Respiratory toxicity and immunotoxicity evaluations of microparticle and nanoparticle C60 fullerene aggregates in mice and rats following nose-only inhalation for 13 weeks.

C60 fullerene (C60), or buckminsterfullerene, is a spherical arrangement of 60 carbon atoms, having a diameter of approximately 1 nm, and is produced naturally as a by-product of combustion. Due to its small size, C60 has attracted much attention for use in a variety of applications; however, insufficient information is available regarding its toxicological effects. The effects on respiratory toxicity and immunotoxicity of C60 aggregates (50 nm [nano-C60] and 1 µm [micro-C60] diameter) were examined in B6C3F1/N mice and Wistar Han rats after nose-only inhalation for 13 weeks. Exposure concentrations were selected to allow for data evaluations using both mass-based and particle surface area-based exposure metrics. Nano-C60 exposure levels selected were 0.5 and 2 mg/m3 (0.033 and 0.112 m2/m3), while micro-C60 exposures were 2, 15 and 30 mg/m3 (0.011, 0.084 and 0.167 m2/m3). There were no systemic effects on innate, cell-mediated, or humoral immune function. Pulmonary inflammatory responses (histiocytic infiltration, macrophage pigmentation, chronic inflammation) were concentration-dependent and corresponded to increases in monocyte chemoattractant protein (MCP)-1 (rats) and macrophage inflammatory protein (MIP)-1α (mice) in bronchoalveolar lavage (BAL) fluid. Lung overload may have contributed to the pulmonary inflammatory responses observed following nano-C60 exposure at 2 mg/m3 and micro-C60 exposure at 30 mg/m3. Phenotype shifts in cells recovered from the BAL were also observed in all C60-exposed rats, regardless of the level of exposure. Overall, more severe pulmonary effects were observed for nano-C60 than for micro-C60 for mass-based exposure comparisons. However, for surface-area-based exposures, more severe pulmonary effects were observed for micro-C60 than for nano-C60, highlighting the importance of dosimetry when evaluating toxicity between nano- and microparticles.

Lung deposition and clearance of microparticle and nanoparticle C60 fullerene aggregates in B6C3F1 mice and Wistar Han rats following nose-only inhalation for 13 weeks.

C60 fullerenes (C60) are spherical structures consisting of 60 carbon atoms that are generated via combustion from both natural and anthropogenic sources. C60 are also synthesized intentionally for industrial applications. Individual C60 structures have an approximate diameter of 1nm; however, C60 readily forms aggregates and typically exist as larger particles that range from nanometers to micrometers in diameter. In this report, lung and extrapulmonary tissue deposition and lung clearance of C60 nanoparticles (nano-C60, 50nm) and microparticles (micro-C60, 1µm) were examined in Wistar Han rats and B6C3F1/N mice after nose-only inhalation for 90 days. Exposure concentrations were 0.5 and 2mg/m(3) (nano-C60) and 2, 15, and 30mg/m(3) (micro-C60). For both C60 particle sizes, the C60 lung burden increased proportionally to exposure concentration. The C60 lung burden was greater in both species at all time points following exposure to nano-C60 particle exposure compared to micro-C60 exposure at the common exposure concentration 2mg/m(3). The calculated C60 particle lung retention half-times were similar for both nano-C60 and micro-C60 exposure at 2mg/m(3) in male mice (15-16 days). In contrast, in male rats, the half-time of C60 particles following nano-C60 exposure (61 days) was roughly twice as long as the half-time following micro-C60 exposure (27 days) at the same exposure concentration (2mg/m(3)) and was similar to the clearance following micro-C60 exposure at higher exposure concentrations (15 and 30mg/m(3)). C60 was detected in bronchial lymph nodes but the burden was not quantified due to the high variability in the data. C60 concentrations were below the experimental limit of quantitation (ELOQ) in liver, spleen, blood, brain and kidney tissues. These tissue burden data provide information for comparison between nanometer and micrometer sized C60 particle exposure and will aid in the interpretation of toxicity data.

Comparative toxicity and carcinogenicity of soluble and insoluble cobalt compounds.

Occupational exposure to cobalt is of widespread concern due to its use in a variety of industrial processes and the occurrence of occupational disease. Due to the lack of toxicity and carcinogenicity data following exposure to cobalt, and questions regarding bioavailability following exposure to different forms of cobalt, the NTP conducted two chronic inhalation exposure studies in rats and mice, one on soluble cobalt sulfate heptahydrate, and a more recent study on insoluble cobalt metal. Herein, we compare and contrast the toxicity profiles following whole-body inhalation exposures to these two forms of cobalt. In general, both forms were genotoxic in the Salmonella T98 strain in the absence of effects on micronuclei. The major sites of toxicity and carcinogenicity in both chronic inhalation studies were the respiratory tract in rats and mice, and the adrenal gland in rats. In addition, there were distinct sites of toxicity and carcinogenicity noted following exposure to cobalt metal. In rats, carcinogenicity was observed in the blood, and pancreas, and toxicity was observed in the testes of rats and mice. Taken together, these findings suggest that both forms of cobalt, soluble and insoluble, appear to be multi-site rodent carcinogens following inhalation exposure.

