 degrees C with specific activities against Avicel and p-nitrophenyl-ß-D-cellobioside of 1.25 U/mg and 1.53 U/mg, respectively.