Evaluation of propargyl alcohol toxicity and carcinogenicity in F344/N rats and B6C3F1/N mice following whole-body inhalation exposure.

Propargyl alcohol (PA) is a high production volume chemical used in synthesis of many industrial chemicals and agricultural products. Despite the potential for prolonged or accidental exposure to PA in industrial settings, the toxicity potential of PA was not well characterized. To address the knowledge gaps relevant to the toxicity profile of PA, the National Toxicology Program (NTP) conducted 2-week, 14-week and 2-year studies in male and female F344/N rats and B6C3F1/N mice. For the 2-week inhalation study, the rats and mice were exposed to 0, 31.3, 62.5, 125, 250 or 500ppm. Significant mortality was observed in both rats and mice exposed to ≥125ppm of PA. The major target organ of toxicity in both mice and rats was the liver with exposure-related histopathological changes (250 and 500ppm). Based on the decreased survival in the 2-week study, the rats and mice were exposed to 0, 4, 8, 16, 32 or 64ppm of PA in the 14-week study. No treatment-related mortality was observed. Mean body weights of male (≥8ppm) and female mice (32 and 64ppm) were significantly decreased (7-16%). Histopathological changes were noted in the nasal cavity, and included suppurative inflammation, squamous metaplasia, hyaline droplet accumulation, olfactory epithelium atrophy, and necrosis. In the 2-year inhalation studies, the rats were exposed to 0, 16, 32 and 64ppm of PA and the mice were exposed to 0, 8, 16 and 32ppm of PA. Survival of male rats was significantly reduced (32 and 64ppm). Mean body weights of 64ppm male rats were significantly decreased relative to the controls. Both mice and rats showed a spectrum of non-neoplastic changes in the nose. Increased neoplastic incidences of nasal respiratory/transitional epithelial adenoma were observed in both rats and mice. The incidence of mononuclear cell leukemia was significantly increased in male rats and was considered to be treatment-related. In conclusion, the key findings from this study indicated that the nose was the primary target organ of toxicity for PA. Long term inhalation exposure to PA led to nonneoplastic changes in the nose, and increased incidences of respiratory/transitional epithelial adenomas in both mice and rats. Increased incidences of harderian gland adenoma may also have been related to exposure to PA in male mice.

Multisite carcinogenicity and respiratory toxicity of inhaled 1-bromopropane in rats and mice.

Two-year 1-bromopropane (1-BP) inhalation studies were conducted because of the potential for widespread exposure, the lack of chronic toxicity and carcinogenicity data, and the known carcinogenicity of structurally related compounds. Male and female F344/N rats and B6C3F1/N mice were exposed by inhalation to 0, 62.5 (mice only), 125, 250, or 500 (rats only) ppm 1-BP for 6 hr/day, 5 days/week for 105 weeks. Exposure of male and female rats to 1-BP resulted in significantly increased incidences of adenomas of the large intestine and skin neoplasms. In male rats, the incidence of malignant mesothelioma of the epididymis was statistically significantly increased at 500 ppm, but the biological significance of this common lesion is unclear. Incidences of pancreatic islet adenoma in male rats were significantly increased at all concentrations relative to concurrent controls but were within the historical control range for inhalation studies. There was no evidence of carcinogenic activity of 1-BP in male B6C3F1 mice; however, significantly increased incidences of alveolar/bronchiolar neoplasms of the lung were present in female mice. Exposure to 1-BP also resulted in increased incidences of nonneoplastic lesions in the nose of rats and mice, the larynx of rats and male mice, the trachea of female rats and male and female mice, and the lungs of mice. Inflammatory lesions with Splendore Hoeppli (S-H) material were present primarily in the nose and skin of exposed male and female rats, indicating that 1-BP caused immunosuppression.

Chemical and physical characteristics of cellulose insulation particulates, and evaluation of potential acute pulmonary toxicity.

BACKGROUND: During installation of cellulose insulation (CI) in new and older houses, significant quantities of airborne material are generated. This study characterized the chemical and physical properties, and potential acute pulmonary toxicity of CI. METHODS: CI from four manufacturers was analyzed for inorganic additives and trace element impurities. Aerosols were generated and size fractionated. The number and size of fibrous and nonfibrous particles in the respirable fractions were determined. Respirable CI particulates were intratracheally instilled in rats (5 mg/kg) to evaluate potential pulmonary toxicity. RESULTS: CI samples were similar in composition with small differences due primarily to fire retardants. Less than 0.1% of CI was respirable and contained few fibers. Acute exposure to CI caused transient inflammation in the lungs and increased 4-hydroxyproline. Microscopic evaluation revealed a minimal to mild, non-progressing granulomatous pneumonitis. CONCLUSIONS: Low concentrations of respirable particles were found in CI aerosols. Particles consisted primarily of fire retardants with few fibers, and caused mild pulmonary toxicity in rats.

Inhalation toxicology and carcinogenesis studies of propylene glycol mono-t-butyl ether in rats and mice.

Propylene glycol mono-t-butyl ether (PGMBE) is used as a solvent in a variety of commercial applications. Male and female F344/N rats and B6C3F(1) mice were exposed to PGMBE by whole-body inhalation for 2 or 14 weeks (0, 75, 150, 300, 600, or 1200 ppm) or 2 years (0, 75, 300, or 1200 ppm); male NBR rats were exposed for 2 weeks. The kidney and the liver were targets of PGMBE toxicity in rats. Renal lesions suggestive of alpha(2u)-globulin nephropathy were observed in male F344/N, in the 2 and 14-week studies, no kidney lesions were seen in NBR rats. In the 2-year study, male rats displayed exposure-related nonneoplastic lesions in the kidney, and may have shown marginal increases in tubular neoplasms. In the liver, the incidences of hepatocellular adenomas occurred with a positive trend in male rats, and may have been related to PGMBE exposure. In mice of both sexes, the major target of PGMBE toxicity was the liver. In the 2-week study, liver weights and in the 14-week study, liver weights and the incidences of centrilobular hypertrophy were increased. In the 2-year study, the incidences of exposure-related hepatocellular adenoma, adenoma or carcinoma combined, and hepatoblastoma occurred with a positive trend, and were significantly increased in 1200 ppm groups. In summary, exposure to PGMBE resulted in nonneoplastic lesions of the kidney characteristic of alpha(2u)-globulin nephropathy, and may have increased renal tubular neoplasms in male rats. Exposure to PGMBE also produced increases in hepatic tumors in male and female mice.

Lung deposition and clearance of inhaled vanadium pentoxide in chronically exposed F344 rats and B6C3F1 mice.

Female F344 rats and B6C3F1 mice were exposed to vanadium pentoxide (V2O5) at concentrations of 0, 0.5, 1, or 2 mg/m3 (rats) and 0, 1, 2, or 4 mg/m3 (mice) for 6 h/day, 5 days/week (for up to 18 months), by whole-body inhalation. Lung weights and lung burdens of vanadium were determined for exposed animals after 1, 5, and 12 days and after 1, 2, 6, 12, and 18 months of V2O5 exposure. Blood vanadium concentrations were determined at 1, 2, 6, 12, and 18 months for all animals including controls. A model that assumed a first-order deposition rate and a first-order elimination rate for vanadium was employed to fit the lung burden data. Comparisons between exposed groups indicated a progressive increase in lung weight with exposure concentration and time on exposure for both species. The vanadium lung burdens appeared to reach steady state in the lowest exposure groups (0.5 and 1 mg/m3 for rats and mice, respectively) but showed a decline in the higher exposure groups. This deposition pattern was similar between rats and mice but the maximum lung burdens were observed at different times (1 or 2 months in mice vs. 6 months in rats). The vanadium deposition rate decreased faster in mice, while the elimination half-lives of vanadium lung burdens were about six- to nine-fold shorter in mice than in rats at 1 and 2 mg/m3. Thus, the retention of vanadium in the lungs at 18 months was lower in mice (approximately 2% retained) compared with rats (13-15% retained) at the common exposure concentrations of 1 and 2 mg/m3. The lung burden data were approximately proportional to the exposure concentration in both species, likely due to concomitant decreases in deposition and elimination to a similar extent with increasing exposure. The area under the lung burden versus time curves and the area under the blood concentration (control-normalized) versus time curves were also proportional to exposure concentration. The progression of pathological changes in the lung with exposure and time is thought to affect the pattern and/or extent of vanadium deposition in the lungs following repeated exposures to V2O5.

Single administration toxicokinetic studies of decalin (decahydronaphthalene) in rats and mice.

Decalin (decahydronaphthalene) is an industrial solvent known to cause alpha2u-globulin nephropathy in male rats. Studies were conducted using decalin (mixture of cis and trans isomers) to (1) characterize systemic elimination of decalin in rats and mice and (2) evaluate disposition of decalin, its metabolites, and kidney alpha2u-globulin in young and old rats of both sexes following a single 6-h whole-body inhalation exposure at up to 400 ppm decalin. Additionally, a separate group of young male F344/N rats were administered either cis- or trans-decalin iv at doses up to 20 mg/kg to assess disposition of each isomer, its metabolites, and kidney alpha2u-globulin. Decalin was eliminated from blood in a dose-dependent manner, regardless of sex, age, or species. C0 and AUC infinity increased supra-proportionally with exposure concentration. Mice were more efficient in eliminating decalin than rats at lower exposure concentrations, but nonlinear elimination kinetics were more noticeable at 400 ppm. Sex differences in blood decalin elimination were observed in rats; females had a consistently higher AUC infinity at all exposure concentrations. There was a dose-dependent increase in kidney decalin, decalone, and alpha2u-globulin in male rats exposed to decalin. Kidney alpha2u-globulin and decalone concentrations in old male rats were substantially lower than those in young males, but were similar to those observed in all (young and old) females. Compared to old males and all females, young male rats had significantly lower urinary decalol concentrations, but higher kidney decalin, decalone, and alpha2u-globulin concentrations. Administration of decalin to male rats as either the cis or trans isomer revealed that more cis -decalone is produced per unit dose as compared to trans-decalone, and that more trans-decalin accumulated in the kidney (as alpha2u-globulin-ligand complexes) compared to cis-decalin. These patterns of isomer-specific metabolism were also reflected in the cis/trans ratios of decalin in blood, as well as urinary decalol metabolites. The ratio of alpha2u-globulin to the total amount of decalin plus decalone measured in the male rat kidney was approximately 1.0. Therefore, alpha2u-globulin was a key factor in the accumulation of decalin and decalone in kidneys of young male rats, decalin and decalone were practically absent in all females and in old males.

Alpha 2u-globulin nephropathy and carcinogenicity following exposure to decalin (decahydronaphthalene) in F344/N rats.

Decalin (decahydronaphthalene) is a widely used industrial solvent known to cause male rat-specific alpha2u-globulin nephropathy. In this project, 13-week and two-year inhalation studies of decalin were conducted consecutively in both sexes of F344/N rats. The key objectives were to (1) characterize the 13-week toxicity of decalin in rats, with an emphasis on nephropathy in males; (2) compare the kidney concentrations of decalin, 2-decalone, and alpha2u-globulin in males over 2 to 13 weeks of decalin exposure; and (3) correlate male rat nephropathy observed in the 13-week study with renal carcinogenicity in the two-year study. F344 rats (M/F) were exposed via whole-body inhalation to 0, 25, 50, 100, 200, or 400 ppm decalin for 13 weeks. Urine was collected at weeks 2 and 6 for creatinine and decalol analyses and at week 12 for clinical urinalysis. Right kidneys were collected from male rats at weeks 2 and 6 and from both sexes at week 13, homogenates were prepared using the whole kidney, and these homogenates were analyzed for alpha2u-globulin, decalin, and 2-decalone. Left kidneys were evaluated for histopathology and cell proliferation utilizing a proliferating cell nuclear antigen technique and counting proximal renal tubular epithelial cells to determine cell labeling indices. Necropsies and histopathologic evaluations were performed at week 13. Decalin exposure caused increases in kidney weight, urinalysis parameters (protein, AST, LDH), kidney alpha2u-globulin concentration, and proximal convoluted renal tubular cell proliferation in males. These changes were accompanied by microscopic lesions (accumulation of hyaline droplets in cortical tubules, regeneration of proximal tubular epithelium, and granular casts in medullary tubules) clearly linked to alpha2u-globulin nephropathy. Both decalin and 2-decalone were related to increased alpha2u-globulin in male kidneys. Kidney concentrations of decalin, 2-decalone, and alpha2u-globulin in exposed females were negligible, while females excreted greater amounts of decalol metabolites in urine than males at weeks 2 and 6. There were no exposure-related microscopic lesions in females. For chronic exposure, F344 rats were exposed via whole-body inhalation to 0, 25, 50 (males only), 100, or 400 ppm decalin for two years. Chronic exposure induced a spectrum of nonneoplastic and neoplastic lesions in the renal cortex of males, ranging from regenerative lesions of chronic nephropathy to tubular carcinomas. Incidences of renal tubular adenoma, tubular carcinoma, combined tubular adenomas and carcinomas, cortical tubular hyperplasia, hyaline droplet accumulation, hyperplasia of pelvic epithelium, and mineralization in renal papilla were increased in exposed males compared to controls. There was a clear increase in the mean severity of chronic nephropathy in decalin-exposed males. It was concluded that the carcinogenic effect on the renal cortical epithelium of male rats exposed to decalin was related to increased turnover of this epithelium, resulting from the cytotoxic effects of alpha2u-globulin accumulation in the renal cortical tubular cell cytoplasm.